Hyundai Tucson Complaints (2022)

374 consumer complaints on file.

#11759767August 26, 2026
FUEL/PROPULSION SYSTEM
Fuel injector went bad causing vehicle engine to misfire and shake rapidly. Check engine light is on. The vehicle only has 40,000 miles on it. Seems to be a very common concern for this make and model and roughly the same years. Will not accelerate instantly and will surge a bit when it does. Will still shake when the vehicle is idle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759644August 26, 2026
UNKNOWN OR OTHER
On August 26, 2026, while driving to work, my 2022 Hyundai Tucson unexpectedly lost power and shut down while the vehicle was being driven. This created a serious safety concern because the vehicle became inoperable while in traffic. This vehicle has had a history of repeated problems and has been taken to Hyundai dealerships for repairs on numerous occasions. Despite these previous dealership visits and repair attempts, the vehicle continues to experience problems. The latest incident, in which the vehicle shut down while being driven, has significantly increased my concern regarding the safety and reliability of the vehicle. The vehicle is being made available for inspection and diagnosis. At this time, the exact component or cause of the failure is unknown. I am requesting that this complaint be documented because of the sudden loss of power while driving and the vehicle's history of repeated dealership visits and repairs. I am concerned that this condition could cause a crash if the vehicle unexpectedly loses power again while traveling in traffic or at highway speeds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759064August 24, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My wife was driving my SUV while I was a passenger. We were in the left lane, and put the left turn signal on while traveling south bound approaching an intersection to take a left turn (traveling approximately 3-5 Miles Per Hour and slowing) at the traffic light (traffic light was green). There was a car in front of us that had stopped waiting for oncoming traffic to clear and make the same left turn onto the same road as us. While traveling in this lane we hit a deep pot hole (not very visible while driving), just as we were approaching the vehicle stopped in front of us. When hitting the pot hole, our SUV seemed to leap forward a bit and when the brakes were applied to slow and stop, the braking system failed (appeared to freeze) and the brakes did not work, and because the braking didn’t work, our vehicle hit the car in front of us. Prior to and after hitting the pothole, no audible warning sounds or visible alerts appeared and no emergency braking was activated. The airbags in our vehicle never deployed. Our safety (my wife and I) as well as the safety of the 2 passengers in the other vehicle were at risk as we all could have been injured in the accident. As we needed the vehicle for transportation, we immediately began filing all the necessary police and insurance reports and brought our vehicle into an Auto Body Repair Shop to be repaired the next day. During the repair work, some of the responsible components may or may not have been replaced and the Auto Body Repair Shop also had all the car sensors recalibrated by a 3rd party, which is why we did not bring the car to a dealership to evaluate. To the best of our knowledge, the manufacturer, the police and the insurance company did not inspect the vehicle. We are not experts, but hitting a pothole might be considered an edge case, so I’m not sure that a dealership would have tried or been able to replicate the issue.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11756964August 14, 2026
ENGINE, ELECTRICAL SYSTEM
The contact owns a 2022 Hyundai Tucson. The contact stated that the check engine warning light illuminated and was cleared; however, the warning light returned hours or days later. The dealer had cleared the check engine warning light approximately 15-16 times. The vehicle occasionally stalled while driving at various speeds. The dealer diagnosed the vehicle with terminal engine failure. The contact was informed that the fuel system needed to be overhauled, and the fuel injectors and caps needed to be replaced. The vehicle was repaired twice. The failure persisted after the contact had confirmed the diagnosis with a certified mechanic. The vehicle was returned to the dealer, who replaced the engine. The vehicle was parked for several hours, and the contact attempted to turn on the headlights, but the headlights failed to illuminate. While driving the vehicle, the vehicle hesitated several times. The following day, the vehicle failed to start approximately four times. The vehicle was driven to the dealer but hesitated several times along the way and failed to start once at the dealer. The dealer diagnosed the vehicle and determined that the battery and other parts needed to be replaced; however, the vehicle was not repaired. The manufacturer was made aware of the failure, and a complaint was filed. The failure mileage was 3,212.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755276August 6, 2026
EXTERIOR LIGHTING, UNKNOWN OR OTHER
While driving at night, the headlights on my 2022 Hyundai Tucson Hybrid shut off randomly, including when using the turn signal. The lights will turn off without warning at highway speeds, creating a serious safety hazard. Using the turn signal can cause the headlights to turn off, and sometimes using the turn signal will temporarily turn them back on. The headlight mode also changes by itself while driving (AUTO to OFF to ON to OFF). Additionally, when the vehicle is turned off, the headlights often stay on no matter what mode the switch is in. I have to restart the vehicle and manipulate the turn signal/headlight stalk multiple times to get the lights to turn off. This is a recurring and dangerous failure that affects nighttime visibility and safety for me and my family. No other electrical issues are present. This is available for inspection. Safety for my family and all others on the road put at risk as the headlights randomly shut off at night. The problem was reproduced by the dealer. The dealer quoted a $1,500 repair, but this a safety‑critical defect in the lighting control system.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755025August 5, 2026
