Kia Sorento Complaints (2025)

136 consumer complaints on file.

#11757326August 16, 2026
VEHICLE SPEED CONTROL, UNKNOWN OR OTHER, ELECTRICAL SYSTEM
The dashboard has a screen display. I couldn’t see my fuel tank information. Every time I would use my turn signal a large green circle would take over the screen. Followed by loss of the screen, meaning no speedometer, rpm, etc. As the problem continued the speedometer started displaying incorrect numbers. Saying I was going 70 miles an hour when I was actually going about 55. Gage for fuel and heat (notifying if car is overheating, was lost for the entirety of my drive).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756660August 13, 2026
ENGINE, POWER TRAIN
The contact owns a 2025 Kia Sorento. The contact stated that while driving approximately 75 MPH, the vehicle lost drive power. The vehicle decelerated and was coasted over to the side of the road. The contact stated that several unknown warning lights flashed on the instrument panel while the vehicle was decelerating. While on the side of the road, the check engine warning light remained illuminated. Additionally, the message "Hybrid Power Control Unit" was displayed. The vehicle was towed to the dealer but was not diagnosed because the dealer was unable to reproduce the failure. The vehicle was not repaired. The contact stated that while the dealer was attempting to duplicate the failure, the vehicle was not being driven at highway speeds like when the failure had occurred. The manufacturer was made aware of the issue, and a case was opened. The failure mileage was approximately 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755773August 9, 2026
UNKNOWN OR OTHER
My rear windshield exploded out when back door was closed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755646August 8, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
I am writing to report a safety concern with my 2025 Kia Sorento plug-in hybrid. On multiple occasions, after starting the vehicle, the instrument panel appears normal, but the vehicle does not enter the ready state. The ready indicator does not illuminate and the vehicle will not shift into drive or reverse. The vehicle will however, unfortunately, shift into neutral and roll, but with no power. The only way to restore normal operation is to completely turn the vehicle off and restart it. This intermittent condition creates a safety concern because it can leave the vehicle unexpectedly immobilized, with no power, and allow the vehicle to move/roll with no control. I respectfully request that Kia investigate this issue for a possible software or hybrid control defect. Please document my report and inform me of any software updates, improvements or service recalls.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755517August 7, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2025 Kia Sorento. The contact stated that on two occasions while driving 70 MPH, the vehicle lost automotive power and the message "Hybrid System Failure" was displayed. The vehicle was pulled over to the side of the road, turned off, and restarted, but the failure persisted, and the vehicle failed to accelerate above 20 MPH. The vehicle was taken to a dealer where it was diagnosed that the fuel pump needed to be replaced. The vehicle was repaired, but the failure reoccurred a week later. The vehicle was taken to another dealer where the failure could not be duplicated. The manufacturer was notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754281August 2, 2026
ENGINE, POWER TRAIN
The engine sputters several times in a single trip, and is available upon request. The engine sputtered and the vehicle stopped in the middle of the road as I was trying to cross 2 lanes of traffic. It has sputtered so bad, I almost rear ended the vehicle in front of me. Yes, the dealership confirmed via text on 7/13/2026. The dealership confirmed it occurred then insisted on my picking up the vehicle despite of that. No effort to fix or determine why that was happening. I was told “the vehicle is learning how I drive, the road was bumpy, and the manufacturer would need more than to cover it” The dealerships invoice to the manufacturer stated “no sputtering” even after acknowledging in writing that it occurred and refused to change the paperwork. The dealership also reset the data and that it “could” resolve everything. If there’s nothing wrong with the vehicle, why would it need to be reset? The manufacturer has been called twice regarding the sputtering issue. No warning lights. Started in 10/2025 the dealership was made aware several times with several appointments and refused to look at the vehicle until the manufacturer contacted them in July.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752370July 23, 2026
UNKNOWN OR OTHER
On [XXX], at approximately [XXX], I attempted to replace a flat tire on my 2025 Kia Sorento while the vehicle was parked on a flat, firm paved surface. I used the factory-supplied emergency scissor jack, rated at 1,200 kg or 2,645.5 lbs. and placed it at the designated factory pinch-weld jacking point. The plugin hybrid Kia Sorrento has a curb weight of over 4000 lbs which is more than the rated weight of the Kia supplied car jack. This is extremely irresponsible and dangerous. While raising the vehicle only enough to remove and replace the tire, the jack’s structural frame buckled, bent, and popped out from under the vehicle causing the vehicle suddenly fall back to the ground. While no one was hurt in the incident someone could have been injured or killed by the falling vehicle or by the car jack which popped out from under the car as it was crushed. In this instance, no one was underneath the vehicle, and no