Toyota bZ4X Complaints (2024)

24 consumer complaints on file.

#11752465July 23, 2026
STRUCTURE:BODY
I was driving during heavy rain when I heard and felt a big thump. I wasn't sure what happened as I did not hit anything in the road. I was in my neighborhood driving at low speeds (<30mph). When I got home, I realized my fender liners and lower splash guard of my car were missing. I went back out to retrieve these pieces of my car, and it appeared the fender liners and the splash guard got torn off my car without impact with anything, as nothing was in the road near it. I was going to attempt to reconnect them but the plastic clips on the front bumper also ripped off, making this a very expensive repair requiring bumper replacement and sensor recalibration. This obviously could put others at risk of running over a large number of components that were left in the road. I read many other instances of other people with the same vehicle (as well as with the Solterra) having an issue where the felt fender liners can become saturated with water, sag, and get caught in the wheels, ripping them off. I was one of those unlucky people to lose both sides and the splash guard all at the same time. The dealership / body shop inspected the vehicle. No warnings at all - just sudden ingestion of the fender liners into my drivetrain.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740953May 29, 2026
UNKNOWN OR OTHER
While operating my 2024 Toyota bZ4X at very low speed on the road , I observed a stationary shipping container directly ahead and applied the brake pedal with maximum force approximately 4 seconds before contact. I held the brake pedal at full pressure continuously. I never touched the accelerator. The vehicle came to what appeared to be a complete stop then continued to advance and made physical contact with the container despite my maintained maximum brake input. The vehicle's own ECU-recorded Freeze Frame Data (retrieved by an authorized Toyota dealer using PCS Data Viewer) confirms the following at the time of the event: Driver brake pedal torque was at sensor saturation (4,048 Nm — the maximum value the sensor can record) for approximately 1.75 seconds prior to impact. Brake hydraulic line pressure peaked at 12.144 MPa and remained above 7.8 MPa throughout that period. Throttle position was 0.0% for the entire recorded interval. All four wheel-speed sensors recorded 0.00 km/h for approximately 2.95 seconds prior to impact. Steering input was effectively neutral; no skid or loss of directional control occurred. The longitudinal accelerometer recorded a peak deceleration spike of -8.97 m/s² at the moment of impact — a value that requires forward velocity and is physically inconsistent with the wheel-speed data showing the vehicle stopped. The Pre-Collision System (PCS) main switch was ON throughout, with no faults, no obstruction flags, and no warning, pre-brake, brake-assist, or auto-brake activation recorded. The Parking Support Brake (PKSB) did not activate. No diagnostic trouble codes were set. In plain terms: with maximum brake pressure applied and zero throttle input, my vehicle continued to move forward into a clearly visible stationary obstacle. The brakes did not maintain authority over the powertrain's creep torque, and no advanced safety system intervened. This indicates a potential defect in the vehicle's brake-override / creep-suppression
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11739440May 22, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
The vehicle experienced a sudden, catastrophic brake-by-wire system failure while operating in one-pedal driving (Regeneration Boost mode). While decelerating at a low speed behind an 18-wheeler semi-truck, the vehicle failed to continue slowing down. I immediately depressed the physical brake pedal, but the vehicle completely ignored the foot pressure. The pedal and braking system became completely unresponsive, and the vehicle kept rolling forward uncommanded. Despite keeping the brake pedal fully depressed, the vehicle did not decelerate, resulting in a front-end low-speed collision with the metal rear bumper of the semi-truck. Because the collision occurred at a very low speed, the operator of the commercial truck was unaware of the impact and safely continued driving forward without stopping. The vehicle's brakes entirely refused to re-engage until I frantically pumped the physical brake pedal and cycled/pressed vehicle control power switches. This action seemingly forced the electronic braking modules to reboot or re-establish hydraulic pressure, allowing the vehicle to finally come to a stop. The vehicle was subsequently removed from the active roadway. This is a severe, life-threatening safety defect involving a total loss of electronic brake-by-wire and friction braking application without any mechanical override intervention, presenting an extreme hazard. The vehicle has been towed directly to an authorized Toyota dealership for a comprehensive electronic diagnostic pre-scan of the Skid Control ECU, Electronic Parking Brake system, and 12-volt auxiliary power systems to retrieve the stored DTC fault logs and freeze-frame data.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11736210May 6, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, VEHICLE SPEED CONTROL, VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:COMPRESSOR