SERVICE BRAKES
Front brake rotors warped causing violent brake pedal pulsating and steering wheel vibration. My vehicle has only 18000 miles. The dealership Hyundai reported problem as a service bulletin TSB 23-BR-004H. I believe this a safety issue and a recall should be annouced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754564August 3, 2026
FUEL/PROPULSION SYSTEM
While driving the car stalled and then the engine shutdown, caused by a misfired fuel injector. Myself and the passengers in the car were minorly safe, as this incident occurred while driving through the Yellowstone National park; having to pull over on the side of the road with no shoulder. The Woody Smith Hyundai Dealership in Idaho Falls confirmed that the feul injectors had misfired, and then replaced them. Prior to the failure, there was no warning until the car was actively stalling and failing (battery light and check engine light came on).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754364August 3, 2026
EXTERIOR LIGHTING, ELECTRICAL SYSTEM
The contact owns a 2022 Hyundai Tucson. The contact stated that while his wife was operating the vehicle, the vehicle lost headlight functionality without warning. In addition, the contact stated that the radio intermittently failed to operate while driving the vehicle. The contact stated that the headlight became operable when his wife was near to her destination. The vehicle was not diagnosed or repaired. Upon investigation, the contact discovered NHTSA Campaign Number: 21V938000 (Electrical System, Exterior Lighting); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 25,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754276August 2, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Unintentional and unexpected activation of emergency collision or adaptive cruise control, causing the vehicle to stop and become immobile in the lane of traffic. I was driving down the interstate with the adaptive cruse control on and the lane keeping assistance on. These both were on for about 20 minutes as I was driving down the highway. There were no vehicles in front of or behind me for a quarter mile or so. I as all alone with nothing around me. All of a sudden it seemed like the collision avoidance system activated. The car came to a complete stop in the right lane of the highway. I tried to proceed and could see the emergency brake was on, the engine was running the car was in drive but it would not move. Flipped on the hazard flashers and traffic caught up to me while sitting in the right lane of the highway waiting to get rear ended. Vehicles were barely getting by at 70 MPH. The car would I pressed the accelerator and the car move d forward enough to get off the highway, this took a minute or two. Once off he highway, I could see the emergency brake would not release. I turned the engine off went out to inspect all the forward sensors. There was no visible issue. I restarted the car after a minute or so and it proceeded normally. That was Saturday, this is Sunday, I am taking the vehicle to Hundai tomorrow for inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753589July 29, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS, ELECTRICAL SYSTEM
On July 24, 2026, while driving on a marked city street with no vehicle, pedestrian, or obstruction ahead, the Forward Collision-Avoidance system on our 2022 Hyundai Tucson Limited AWD applied emergency braking on its own, three to four separate times, each lasting one to two seconds. Traffic behind us nearly struck our vehicle. My family was in the car. This is the latest event in a progressive electrical fault history. In June 2025, under warranty at 48,037 miles, a Hyundai dealer documented recurring multi-system warning cascades (forward safety, lane keeping, high beam assist, speed limit warning) and a failed auto start/stop system. The dealer's listed resolution was "battery voltage / replace battery"; their invoice records that no repair was performed. We replaced the battery at our own expense. The faults continued. In June 2026, the start/stop system shut the engine off at a red light and the vehicle would not restart, leaving us disabled in a live traffic lane. Power was only restored by cycling the hood release. Since then, TCM and ECU software updates and a battery harness replacement (our expense, approx. $1,200) have been performed. The faults persisted after these repairs and have now escalated to uncommanded emergency braking. Date- and time-stamped video and photographs exist for multiple events. Two Hyundai dealerships have not identified a root cause. Similar phantom braking reports exist from other owners of this model year. We no longer consider the vehicle safe to drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750511July 15, 2026
SERVICE BRAKES
On XXX, while approaching a stop sign, the vehicle did not engage the brakes as expected. I had to press the brake pedal multiple times, and the vehicle jerked several times before it came to a stop. Given that a brake failure of this kind poses an immediate risk to my safety and the safety of others on the road, I had the vehicle towed in for service right away. I took the vehicle to Courtesy Hyundai of Tampa (3810 W Hillsborough Ave, Tampa, FL 33614) on Monday, XXX (Repair Order #XXX). Service Advisor Dominick DeLeva documented the complaint and had the vehicle test driven. The dealership's notes state that the issue could not be duplicated, no fault codes were present, and the brake fluid level was correct. A multi-point inspection was also completed. The vehicle was returned to me on July 14, 2026, with no repairs made and no explanation for the braking irregularity I experienced. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749738July 11, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: WARNINGS
