Mercedes-Benz Sprinter Complaints (2014)

71 consumer complaints on file.

#11771725October 16, 2026
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
The contact owns a 2014 Mercedes-Benz Sprinter 3500. The contact stated that while driving at an undisclosed speed, the front exhaust pipe, including the catalytic converter, failed. A flow of unmitigated exhaust gas incinerated the wiring and fuel lines during operation. The dealer was contacted. The manufacturer was notified of the failure by telephone. The failure mileage was approximately 181,810.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629637December 9, 2024
ENGINE
The contact owned a 2014 Mercedes-Benz Sprinter 2500. The contact stated while driving at an undisclosed speed, a loud pop was heard, and noticed there was smoke coming from the engine with the check engine warning light illuminated. The contact was a Sprinter van driver. The contact pulled the vehicle over and had the passengers located in the vehicle exit the vehicle. The contact stated that the engine had caught on fire. The vehicle was extinguished by the Fire Department. A fire report was not filed, however, the cause for the failure was not yet determined. A police report was not filed. No injuries were sustained. The vehicle was towed to an independent mechanic. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 131,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11519224April 27, 2023
ENGINE
The contact 2014 Mercedes-Benz Sprinter 2500. The contact stated that the vehicle lost motive power while driving approximately 65 MPH. The check engine warning light was illuminated. The vehicle veered to the side of the roadway. The vehicle was able to be restarted; however, while the accelerator pedal was depressed, the vehicle failed to properly accelerate. The vehicle was towed to a dealer where it was diagnosed that the ECU computer needed to be replaced. On another occasion, while driving approximately 45 MPH, and the accelerator pedal was depressed but the vehicle did not accelerate as designed. Additionally, the contact stated that there was a whooshing sound coming from the vehicle, with the check engine warning light illuminated. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the turbo, wastegate, and control unit needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 177,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505086February 2, 2023
ENGINE, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, VEHICLE SPEED CONTROL
THE FOLLOWING HAS BEEN SENT TO MERCEDES CORPORATE CUSTOMER SERVICE All of the following has started happening since an exhaust recall was done by Mercedes. In September 2022, we were driving cross country to Denver Colorado and enough codes piled up in the background that we went into limp mode in the middle of 70 MPH highway traffic. This happened without warning and was an extreme safety concern. But I was lucky to be near an exit and already in the right lane. I reset these codes and finished going to Denver the next day. The two Sprinter dealers in Denver were backlogged several weeks; so we spent over $600 trying to troubleshoot the issues with Colorado Fleetworks, a qualified Sprinter specialist. He checked codes too; ran other diagnostics; replaced the fuel filter and air filter even though they had been done only 10,000 miles earlier; and performed a forced DPF regeneration. He also replaced the DPF pressure sensor. This work did not help change the daily multiple code problems. We had to reset them every day coming back from our trip. When we returned home we took it to the dealer. They confirmed the codes, reset them, and test drove it 25 miles. Since codes didn't return, they said, "There is nothing we can do if we don't witness active codes." I said, "How active do they have to be? I will have codes in the next 20 to 30 miles like I do every day I drive it." These never happened in the 6 years prior to the recall wok. Either the programming is confused, some of the new sensors are faulty, or something. A totally separate problem is the faulty factory crimps on the connector of the rail pressure sensor. This is a known defect; and we've had the exact same symptoms and code as noted in Xentry TSB MC-10135520-9999. The engine has actually cut off when turning into traffic a few times. This is an extreme safety concern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11437380October 19, 2021
ENGINE
