Ford F-550 Complaints (2003)

33 consumer complaints on file.

#11061627January 10, 2018
ENGINE, FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 FORD F-550 SD. WHILE DRIVING UNKNOWN SPEEDS, THE ENGINE STALLED WITHOUT WARNING AND THE FUEL TANK DISINTEGRATED. THE FLOAT FILTER AND FILTER WERE CLOGGED. THE CONTACT CALLED A LOCAL DEALER (VISION FORD, 1500 S WHITE SANDS BLVD, ALAMOGORDO, NM 88310) AND WAS ADVISED TO SCHEDULE A SERVICE APPOINTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 107,550.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10946265January 18, 2017
ENGINE, FUEL/PROPULSION SYSTEM
WATTER SEPERATOR VALVE DUMPED FUEL ON THE TURBO CAUSING A FIRE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10481643October 11, 2012
ENGINE AND ENGINE COOLING:ENGINE:DIESEL, EQUIPMENT:APPLIANCE:AIR CONDITIONER
I HAVE EXPERIENCED NUMEROUS ENGINE FAILURES, OF WHICH I HAVE THE RECEIPTS, ON MY F500 FORD WITH THE 6.0 DIESEL ENGINE, AT A COST TO ME OF OVER $7,000. AT THE TIME OF THE FAILURES, THE ENGINE WAS ONLY OUT OF WARRANTY FOR A SHORT PERIOD OF TIME. BECAUSE A DIESEL SHOULD LAST FOR A RELATIVELY LONG PERIOD OF TIME AND SHOULD NOT HAVE THESE TYPES OF PROBLEMS, I ASKED FORD TO COVER THE BILL. IN SHORT, FORD WOULD NOT GIVE ME THE TIME OF DAY OR ADMIT TO ANYTHING. I AM VERY CONCERNED AS I DON' T MAKE THE KIND OF MONEY IT TAKES TO CONTINUALLY INVEST IN AN ENGINE THAT SHOULD STILL RUN FINE. I HAVE ALSO DISCUSSED THIS WITH OTHERS THAT OWN THE SAME ENGINE AND HAVE FOUND THAT THE TYPE OF PROBLEMS THAT I'VE HAD ARE QUITE COMMON WITH THE 6.0 ENGINE. I HAVE ALL THE RECEIPTS AND EXPECT FORD TO TAKE RESPONSIBILITY FOR WHAT IS CLEARLY A POORLY BUILT ENGINE. I'M ALSO HAVING TROUBLE WITH THE AIR CONDITIONER FOR YEARS AND HAVE BEEN UNABLE TO FIND THE PROBLEM. I AWAIT YOUR REPLY AND CAN SEND YOU A COPY OF THE BILLS AND MY CORRESPONDENCE WITH FORD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461248June 11, 2012
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
NORCOLD CORP. ISSUED SAFETY RECALL # 10E-049 ON/ABOUT OCTOBER 21, 2010 FOR REFRIGERATOR UNITS IN RECREATIONAL VEHICLES FOR A POTENTIAL "FIRE" IN THE COOLING UNIT(S). A CERTIFIED RV DEALER CONFIRMED FIRE DAMAGE TO UNIT OWNED AND OPERATED BY COMPLAINANT . NORCOLD CORP. HAS REFUSED TO HONOR SAFETY RECALL(S) AND REPAIR SAID DAMAGED UNITS. THE FIRE WAS CONTAINED TO THE REFRIGERATOR UNIT ONLY HOWEVER ITS A TOTAL LOST. THERE ARE MILLIONS OF SIMILAR DEFECTIVE REFRIGERATOR UNITS BEING USED ON THE NATIONAL'S HIGHWAYS BY UNSUSPECTING RV OWNERS POSING A SERIOUS SAFETY AND HAZARDOUS POTENTIAL FOR A CATASTROPHIC EVENT THAT WILL ENDANGER THE TRAVELING PUBLIC. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10418001August 8, 2011
FUEL SYSTEM, DIESEL
TL*THE CONTACT OWNS A 2003 FORD F-550. THE CONTACT STATED THAT WHILE DRIVING 55-60 MPH, THE VEHICLE STALLED. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FUEL TANK INNER LINING WAS DE-LAMINATING AND BEING DRAWN INTO THE FUEL SYSTEM. AS A TEMPORARY REMEDY, THE CONTACT DECIDED TO DE-LAMINATE THE FUEL TANK. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTICS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10389840March 11, 2011