Phantom braking while driving under a bridge. No cars around but Tucson warned collision while driving under a bridge and slammed on the brakes! This has happened multiple times. This fake safety feature is actually a hazard!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749646July 10, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
When driving have been reviving a warning that says adaptive cruise control failure followed by a short time were the car may unexpectedly break on the interstate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746896June 27, 2026
FUEL/PROPULSION SYSTEM
I became aware of a Technical Service Bulletin that Hyundai published in Jan 2025 acknowledging that many vehicles (of which mine is one) have a faulty fuel injector and it will fail. Hyundai elected to not issue a recall on this issue so the public has no idea they are driving vehicles that are just awaiting for a malfunction in their engine. It appears the reason Hyundai is doing this is because fuel injectors are only covered on the manufacturer’s limited 5-year 60,000-mile warranty so they are hoping the faulty injectors last long enough to get beyond that point and customers don’t know the injectors were even faulty to begin with (because TSBs are not public knowledge). Hyundai can then charge for full repairs and omit admittance that the injectors were faulty and blame it on wear and tear. Mine failed beyond 60,000 miles and I am in this predicament. I imagine most customers with 2022 vehicles have not driven as much as me and haven’t had this come up. It seemed like something I should inform someone about. Do with this what you wish
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746292June 24, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My 2022 Hyundai Tuscon came to a complete stop on the highway in Colorado twice in the last 2 months for no apparent reason. There weren't any obstacles or cars in front of me that would have caused the car to brake suddenly. I had passengers in the car and we were jolted forward. The air bags did not inflate and we were not hit from behind, but we could have been severely injured or killed. There are numerous "phantom braking" reports like this here on the NHTSA site for the 2022 model as well as more recent models. Yet Hyundai has only issued recalls for the 2025 and 2026 models. How are you addressing this issue?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744787June 17, 2026
UNKNOWN OR OTHER
Fuel door actuator failed to unlock had to take the car into the dealership to replace a malfunctioning actuator. Left me stranded at a gas station unable to fuel the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743887June 13, 2026
SERVICE BRAKES, FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
On 3 occasions over my 18-month ownership of this certified pre-owned Hyundai 2022 Tucson, the vehicle surged suddenly forward WITH BRAKE APPLIED at creeping (parking) speeds of 3-4 mph. No warning lamps were observed. On the most recent (3rd) occasion, a crash over a sidewalk and into a storefront caused $10,000 damage. No pedestrians were harmed, no airbags deployed and neither passenger was harmed. The service department is "unable to duplicate" the surging behavior and declares the car mechanically "safe to drive."
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11743833June 12, 2026
POWER TRAIN, ENGINE, VEHICLE SPEED CONTROL
My 2022 Hyundai Tucson Experience, a sudden transmission failure at approximately 92,520 miles. The vehicle develop shifting issues and abnormal noises before losing propulsión. While driving. Hyundai diagnosed and internal Transmission failure and approved transmission replacement. I’m concerned about the sudden loss of proportion and the safety risk this creates. Hyundai proposed repair is to replace the transmission with a rebuild remanufacture transmission rather than a new transmission. I am concerned about the reliability of the repair following a complete transmission failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742609June 7, 2026
ENGINE, VEHICLE SPEED CONTROL
I am submitting this complaint regarding my 2022 Hyundai Tucson equipped with the 2.5L engine. The vehicle has experienced multiple incidents of severe engine misfiring while driving. During these events, the engine begins to shake violently, the entire vehicle vibrates, and engine power is significantly reduced. The vehicle becomes unable to accelerate normally, creating a serious safety hazard, especially when driving on highways or in traffic. The malfunction has occurred several times. Diagnostic trouble codes P0302 and P0303 have been recorded, indicating cylinder misfires. In some cases, turning the engine off and restarting it temporarily restores normal operation. On other occasions, adding fuel system cleaner appeared to temporarily improve the condition. However, the problem eventually returns. Because the condition is intermittent, the Hyundai dealership has been unable to reproduce the failure during inspection and therefore has not performed a repair under warranty. Despite multiple visits, the root cause remains unidentified. I am concerned that the sudden loss of power and severe engine vibration could result in an accident if the vehicle is unable to maintain speed or accelerate while traveling at highway speeds. This issue has significantly affected the safe operation of the vehicle. I request that this matter be investigated, as it appears to be a recurring safety-related defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742140June 4, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I was told there was a known issue with the electrical system with the front bumper harness and wiring harness need to be replaced due to water damage & Vehicle's horn keeps on going out and has to be replace
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Tucson