The contact owns a 2014 Mercedes-Benz Sprinter 2500. The contact stated while driving at 35-40 MPH, he saw smoke coming from underneath the hood of the vehicle. There were no warning lights illuminated. The contact stated as he veered to the side of the road, the vehicle inadvertently stalled. The vehicle was towed to the dealer who informed the contact that they were unable to diagnose the vehicle. Then the vehicle was towed to the independent mechanic who diagnosed that the engine needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 200,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11430678August 26, 2021
SERVICE BRAKES
received a recall for the ESP electronic stability control system inApril 2021, dealership made an appointment for May 2021. Then told me the reaper parts were not available, but would contact me asp, . Today, August 26th I checked to see why no notification, was told thy had the parts, but could not get to my project until later October. I told them that date would not work asm I was driving the vehicle to New York beginning October first. They failed to call me, and now put me at the back of the line for repairs. My notice from your office, dated August and received on the 18th go August suggests the time for repair would be one hour. My problem, related to their failure to notify, is I can not wait till late October. Any help?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11418342May 24, 2021
ELECTRONIC STABILITY CONTROL (ESC)
The contact owns a 2014 Mercedes-Benz Sprinter 3500. The contact stated while driving 60 mph, the rear wheel speed sensor failed causing the transmission to inadvertently downshift. The contact stated that the abs warning light was illuminated. The vehicle was taken to a local dealer to be diagnosed. The mechanic determined that the rear wheel speed sensor needed to be replaced. The vehicle was repaired however, the failure recurred two years later. The contact was relating the failure to NHTSA campaign number: 21V042000 (Electronic Stability Control). The manufacturer was not informed of the failure. The failure mileage was approximately 28,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11404661March 24, 2021
ELECTRICAL SYSTEM, WHEELS
WHEELE SPEED SENSOR PROBLEMS AND NEEDING REPLACED EVERY 3 4 MONTHS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11404424March 23, 2021
ENGINE
THIS VEHICLE, PLUS NUMEROUS OTHER MB MODELS, ARE THE SUBJECT OF AN EMISSIONS LAWSUIT. THERE IS A REMEDY AVAILABLE TO RECTIFY THE ISSUE AND TO QUALIFY THE RESPECTIVE OWNERS TO SOME SIGNIFICANT COMPENSATION. I DISCOVERED THIS BY ACCIDENT ON-LINE. I HAVE NOT BEEN CONTACTED BY MB AND THERE IS NO RECALL FROM NHTSA. MY QUESTION IS WHY ISN'T THERE A NHTSA RECALL? FOR MORE DETAILS, ACCESS THE HAVENS BERGMAN WEBSITE. THEY ARE THE LEAD ATTORNEYS PURSUING THE CASE. REGARDS, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11403082March 15, 2021
VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL (ESC)
TL* THE CONTACT OWNS A 2014 MERCEDES-BENZ SPRINTER 3500. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE SURGED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE AND THE VEHICLE DROVE AS DESIGNED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21V042000 (ELECTRONIC STABILITY CONTROL) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE VEHICLE WAS TAKEN TO SEVERAL UNKNOWN LOCAL DEALERS TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE REAR WHEEL SPEED SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER THE FAILURE RECURRED. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 15,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11398890March 3, 2021
VEHICLE SPEED CONTROL, WHEELS, LANE DEPARTURE: BLIND SPOT DETECTION
WHEEL SPEED SENSOR ON VEHICLE HAS MALFUNCTIONED MULTIPLE TIMES. WHEN SPEED SENSOR MALFUNCTIONS THE VEHICLE SPEED SURGES AND OPERATES ERRATICALLY ON ITS OWN. CONDITION HAPPENS WHEN VEHICLE IS IN MOTION. CONDITIONS HAPPEN AT DIFFERENT SPEEDS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387017January 7, 2021
SERVICE BRAKES, ENGINE, VEHICLE SPEED CONTROL
IT STARTED WITH TRANSMISSION NOT SHIFTING, DASH WARNING LIGHTS FLASHING, NO CRUISE CONTROL ALL WHILE IN MOTION
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11383887December 17, 2020
SERVICE BRAKES, VEHICLE SPEED CONTROL, WHEELS
WHEEL SPEED SENSORS MALFUNCTIONING WHILE DRIVING. GOING ON THE THIRD TRIP TO THE DEALER FOR RNR. THIRD FAULT AFTER A COUPLE OF HUNDRED MILES SINCE THE SECOND RNR. MANY INTERNET FORUMS EXPLAIN SAME ISSUES N FRUSTRATIONS. VEH HAS ONLY 13500 MILES, THREE RNRS WITHIN THE 500-1000 MILES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11378630December 9, 2020
UNKNOWN OR OTHER
