Mercedes-Benz Sprinter Complaints (2015)

30 consumer complaints on file.

#11571048February 9, 2024
SEATS
seat that driver sits on coming apart at 7 1/2 years am only driver an is my personal van , van is not a work van dealer wants $850 plus installation . my last van had 15 yrs was in good shape and no tears . when washing my seat with warm water and cloth its coming apart looks like bad material
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11514446March 29, 2023
STEERING
The contact owns a 2015 Mercedes-Benz Sprinter 2500. The contact stated that while the vehicle was parked in the driveway, he noticed fluid dripping from the vehicle. The contact stated that upon inspecting the vehicle, he noticed that the power steering hose was leaking. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 20V663000 (Steering) The manufacturer was notified of the failure and referred the contact to the dealer. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387883January 13, 2021
VEHICLE SPEED CONTROL
BOTH REAR WHEEL SENSORS WENT OUT WITHIN 2 MONTHS OF EACH OTHER. ONE 6,000 MILES, THE OTHER 8,000 MILES. BOTH HIGHWAY DRIVING NO ROUGH ROAD
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11376369November 25, 2020
STEERING
I NOTICED A RECALL FOR THE MB SPRINTER 2500 - YEAR 2015-2020 WITH A LEAKING POWER STEERING CLAMP/HOSE.(20V-663) MY VAN IS NOT INCLUDED IN THIS RECALL DESPITE BEING A 2015 MB SPRINTER 2500. I HAD THIS PART REPLACED ON MY VAN TWO WEEKS AGO. PLEASE DIG DEEPER INTO THE VANS AS THERE ARE OTHER VINS THAT ARE BEING AFFECTED BY THIS EXACT SAME ISSUE THAT ARE NOT BEING INCLUDED IN THE RECALL. I HAD TO REPLACE THE DRIVE BELT TOO AS THE POWER STEERING FLUID WAS LEAKING ON THAT BELT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11376216November 24, 2020
VEHICLE SPEED CONTROL
I WAS DRIVING ON THE FREEWAY WITH MY CRUISE CONTROL SET AT 65. THE VEHICLE ABRUPTLY STARTED ACCELERATING. FORTUNATELY I HAD LEFT MYSELF A GOOD DISTANCE FROM THE SEMI IN FRONT OF ME OR I WOULD HAVE RAMMED INTO THE BACK OF IT. THIS WAS QUITE UNNERVING AND AFTER BRAKING I RECEIVED THE FOLLOWING ERROR CODES: ABS, ESP, TRACTION CONTROL AND CRUISE CONTROL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11374997November 17, 2020
SERVICE BRAKES, FUEL/PROPULSION SYSTEM, POWER TRAIN
THIS VEHICLE HAS HAD 4 SEPARATE WHEEL SPED SENSOR FAILURES. WHEN EACH INCIDENT OCCURRED, THE VEHICLE WILL ACCELERATE ON ITS OWN AND AT THE SAME TIME THE ABS WILL NOT ALLOW FULL BRAKING PRESSURE WHILE UNDERWAY. YOU WILL HEAR THE ABS SOUND LIKE IT'S SLIDING ON A SLIPPERY SURFACE IN ANY CONDITION. AS THE VEHICLE ACCELERATES AND BRAKING PRESSURE IS GREATLY REDUCED, IT IS SOMETIMES NECESSARY TO QUICKLY SHOVE THE VEHICLE IN NEUTRAL TO KEEP FROM HITTING ANYTHING AHEAD. WHEN THESE FAILURES OCCUR IT CAN BE AT ANY SPEED OR ON ANY SURFACE. THIS VEHICLE WAS PURCHASED NEW AND NOW HAS APPROXIMATELY 45,000 MILES. OCCASIONALLY, PRIOR TO THE DASH LIGHTS INDICATING A WHEEL SPEED SENSOR FAILURE, THE VEHICLE WILL