Hyundai Sonata Service Bulletins (2022)
78 manufacturer communications on file.
- September 20, 2022•Document ID: 10222082Service Bulletin/Repair InstructionsPOWER TRAIN; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 22-FL-006H
- Date Added:
- September 27, 2022
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides the procedure to update ECU and TCU of a vehicle experiencing any of the following DTC: P013E - O2 Sensor Delayed Response - Rich to Lean Bank 1 Sensor 2 P0456 - Evaporative System
Associated Products (4)Associated Documents - August 16, 2022•Document ID: 10218647Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 22-01-059H
- Date Added:
- August 24, 2022
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides the procedure to update the TCU software to improve drivability and shift quality.
Associated Products (5)Associated Documents - July 28, 2022•Document ID: 10217251Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 22-EM-010H
- Date Added:
- August 5, 2022
- Manufacturer:
- HYUNDAI
SummaryFollow the guidelines outlined in this bulletin to inspect and clean or replace certain components of the engine intake system accordingly during engine short block or sub-assembly replacement.
Associated Products (20)2026 Hyundai Venue2023 Hyundai Elantra2022 Hyundai Accent2022 Hyundai Elantra2022 Hyundai Kona2022 Hyundai Palisade2022 Hyundai Santa Cruz2022 Hyundai Santa Fe2022 Hyundai Sonata2022 Hyundai Tucson2022 Hyundai Venue2021 Hyundai Accent2021 Hyundai Elantra2021 Hyundai Kona2021 Hyundai Palisade2021 Hyundai Santa Fe2021 Hyundai Sonata2021 Hyundai Tucson2021 Hyundai Veloster2021 Hyundai VenueAssociated Documents - July 14, 2022•Document ID: 10217258Service Bulletin/Repair InstructionsTIRES
- Mfr Comm. #:
- 22-GI-006H
- Date Added:
- August 5, 2022
- Manufacturer:
- HYUNDAI
SummaryEffective June 2, 2008, Federal Motor Vehicle Safety Standard 110 (FMVSS 110) established a threshold for correcting load carrying capacity information indicated on tire placards when vehicle weight has been increased before retail sale. This limit is the lesser of 1.5% of GVWR or 100 pounds. If the total added weight exceeds the lesser of the limit, a label must be added to the driver-side B-pillar within 25mm (1 inch) of the original tire placard.
Associated Products (24)2026 Hyundai Venue2023 Hyundai Elantra2023 Hyundai Nexo2022 Hyundai Accent2022 Hyundai Elantra2022 Hyundai Ioniq 52022 Hyundai Kona2022 Hyundai Nexo2022 Hyundai Palisade2022 Hyundai Santa Cruz2022 Hyundai Santa Fe2022 Hyundai Sonata2022 Hyundai Tucson2022 Hyundai Venue2021 Hyundai Accent2021 Hyundai Elantra2021 Hyundai Kona2021 Hyundai Nexo2021 Hyundai Palisade2021 Hyundai Santa Fe+ 4 moreAssociated Documents - July 14, 2022•Document ID: 10217250Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 22-AT-009H
- Date Added:
- August 5, 2022
- Manufacturer:
- HYUNDAI
SummaryIf you are servicing an applicable vehicle with a âCheck Engineâ light on and one or more of the DTC listed on Page 2, follow the repair procedure and perform the diagnosis. If necessary, replace the High Flow electric oil pump (HF EOP) for HF EOP issues or the Dual Clutch Transmission for High Pressure electric oil pump (HP EOP) issues.
Associated Products (9)Associated Documents - June 3, 2022•Document ID: 10215599Service Bulletin/Repair InstructionsSTEERING
- Mfr Comm. #:
- 218/231 amend
- Date Added:
- July 9, 2022
- Manufacturer:
- HYUNDAI
SummaryCertain vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
Associated Products (8)Associated Documents - April 28, 2022•Document ID: 10211671Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 22-AT-005H
- Date Added:
- May 10, 2022
- Manufacturer:
- HYUNDAI
SummaryIf you are servicing an applicable vehicle with a âCheck Engineâ light on and one or more of the DTC listed below, follow the repair procedure and replace the related solenoid and valve body harness.
Associated Products (8)Associated Documents - April 8, 2022•Document ID: 10211677Service Bulletin/Repair InstructionsSTEERING
- Mfr Comm. #:
- 22-ST-003H
- Date Added:
- May 10, 2022
- Manufacturer:
- HYUNDAI
SummaryCertain 2020-2022MY Sonata (DN8A) vehicles may develop a bearing noise within the Motor Driven Power Steering (MDPS) column worm shaft assembly. If bearing noise is heard, follow the procedure in this bulletin to replace the worm shaft bearing.
Associated Products (2)Associated Documents - March 21, 2022•Document ID: 10210208Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM
- Mfr Comm. #:
- 22-01-006H-3
- Date Added:
- April 8, 2022
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.
Associated Products (3)Associated Documents - February 16, 2022•Document ID: 10208860Service Bulletin/Repair InstructionsCOMMUNICATION:MANUFACTURER TELEMATICS; ENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM; EQUIPMENT
- Mfr Comm. #:
- 22-01-006H-2
- Date Added:
- March 8, 2022
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides the procedure to update the ECU and TCU software to improve drivability and shift quality when accelerating.