FUEL SYSTEM, DIESEL
TL*THE CONTACT OWNS A 2003 FORD F550. THE CONTACT STATED THAT THE FUEL TANK HAD DELAMINATED AND CAUSED THE FUEL TANK TO CLOGGED UP. THE FAILURE ALSO CAUSED THE VEHICLE TO LOSE POWER AND STALL WHILE DRIVING UPHILL. THE WAS RESPONSIBLE FOR PAYING $900 TO REPLACE THE FUEL TANK SINCE THERE WERE NO WARRANTIES OR RECALLS. THE MANUFACTURER CONFIRMED THAT THERE WERE NO RECALLS AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10360708October 15, 2010
FUEL SYSTEM, DIESEL
I HAVE 2 FORD F550 TRUCKS (2001,2003). BOTH TRUCKS WITH VERY LOW MILEAGE (37K, 56K MILES). BOTH DIESEL ENGINES. BOTH HAVE ONLY HAD EITHER SHELL OR CHEVRON FUEL PUT IN THEM. NO BIO FUELS. THE INTERIOR OF BOTH MY TRUCKS FUEL TANKS ARE DELAMINATING AND CAUSING THE VARIOUS FUEL FILTERS TO CLOG WITH A METALLIC DEBRIS AND RUST. FORD MOTOR COMPANY IS BLAMING THE DELAMINATING ON THE FUEL USED IN THE TRUCKS. MY DEALER (WESTLIE FORD, CAMAS, WASHINGTON) WHERE I PURCHASED THESE TRUCKS CANNOT WARRANTY THE REPLACEMENT TANKS NEEDED TO REMEDY THIS PROBLEM. THIS IS AN EPIDEMIC FOR FORD MOTOR COMPANY! WORD HAS IT FORD HAS FIXED THE PROBLEM WITH THE NEW COATING ON THE NEW TANKS BUT, I CAN FIND NO ANNOUNCEMENT FROM FORD MOTOR COMPANY SAYING SO. AVERAGE COST TO REPLACE THIS TANK RUNS BETWEEN $1,500 - $2,500 DOLLARS. HOW MANY PEOPLE MUST DIE WHEN THEIR FUEL SYSTEMS GET CLOGGED BY THE DELAMINATING PARTICLES OF THE FUEL TANK AND STOP DEAD ON A FREEWAY OR FOGGY NIGHT? FORD MOTOR COMPANY SHOULD FIX THIS PROBLEM! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10353454September 2, 2010
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
TL* THE CONTACT OWNS A 2003 FORD F-550. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A SEVERE LOSS OF POWER AND SMOKE WAS COMING FROM THE EXHAUST PIPE, DUE TO THE UNISON RINGS FAILING. THE RINGS ARE A PART OF THE TURBO CHARGER ON THE ENGINE AND THE CONTACT HAD TO HAVE THEM REPLACED TWICE. THE DEALER STATED THAT THIS WAS A KNOWN FAILURE AND THAT IT WAS NOT COVERED UNDER THE WARRANTY. THE DEALER PLACED NICKEL PLATED RINGS INSTEAD OF THE STEEL RINGS ON THE VEHICLE AND THE PROBLEM SEEMS TO BE RESOLVED. THE FAILURE MILEAGE WAS 1038 AND THE CURRENT MILEAGE WAS 9500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351117August 22, 2010
TIRES, TIRES:TREAD/BELT
HERCULES S-209 TIRE BLEW ALL TREAD LOST MAJOR SEPARATIONS OTHER TIRES NOTICE WIDESPREAD MINOR CRACKING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10334114June 1, 2010
FUEL SYSTEM, DIESEL
FUEL TANK DELAMINATION. CLOGS FUEL SYSTEM, AND TRASHES INJECTORS AND PUMPS. NEW TANK, INJECTORS, PUMP. CLEAN FUEL SYSTEM. FORD SAYS BIOFUEL, NEVER USE BIOFUEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10330466May 14, 2010
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