ALSO CUT ALL POWER. THIS TYPICALLY HAS HAPPENED ON HARD ACCELERATION ONTO A HIGHWAY, BEING EQUALLY DANGEROUS TO DRIVE. THE VEHICLE IS JUST GOING OUT OF WARRANTY AND I HAVE TRIED TO WORK OUT A SOLUTION WITH MERCEDES WHO HAVE NOW STATED I HAVE NO CLAIM. A FINAL FACTOR IS THAT AT ABOUT 10,000 MILES THIS VEHICLE HAD A MASSIVE SHORT THAT LITERALLY MELTED THE BATTERY DOWN. I HAVE SUGGESTED TO MERCEDES THAT THAT INCIDENT, UNDER WARRANTY, MAY HAVE DONE SEROUS HARM TO THE ENTIRE ELECTRICAL SYSTEM/COMPUTERS.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11366869October 28, 2020
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
SEE UPLOADED DOCUMENT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11364340October 14, 2020
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
IN OCTOBER OF 2018 AT 28,860 ODOMETER MILES, THE PASSENGER REAR WHEEL SPEED SENSOR FAILED WHILE DRIVING FROM ATLANTA, GA TO WEST PALM BEACH, FL. CAUSING THE EPS, ABS, ANTI_COLLISION AND CRUISE CONTROL SYSTEM TO STOP FUNCTIONING WITH WARNING MESSAGES DISPLAYED ON THE DASH. I EXPERIENCED ERRATIC SPEEDS WHILE MANUALLY DRIVING HOME. ON OCTOBER 3, 2020, AT 39,214 ODOMETER MILES, THE SAME ISSUE HAPPENED AGAIN, ONLY THIS TIME IT WAS THE FRONT PASSENGER WHEEL SPEED SENSOR THAT FAILED WITH ALL THE SAME WARNING LIGHTS AND DISABLED EPS, ABS, ANTI-COLLISION AND CRUISE CONTROL SYSTEMS BEING SHUT DOWN. IN BOTH CASES THE FAILED SENSORS WERE REPLACED UNDER THE MERCEDES-BENZ EMISSION WARRANTY. I AM VERY CONCERNED THAT THESE FAILURES ARE COMMON WITH THIS MODEL VEHICLE AND I WILL CONTINUE TO EXPERIENCE FAILURES OF THESE SENSORS AFTER THE WARRANTY EXPIRES. I HAVE REPLACED TWO OF THEM SO FAR WITH LESS THAN 40,000 MILES ON THE VEHICLE AND THERE ARE STILL TWO MORE ORIGINAL SENSORS YET TO FAIL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11363787October 11, 2020
ELECTRONIC STABILITY CONTROL (ESC), POWER TRAIN, VEHICLE SPEED CONTROL
THIS IS A WINNEBAGO VIEW 24G ON SPRINTER 3500 CHASSIS. WHILE HIGHWAY DRIVING, SUDDEN ABS AND ESP WARNING LIGHT WITH MESSAGE TO GO TO WORKSHOP. CRUISE CONTROL STOPS WORKING. LOSS OF POWER AND SHIFTING ABILITY IS INTERMITTENT. WAS ABLE TO DRIVE (WITHOUT CRUISE CONTROL AND WITH WARNING LIGHTS ON) FOR 100+ MILES TO SHOP. WHEN LOSS OF POWER OCCURED, I WOULD PULL OFF THE ROAD AND TURN OFF ENGINE, AND THIS WOULD TYPICALLY RESOLVE THE PROBLEM FOR AWHILE SPRINTER AUTHORIZED SERVICE CENTER REPLACED BOTH REAR WHEEL RPM SENSORS 7/3/20 ($581.09). SAME CONDITION RE-APPEARED DURING SIMILAR DRIVING CONDITION. SAME SPRINTER DEALER REPLACED RIGHT FRONT WHEEL SPEED SENSOR TO RESOLVE THE PROBLEM ON 8/18/20 ($507.48).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11362556October 3, 2020
VEHICLE SPEED CONTROL