injury occurred although it would have been very easy for this to have resulted in serious injury or death if the jack failure occurred while the tire was removed or a tire iron engaged during the failure. I feel fortunate to not have been seriously injured. There was no visible deformations or other symptoms before the failure. The problem was not reproduced because the jack sustained permanent structural damage and could not safely be used again. The vehicle and failed jack were inspected by Serramonte Kia, 600 Serramonte Boulevard, Colma, CA 94014, on [XXX], at approximately [XXX]. The failed jack has been retained and is available for inspection upon request. Photographs and dealership documentation are also available. Because Kia supplied this jack specifically for emergency tire changes on this vehicle, and it failed during its intended use under proper conditions, I request investigation into whether the jack has inadequate structural strength or design margin, defective materials or manufacturing, or another safety defect INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751110July 17, 2026
POWER TRAIN, ENGINE
The contact owns a 2025 Kia Sorento. The contact stated that while driving approximately 75 MPH, the vehicle lost automotive power and failed to exceed 30 MPH. The contact pulled over to the side of the road to avoid other vehicles. No warning lights were illuminated. The vehicle was towed to a dealer to be diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 16,386.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749335July 9, 2026
ENGINE
The contact owns a 2025 Kia Sorento Hybrid. The contact stated that while driving at approximately 55 MPH, the vehicle suddenly decelerated and failed to exceed 35 MPH before stalling and losing power. Emergency services were contacted and assisted with pushing the vehicle to the side of the road. The vehicle was towed to a dealer, who held the vehicle for two days but had not diagnosed the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 11,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748874July 7, 2026
ELECTRICAL SYSTEM
Wireless cell phone charging pad causes phone to overheat. I have tried other vehicles (Ford Explorer) and this had no detrimental effect on cell phone. As well as heating the cell phone (Apple iPhone 16) it also doesn’t charge the phone. I have also tried other cell phones (Apple iPhone 16 and 14) and same issues were presented. The safety issue is the inability to charge the cell phone reliably as well as the very hot condition caused to the cell phone. I purchased this vehicle new in July 2025 and I realized the issue almost immediately. I did let my Kia service department know of this and was told at the time that this is very common and that a recall (repair) would likely be available soon. To be best of my knowledge this hasn’t happened. The only reason I am bringing it up now is that my son in law (the Ford Explorer) mentioned that he utilizes his with no problem. Thank you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748424July 6, 2026
ELECTRICAL SYSTEM
Hybrid Control Unit failure was the fault that came up on the screen. 3rd time within 3 months now. The HCU was just replaced a week ago at the KIA dealership and the vehicle is only 1 year old. This left my wife stranded on the side of a busy highway in 100 degree temps over the 4th of July holiday.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748461July 6, 2026
UNKNOWN OR OTHER
1st incident: Vehicle was unable to accelerate when attempting to speed up on freeway entrance ramp- high RPMs while continuing to decelerate and eventually vehicle would not move at all anymore. The driver assist system continued to activate the brakes due to high RPMs even though the vehicle could not accelerate. Very unsafe driving conditions on a busy freeway as the car could not go faster than 30 mph, and eventually stalled out completely. Vehicle brought to dealership and replaced fuel pump as they said there was a leak found. 2nd incident: Vehicle was unable to accelerate when attempting to speed up on freeway entrance ramp- high RPMs while continuing to decelerate. Driver assist was turned off in this instance. Car currently still at dealership, as they have so far been unable to identify the problem. Both incidents created very unsafe driving conditions, as the freeway speed limit is 75 mph and my car was unable to go over 30 mph despite fully depressing the gas pedal and having plenty of gas in the tank. Both instances occurred when the hybrid battery was low (<15%).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748306July 4, 2026
FUEL/PROPULSION SYSTEM
I purchased a 2025 Kia Sorento Hybrid from Dulles Kia. Since I've owned it, I've had the same problem three times — my car randomly goes into limp mode while I'm driving. It doesn't matter what speed I'm going. The car just starts slowing down on its own, won't let me accelerate, and the RPMs start surging up and down. It's terrifying. The first time it happened, it was towed to Fayetteville Kia. They couldn't even recreate the problem. They redownloaded some software and sent me on my way. The second time it happened, it was taken to Herson's Kia in Rockville. This time they were able to recreate it. They told me it was the fuel pump and replaced it under warranty. Now it's happened again — this time while I was on vacation in Ocean City, Maryland. I was stranded with my two dogs, one of which is my service animal. I had to arrange a tow and find a last-minute hotel out of pocket. The car is currently at Pohanka Kia in Salisbury. They first told me it was a fuel injector, then changed their diagnosis to a valve seal issue — and apparently it's a known issue with this type of vehicle. It has now been sitting at the dealership for over a week. This is the third time the same problem has occurred. It has ruined multiple vacations and left me stranded, stressed, and without my car for extended periods. I just want a car that works.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747831July 1, 2026
