Hyundai Tucson Complaints

6,738 consumer complaints on file.

#11747047June 28, 2026
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Vehicle: 2025 Hyundai Tucson Hybrid | Purchase Date: 10/2025 | Mileage: ~2,800 | FAILURES: On 5/11/2026, the AEB warning light (FCA system) activated without cause while parked. On 5/13/2026, the left side instrument cluster went completely dark and was unresponsive. Multiple reboots failed to restore it. Infotainment (right side) rebooted; instrument cluster did not. Vehicle brought to Hyundai of Las Vegas on 5/15/2026. RECALL CONNECTION: This is consistent with Recall 26V047000 (Hyundai #293), issued 1/26/2026, for 2025 Tucson instrument panel failure violating FMVSS No. 101. My VIN is not in the database. I request VIN inclusion review as my experience is identical. The OTA/dealer software update was never applied prior to this failure. SAFETY RISK: Loss of instrument cluster eliminated ability to monitor speed, fuel, and warnings while driving. Unprompted AEB activation raises concern about FCA reliability — risks unexpected braking to cause potential crash or failure to engage. Consistent with FCA recall issued 5/16/2026 for my vehicle. DEALER: Hyundai of Las Vegas confirmed and repaired under warranty, described to me only as a hard reset. Diagnostic was not indicated on my report. Service advised me that recurrence is likely. Note: FCA recall issued 5/16/2026 was not addressed during this visit. Second appointment required. NHTSA: 26V047000 | Hyundai Recall: #293 | Case: 42767545
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747066June 28, 2026
UNKNOWN OR OTHER
I was driving using adaptive cruise control, and my entire instrument cluster went blank. Everything, I couldn't see my speed, if cruise control was on, the HUD display everything went dark then came back on in about 10-15 seconds. This was very concerning. I had no way to know if the safety systems like adaptive cruise control, forward crash section etc were still working. Lost my GPS directions, couldn't tell my speed This was extremely dangerous.This needs to be fixed asap.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746896June 27, 2026
FUEL/PROPULSION SYSTEM
I became aware of a Technical Service Bulletin that Hyundai published in Jan 2025 acknowledging that many vehicles (of which mine is one) have a faulty fuel injector and it will fail. Hyundai elected to not issue a recall on this issue so the public has no idea they are driving vehicles that are just awaiting for a malfunction in their engine. It appears the reason Hyundai is doing this is because fuel injectors are only covered on the manufacturer’s limited 5-year 60,000-mile warranty so they are hoping the faulty injectors last long enough to get beyond that point and customers don’t know the injectors were even faulty to begin with (because TSBs are not public knowledge). Hyundai can then charge for full repairs and omit admittance that the injectors were faulty and blame it on wear and tear. Mine failed beyond 60,000 miles and I am in this predicament. I imagine most customers with 2022 vehicles have not driven as much as me and haven’t had this come up. It seemed like something I should inform someone about. Do with this what you wish
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746645June 26, 2026
UNKNOWN OR OTHER
My 2025 Mazda CX-5 has an intermittent defect that causes Android phones connected to Android Auto through the vehicle's USB-C port to unexpectedly perform a complete device reboot while the vehicle is being driven. The problem began in August 2025 after I purchased a Google Pixel 9. I initially believed the phone was defective and spent several months troubleshooting the phone. After the same problem occurred with my son's Google Pixel 10, I determined the issue was not phone-specific. I reported the problem to Mastria Mazda in March/April 2026 and returned again in May 2026. I opened a case with Mazda Customer Experience on June 4, 2026. The vehicle software has been updated, but the defect remains. The failure is random. It does not occur immediately after connecting the phone and is not associated with navigation, music, phone calls, messaging, or trip duration. It can occur once during a trip or multiple times during the same trip. The defect has been reproduced with two different phones (Google Pixel 9 and Pixel 10) using multiple USB-C cables. The same phones were then tested using wired Android Auto in another 2025 Mazda CX-5 (loaner driven for one week), a Mazda3, a Mazda CX-90, and a Tesla. The problem did not occur in any of those vehicles. My Pixel 9 also works normally in my vehicle when using wireless Android Auto. The reboots occur only through the wired USB-C Android Auto connection in my vehicle. This creates a safety hazard because Android Auto immediately disconnects, causing the sudden loss of navigation, the head-up display directions, hands-free calling, and voice commands while driving. The defect has occurred multiple times during Boston morning rush-hour traffic and while navigating a major highway interchange under construction where lane assignments had been temporarily changed. The unexpected loss of navigation and driver information at these critical moments creates a significant driver distraction and potential safety risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746702June 26, 2026
