Ford F-250 Complaints (1996)

187 consumer complaints on file.

#11543544September 9, 2023
VEHICLE SPEED CONTROL
Cruise control switch began smoking, disconnected it and took it to Awesome Ford of Chehalis, WA for recall service sometime in June or July. Service tech found that brake fluid had wicked its way up electrical harness into cruise control servo, necessitating replacement in order to complete recall service. FoMoCo has been unable/unwilling to replace cruise control servo and is instead requiring that I pull one from a wrecking yard in order to complete recall service.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11469663June 16, 2022
FUEL/PROPULSION SYSTEM
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE. ABOUT 5 GALLONS OF FUEL SPILLED OUT OF FILL TUBE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11196563April 15, 2019
FUEL/PROPULSION SYSTEM
FUEL RUNNING OUT FOUNT TANK IN DRIVEWAY WITH SELECTOR ON REAR TANK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11024911September 21, 2017
FUEL/PROPULSION SYSTEM
EXCESS FUEL FROM REAR TANK IS RETURNED TO FRONT TANK CAUSING FUEL OVERFILL AND FUEL LEAK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10837715February 23, 2016
FUEL/PROPULSION SYSTEM
FRONT FUEL TANK STOPPED WORKING. VEHICLE RUNS USING REAR FUEL TANK. IF I TAKE OFF THE FRONT TANK FUEL CAP, GAS POURS OUT SOMETIMES SPRAYS ( ABOUT 8 OUNCES OR SO) . FRONT FUEL TANK SEEMS TO BECOME PRESSURIZED. THIS CAN HAPPEN EVERY TIME YOU DRIVE IT ( IF YOU REMOVE THE FRONT CAP). IN MY OPINION THIS IS A DEFINITE SAFETY HAZARD THAT NEEDS TO BE ADDRESSED. I DID SOME SEARCHES ON THE INTERNET AND THIS PROBLEM IS QUITE COMMON. BIG FIRE HAZARD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10794901November 19, 2015
TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 1996 FORD F-250 EQUIPPED WITH UNIROYAL LAREDO TIRES, SIZE: 265/75R16 (NA). WHILE MAKING A RIGHT TURN AT APPROXIMATELY 50 MPH, THE FRONT PASSENGER SIDE TIRE RUPTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS CONFIRMED THAT THE TREAD SEPARATED AND THE TIRE NEEDED TO BE REPLACED. THE TIRE WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 185,000 AND THE TIRE FAILURE MILEAGE WAS 15,000. THE DOT NUMBER WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10766371September 21, 2015
FUEL/PROPULSION SYSTEM
FUEL SPILLS FROM REAR TANK WHEN FUELING FRONT TANK. ENGINE SPUTTERS AND QUITS WHILE RUNNING DUE TO FUEL PRESSURE FAILURE..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10668218December 25, 2014
STEERING
THIS IS NOT A COMPLAINT BUT TO LET EVERYONE KNOW WHAT I HAVE FOUND TO BE PART OF THE PROBLEM ON THE STEERING NOT RETURNING AFTER A TURN. THE STEERING COLUMN BEARING IN THE TOP OF THE COLUMN IS BAD. I HAVE HAD TO REPLACE AT LEAST 20 OF THESE FOR THIS COMPLAINT AND FIXED THE PROBLEM. THE LOCKING OF THE STEERING WHEN BREAKING IS A HYDROBOOST PROBLEM NOT A STEERING PROBLEM. FORD NEED TO RESEARCH THIS AND CORRECT IT BEFORE THERE IS A DEATH BECAUSE OF IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10648731October 20, 2014
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1996 FORD F250. THE CONTACT STATED THE VEHICLE WAS OFF AND THE KEY WAS OUT OF THE IGNITION WHEN THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE WHO STATED THAT THE FIRE STARTED UNDER THE HOOD FROM A WIRE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNAVAILABLE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10609228July 9, 2014
TIRES, TIRES:TREAD/BELT
KUMHO KL78 245/75R16 LOAD RANGE E TIRE. PURCHASED A SET OF KL78 TIRES IN NOVEMBER 2011 FOR MY 3/4 TRUCK. SINCE THE TIME OF PURCHASE I HAVE PUT LESS THAN 20,000 MILES ON THE TRUCK / TIRES. THREE OF THE TIRES HAVE DEVELOPED LARGE DEFORMATION ACROSS THE TREAD CAP, LIKE A BULGE. THIS IS A MANUFACTURING SAFETY DEFECT CAUSED BY THE SEPARATION OF STEEL BELTS OF THE TIRE ALLOWING THE RUBBER TO DEFORM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10593652May 23, 2014
SEATS
TL* THE CONTACT OWNS A 1996 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE DRIVERS SEAT RECLINED INDEPENDENTLY. THE CONTACT WAS A LICENSED MECHANIC WHO STATED THAT THE BOLTS THAT HOLD THE SEAT UPRIGHT WERE BROKEN. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10584057April 21, 2014
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 1996 FORD F-250. THE CONTACT STATED THAT HE WAS REPLACING THE GLOW PLUGS WHEN THE VEHICLE SUDDENLY CAUGHT ON FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE MANUFACTURER WAS CONTACTED AND THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 06V286000 (VEHICLE SPEED CONTROL). THE CONTACT LATER RECEIVED A CALL FROM THE MANUFACTURER'S LEGAL TEAM, WHO ADVISED THAT THE FIRE WAS NOT RELATED TO THE RECALL. THE CONTACT STATED THAT THE MANUFACTURER NEVER INSPECTED THE VEHICLE TO MAKE THAT DETERMINATION. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 200,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10522089June 27, 2013