POWER TRAIN
The transmission is not shifting gears correctly. The engine revs loudly and hesitates for a few seconds before shifting. There were no warning lamps. The vehicle has not been inspected yet. This causes a dangerous situation when driving and accelerating in traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747203June 29, 2026
COMMUNICATION: AUTO CRASH NOTIFICATION, ELECTRICAL SYSTEM
The contact owns a 2025 Kia Sorento. The contact stated the messages "Take A Coffee Break" and "Hands on Steering Wheel" consistently illuminated while driving. The vehicle was taken to the dealer, who stated that there was no issue with the vehicle. While driving approximately 60 - 70 MPH, the Forward Collision Avoidance system activated, causing the vehicle to swerve towards the right, and the brakes activated. The contact manually turned the steering wheel and depressed the accelerator pedal to continue driving. The vehicle was returned to the dealer; however, the dealer was unable to determine the cause of the failure because there was no data on the EDR. The dealer rebooted the software; however, 23 days later, the failure reoccurred. The vehicle was returned to the dealer, and the contact was informed that the software was updated. The vehicle had not been driven since the second software update. The manufacturer was informed of the failure. The contact opened a case with the Better Business Bureau. The failure mileage was 293.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746457June 25, 2026
ENGINE, POWER TRAIN, FUEL/PROPULSION SYSTEM
For an unknown reason when driving on the highway in heavy traffic the engine started to shake violently causing us to immediately pull over and when we opened the hood the engine was shaking violently. This was a dangerous situation because during this time the engine was not very responsive to input. No warning lights came on at all.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746569June 25, 2026
UNKNOWN OR OTHER
Warning lights on while driving. The emergency triangle, collison warning, break warning, both turn signals, and departure warning lights were illuminated. We were concerned of causing damage to the vehicle and pulled over. Dealer knows of issues in CA and AZ with other Sorentos. Dealer said it is due to camera overheating; the camera housing is metal and therefore causes this issue. No known fix and we are apprehesive to drive it. KIA customer care had no information and only said to go to dealer when lights are on so a code can be pulled. I believe the housings need to be replaced if that is the case and if there is a true issue with the vehicle I cannot distignuish between "camera" or mechanical when lights come on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746296June 24, 2026
UNKNOWN OR OTHER
My sunroof exploded.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744877June 17, 2026
FUEL/PROPULSION SYSTEM
My 2025 Kia Sorento Hybrid, with approximately 20,000 miles, has experienced a sudden loss of power and entered a limp-mode condition twice within two days. During both incidents, the vehicle would not accelerate normally and was unable to maintain expected traffic speed, creating a significant safety hazard. No warning lights, warning messages, or check-engine light appeared before or during either event. After the incidents, no OBD-II diagnostic trouble codes were present. Stopping and starting the vehicle restored normal operation temporarily, but the problem reoccurred. The sudden and unexplained loss of propulsion without any warning or stored fault codes increases the risk of a crash, particularly when merging, passing, or driving in traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744327June 15, 2026
ENGINE, FUEL/PROPULSION SYSTEM
Around XXX the car was suddenly unable to accelerate properly. When pushing the accelerator, the engine would rev only after a long lag, would rev significantly higher than normal without shifting, and the acceleration response was dramatically less than usual. It felt as if the engine simply had no power, or at times almost as if something were resisting the engine. It made it nearly impossible to accelerate past roughly 40mph and the response in acceleration from the pedal was very unpredictable. A mechanic was able to replicate the issue and it was initially attributed to the high pressure fuel pump. Roughly a week after the pump was replaced in early August 2024, the issue occurred again and was again replicated by the dealer and attributed to the fuel sensor, which was replaced. The issue then re-occurred on June 14, 2026. The car is currently in the shop awaiting diagnosis and repair. At no point during any of these instances did any warning appear on the dashboard or anywhere else in the car. The parts are not available for inspection, it is unclear to me who from Kia or any other organization has examined them beyond the dealership (Kia of Riverdale in Riverdale, NJ). The safety of the car’s occupants and potentially other motorists was put at risk by acceleration performing radically differently than would be anticipated from a properly functioning car. The issue was noted several times, including while pulling out of a parking lot onto a busy road and while attempting to keep up with traffic on a busy divided highway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sorento