ON 10/15/2018 WHILE DRIVING THE VEHICLE I BEGAN EXPERIENCING FLUCTUATIONS IN SPEED, WHAT FELT TO BE AT TIMES A SLIPPING TRANSMISSION, DIFFICULTY BREAKING, AND INEXPLICABLE WARNINGS ON MY DASH MESSAGE BOARD, AND A FEELING OF A LOSS OF CONTROL OF THE VEHICLE. I HAD THE VEHICLE TOWED FROM TUNICA, MS. TO MEMPHIS, TN. TO TAG TRUCK CENTER, A CERTIFIED REPAIR CENTER FOR SPRINTERS, WHERE THEY DIAGNOSED A FAULT IN THE RIGHT REAR WHEEL SPEED SENSOR. THEY REPLACED THE RPM SENSOR. THE COST FOR THE REPAIR WAS $494.20. AT THE TIME I HAD 23,029 MILES ON THE VEHICLE, BUT THE REPAIR WAS NOT COVERED BY A VEHICLE WARRANTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11349032August 13, 2020
STRUCTURE:BODY, SUSPENSION
TL* THE CONTACT OWNS A 2016 THOR SIESTA INSTALLED ON A 2015 MERCEDES BENZ SPRINTER 3500 CHASSIS. THE CONTACT STATED THAT UPON APPROACHING A STOP, THE CONTACT HEARD A LOUD ABNORMAL GRATING NOISE. UPON INSPECTION, THE CONTACT NOTICED THAT THE RECEIVER HITCH THAT WAS ATTACHED TO A BAR HAD FRACTURED FROM THE CHASSIS. THE TOW BAR WAS STILL ATTACHED TO THE RECEIVER HITCH HOWEVER, DUE TO THE FAILURE, THE TOW BAR WAS DRAGGING ON THE ROAD. THE SAFETY CABLE FROM THE TOW BAR WAS ALSO NO LONGER ATTACHED TO THE VEHICLE. THERE WERE NO WARNING LIGHTS ILLUMINATED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 31,842.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11342464July 31, 2020
ELECTRONIC STABILITY CONTROL (ESC)
WHILE GOING UPHILL AT ABOUT 50 MPH ON A HIGHWAY THE VEHICLE DID A HARD DOWNSHIFT AND THREE ENGINE LIGHTS CAME ON,ESP,ABS&ASR . I STOPPED AND CHECK TIRES AND AIR PRESSURE ALL OK. AT TIMES THE ENGINE WOULD BUCK, THEN SPEED UP. TURNED OFF ENGINE THEN STARTED IT AGAIN. I WAS ABLE TO DRIVE ABOUT 50 MILES TO MERCEDES DEALER WHO DIAGNOSED AS THE REAR AXEL SPEED SENSORS FAILURE. MEDFORD MERCEDES-BENZ REPLACED BOTH REAR REAL AXEL SPEED SENSORS (VEHICLE MILEAGE 27907) COST $909.00. VEHICLE WARRANTY ON SPEED SENSOR IS 5 YR OR 100,000 MILES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11325693May 24, 2020
ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL, WHEELS
I'M EXPERIENCING WHEEL SPEED SENSOR MALFUNCTION AND FAILURE AT INTERSTATE HIGHWAY SPEED. IT'S HAPPENED APPROX 10 TIMES. ONCE WHEN ENCOUNTERING A DIP IN THE ROAD. ONCE IN HEAVY CROSS WINDS. AND LASTLY WHEN PASSING AN 18 WHEELER. UPON MALFUNCTION, MY CAMPER LOOSES POWER DUE TO CRUISE CONTROL DROPPING OUT. THIS PUT ME IN UNSAFE CONDITION PASSING 18 WHEELER. FIRST FAILURE WAS ON I-8 IN REMOTE COUNTRY. I MADE IT TO SAFE AREA BUT WAS VERY STRESSED. FAULT CLEARED AFTER RESTARTING MY ENGINE. NEXT EVENT WAS IN COLORADO IN AUGUST 2019. IN HEAVY CROSSWIND ON INTERSTATE SYSTEM CODED 'WHEEL SPIN, LOSS OF TRACTION.' MULTIPLE TIMES I STOPPED, KILLED ENGINE, BUT CODES DIDN'T CLEAR. UPON LEAVING CAMP IT CODED ADDITIONAL ABS FAILURE. THIS RESULTED IN BREAKDOWN. VEHICLE BECAME ERRATIC JERKING AND LURCHING. I CALLED MERCEDES AND WAS TOWED 250 MILES TO DEALER IN LITTLETON CO. RIGHT REAR WHEEL SPEED SENSOR REPLACED. LASTLY THIS HAPPEN AGAIN TWO DAYS AGO ON I-20 IN LOUISIANA. WHILE PASSING AN 18 WHEELER MY SPRINTER CODED 'WHEEL SPIN, VEHICLE SKID'.' IMMEDIATE LOSS OF CRUISE CONTROL CAUSED LOSS OF SPEED. THE LARGE TRUCK SPED BY ME IN THE INSIDE LANE BUFFETING ME BADLY! I