Toyota RAV4 Complaints (2025)

79 consumer complaints on file.

#11759163August 24, 2026
STRUCTURE:BODY
I purchased my vehicle new from the dealership in 2025. After driving the vehicle for several months I noticed the back seat floors were filling with road dirt and debris. I also noticed water was getting into the doors frames. This will certainly cause rust to the doors early on. I made an appointment with the dealership to investigate the problem, and looked forward to them resolving the issues. The dealership had the regional tech person (FTS) come out to look into the matter. I was told there was nothing they could do it was part of the car design. I expressed it was a design flaw that needs to be addressed. I have reached out to Toyota Brand Engagement Center (7/29/26), and received no follow-up to date. I would to request an investigation into these issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756950August 14, 2026
UNKNOWN OR OTHER
I was driving on a 4 lane highway heading north bound in the right hand lane with my sister in the passenger seat both wearing seat belts traveling at approximately 55-60 miles per hour. Traffic was light. At the time of the incident other cars were at least 1/2 mile in front of me with no car close behind me and no one passing me. There were also no overpasses at the time of the incident. I heard what sounded as a large and loud explosion. The car continued to drive just fine but within minutes I realized the panoramic sunroof roof exploded. My exit was approximately 1 mile from the incident and I live 1/2 mile from that exit so I continued driving to my driveway. I continued hearing what sounded like ice cubes cracking after being placed in a warm liquid. The window was completely shattered and all the frame was out of the window laying on the top of my car. I made calls to my insurance, Toyota corporate in [XXX], my specific car dealer where I purchased and service my vehicle and XXX. The incident happened on Wednesday XXX at 1:15pm. Photos were sent to Toyota corporate. The car was towed that day to my dealer and was inspected Thursday XXX by my insurance adjuster. It is currently being inspected by my Toyota dealer. I’m currently waiting for a call from my car dealer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756736August 13, 2026
EXTERIOR LIGHTING
This is not about my car. It is about other cars. I have seen multiple SUVs traveling on the highway with their front lights on, but no rear lights. This happened the other day when it was dark and with heavy rain. This is a safety issue. A Gemini AI search says this is a problem with many new cars. It is a switch setting error. You need to correct this situation before someone gets rear ended. There should be no switch setting that allows driving with front but no back lights, or at least there should be a warning light on the dash board.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755990August 10, 2026
UNKNOWN OR OTHER
While driving with apple carplay and maps displayed for directions, Toyota's Experience Drive Connect screen appears on display. The only way to get back to navigation is to pull over shut the car off, or reboot the display by holding the volume button in. It's a safety issue— a driver distraction The owner is held captive with the advertising until they buy a subscription, over and over again
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755096August 5, 2026
VISIBILITY/WIPER
Driving at 70mph on the freeway when the rear windshield blew out. Seemingly for no reason. Didn't sound like anything hit the windshield, just the pop of the glass. Seems like a defective windshield.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754305August 2, 2026
ENGINE, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
On July 31, 2026, while traveling approximately 55 mph on a Maryland highway, my 2025 Toyota RAV4 unexpectedly lost power and shut off while in motion. There was no check-engine warning before the failure. The vehicle became disabled in a travel lane. Police responded, and the lane had to be closed because the vehicle could not be safely moved. There was no crash, fire, or injury. The vehicle was taken to an authorized Toyota dealership. The dealer documented that it had “shut off mid drive,” reported finding no codes in the engine ECU, and performed service campaign 26TC03 concerning an incorrect mass airflow sensor reading. The dealer replaced a radiator air guide and stated that the vehicle should return for further diagnosis if it stalled again. On August 2, only approximately 36 miles after that service, the vehicle failed to restart at approximately 40,529 miles and required a jump. LTA and pre-collision system malfunction warnings appeared. The pre-collision warning returned while the vehicle was moving, and the Toyota connected app also recorded the malfunction. The vehicle was then towed back to the dealership and is available for inspection. The cause remains unknown. The concern involves an intermittent engine shutdown/no-start condition, a possible 12-volt electrical or charging-system failure, and the loss of forward-collision and lane-assistance functions. The dealer’s prior multipoint inspection marked the battery as acceptable, but no actual CCA battery-test result was documented.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753616July 29, 2026
ELECTRICAL SYSTEM, ENGINE
Drove home vehicle under 20,000 miles 2025, got to drove way parked and car stalled shaking amd stated steering power low, and shut off. Tried to re start it and did the same thing stalled shook amd shut off with the same warning. No previous issues
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752158July 22, 2026
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:CONDENSOR/EVAPORATOR