ENGINE
The contact owns a 2016 Hyundai Tucson. While the contact’s daughter was driving approximately 55 MPH, the vehicle started to lose motive power. The vehicle failed to restart immediately. The vehicle was started after a while; however, the check engine warning light was illuminated. The vehicle was taken to a Goodyear Service Center to be diagnosed. The contact was informed that the engine had seized and needed to be repaired. The dealer was contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,479.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746737June 26, 2026
FORWARD COLLISION AVOIDANCE
The contact owns a 2025 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the vehicle unintendedly stopped. The vehicle suddenly experienced an automatic emergency braking failure. The vehicle was stuck in gear and was jerking while moving forward. While in drive, there was an abnormal popping sound coming from the vehicle. The battery discharge message was displayed and after several minutes the vehicle resumed normal operation. The vehicle was taken to the local dealer previously, but the dealer was unable to determine the cause of the failure. The local dealer was contacted again, and the contact was informed about NHTSA Campaign Number: 26V316000 (Forward Collision Avoidance) and about a trade-in. The vehicle was not diagnosed or repaired. The contact called another local dealer Feldman Hyundai of New Hudson Service & Parts Center (30492 Lyon Center Dr, New Hudson, MI 48165); where an appointment was scheduled for a later date. The manufacturer was contacted and filed a claim. The failure mileage was approximately 100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746828June 26, 2026
POWER TRAIN
After purchase, I drove home on the highway and noticed an obvious rattle/vibration. I returned the vehicle 3 times before it was finally discovered that there was a defect in the drive shaft. To hide the defect, during manufacturing multiple balance weights were installed on the same side of the drive shaft to allow it to pass safety checks, despite posing a major safety risk. The vehicle has been declared a Lemon and they must repurchase, but I suspect this problem will extend beyond my one vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746742June 26, 2026
UNKNOWN OR OTHER, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My car was recalled because the auto brake was triggering incorrectly and causing issues (at least 4 accidents with injuries are known to have been casued by this problem). I brought my car in to have the auto braking issue fixed, after I had already been rear ended due to it automatically activating (submitted a previous NHTSA claim about this.) The same defect recurred while I was driving yesterday evening. A pedestrian had fully cleared a crosswalk, I attempted to pull forward, and the auto-brake triggered without cause, locking up the vehicle and nearly causing me to be rear ended again. This is an ongoing safety issue that was supposed to have been corrected and clearly was not.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746736June 26, 2026
POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2025 Hyundai Tucson. The contact stated that while in reverse, several warning lights illuminated on the instrument panel, and the vehicle suddenly reversed without depressing the accelerator pedal and crashed into a light post. The air bags did not deploy. There were no injuries sustained. The contact sought medical attention after being overwhelmed by the experience. A Police report was not filed. The contact was able to drive the vehicle, and the vehicle was taken to the dealer, and the front-view camera was updated; however, the dealer was unable to determine the cause of the failure. The vehicle was taken to Imperial Body Shop to repair the body damage. After the software update was performed, the contact became aware that the vehicle failed to turn off immediately, and several attempts were needed to turn off the vehicle. On another occasion, the contact was able to turn off the vehicle; however, the engine continued to run. Several attempts were needed to turn off the vehicle. The manufacturer was made aware of the failure. The manufacturer opened a case for the failure. The failure mileage was approximately 7,500.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11746594June 25, 2026
ENGINE, FUEL/PROPULSION SYSTEM