MAINTAINED CONTROL BUT THIS WAS UNSAFE FOR MYSELF AND THE TRUCK DRIVER! UPON GETTING OFF INTERSTATE I GOT ABS CODE WITH VEHICLE STUCK IN LOW GEAR (COMPUTER GENERATED RESPONSE).MERCEDES HAS ONCE AGAIN TOWED MY SPRINTER TO DEALER FOR REPAIR. ALL SAID THESE SENSORS ARE NOT FIT FOR PURPOSE. THEIR FAILURES AT HIGHWAY SPEED PUT OPERATORS AT RISK. THIS RUINS CONSUMERS PLANS.IT PUTS US UNSAFELY ON THE SIDE OF THE ROAD WAITING ON TOW TRUCKS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11320295April 6, 2020
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
WHILE DRIVING OUR 2015 MERCEDES SPRINTER 3500 ON I-5 SOUTH FROM OAKLAND, CA TO JOSHUA TREE NATIONAL PARK ON THURSDAY, MARCH 19 SUDDENLY OUR SPEED CONTROL QUIT FUNCTIONING AND THE ABS, ESP AND TRACTION CONTROL LIGHTS ON OUR INSTRUMENT PANEL LIGHTED UP. WE IMMEDIATELY CALLED A MERCEDES BENZ SERVICE DEPARTMENT IN BAKERSFIELD, CA AND WERE TOLD THAT AS LONG AS THE VAN SEEMED TO BE DRIVING , BRAKING AND HANDLING NORMALLY WE DID NOT NEED TO BRING IT IN FOR SERVICE BUT COULD CONTINUE DRIVING. THE VAN DID SEEM TO BE RUNNING NORMALLY SO WE DROVE ON WITHOUT SPEED CONTROL. ABOUT 400 MILES LATER AS WE WERE DRIVING INTO JOSHUA TREE NATIONAL PARK THE BRAKES STARTED TO MAKE A LOUD CLICKING NOISE WHEN THE PEDAL WAS DEPRESSED COMPLETELY AND THE TRANSMISSION WOULD NO LONGER SHIFT OUT OF 2ND GEAR MAKING IT IMPOSSIBLE TO DRIVE OVER 30 MPH. WE HAD TO HAVE THE VAN TOWED 46 MILES BACK TO PALM SPRINGS, CA AND AWAIT THE MERCEDES BENZ SERVICE DEPARTMENT THERE OPENING ON MONDAY, MARCH 23. AT THE SERVICE DEPARTMENT THEY DIAGNOSED THE REAR WHEEL SPEED SENSORS HAD FAILED WITH ONLY 48,271 MILES ON THE ODOMETER. THE FOLLOWING DAY THEY REPLACED THE REAR WHEEL SPEED SENSORS AND THE VAN WAS RUNNING NORMALLY AGAIN. I HAVE RESEARCHED THE PROBLEM WITH THE WHEEL SPEED SENSORS ON MERCEDES BENZ SPRINTER VANS. IT SEEMS TO BE A COMMON PROBLEM AT LEAST FROM THE YEAR 2013-2016. IT IS UNACCEPTABLE THAT A VAN THAT MERCEDES PROMOTES FOR ITS UTILITY HAS THIS KIND OF FAILURE COMMONLY. IT IS A SIGNIFICANT SAFETY ISSUE. WE WERE DRIVING ON DRY PAVEMENT SO NOTICED NO PROBLEM WITH PERFORMANCE UNTIL THE BRAKES BEGAN TO MALFUNCTION AND THE VAN WOULD NOT SHIFT ABOVE 2ND GEAR. IF WE HAD BEEN ON WET OR SLICK ROADS THE LACK OF ANTI-LOCK BRAKES, TRACTION CONTROL AND ELECTRONIC STABILITY CONTROL WOULD HAVE MADE THE VAN DANGEROUS TO DRIVE. MERCEDES BENZ NEEDS TO DO SOMETHING TO REMEDY THIS COMMON FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11310621February 21, 2020
ELECTRONIC STABILITY CONTROL (ESC)
THIS IS THE SECOND TIME THE RPM SPEED SENSORS HAVE NEEDED TO BE REPLACED ON MY 2016, 3500 MERCEDES SPRINTER
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11278213November 5, 2019
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING
TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ SPRINTER 2500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SURGED AND THE ANTI-SKID AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF MELBOURNE (509 E NASA BLVD, MELBOURNE, FL 32901) WHERE IT WAS DIAGNOSED THAT THE WHEEL SPEED SENSOR WAS DEFECTIVE. THE SENSOR WAS REPLACED. THE CONTACT STATED THAT ALL FOUR WHEEL SENSORS WERE REPLACED WITHIN THE LAST YEAR. THE REPAIRS WOULD LAST APPROXIMATELY FIVE MONTHS BEFORE THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED 10% OFF THE REPAIR COST. THE CONTACT STATED THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 12,000. *PM CONSUMER STATES THAT VEHICLE IS UNSAFE TO DRIVE IN RAIN OR ON WET ROADS. *DL
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11253828September 7, 2019
SERVICE BRAKES
WHILE DRIVING, THREE WARNING LIGHTS ILLUMINATED ADVISING I HAD LOST MY ABS AND MY CRUISE CONTROL FAILED. THE VEHICLE SOON WENT INTO LIMP MODE. BOTH REAR WHEEL ABS SPEED SENSORS FAILED AND WERE REPLACED BY A MERCEDES SPRINTER DEALER. I SOON DISCOVERED THIS IS A VERY COMMON FAILURE. THE VEHICLE ONLY HAD 32000 MILES ON IT WHEN THE PROBLEM OCCURRED. THE SERVICE AGENT SAID IT WAS A VERY COMMON PROBLEM ON THE SPRINTER RV VEHICLES. I FEEL MERCEDES SHOULD FIX THE PROBLEM AS IT IS AN INHERENT SAFETY PROBLEM FOR THESE VEHICLES. I WAS TRAVELING 65 MPH ON AN INTERSTATE HIGHWAY WITH CRUISE CONTROL ENGAGED WHEN THE PROBLEM OCCURRED. THIS COULD HAVE BEEN A SAFETY ISSUE HAD I NEEDED THE BRAKES AT THAT MOMENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11253423September 5, 2019
PARKING BRAKE
TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ SPRINTER 2500. WHILE PARKING ON A HILL WITH THE EMERGENCY BRAKE APPLIED, THE BRAKE FAILED AND THE VEHICLE STRUCK A CURB IN REVERSE. THERE WERE NO WARNING INDICATORS ILLUMINATED. AT A LATER DATE, WHILE DRIVING 35 MPH, THE CONTACT HEARD AN ABNORMAL NOISE AND THE REAR WHEELS SEIZED. THE CONTACT WAS ABLE TO PARK THE VEHICLE ON THE SIDE THE ROAD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF HANOVER (LOCATED AT 1877 WASHINGTON ST, HANOVER, MA 02339, (781) 924-4200) WHERE IT WAS DIAGNOSED THAT A SPRING HAD FRACTURED AND THE EMERGENCY BRAKE ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 69,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11233973July 22, 2019
AIR BAGS
TAKATA RECALL: MERCEDES ADVISED ME THAT THE REPLACEMENT AIRBAGS FOR PASSENGER SIDE MAY NOT BE READY UNTIL 2020. THIS IS UNACCEPTABLE. THEREFORE THIS IS MY FORMAL COMPLAINT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11228437June 29, 2019
UNKNOWN OR OTHER
MY AIR CONDITIONING SYSTEM WENT OUT AT 90K IT'S A VERY COMMON PROBLEM FOR THIS VEHICLE ACCORDING TO MY MECHANIC. THE AC COMPRESSOR STOPPED WORKING CAUSING A $3000 BILL THEN TO MAKE MATTERS WORSE THE NEW ONE BROKE DOWN 1Y LATER THEN THEN 2ND ONE BROKE AFTER JUST 3 MONTHS OF BEING ISOLATED. NOW THE 3RD ONE IS OUT AND THEN WARRANTY WON'T COVER IT BECAUSE IT WAS ONLY FOR 2Y . I'M SO FRUSTRATED ABOUT MERCEDES NOT ISSUWING A RECALL OR SOMETHING THAT WILL HELP OWNERS LIKE ME OF BEEN STUCK WITH A HUGE REPAIR BILL AND FRUSTRATION
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mercedes-Benz Sprinter