Mercedes-Benz Sprinter Complaints (2017)

41 consumer complaints on file.

#11758341August 20, 2026
WHEELS:RIM
The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact stated that while driving at an undisclosed speed, the front driver's side tire became deflated. The vehicle was driven to the dealer, where the contact was informed that the front driver's side rim was cracked. The contact was informed that the front driver's side rim needed to be replaced. The contact was informed that the parts were unavailable. The vehicle was taken to an independent mechanic, where the contact was informed that the failure had reoccurred due to potholes in the road. The vehicle was repaired; however, the failure reoccurred. The failure became a persistent failure. Additionally, the contact stated that the front passenger's rim and both rear rims were all cracked. In addition, the driver's side rear tire was damaged because of the failure. The contact stated that parts were unavailable at the dealer. The contact stated that during the failure, the contact had to search around for replacement rims. The manufacturer was not made aware of the failure. The failure mileage was approximately 15,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744347June 15, 2026
AIR BAGS, ELECTRICAL SYSTEM
The vehicle has swivel seats. When the driver’s seat swivel, it’s severed the wires, the control the SRS system.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706703December 23, 2025
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Odometer Fraud. The contact purchased a 2017 Mercedes-Benz Sprinter 2500. The contact stated that it was discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the mileage was 41,000. It was later discovered upon diagnosis that the mileage was 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676933July 29, 2025
ENGINE, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
The contact owns a 2017 Mercedes-Benz Sprinter 2500. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed knock sensor, debris in the EGR valve, insufficient Selective Catalytic Reduction(SCR), and low DEF. The contact was informed that the knock sensor and the SCR converter needed to be replaced, and the EGR valve needed to be cleaned. The vehicle ws not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 73,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632139December 23, 2024
FUEL SYSTEM, DIESEL
The contact owns a 2017 Mercedes-Benz M3CA76 Sprinter 3500. The contact stated while driving at approximately 65 MPH, the diesel purifier, Diesel Exhaust Fluid, DEF system, warning illuminated. The contact stated that the failure of the DEF system had occurred before the recent failure. The contact stated that the first failure had occurred several years ago. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that the DEF system again needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 325,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631555December 19, 2024
FUEL SYSTEM, DIESEL
The contact owns a 2017 Mercedes- Benz Sprinter 350. The contact stated that while driving at various highway speeds the warning message "DEF Is Low" had suddenly displayed and the vehicle went into "Limp Mode" causing the speed to suddenly reduce to 5 MPH. The vehicle was taken to the local dealer who diagnosed that the DEF tank was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 44,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11593949June 12, 2024
UNKNOWN OR OTHER
Check engine light Nox sensor failure message
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11541965August 31, 2023
TIRES
The contact owns a 2017 Mercedes-Benz Sprinter 2500 equipped with Kumho Tires, Tire Line: Road Venture TR, Tire Size: LT245/75/R16, DOT Number: H211YD5F1717. The contact stated that while he was cleaning the vehicle, he noticed that the front tires had pieces of tire rubber around the tire and that the tread was delaminating. The contact inspected the rear tires and noticed that there was premature tire wear on the tread of both tires. The contact called the tire manufacturer who directed him to take the vehicle to an independent tire dealer for diagnostic testing where it was confirmed that the tires were undergoing premature wear. The manufacturer was notified of the failure. The approximate vehicle failure mileage was 18,000 and the tire failure mileage was 18,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11540773August 25, 2023
STRUCTURE
The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact stated while driving approximately 25 MPH, he had to brake abruptly, due to an animal crossing the roadway. Then he heard a loud sound coming from underneath the vehicle, when he took his foot off the brake. . The contact pulled over to the side of the road and saw the water tank had fallen to the ground. The vehicle was taken to an independent mechanic where the water tank was firmly re-attached to the RV. The manufacturer was notified of the failure, but has to date denied responsibility for inadequately attaching the water tank to its RVs. The failure mileage was 49,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539850August 21, 2023
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, VEHICLE SPEED CONTROL
The ESP and ABS warning lights went on suddenly after what sounded like a thud. The car had not run over anything. There was some initial brief chattering of the break pedal, and that subsided. The car was not near a suitable and available repair shop at the time. It was driven to complete a trip. There were several instances of break pedal chattering that led concern about the controllability of the vehicle. During the trip, it was taken to a brake shop, and the technicians felt it was likely safe to drive. Eventually after the servicing dealer first replaced the front speed sensors, the ESP unit was found to be shorted. This event is of concern because the speed sensors on the rear have been replaced on recall and the front speed sensors have been granted an extended warrantee. Both feed into the ESP unit that failed. It seems possible the previously suspect parts may have damaged the ESP unit. There appears to be a safety issue with faulty break performance in this situation. The vehicle only had about 13,000 miles on the odometer. at the time of the event. Service an repair records are available upon request
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11530098July 3, 2023
UNKNOWN OR OTHER