TL* THE CONTACT OWNS A 2003 FORD F550 SD. WHILE DRIVING AT APPROXIMATELY 45-50 MPH, THE VEHICLE WOULD EXHIBIT EXCESSIVE SHAKING AND WOULD LOSE POWER. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE INDEPENDENT MECHANIC ADVISED THAT THE INSIDE LINING OF THE FUEL TANK WAS PEELING AND CLOGGING THE FUEL LINES. THE MANUFACTURER WAS CONTACTED BUT WOULD NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 48,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10297562December 30, 2009
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
TL* THE CONTACT OWNS A 2003 FORD F-55O. WHILE DRIVING THE VEHICLE STALLED WITHOUT WARNING. HE WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD-WAY. THE VEHICLE WAS TOWED TO A FORD DEALER AND A TECHNICIAN DISCOVERED AN INTERNAL OIL LEAK FROM THE PUMP. THE REPAIRS WERE PERFORMED UNDER WARRANTY. SEVERAL DAYS AFTER THE REPAIR AN IDENTICAL FAILURE OCCURRED. A TECHNICIAN FROM THE DEALER STATED THAT THE FUEL TANK DELAMINATED DUE TO THE DIESEL FUEL. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE MILEAGE WAS 101000. THE CURRENT MILEAGE WAS 102000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10295487December 13, 2009
FUEL SYSTEM, DIESEL
ENGINE FAILED AND VEHICLE STOPPED WORKING. THE CULPRIT WAS THE FORD FUEL TANK THAT HAD DELAMINATED. THE TANK HAD TO BE REPLACED. THE COST: $2223.41. ADDITIONALLY, THERE WAS A LOSS OF REVENUE AS THIS VEHICLE IS USED FOR PRODUCTION PURPOSES. FORD DENIED RESPONSIBILITY FOR ANY DEFECTS OF THEIR FUEL TANKS. WITH NO OTHER CHOICE, WE HAD TO PAY FOR THE REPAIRS OUT OF POCKET. THIS IS A SAFETY ISSUE, AS THESE VEHICLES ARE USED FOR COMMERCIAL USAGE DAILY. THIS IS ALSO A FINANCIAL BURDEN THAT HAS BEEN FORCED ONTO US UNFAIRLY. THEY NEED TO TAKE RESPONSIBILITY AND RECALL THESE FUEL TANKS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10293747November 28, 2009
ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL
ENGINE FAILED AND VEHICLE STOPPED WORKING. THE CULPRIT WAS THE FORD FUEL TANK THAT HAD DELAMINATED WHICH CAUSED DEBRIS TO MOVE THROUGH THE FUEL FILTER AND ENGINE. THE ENGINE HAD O BE REPLACED. THE TANK HAD TO BE REPLACED. THE COST: $10,345.00. ADDITIONALLY, THERE WAS A LOSS OF REVENUE AS THIS VEHICLE IS USED FOR PRODUCTION PURPOSES. FORD DENIED RESPONSIBILITY FOR ANY DEFECTS OF THEIR FUEL TANKS. WITH NO OTHER CHOICE, WE HAD TO PAY FOR THE REPAIRS OUT OF POCKET. THIS IS A SAFETY ISSUE, AS THESE VEHICLES ARE USED FOR COMMERCIAL USAGE DAILY. THIS IS ALSO A FINANCIAL BURDEN THAT HAS BEEN FORCED ONTO US UNFAIRLY. THEY NEED TO TAKE RESPONSIBILITY AND RECALL THESE FUEL TANKS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10293027November 20, 2009
FUEL SYSTEM, DIESEL
VEHICLE STOPPED WORKING. THE CULPRIT WAS THE FORD FUEL TANK THAT HAD DELAMINATED. THE TANK HAD TO BE REPLACED. THE COST: $1600.00. ADDITIONALLY, THERE WAS A LOSS OF REVENUE AS THIS VEHICLE IS USED FOR PRODUCTION PURPOSES. FORD DENIED RESPONSIBILITY FOR ANY DEFECTS OF THEIR FUEL TANKS. WITH NO OTHER CHOICE, WE HAD TO PAY FOR THE REPAIRS OUT OF POCKET. THIS IS A SAFETY ISSUE, AS THESE VEHICLES ARE USED FOR COMMERCIAL USAGE DAILY. THIS IS ALSO A FINANCIAL BURDEN THAT HAS BEEN FORCED ONTO US UNFAIRLY. THEY NEED TO TAKE RESPONSIBILITY AND RECALL THESE FUEL TANKS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10293031November 20, 2009