IN JUNE OF 2020 THIS VEHICLE CAUGHT ON FIRE, ORIGINATING IN THE ENGINE COMPARTMENT ACCORDING TO MY DRIVER. THE VEHICLE WAS A TOTAL LOSS RESULTING IN NO BODILY HARM AND MY INSURANCE COMPANY PAID ME A SETTLEMENT AND IS STILL INVESTIGATING LAST I HEARD. I ALSO HAD TO REPLACE TWO WHEEL SPEED SENSORS OUT OF POCKET THAT MY LOCAL DEALER DIDN'T RECOGNIZE THEY SHOULD HAVE BEEN COVERED UNDER WARRANTY. MY DEALER DID EVENTUALLY ACKNOWLEDGE THEY SHOULD HAVE BEEN COVERED, BUT REFUSE TO REIMBURSE SINCE THEY DIDN'T DO THE WORK.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11375403November 19, 2020
SERVICE BRAKES, ENGINE, VEHICLE SPEED CONTROL
I WAS DRIVING ON THE HIGHWAY DURING RAIN AND 3 MESSAGES DISPLAYED ON THE DASH: 1) ESP (ELECTRONIC STABILITY PROGRAM) VISIT WORKSHOP, 2) ASR (ACCELERATION SLIP REGULATION) ICON VISIT WORKSHOP AND 3) ABS (ANTI-LOCK BRAKING SYSTEM) VISIT WORKSHOP. ALSO RECEIVED COLLISION AVOIDANCE ASSIST INOPERATIVE NOTIFICATION. I PULLED OFF THE HIGHWAY AND EXPERIENCED UNEXPECTED ACCELERATION AND ERRATIC GEAR SHIFTING RESULTING IN EXTREMELY UNSAFE OPERATION. LATER, MERCEDES SERVICE DETERMINED THE LEFT REAR WHEEL SPEED SENSOR WAS THE PROBLEM (SEE ATTACHED). DIAGNOSIS AND FIX WAS $473.99 PLUS TAX. THEY SAID THIS IS A COMMON PROBLEM WITH SPRINTERS ESPECIALLY IF UPLIFTED TO RV. I UNDERSTAND THERE IS AN ONGOING NHTSA INVESTIGATION OF THIS PROBLEM. I STRONGLY BELIEVE THESE WHEEL SPEED SENSORS SHOULD BE RECALLED DUE TO THEIR EFFECT ON ESP, ASR, ABS AND COLLISION AVOIDANCE ASSIST CAUSING UNEXPECTED ACCELERATION AND ERRATIC GEAR SHIFTING WHICH RESULTS IN EXTREMELY UNSAFE OPERATION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11375286November 18, 2020
VEHICLE SPEED CONTROL, WHEELS, LANE DEPARTURE: BLIND SPOT DETECTION
WHILE DRIVING ON INTERSTATE HIGHWAY, THE FOLLOWING WARNING MESSAGES APPEARED: ABS, ESP AND ARS NOT FUNCTIONING AND TAKE TO WORKSHOP. ALSO, THE BLINDSPOT WARNING ON MIRRORS STOPPED WORKING, AS DID THE CRUISE CONTROL. DROVE SEVERAL HOURS TO NEAREST MERCEDES DEALERSHIP WITHOUT THESE SAFETY FEATURES. PROBLEM DIAGNOSED AS RPM SENSOR FAILURE. WAS ADVISED THAT ALTHOUGH ONLY ONE SENSOR FAILED, THEY RECOMMENDED REPLACING BOTH AT THE SAME TIME. AT THE TIME, THE VEHICLE ONLY HAD 40,111 MILES ON ODOMETER, BUT WAS NOT COVERED UNDER WARRANTY. SERVICE ADVISOR STATED THAT SENSOR MAY HAVE GOTTEN HOT, SUGGESTING I HAD DRIVEN WITH EMERGENCY BRAKE ON. I TOOK EXCEPTION TO THIS, AS I RARELY EMPLOY THE E-BRAKE UNLESS I AM ON A VERY STEEP INCLINE, AND HAD NOT USED DURING THIS TRIP. REPAIR COST TOTALED OVER $700. COPY OF BILL ATTACHED. THIS OCCURRED ON SEPTEMBER 8, 2018, AS I WAS BEGINNING A MULTI-STATE TRIP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11365920October 23, 2020
SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
AFTER DRIVING FOR SEVERAL HOURS, THE CRUISE CONTROL WOULD DROP OUT & THE ABS, STABILITY CONTROL & WHEEL SPEED SENSOR LIGHTS WOULD COME ON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11365594October 21, 2020
SERVICE BRAKES
ABS SAFETY FOR OUR 2015 MERCEDES SPRINTER CHASSIS [XXX]. TWO YEARS AGO WE STARTED TO HAVE PROBLEMS WITH OUR ABS BRAKING. TWO DIFFERENT DEALERS SAID THE RIGHT REAR SENSOR IS DEFECTIVE. THEY WERE CHANGED BUT PROBLEM RETURNED. WE ARE CONCERNED ABOUT OUR SAFETY NOT HAVING BRAKES THAT SHOULD WORK ACCORDING TO THE MANUFACTURE. WITH OUT ABS THE CRUISE CONTROL DOES NOT WORK EITHER. THANK YOU FOR ANY HELP. NOTE; THE MANY FRUSTRATED OWNERS DISCUSSIONS ON THE INTERNET ABOUT THIS PROBLEM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11360999September 24, 2020
ELECTRONIC STABILITY CONTROL (ESC)
POWER STEERING WENT OUT AND CAR CRASHED. MERCEDES BENZ WALNUT CREEK CALIFORNIA REFUSED FREE REPAIR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11355724September 18, 2020
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
VEHICLE WAS DRIVEN ABOUT 5 MILES, PARKED AND NOT RUNNING, ABOUT 2.5HRS LATER FIRE STARTED ON THE LEFT REAR SIDE / UNDERCARRIAGE. FUEL TANK CAUGHT FIRE. NO PRIOR RUNNING DEFECTS. STARTING POINT FOR THE FIRE APPEARS AT OR NEXT TO FUEL TANK ON THE LEFT SIDE WITH THE FIRST FLAMES VISIBLE UP THE LEFT REAR WHEEL HOUSING WITH THE VEHICLE PARKED ON A SLIGHT INCLINE AND THIS ETCHED IN AN ARC SHAPE ABOVE THE LEFT REAR WHEEL. INSIDE VEHICLE NO PERSONAL ITEMS OR AFTERMARKET MODIFICATIONS. FIRE SPOTTED APPROXIMATELY 3:15 - 3:17 EASTERN TIME, WEATHER TEMPS IN MID 70S. THIS WAS A HIGH TOP 12 PASSENGER MODEL 144" WHEELBASE WITH AUXILIARY AIR AND HEAT OPTIONS. NO OCCUPANTS AND NO INJURIES.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0

← Back to Mercedes-Benz Sprinter