The front left wheel cover shifted and nearly sheared off the tire valve stem. Had this happened while we were on the road, the tire would have had a very fast deflate/explosion. This would have put the 24ft. RV into an uncontrollable nose-dive and possible crash situation. The nearly-sheared valve stem was discovered by technicians while we were having routine maintenance done at the authorized Mercedes dealership. They removed the tire and replaced the valve stem. We were told by the Service Manager that this usually happens to the rear dual wheels, not the front. We have had zip ties put on to keep the wheel "hubcaps" (beauty rings) on the wheels because they are notorious for flying off. There are no warning lights etc. to indicate any wheel issues. This RV (Sprinter) has been in to authorized Mercedes Sprinter dealership for regular service over the past 4 years and only this time (June 26, 2023) was the problem discovered. The Mercedes Service Dept. in Eugene is the only technicians this RV has been in contact with. They seem to be aware that this "sheering" of valve stems is a reoccurring problem with Sprinters.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529306June 28, 2023
SERVICE BRAKES, VEHICLE SPEED CONTROL
I'm getting wheel sensor errors and the vehicle goes into limp mode and disables the cruise control, even after replacing the sensors. Very frustrated with this dangerous situation!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11523447May 23, 2023
TIRES
The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact stated that on two separate occasions while driving at undisclosed speeds, the vehicle started shaking and the contact heard a loud sound coming from the vehicle. The contact veered off the roadway and noticed that the hub cap had detached from the wheel. The contact stated that he was not aware that the inside tire had deflated. The contact then stated that he removed the hubcap from the road and continued driving to the nearest tire shop where it was diagnosed that rear driver’s side inside tire was deflated and needed to be replaced. The vehicle was repaired. The contact stated that on another occasion the vehicle was taken to the dealer for service, where the two rear passenger’s side tires were rotated, and the contact retrieved the vehicle however, while driving at an undisclosed speed, the vehicle failed to operate as needed. The contact pulled over to the nearest service station where it was inspected and the contact was informed that the two rear passenger’s side valve stem were entangled in the hub caps and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall. The failure mileage was approximately 26,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11453388February 22, 2022
ELECTRICAL SYSTEM
The contact owns a 2017 Pleasure Way RV built on a 2017 Mercedes-Benz Sprinter 2500 chassis. The contact stated while driving approximately 70 MPH, the vehicle experienced a loss of motive power, brakes, power steering, and engine functionality. The vehicle was pulled over and restarted and functioned as designed however, the failure recurred. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed with needing the engine wiring harness replaced. The dealer reported that the harness showed signs of abrasions which caused the harness to ground out leading to loss of power. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11436675October 13, 2021
STEERING
The contact owns a 2017 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA campaign number: 20V663000 (Steering) however, the part to do the recall repair was unavailable. The contact called the local dealer who stated that parts were not yet available. The contact was informed the parts were backordered until May 30, 2022. The contact stated the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11430294August 24, 2021
STEERING
The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact received notification of NHTSA Campaign Number: 20V663000 (Steering) however, the part to do the recall repair was unavailable. The dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11427005July 29, 2021
ELECTRONIC STABILITY CONTROL (ESC)
The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact received a recall notification for NHTSA Campaign Number: 21V042000 (Electronic Stability Control) however, the dealer informed the contact that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11426633July 27, 2021
WHEELS:RIM
The contact's parents own a 2017 Mercedes-Benz Sprinter 3500. The contact stated that his parents had experienced multiple flat tire failures with various tires on the vehicle. An independent mechanic discovered that there were multiple cracks on three of the rims on the vehicle. Due to that discovery, his parents had all six tires and rims replaced on the vehicle. Recently, the contact discovered that the driver’s side inner tire had blown out after parking the RV. The contact called for emergency assistance and had the tire replaced. On a separate occasion, the contact noticed after parking the vehicle, the rear passenger’s side outer tire was flat. The contact again called for emergency assistance and while the tire was being replaced, it was discovered that the sidewalls had all fallen apart inside the tire. The vehicle was not diagnosed nor repaired. The contact believed that the cause of the tire failures was related to the rims on the vehicle. Neither the manufacturer nor the dealer was notified of the failure. The failure mileage was 8,100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11423787July 7, 2021
ELECTRONIC STABILITY CONTROL (ESC)
The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact received notification of NHTSA campaign number: 21V042000 (Electronic Stability Control) however, the part to do the recall repair was unavailable. The contact called the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue but was unable to provide a date when parts would be available. The contact had not experienced a failure. Vin tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11419206June 1, 2021
ELECTRONIC STABILITY CONTROL (ESC)
The contact owns a 2017 Mercedes-Benz Sprinter 3500. The contact stated while driving at 65 MPH, the cruise control disengaged as the ABS and ESP warning lights illuminated. The contact pulled the vehicle over and read the owner's manual to get information on the failure. Upon restart, the check engine warning light illuminated. The contact received notification of NHTSA campaign number: 21V042000 (Electronic Stability Control) however, the part to do the recall repair was not yet available. The manufacturer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was 5,500. Vin tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mercedes-Benz Sprinter