#1. This vehicle uses a lot of oil !!! It burns through it like crazy I have to check the oil every other day. #2. When I come to a stop while driving and give it gas to take off IT WONT GO !!!!! It hesitates and when it does go it LUNGES FORWARD!! This is a huge manufacturer problem not a buyer problem. The engine is junk.! 3. I’ve called numerous places to get help. This car needs to be recalled. This is a huge safety violation. It doesn’t wanna go when you give it gas and when it does, it lunges forward that can cause a huge accident on the highways. This car was made in China. It is junk. I’ve called to get help with this issue and no one wants to help. Nobody returns my calls and I’ll Hyundai wants to do is it even more money out of me when this isn’t my fault the car is junk. For safety concerns I would like someone to call me at [XXX]. This car needs to be recalled and my daughter has one. It’s doing the same thing except hers is a lot worse. Hers is further advance where it’s actually stalling in the middle of the road while driving huge safety violation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746534June 25, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS, BACK OVER PREVENTION: WARNINGS
I had the Hyundai recall 302 performed on 5/27/2026 and after the software update none of the front sensors worked. My wife had a 2 mph bump with the car in front of her on [XXX]and there was no warnings, also no damage no injuries that I'm aware of. So I started to investigate why there was no alarm sounded or any red warning light on the dashboard. Pulled the car into the garage and up to 6 inches from the garage wall no warning on the dash. Took the car back to the dealership on 6/5/2026 they changed some settings and it still failed to warn of an still failed. The gave me a service appointment on 6/9/2026 they calibrated the front windshield sensor and now the parking assist sensors worked. When I pulled into the garage the front camera showed yellow and red warnings as I approached the wall. That fixed the parking sensors issue. Still no forward collision avoidance warning shortly there after was referred to the service manager Rich Block he stated that the front bumper cover would need top be removed to calibrate the radar behind the bumper, but Hyundai's warranty would not cover it and, I should call Hyundai Customer care. I did and was contacted by Mohamed at National Consumer Affairs (714) 922 - 3276. and here we we sit. when they pulled the bumper they found the mounting bracket was bent. Mohamed at National Consumer Affairs (714) 922 - 3276 stated could I prove that all this happened after recall 302. I can only prove the parking sensor issue because after recalibration they worked. Hyundai Motors refuses to accept any responsibility for this incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11746494June 25, 2026
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2023 Hyundai Tucson. The contact stated that the panoramic sunroof exploded while driving at approximately 40-50 MPH. The rear section of the sunroof glass had shattered into several pieces without impact. The contact closed the shade, and the glass fell inward. There was glass inside the shade and the roof. There were no injuries. There was an abnormally loud sound like a handgun or several balloons popping. The vehicle was previously inspected, and there were no issues found with the sunroof. The vehicle was taken to the local dealer, and the dealer stated that a rock might have caused the failure. The vehicle was not repaired. The dealer referred the contact to the insurance company for assistance. The manufacturer was contacted, and an appointment was scheduled with the local dealer. Additionally, the manufacturer provided a loaner vehicle. The failure mileage was approximately 24,038.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746359June 25, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Forward crash avoidance system keeps activating causing the car to brake on it's own. This was previously fixed on my car once back in 2022 and now in 2026 it is happening again. I have been trying to communicate with Hyundai regarding additional years to current recall but their not going to even though they have known for years this was an issue and included older models than their current recall. This is not a one time issue this is the second time and until fixed it continously caused the vechile to randomly brake, it's going to get someone seriously injured or killed if they don't address it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746111June 24, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
While driving my 2024 Hyundai Tucson Hybrid at approximately 20-25 mph approaching a red light, a sudden and total loss of brake power-assist occurred. Upon applying the brakes, the pedal became instantly rigid and rock-hard. Despite pumping the pedal multiple times and applying heavy manual foot pressure, the vehicle failed to stop, resulting in a low-speed rear-end collision with a stationary car stopped at the traffic light. No dashboard warning lights or malfunction indicators illuminated during or immediately following the event. After the collision, the vehicle's ignition was turned off and then restarted. Following this power cycle, normal braking functionality temporarily returned. The low-speed impact displaced an ultrasonic sensor in the front bumper. This intermittent electronic brake failure poses a catastrophic safety hazard to pedestrians and occupants if it recurs at higher speeds
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11746127June 24, 2026
ENGINE