FUEL SYSTEM, DIESEL
VEHICLE STOPPED WORKING. THE CULPRIT WAS THE FORD FUEL TANK THAT HAD DELAMINATED. THE TANK HAD TO BE REPLACED. THE COST: $1600.00. ADDITIONALLY, THERE WAS A LOSS OF REVENUE AS THIS VEHICLE IS USED FOR PRODUCTION PURPOSES. FORD DENIED RESPONSIBILITY FOR ANY DEFECTS OF THEIR FUEL TANKS. WITH NO OTHER CHOICE, WE HAD TO PAY FOR THE REPAIRS OUT OF POCKET. THIS IS A SAFETY ISSUE, AS THESE VEHICLES ARE USED FOR COMMERCIAL USAGE DAILY. THIS IS ALSO A FINANCIAL BURDEN THAT HAS BEEN FORCED ONTO US UNFAIRLY. THEY NEED TO TAKE RESPONSIBILITY AND RECALL THESE FUEL TANKS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10273607June 12, 2009
POWER TRAIN:AUTOMATIC TRANSMISSION
TL*THE CONTACT OWNS A 2003 FORD F550 SUPER DUTY. WHILE IDLING, THE VEHICLE SHAKES AND LUNGES FORWARD WITHOUT WARNING. THE VEHICLE ALMOST LUNGED INTO TRAFFIC WHILE AT IDLING AT A STOP LIGHT ON ONE OCCASION. A COMPONENT WAS REPLACED BY THE PREVIOUS OWNER, BUT THE FAILURE STILL PERSISTS. THE CONTACT FEELS THAT A CRASH COULD OCCUR. THE CURRENT MILEAGE WAS 47,000 AND FAILURE MILEAGE WAS 46,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10260321February 28, 2009
FUEL SYSTEM, DIESEL
TRUCK WAS RUNNING ROUGH AND WAS LOOSING POWER. THEY REPLACED THE GAS TANK INJECTORS AND A PUMP. THE DEALER STATED THAT THE DIESEL WAS EATING AWAY AT THE LINER OF THE TANK. MY TRUCK IS ONLY 5 YEARS OLD. IT HAS COST HUNDREDS OF DOLLARS TO FIX. THE TRUCK IS IN THE SHOP RIGHT NOW FOR SAME PROBLEMS NO POWER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10251394December 10, 2008
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2003 FORD F550 SUPER DUTY. WHILE DRIVING LESS THAN 70 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY FOLLOWING, FLAMES APPEARED UNDER THE HOOD OF THE VEHICLE. THE FIRE WAS DESCRIBED AS "VIOLENT" WITH FLAMES AT LEAST 70 FEET HIGH. THE POLICE AND FIRE DEPARTMENTS WERE CALLED TO THE SCENE AND A REPORT WAS FILED. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE CONTACT HAS SUPPORTING DOCUMENTATION, INCLUDING VIDEOS AND PHOTOS. THE FAILURE AND CURRENT MILEAGES WERE 125,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10251041December 8, 2008
FUEL SYSTEM, DIESEL
2004 FORD SUPER DUTY W 6.0 LITER DIESEL. FUEL TANK INTERNAL COATING IF FLAKING OFF. ENGINE LOOSES POWER AND STOPS WITHOUT WARNING. MOST OF TANK HAS PEELED OFF WHICH PLUGS UP FUEL STRAINER IN TANK. TRUCK WAS TOWED AND THIS WASHED THE DEFECTIVE MATERIAL FROM THE FUEL STRAINER. NO CODES WERE DETECTED. THIS HAS HAPPENED 2-3 TIMES BEFORE WE CAUGHT IT. TANK AND INTERNAL PUMP WERE REPLACED AT ABOUT 120,000 MILES AT MY COST. I HAVE ALL THE PARTS. VEHICLE WILL LOOSE POWER IMMEDIATELY WITHOUT WARNING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-550