The car show on the screen a message in regards to the Adaptative Cruise Control Malfunction and it’s showing an orange sign light.. Another problem it’s in regards the AC.. it’s not working
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735739May 5, 2026
POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2024 Toyota BZ4X. When pressing the accelerator toelerator pedal to go onto the freeway, the vehicle failed to accelerate and suddenly shifted to neutral. The contact would have to press the brake pedal, the contact would immediately shift the vehicle back to Drive and continue forward. While continuing to drive, the vehicle accelerated. There were no warning lights. The failure had occurred 3 times. When attempting to start the vehicle one day, the vehicle failed to start. The tow company came and provided a jump-start, and then advised the contact to drive carefully, but if it failed to go in reverse. The next morning, the tow company's mechanic came again and confirmed battery failure, then recommended the vehicle be taken to the dealer. The vehicle was towed to the dealer, who stated that the battery had not failed, but had not provided a diagnosis for the failure. The vehicle had not been repaired. The dealer had driven the vehicle back to the contact's home. After the vehicle was returned, the failure occurred again. The manufacturer was informed, and a claim had been filed. The failure mileage was 9,787.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735209May 1, 2026
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:COMPRESSOR
What component or system failed or malfunctioned, and is it available for inspection upon request? The HVAC system, specifically the electric A/C compressor, has failed. The system produces a loud grinding/buzzing noise and has been diagnosed by authorized Toyota dealerships as requiring full compressor replacement. The vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? This failure directly impacts the vehicle’s defrost system, which is critical for maintaining windshield visibility. Reduced or failed defrost capability creates a safety hazard by impairing visibility while driving, increasing the risk of an accident. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue has been confirmed by multiple authorized Toyota dealerships, including Sheehy Toyota and Mike Calvert Toyota. Both independently diagnosed a failed A/C compressor requiring replacement. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes. The issue has been escalated to Toyota Corporate, and a case manager has reviewed the dealership findings. Documentation has been submitted to Toyota for warranty and goodwill consideration. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. A grinding/buzzing noise began when the A/C system was activated and was formally reported to Sheehy Toyota on October 27, 2025, while the vehicle was under warranty. The issue was not repaired at that time. The condition progressively worsened and resulted in confirmed compressor failure on March 25, 2026.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699930November 17, 2025
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I LEASED A TOYOTA BZ4X THE PARKING BRAKE LIGHTS AND OTHER LIGHTS COME ON AND OFF WHILE I AM DRIVING AND FOB IS NOT TOUCHED. I TOOK CAR IN TO BE SERVICE FOR REGULAR MAINTENANCE AND WAS TOLD I HAD TO PAY $295 AND I AM UNDER WARRANTY. I WAS SOLD THE CAR BRAND NEW AND I DON'T THINK IT IS. I KEEP HEARING PEOPLE TALKING WHEN THE CAR IS POWERED OFF. I REPORTED THIS SEVERAL TIMES AND WAS IGNORED. MY CAR KEEPS TRYING TO CUT OFF WHILE I AM DRIVING AND THE CAR STARTS SHAKING, ALL THE LIGHTS COME ON THEN GO OFF. I WAS TOLD I COULD GET MY CAR SERVICE ANYWHERE FOR NO CHARGE UNDER WARRANTY. I WAS TURNED AWAY. ITS N BEEN A YEAR AND NO SERVICE CAR HAS NOT BEEN SERVICED AT ALL. I TOOK IT 2 TIMES FOR SERVICE AND THE CAR HAS NOT BEEN SERVICE. IT IS SUPPOSED TO BE NEW.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695462October 24, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM
The vehicle experienced repeated electrical and brake system malfunctions that pose serious safety concerns. On multiple occasions, the brake pedal became stiff and unresponsive while driving, and the parking brake system failed to engage properly. In addition, the ignition system often failed to start, even when the battery and all power indicators appeared normal. At times, the vehicle’s electrical system completely shut down without warning — causing loss of power functions, dashboard lights, and essential safety controls. These failures occur intermittently and unpredictably, making the vehicle unreliable and unsafe to operate. The issue has been reported to the dealer for inspection, but the problem continues to occur. It appears to be related to the vehicle’s electronic brake control and ignition system. This malfunction places the driver and others at potential risk, especially if the brake system or electrical components fail while the vehicle is in motion.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692228October 8, 2025
ELECTRICAL SYSTEM, WHEELS, LANE DEPARTURE: WARNING
I am writing to formally report ongoing issues with my Toyota bZ4X that raise serious safety concerns. The vehicle has been inspected twice by authorized Toyota service centers, and each time I have been told that no problems were found. However, the following issues continue to persist: 1. Inaccurate Battery Readings: The electric system appears to malfunction regularly. The displayed battery percentage and estimated mileage are inconsistent and unreliable. For example, the battery may indicate a higher percentage while simultaneously showing a drastically reduced range, or vice versa. 2. Lane Departure Warning Malfunction: The lane departure system activates erratically, sometimes without any lane deviation. At other times, it fails to engage when it should, which compromises the vehicle’s safety features. 3. Tire Pressure Monitoring System (TPMS) Alerts: Warning lights frequently come on indicating that the tires are losing pressure, even after verifying that tire pressures are within recommended levels. These warnings occur unpredictably and without cause. Despite having the vehicle inspected twice, I have not received a resolution or acknowledgment of any defects. Toyota has stated that nothing is wrong with the vehicle, but the issues are ongoing and continue to impact the car’s drivability and safety. These problems are not only frustrating but also present a potential risk while driving. I am requesting that Toyota take this matter seriously, investigate the root cause of these electrical system malfunctions, and provide a resolution that ensures the vehicle operates safely and reliably.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682437August 22, 2025
ELECTRICAL SYSTEM
The 12 volt battery does not maintain a charge. I have had it replaced twice. I purchased new January 2025; first battery replaced on March 20, 2025; second battery replaced August 13, 2025. I am currently having the same issue with the battery management system which controls temperature and battery usage. After sitting overnight, I drove my car approximately three miles parked and attempted to use the key fob to secure the vehicle, it failed. I had no problem or indication at the start of my trip. I had to secure the door with my physical key. I returned to the vehicle 15 minutes later and the key fob would not work at all. I accessed the vehicle with the physical key. The alarm was activated upon entry. I tried to use my key fob to get the vehicle to deactivate the alarm system but it would not work. Approximately five minutes later and after several attempts, the alarm stopped and the vehicle was showing ‘Ready’ but ‘No Key Detected’ was flashing on the information screen and vehicle would not change mode from park to reverse or drive. After several attempts of holding the key fob directly over the ‘START/STOP’ button, the car showed ‘ READY’ and I was able to change modes. The vehicle started flashing ‘NO KEY DETECTED’ continuously while I quickly drove back home. I parked in my driveway and made an appointment with Toyota for service. Later in the day, I attempted my key fob again, to no avail. I was able to get the key detected, display showed ‘Ready’ and mode changed. My car does not start (READY) until after several attempts. The dealership advised the battery failed a load test overnight and was replaced (August 15th) After the second replacement my car sat overnight. I drove a few miles to a charging station. I placed the car in ‘My Room Mode’ to have access to the climate control system and radio. The car started flashing ‘low voltage/battery’, I turned off the accessory mode, returned to the dealer, and awaiting resolution. Case filed with NCDS/CDSP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682285August 21, 2025
LANE DEPARTURE: BLIND SPOT DETECTION, SEATS, VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
