Hyundai · Model Report
Showing safety data for the 2002 model year only.
Hyundai Motor Company (Hyundai) is recalling certain model Year 2001-2006 Santa Fe vehicles manufactured from March 31, 2000, through February 15, 2006, that are registered and operated, or which were originally sold and registered, in the following 20 Âsalt belt" states and the District of Columbia: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. The affected vehicles may experience front coil spring corrosion from road salt, causing the coil spring to fracture and make contact with the tire.
HYUNDAI IS RECALLING 83,355 MY 2001-2003 SANTA FE VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE REAR TRAILING ARMS, WHICH COULD LEAD TO THINNING OR PERFORATION OF THE REAR TRAILING ARM STEEL. OWNERS MAY SEE OR FEEL SLIGHT TO MODERATE CHANGES IN VEHICLE OPERATION WHICH WILL INCREASE IF THE VEHICLE IS NOT REPAIRED. THESE CHANGES INCLUDE A LOWERING OF VEHICLE HEIGHT THAT CAN LEAD TO TIRE MISALIGNMENT AND STEERING PULL. OWNERS MAY ALSO NOTICE A CREAKING SOUND.
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 2.7 LITER V-6 ENGINES, IMPROPERLY MANUFACTURED CRANKSHAFT POSITION SENSORS (CPS) WERE INSTALLED. THE CPS CASES WERE IMPROPERLY MANUFACTURED AND DID NOT MEET DIMENSIONAL SPECIFICATIONS. INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE PRINTED CIRCUIT BOARD CAPACITOR.
The starter motor housing bottom ear bracket that holds the bolt to the transmission has broken off on 3 different starters in the same exact spot on all 3.
No injuries · No fire · No crash
While dragging the trash can back to the house, I was approaching fence in front of the house, at a slow speed, as I applied the brakes the car started to accelerate. Pressing down harder on the brakes ,it felt like stepping on a brick, with no braking taking place the car accelerated at a high rate. At this time the car crashed into the left side of the garage and continued into the cement porch taking out the fence, fill tube, and vent tube of the oil tank. At this time I push gear shift into N and turned off the engine. At this time there is damage done to house and car is now totaled with no injuries. Hate to think what would have happened if this happened at the major 4 lane intersection 1 mile from my home.
I WAS RIDING DOWN THE ROAD AND FELT THE CAR FEEL AS IF IT WAS FLOATING. THE NEXT THING I KNOW THE CAR FEELS LIKE THE TIRE CAME OFF AND IT HAD. RUSTED COMPLETELY OFF. I HAD TWO CHILDREN IN THE CAR AND CAME VERY CLOSE TO BEING HIT IN THE REAR BECAUSE I LOST CONTROL OF THE VEHICLE. IT SEEMS AS IF IT IS THE CONTROL ARM BAR. THIS INCIDENT HAPPENED ON GALL BLVD. ZEPHYRHILLS FL.
No injuries · No fire · No crash
TL* THE CONTACT CALLED ON BEHALF OF A CLIENT WHO OWNS A 2002 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE HIS CLIENT WAS DRIVING AT 55 MPH, SHE EXPERIENCED WHAT SHE THOUGHT WAS A FLAT TIRE ON THE REAR OF THE VEHICLE. AS THE CLIENT BEGAN TO PULL OVER, THE ENTIRE PASSENGER'S SIDE REAR CONTROL ARM COLLAPSED WITHOUT WARNING. DUE TO THE FAILURE, THE CONTACT'S CLIENT HAD THE VEHICLE TOWED TO HIS INDEPENDENT MECHANIC SHOP WHERE HE DISCOVERED THAT THE ENTIRE LOWER REAR CONTROL WAS CORRODED AND HAD DETACHED FROM THE VEHICLE. THE CONTACT LINKED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 09V123000 (SUSPENSION) HOWEVER, UPON SPEAKING WITH TWIN CITY HYUNDAI (3024 ALCOA HWY, ALCOA, TN 37701) THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.*DT*JB
No injuries · No fire · No crash
MY 2002 HYUNDAI SANTA FE IS SHARPLY JERKING TO THE RIGHT ITS ALMOST IMPOSSIBLE TO STOP IT SOUNDS AS IF THE CAR IF GOING TO FALL INTO PEICES IM A DISABLED MOM WITH ONE ONE THE WAY I CAN'T DRIVE FOR FEAR IM GOING TO LOSE THE WHEEL AND CRASH
No injuries · No fire · No crash