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 1996 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WAS SITTING IN A RESIDENTIAL DRIVE WAY WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND DETERMINED THAT THE SPEED CONTROL DEACTIVATION SWITCH WAS THE CULPRIT. THE VEHICLE WAS DESTROYED. THE CONTACT SPOKE WITH THE MANUFACTURER IN REGARD TO NHTSA CAMPAIGN ID NUMBER: 06V286000 (VEHICLE SPEED CONTROL), BUT WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE AND THE CURRENT MILEAGES WERE 150,000. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10499660February 22, 2013
STRUCTURE:BODY, STRUCTURE
TL* THE CONTACT OWNS A 1996 FORD F-250. THE CONTACT STATED THAT THE CROSS MEMBER, WHICH HELD THE REAR OF THE FUEL TANK WAS CORRODED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 96V146000 (STRUCTURE) THAT BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10493207January 16, 2013
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 1996 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT THE SPEED CONTROL DEACTIVATION SWITCH BECAME OILY AND STARTED LEAKING BRAKE FLUID. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE SPEED CONTROL DEACTIVATION SWITCH WOULD NEED TO BE REPLACED. THE CONTACT WAS INFORMED OF A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOTIFIED BUT ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL AND OFFERED NO OTHER ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 131,000. UPDATED 02/12/13*LJ THE CONSUMER STATED THE SPEED CONTROL ACTIVATION SWITCH FAILED. HE NOTICED THE CRUISE CONTROL STOPPED WORKING EIGHT MONTHS PRIOR. HE THEN NOTICED A WIRING HARNESS/CONNECTOR NEAR THE BAKE FLUID RESERVOIR WAS OILY AND THAT THE RESERVOIR WAS LOW. THE DEALER REPLACED THE SWITCH. UPDATED 02/13/13
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10481090October 19, 2012
TIRES
TWO OUT OF FOUR KUMHO TIRES HAVE FAILED WITH A THIRD ONE ON ADVISEMENT IN POOR CONDITION. ONE TIRE SEPARATED IN HIGHWAY TRAFFIC AT HIGHWAY VELOCITY. EXTENSIVE DAMAGE TO VEHICLE, BODY AND FUEL SYSTEM. VERBALLY AND IN WRITING I ASKED FOR AN INVESTIGATION INTO THIS MATTER WITH NO ACTION BEING TAKEN. I HAVE MAINTENANCE LOGS, RECEIPTS, PICTURES, ESTIMATES AND ALL EMAIL CORRESPONDENCES FOR YOUR REVIEW. *TR ON SEPTEMBER 10, 2010, UPON A VISUAL INSPECTION, THE CONSUMER NOTICED THE RIGHT REAR TIRE WAS GETTING READY TO SEPARATE. SO, HE REPLACED IT WITH ONLY 15, 979 MILES ON THE VEHICLE. ON SEPTEMBER 25, 2012, THE LEFT REAR TIRE SEPARATED AT HIGHWAY SPEED WITH 22,642.6 MILES ON THE TIRE, THE APPROXIMATE TREAD WAS 7/32. UPDATED IVOQ 11/19/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10450086March 2, 2012
TIRES, TIRES:TREAD/BELT
PLY SEPARATION. TIRE STORE CONFIRMED THEY WERE AWARE OF OTHER OCCURRENCES. THERE'S NO SECTION TO REPORT TYPE IN FORM SO I WILL HERE. TYPE APT. M&S LT235/85/R16. OTHER I.D. INFO.120/116Q. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10432898October 26, 2011
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 1996 FORD F-250 DIESEL. THE CONTACT STATED THAT WHILE DRIVING, AN ODOR OF BURNING PLASTIC BURNING WAS EMITTED INTO THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE CRUISE CONTROL BURNED A HOLE IN THE BRAKE FLUID RESERVOIR. AS A RESULT, THE CRUISE CONTROL LINES AND THE BRAKE FLUID NEEDED TO BE REPLACED. IN ADDITION, THE BRAKES WERE NOT RESPONDING PROPERLY. THE VEHICLE WAS THEN TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BRAKE BOOSTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 183,628 AND THE CURRENT MILEAGE WAS 186,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10399114May 4, 2011
STEERING
TL*THE CONTACT OWNS A 1996 FORD F250 DIESEL. THE CONTACT STATED THE STEERING COLUMN BECAME VERY LOOSE WHILE DRIVING. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 77,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10386991March 9, 2011
STEERING
TL* THE CONTACT OWNS A 1996 FORD F250 DIESEL. THE CONTACT WAS ENTERING A RESIDENTIAL PARKING GARAGE WHEN THE STEERING WHEEL COMPLETELY FRACTURED FROM THE VEHICLE. THE CONTACT WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND ENGAGED THE EMERGENCY BRAKE TO BRING IT TO A STOP. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE THE MECHANIC DIAGNOSED THE FAILURE AS A WEAK STEERING COLUMN WHICH WOULD REQUIRE REPLACING. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 263,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250