I am very concerned about potential accidents for my self and others driving this vehicle. I have multiple close call accidents because the left view mirror does't have proper view to see cars on left side especially if they are close. The way seat and the side of the vehicle is shaped its very hard to still see manually with head turned to the left rear side. The mirror or the shape or position needs to be changed for safety to prevent accidents.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681777August 20, 2025
STRUCTURE:BODY
LEFT FRONT FENDER AND HOOD CONTACTED UPON GOING INTO A DIP IN THE ROAD DURNING ROAD CONTRUCTION PERFORMED BY BITUMINOUS ROADWAYS, INC. DAMAGE TO FENDER AND HOOD. VEHICLE BODY AND OR FRAME WISTED. BROUGHT THE VEHICLE TO LAMETTRY'S IN BURNSVILLE MINNESOTA. THEY STAED THAT THE DIP IN THE ROAD MAY HAVE CAUSED THIS CONDITION AS SEEN FROM THE SCRAPE MARKS ON LATCH. TOYOTA DEALER INSPRSTION AND CASE OPENED. CRUNCH NOISE HEARD DURING INCIDENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675770July 23, 2025
AIR BAGS
Driver sustained severe hand injuries due to airbag deployment while the hand was on the horn pad. Possible over-aggressive deployment or module failure. Incident occurred on [XXX], while driving a 2024 Toyota BZ4X (VIN: [XXX] ). Requesting formal investigation into the airbag system and front structural integrity of this vehicle model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11666897June 14, 2025
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS, STRUCTURE:BODY:BUMPERS
On [XXX], while driving through a common roadway puddle at a safe speed, the front bumper on my BZ4X detached from the undercarriage shield and tore away from the clips. This type of damage is clearly disproportionate to the conditions and reflects a deficiency in structural design. After researching this issue, I found that many other BZ4X owners have experienced the same bumper detachment and undercarriage shield failure under minimal driving conditions. These consistent reports indicate a widespread manufacturing defect, not isolated driver error or negligence. For example: On multiple owner forums and complaint sites like NHTSA.gov and Reddit, BZ4X owners have documented similar instances of bumpers tearing off from puddles or light snow. A widely circulated post on Reddit’s r/Toyota described a nearly identical issue, stating that “driving through a shallow puddle at a slow speed caused the bumper to rip off like paper.” The issue has even reached automotive press outlets and consumer advocate blogs, highlighting growing concern over the poor mounting of the bumper and the fragile undercarriage shield. Given the consistency and severity of these reports, this clearly represents a design flaw. The bumper is failing to withstand routine driving conditions, and this undermines not only the durability of the vehicle but also customer confidence and safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664415June 2, 2025
STRUCTURE:BODY
I was driving very slowly (5 to 10 MPH) through a rain storm on May 28th. The water rose to about 6 inches (fairly still, not rushing water), and I heard a loud and alarming noise under the car. I drove on for one block on a neighborhood street until I could get to higher ground. I discovered that the force of the water pulled down the fabric and plastic shrouds from the wheel-well into the wheels. The cloth and plastic shrouds were then pulled under the wheels, and the whole connected assembly was ripped off the car. This caused damage to both front fenders, the front bumper, and possibly to the safety sensors behind the bumper. I took it to my local Toyota dealer the next day, and they said this happens all the time, and that it will cost at least $2,000 to repair -- maybe double that if the safety sensors behind the bumper were damaged. I posted to some forums on-line about this problem, and heard from many other owners of the BZ4X and the identical car from Subaru (Soltera) that they had experienced the same thing. The Toyota dealer is correct -- this happens all the time -- it is clearly a serious design flaw, and it is a serious safety concern. The Toyota dealer has said that this is my problem, not theirs. The Toyota USA customer-service said the same thing. They clearly do not want to accept responsibility for a badly designed front-bumper assembly. This car has less than 3,000 miles on it, and despite my extremely cautious driving, it is already falling apart.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663632May 29, 2025
STEERING, WHEELS, LANE DEPARTURE: ASSIST