The contact owns a 2025 Toyota Rav4. The contact stated that while driving the vehicle at an undisclosed speed and activating the A/C, there was hot air coming from the vents. The dealer was contacted, and the contact was informed that the A/C condenser was damaged by an object, causing a refrigerant leak. The contact stated that the vehicle was sold with the pre-existing failure. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 556.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752060July 22, 2026
UNKNOWN OR OTHER
While driving using Apple Carplay with maps loaded, the multimedia screen switches to Toyota's Experience Drive Connect. The only way to get directions back up is to reboot the Multimedia screen by holding down the power switch, which takes a long time while trying to navigate. I called Toyota Connected Services and was informed that they are aware of the problem, but there is nothing they can do unless I pay for services I don't want or need. this has been happening since we purchased the car new 12/31/2026
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749804July 12, 2026
UNKNOWN OR OTHER
Navigation system does not place the car in the correct location. The location will shift and "float" while trying to navigate. Toyota has acknowledged that the navigation failure is due to a firmware issue with no current available solution or repair. We have tried working with the dealer with repeated visits, a certified letter and arbitration with NCDS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748090July 2, 2026
VEHICLE SPEED CONTROL
Sudden self-acceleration by new RAV4 hybrid with less than 1000 miles on it. I made a hard left at low speed onto an uphill residential street. Saw a car backing down the street 1/2 block ahead so I took my foot off accelerator to slow down. Instead, car self-accelerated while my foot was not pressing any pedal, and shot uphill and over a speed bump, throwing the car off course toward parked cars. I stepped hard on brake, and assisted braking probably also kicked in. Car slammed to a stop. No damage or injuries. I took the car to Toyota dealer service immediately to report and address self-acceleration. Was told Vehicle Control History confirmed an event but not its nature or cause; didn’t find problem. Dealer claimed they reported incident to Toyota national center as UA (Unintended Acceleration), as we requested. Returned the car to me without repair or further diagnostic steps. There was never any follow up by Toyota, local or national. One year later, a similar self-acceleration by this car after a hard left turn at low speed caused life-threatening event and damage. I was told then that Toyota corporate had no record of first UA incident. The 2nd incident is reported separately on this site. I have now realized it’s important to report each incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745582June 22, 2026
TIRES:SIDEWALL
Properly inflated at all times "Firestone Destination LE2 225/65R17" tire ruptured suddenly! There is a 1" radial slit in the sidewall near the beginning of the tread line.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745366June 20, 2026
UNKNOWN OR OTHER
As i was driving to work my sunroof shattered out of nowhere, there was no provocation. There was a big pop and then there were noises coming from the roof. When i checked I saw the sunroof had shattered into tine pieces. Toyota does not want to take responsability into this incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744255June 15, 2026
ENGINE, ELECTRICAL SYSTEM, POWER TRAIN
UNKNOWN - On XXX, at just 7,741 miles, my 2025 Toyota RAV4 XLE Premium AWD (VIN: [XXX]) suffered a catastrophic and life-threatening complete mechanical and hydraulic transmission failure. The vehicle completely lost forward propulsion when placed in Drive mode, rendering it entirely immobile. When placed in Reverse gear, the transmission violently over-pressurized, causing the vehicle to suddenly surge and jump uncontrollably. Simultaneously, the dashboard displayed 6 critical safety system failures: 1. Check Engine — electronic control malfunction 2. Vehicle Stability Control System (VSC/TRAC) malfunction 3. Secondary Collision Brake System malfunction 4. Pre-Collision System malfunction 5. Parking Brake System malfunction 6. Advanced Ultrasonic Detecting and Ranging System malfunction Ourisman Toyota Chantilly (RO# XXX) has confirmed complete transmission failure. Fault codes found: P28167F — Pressure Control Solenoid H Actuator Stuck Off, P08BA7F — Pressure Control Solenoid L Actuator Stuck Off. Estimated repair cost: $11,347.42. While this failure fortunately occurred on a local road, had it occurred while merging onto I-66 or I-95 at highway speeds, it would have inevitably caused a catastrophic high-speed collision. This represents an extreme manufacturing defect and life-threatening safety hazard. Toyota Corporate Cases opened: #XXX (original case) and #XXX (full replacement request). I am requesting full vehicle replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743586June 11, 2026
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2025 Toyota RAV4. The contact stated that while driving under normal conditions, the contact heard an abnormally loud, violent, and shattering sound. The contact then noticed that the moonroof glass panel had exploded without impact, causing shattered glass to fall inside the cabin. A police report was filed. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 12,838.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743189June 10, 2026
WHEELS
I purchased this car used in December 2025 with 10k miles on it. After 15k mileage, the rear tires were bald and I had to buy new tires. I then took it back to the dealer and had to pay to get an allignment, as I was concerned that is what was causing the tires to go bald so fast. That was less than 2 months ago and now I'm in getting the 20k service appointment and the rear allignment is now off way more than when I paid to get it checked. Apparently the rear wheels cannot be adjusted? The right rear is way off and this is for sure causing uneven wear on my tires. It is for sure an issue and should not be, in that the car is new. It is obvious it is a fault in design and for sure can cause major safety issues, let alone burn my money up in needing new tires every less than a year.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742513June 6, 2026
VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS
2 incidents of Sudden Unintended Acceleration. No warning lights etc in either. Car damaged but available for inspection. Now encountering difficulties initating Toyota investigation. 1st incident (4/18/25; mileage 967) occurred after a hard left turn. After turn onto uphill street, I took my foot from accelerator to slow and maintain distance from a car backing down hill ahead. Instead, car self-accelerated and shot uphill, over speed bump with increasing speed. Did not respond to braking until it was close to hitting a parked car. Stopped with a slam; probably brake assistance engaged. No damage or injury, but I was shaken. Took car immediately to Toyota dealer to inspect. Was told RoB confirmed an event but not its nature or cause; identified nothing wrong. They hypothesized cruise control might have been triggered accidentally (no evidence, not plausible). Claimed they submitted report to Toyota national center. After 2nd incident, Toyota national said they had no record of 1st event. Their standard safety inspection protocols were not followed. Returned car to me without repair or follow up. 2nd incident ensued. 2nd self-acceleration event (2026) also occurred after hard left turn to make U turn at low speed, braking while completing turn. When I took my foot off brake, before I could press it on accelerator, car shot diagonally across street. Jumped curb and traveled at considerable speed 100' up landscaped slope. Destroyed 6 large shrubs and 3 trees 9' tall. Did not stop despite constant driver braking. Forward collision prevention system did not engage to prevent uprooting trees. Car stopped only after I turned steering wheel sharply to left to avoid hitting a full-size tree trunk. Then car responded to braking, acceleration ended, car stopped next to tree without impact. Terrifying life-threatening event but only damaged landscape and car. Police came, assessed incident, determined not a police matter, did not file police report.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742361June 5, 2026
SERVICE BRAKES
The brakes have been overly sensitive... but then, without warning, braking power is completely lost. This has happened on 2 separate occasions... the pedal goes all the way to the floor and provides ZERO braking power. We can no longer trust this car on the road. Toyota sent someone to inspect the vehicle and they claim that they have found no problems or issues and that they have not been able to reproduce the problem. There were no warning lamps or message; there were no prior symptoms, other than the brakes were overly sensitive. These symptoms occurred immediately after purchasing the car. Toyota refuses to purchased the car back from us, and now we are stuck with a very dangerous vehicle. Interestingly, I have found others talking about EXACTLY the same symptoms on other Toyota Rav4 vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740541May 28, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS, SERVICE BRAKES
My daughter reported an incident that occurred on XXX while driving this vehicle. As she drove, it slammed on the brakes (without any input from her) causing her to skid. The vehicle brought itself to a stop and the engine turned off. She reported that there were no vehicles or other object close to the front of her vehicle. The incident did not cause a crash or cause anyone to be injured. It was, however, a very scary situation that almost caused her to be rear-ended by the vehicles that were following her. The car was taken to Cobb County Toyota in Kennesaw, Georgia for an inspection the morning of May 28, 2026. As of this submission, the vehicle is still at the dealership service department for inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738833May 19, 2026
UNKNOWN OR OTHER
The multimedia screen which shows the map and direction guidance became to blank occasionally, just white grey since February 2026. I immediately lost the direction. It could be back by restarting the engine at the beginning. The problem got worse, happened more often, some times the screen couldn't be back by restarting engine, but I found that it could be reset by pressing the volume button for long time. I reported to Toyota local dealer - Hendrick Toyota Apex and Toyota Brand Engagement center, the case manager is Freddy. The local dealer run diagnosis twice, couldn't detect any problem. On May 11, the screen totally died, black, no any light. Restarting engine or pressing the volume Botton couldn't get the screen back any more. the audio system is still working, I tried to use the map on my iPhone, the direction map couldn't be showed, only the text direction shows. Because the system let map show on screen, it assumes that the map shows one screen but it is not. I lost car screen and the phone direction at the same time. Plus the backup camera doesn't show on the screen. Therefore, it is underivable in any unfamiliar area, and dangerous to drive in neighborhoods. I reported to local dealer and Toyota Brand Engagement center with videos. May 18, the local dealer run diagnosis again, found nothing wrong. But before I leave, the screen became blank. This morning it happened again. The problem is not fixed. Freddy told me he suggested to local dealer to replace the screen, I am waiting Hendrick Toyota Apex call me for the appointment. I can't upload videos. If you want to see the videos, please tell me where and how to upload the videos. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota RAV4