I am filing a safety complaint regarding my Hyundai vehicle after experiencing a sudden engine failure that appears consistent with known rod bearing and engine defects affecting certain Hyundai engines. While driving, my vehicle began making a knocking noise and shortly thereafter suffered catastrophic engine failure. The engine lost power and became inoperable, requiring the vehicle to be towed. This failure occurred without any prior indication that the engine was about to fail. My concern is that this type of engine failure creates a significant safety hazard because it can occur unexpectedly while driving, potentially causing a loss of power in traffic and increasing the risk of a crash. The dealership inspected the vehicle and engine but did not report excessive sludge buildup. I have provided available maintenance records showing that oil changes were performed during my ownership. Despite this, there appears to be disagreement regarding the cause of the failure. I am aware of reports involving rod bearing and engine failures in similar Hyundai vehicles and believe NHTSA should investigate whether this failure is related to a broader manufacturing or design defect. The cost of replacing the engine is substantial, and consumers may be placed at risk if these failures occur while vehicles are being operated on public roads. I am requesting that NHTSA review this issue and determine whether additional investigation, recalls, or other corrective actions are warranted. Vehicle Information: Year: 2017 Make: Hyundai Model: Tucson Mileage at Failure: Approximately 72,000 miles Date of Failure: [XXX] VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746292June 24, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My 2022 Hyundai Tuscon came to a complete stop on the highway in Colorado twice in the last 2 months for no apparent reason. There weren't any obstacles or cars in front of me that would have caused the car to brake suddenly. I had passengers in the car and we were jolted forward. The air bags did not inflate and we were not hit from behind, but we could have been severely injured or killed. There are numerous "phantom braking" reports like this here on the NHTSA site for the 2022 model as well as more recent models. Yet Hyundai has only issued recalls for the 2025 and 2026 models. How are you addressing this issue?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746238June 24, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
The contact owns a 2025 Hyundai Tucson. The contact stated that while reversing, the vehicle reversed 6-inches, and the Forward Collision Avoidance system erroneously engaged because there were two bikes mounted on the rear of the vehicle. The contact stated that the failure had been recurring consistently, requiring the driver to deactivate the Forward Collision Avoidance feature while reversing with the bikes mounted on the rear of the vehicle. The vehicle was taken to the dealer, where the contact was informed that there was no fix for the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and confirmed that there was no fix for the failure. The contact became aware that the VIN was included in NHTSA Campaign Number: 26V316000 (FORWARD COLLISION AVOIDANCE); and associated the failure with the recall. The failure mileage was approximately 500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746132June 24, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: WARNINGS
I was driving in a line of cars when there was a sudden slowing of all cars ahead of my 2025 Hyundai Tucson Hybrid. Car's Forward Collision Avoidance system applied brakes too early and too hard. Car behind me almost collided with my car's rear. My 2025 Hyundai Tucson Hybrid had less than 1,300 miles. I confirmed this early collision avoidance early braking incident to salesman, Stephan, on May 7, 2026 during service at Piazza Hyundai of West Chester. I explained it was a near collision by car behind me. No action taken by dealership, and no recall information was provided to me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745847June 23, 2026
ENGINE, STEERING, VEHICLE SPEED CONTROL
While traveling on the highway the car began to lose speed rapidly until coming to a complete stop, no warning lights were present prior.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745908June 23, 2026
STRUCTURE:BODY
Within the last month, the passenger side front door will no longer open from the outside even if the door is unlocked. The driver must lean over to open the passenger door from the inside. Then approximately one week ago, the passenger rear door began to have issues in that it would not open from the outside nor would it open from the inside. This is a known safety issue which puts passengers at risk. A Technical Service Bulletin 21-bd-006h extends the warranty coverage to 10 years/unlimited mileage, however my 2016 Hyundai Tuscon is six (6) months outside of this window. The local Hyundai dealership will not fix under this door latch warranty extension and quoted a cost of $885.00 to remove and replace both latches. I currently have a case opened with Hyundai USA Customer Affairs and am waiting to see if Hyundai will cover the cost of repairs and fix the two door latches. If they do not, I will consider legal remedies.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Tucson