Steering system, potentially related to electric power steering (EPS) or driver-assist systems (lane keeping or steering assist). While completing a routine right-hand turn, my husband began to straighten the steering wheel when the steering system suddenly and sharply turned further right without any driver input. This caused the vehicle to strike a curb, damaging both passenger-side wheels and the front tire. There were no warning lights or indicators, and road and weather conditions were normal. The uncommanded steering input appeared to come from the vehicle itself. The incident resulted in loss of directional control and could have been severe had another vehicle, pedestrian, or cyclist been present. This behavior reflects a serious and unexpected failure in the steering or driver-assist system, posing a direct threat to driver and public safety. I reported the incident to my local Toyota dealership. I have since signed Toyota’s EDR (Event Data Recorder) consent form, and an official inspection has occurred but they haven't provided detail. They also did not make me aware the inspection was taking place and did it without coordination. They have not confirmed that this has happened before. A similar, though less severe, issue occurred previously while I was driving on the highway. As I approached a merging lane to my right, the car suddenly pulled sharply to the right, seemingly misinterpreting the lane markings or misjudging its position. There were no vehicles next to me at the time, and I was able to regain control. While it did not result in a collision, it was alarming and appears to have been a driver-assist or steering control malfunction.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11654242April 12, 2025
ELECTRICAL SYSTEM
The air conditioner/heat pump has went out twice in 5 months. AC compressor failure poses several safety risks, including the potential for fires, refrigerant leaks leading to health hazards, and increased humidity fostering mold and mildew growth, which can worsen indoor air quality and lead to respiratory issues. Causing concern of leaking refrigerant into the cabin of the vehicle could lead to cancer and death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11653558April 8, 2025
UNKNOWN OR OTHER
Sparks coming out the charge port
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650834March 26, 2025
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, SERVICE BRAKES
2024 BZ4x, 590 miles on ODO. Purchased the car on Sunday, 03/23/2025. Monday Morning - Turning on the Car (In my garage). I had it in "ready" while I tried to connect my Toyota app to the car, While talking to Toyota engagement for help.. (Never was able to change the primary driver on it.) The accessory lights flickered and a bell went on and off. Then the car went totally black. Toyota called a tow truck driver. He jumped the 12 volt. It gave it enough juice so I put in reverse and there was a Loud Grinding noise. "Brake System Malfunction- Take to Dealer." Tow truck loaded it up, grinding and all, took it to Toyota. There, found out the 12 volt battery died. No reported grinding when off loading or at the dealer. Toyota Dealer replaced the 12 volt battery on Monday 03/24/2025. Picked it up, drove it around about 40 miles and parked it in my garage. Parked with >80% battery on Lith battery Monday night 21:00. Sat in the Garage on Tuesday. Wednesday Morning 08:00am, 12 Volt COMPLETLY DEAD. It's back at the dealership. MY safety concern - Does this mean the Brake system will "malfunction" if the 12 volt battery isn't holding enough charge to operate the BRAKE SYSTEM?! Not sure if it means the parking brake or the actual brakes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11644322February 22, 2025
UNKNOWN OR OTHER
**Report to NHTSA – 12-Volt Battery Issue in Toyota BZ4X** **Vehicle Information:** - **Make & Model:** Toyota BZ4X - **Issue:** 12-Volt Battery Drain **Description of the Problem:** I have been experiencing repeated issues with the 12-volt battery in my Toyota BZ4X. If the vehicle is not driven for one or two days, the battery depletes, requiring a jump-start to operate. I have taken the car to the dealership for inspection on two separate occasions—once in November and again recently. On both visits, the dealer was unable to identify any issues. However, despite these inspections, the problem persists. Most recently, after taking the vehicle to the dealership, the car once again failed to start the following day and required another jump-start. **Safety Concern:** This recurring battery failure presents a significant safety risk, particularly if the vehicle becomes inoperable in a remote location or in an emergency situation. The inability to start the car reliably raises concerns about potential hazards, especially in extreme weather conditions or areas with limited access to assistance. **Request for Investigation:** I urge the NHTSA to investigate this issue further, as it affects the reliability and safety of the vehicle. A resolution is necessary to ensure that the 12-volt battery functions as intended without leaving drivers stranded.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota bZ4X