Associated Products (3)Associated Documents - February 7, 2022•Document ID: 10208864Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EQUIPMENT
- Mfr Comm. #:
- 22-01-014H
- Date Added:
- March 8, 2022
- Manufacturer:
- HYUNDAI
SummaryThis bulletin describes the procedure to update wireless CarPlay to alleviate frequent disconnection of wireless CarPlay caused by other wireless noise from unknown sources which could make wireless communication unstable between D-Audio and mobile phone.
Associated Products (5)Associated Documents - February 3, 2022•Document ID: 10208865Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 22-01-018H
- Date Added:
- March 8, 2022
- Manufacturer:
- HYUNDAI
SummaryCertain 2020-22MY Sonata (DN8a) and 2021-22MY Santa Fe (TMa) vehicles equipped with 2.5L engine may exhibit a MIL with DTC(s): ⢠P2074: Mass Airflow Sensor Plausibility ⢠P2074F0: Manifold Absolute Pressure/Mass Air Flow - Throttle Position Correlation at Lower Load ⢠P2074F1: Manifold Absolute Pressure/Mass Air Flow - Throttle Position Correlation at Medium or High Load Secondary DTC(s) below may also be stored: ⢠C136081: ESP Irreversible Error ⢠C161308: CAN Signal Error EMS ⢠C161386: CAN Signal Error EMS ⢠C169381: Blind-Spot Collision Warning â CAN signal failure - ESC ⢠C174181: ESC Not Available VSM (Check ESC) ⢠C183586: CAN Message Failure ESC/IEB Vehicles diagnosed with DTC(s) may also experience reduced engine performance and limited power reduction mode. The ECM software revises the logic to accurately detect the amount of air the engine is receiving.
Associated Products (4)Associated Documents - January 21, 2022•Document ID: 10207809Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 22-AT-001H
- Date Added:
- February 8, 2022
- Manufacturer:
- HYUNDAI
SummaryThis TSB provides a procedure to diagnose the push button shifter operation. If you are servicing a vehicle with any symptoms or DTC listed below, follow the Service Procedure, Page 2.
Associated Products (7)Associated Documents - December 22, 2021•Document ID: 10206365Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
- Mfr Comm. #:
- 21-EM-012H
- Date Added:
- January 8, 2022
- Manufacturer:
- HYUNDAI
SummaryCertain vehicles listed below equipped with 2.5T turbo engines may have a misassembled check valve for the PCV (Positive Crankcase Ventilation) system, resulting in engine oil entering the intake and contaminating the air cleaner. This bulletin describes the procedure to clean the air intake system and replace the PCV check valve and air cleaner.
Associated Products (5)Associated Documents - December 9, 2021•Document ID: 10206359Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
- Mfr Comm. #:
- 21-01-075H
- Date Added:
- January 8, 2022
- Manufacturer:
- HYUNDAI
SummaryCertain 2020-22MY Sonata (DN8a), 2021-22MY Santa Fe (TMa), and 2022MY Tucson (NX4/NX4a) vehicles equipped with 2.5L engine may exhibit a MIL with DTC(s): ⢠P2074: Mass Airflow Sensor Plausibility ⢠P2074F0: Manifold Absolute Pressure/Mass Air Flow - Throttle Position Correlation at Lower Load ⢠P2074F1: Manifold Absolute Pressure/Mass Air Flow - Throttle Position Correlation at Medium or High Load Secondary DTC(s) below may also be stored: ⢠C136081: ESP Irreversible Error ⢠C161308: CAN Signal Error EMS ⢠C161386: CAN Signal Error EMS ⢠C169381: Blind-Spot Collision Warning â CAN signal failure - ESC ⢠C174181: ESC Not Available VSM (Check ESC) ⢠C183586: CAN Message Failure ESC/IEB Vehicles diagnosed with DTC(s) may also experience reduced engine performance and limited power reduction mode. The ECM software revises the logic to accurately detect the amount of air the engine is receiving.
Associated Products (5)Associated Documents - October 29, 2021•Document ID: 10203278Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21-EM-011H
- Date Added:
- November 6, 2021
- Manufacturer:
- HYUNDAI
SummaryCertain Sonata N-Line vehicles may have an uneven appearance between LH and RH exhaust tips due to slightly misaligned rear mufflers. This bulletin describes the procedure to adjust and realign the rear mufflers to correct the appearance.
Associated Products (2)Associated Documents - July 13, 2021•Document ID: 10200075Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 21-AT-009H
- Date Added:
- August 7, 2021
- Manufacturer:
- HYUNDAI
SummaryThis TSB provides a procedure to diagnose the push button shifter operation.
Associated Products (6)Associated Documents - June 14, 2021•Document ID: 10199101Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 21-AT-007H
- Date Added:
- July 9, 2021
- Manufacturer:
- HYUNDAI
SummaryIf you are servicing an 8-speed front-wheel-drive vehicle with the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. ï· DIAGNOSTIC TROUBLE CODES: ï P070500 - Transmission range sensor circuit malfunction ï P070512 - Transmission range sensor circuit malfunction ï P070514 - Transmission range sensor circuit malfunction ï P07051C - Transmission range sensor circuit malfunction ï P070600 - Transmission range sensor circuit range/performance ï P070661 - Transmission range sensor circuit range/performance ï P070696 - Transmission range sensor circuit range/performance ï· SYMPTOMS: ï Malfunction Indicator Light (MIL) illuminated ï 5th gear fail-safe ï No gear indication in cluster ï Intermittently wonât shift into D or R ï Intermittently wonât shift out of Park ï Intermittent ly no engine cr ank/no start in âPâ or âNâ with or without MIL or DTC.
Associated Products (5)Associated Documents