Ford F-150 Complaints (1993)

586 consumer complaints on file.

#11613783September 10, 2024
VEHICLE SPEED CONTROL, SERVICE BRAKES, HYDRAULIC
The contact owns a 1993 Ford F-150. The contact became aware that the VIN was included in NHTSA Campaign Number: 05V017000 (Vehicle Speed Control); however, the part to do the recall repair was not yet available. The contact stated that while replacing the brake master cylinder, the contact noticed that there was brake fluid leaking onto a connector. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and contacted the dealer. The failure mileage was approximately 156,000. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596212June 24, 2024
FUEL SYSTEM, GASOLINE, VEHICLE SPEED CONTROL
The contact owns a 1993 Ford F-150. The contact became aware that the VIN was included in NHTSA Campaign Numbers: 00V424000 (Fuel System, Gasoline) and 05V017000 (Vehicle Speed Control); however, the parts to do the recall repairs were not yet available. The contact stated that while inspecting the fuel tanks, he noticed that fuel had transferred from one tank to the other, nearly causing the tank to overfill. The local dealer was contacted and advised the contact that the vehicle was not covered under the recalls because the VIN was not included; however, the VIN tool indicated that the VIN was included. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and advised the contact that the VIN was not included in the recalls due to the manufactured date of the vehicle. The failure mileage was approximately 360,000. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11580079March 29, 2024
POWER TRAIN
The contact owns a 1993 Ford F-150. The contact stated while driving downhill in 4WD, and letting off the accelerator pedal, the transmission unintendedly shifted into neutral. The contact pulled over and placed the vehicle in park(P) before shifting into to drive(D) for the vehicle to operate as needed. No warning lights were illuminated. The contact stated that the failure recurred. The vehicle was not taken to the dealer and was not repaired. The contact referenced NHTSA Campaign Number: 93V089000 (Power Train) as a possible solution however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was approximately 200,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11541682August 30, 2023
FUEL/PROPULSION SYSTEM
To whom it may concern. I have a 1993 Ford F-150 pickup truck. I have recently experienced the problem with the fuel system described in NHTSA Campaign ID Number 93V125000, NHTSA Action Number EA93001. This defect in the fuel pump causes the fuel drawn from the front tank to be returned to the rear tank. In short time the rear tank capacity can be exceeded causing fuel to spill from filler neck into the environment. Not only is this an environmental issue, it is a major safety issue as the fuel could ignite causing a fire that could easily result in severe injury or death. I have contacted Sanderson Ford in Phoenix asking that they repair this problem under the conditions of the recall and they are refusing to do so. I am asking that NHTSA instruct Ford to repair this problem as described in the recall. Again, this problem causes raw fuel to spill from the tank into the environment causing both and environmental issue along with a major safety issue. The fuel could easily catch fire resulting in severe injury or death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519234April 27, 2023
FUEL/PROPULSION SYSTEM, ENGINE
The recall 00S57 was not done. This was my husbands vehicle and he has since passed away and when I went to get renewal plates for Kentucky since I have moved I saw the recalls and called Ford dealer. They can fix the 05S28 speed control system modification recall which I have scheduled, however they advised parts for repair are no longer available from Ford. I have not had an issue as yet, however since the recall is engine and gas related which could cause a fire, I would like to get the vehicle fixed. Please advise. Thank you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11434541September 27, 2021
UNKNOWN OR OTHER, POWER TRAIN
Regarding Ford Safety Recall 93S65 4X4 Transfer Case comes out of gear while in 4X4 High and will roll away, pops out of gear while in reverse, shift indication lights fail to report proper placement of the transfer-case, at start up the Vehicle shifts on its own, Shift from 2H to 4H results in Chatter, the Vehicle is currently stuck in 4L. I found a recall publication (TSB 92-01-08 (Excerpt) Touch-Drive ESOF Operation) that is specifically related to this problem Safety Recall 93S65. Affected Vehicles: 1993 Model F- Series and Bronco 4x4 Vehicles. I went to DCH Ford in thousand Oaks for direction, I spoke with [XXX] (Service Director) [XXX], [XXX] regarding this recall. Ford and NTSB do not show this Recall. Ford must address this safety recall first. Please advise INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11426323July 25, 2021
FUEL/PROPULSION SYSTEM
Started hearing fuel pump stay engaged after turning engine off and could smell fuel during these times. Fueled up rear tank next morning and when I arrived at work and got out with truck still running there was gasoline pouring out from the front gas tank spiller neck at an alarming rate. When I selected the front tank it stopped flowing. Next day while in traffic at light When I engaged the gas pedal and fished tailed due to a puddle off gasoline dumping from truck onto rd. In front of rear tires. Started having poor acceleration and seemed as if truck wasn’t getting enough fuel or lacked power. Still has open recall so I brought it to Ford dealership explain the issue and also that cross fuel flow in those year trucks has a recall for same issue. Trucks been there 2 weeks and I’m being told it’s to be $2700 to replace both fuels pumps and shuttle valves. I showed them video of gas pouring from the truck and showed them fords recall and remedy for issue. They said they will not fix this problem in truck and I must cover cost. This after knowing of recall and seeing a video of fuel spillage will not cover cost. This is unsafe I feel as any source of ignition may cause a fire from immediate gas spillages. Ford said they would over do repair if 12 years from start of warranty date of truck or Under 150k . Truck is under that mileage . But refuse to make repair under prior recall even though this is extremely dangerous situation to be driving truck. Trucks still in shop and I’m awaiting for a response from Ford corporate as I contacted them to explain issue in hopes they would honor repair as I feel it necessary for the safety of myself, family, and those others whom may be hurt in the event an accident occurs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11415850May 10, 2021
FUEL/PROPULSION SYSTEM
I JUST GOT THIS TRUCK USED AND REALIZED IT HAS DUAL GAS TANKS BUT ONLY THE REAR GAS TANK WORKS. I PUT GAS IN BOTH TANKS NOT KNOWING THAT I REALIZED AFTER THAT THE FRONT TANK DOESN'T WORK... THE NEXT MORNING I NOTICED GAS SPILLING OUT FROM UNDER THE TRUCK BECAUSE SOME OF THE GAS FROM THE REAR TANK IS GOING INTO THE FRONT 1 AND MAKING IT OVERFLOW.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11322299April 26, 2020
FUEL/PROPULSION SYSTEM
FUEL IS SPEWING FROM THE GAS TANK /CAP WHERE YOU FILL IT. WHEN THE TRUCK IS PARKED THE GAS CAP HISSES LIKE IT IS PRESSURIZED. GAS IMMEDIATELY STARTS POURING OUT OF THE GAS CAP AND EVEN SPEWS OUT. I'VE TAKEN SPECIAL CARE NOT TO OVERFILL EITHER TANK. I AM CONCERNED THIS TRUCK IS NOT SAFE TO DRIVE. THIS OCCURS SHORTLY AFTER DRIVING, IT STARTS, SPUTTERS AND THEN STOPS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11058342January 3, 2018
FUEL/PROPULSION SYSTEM
NHTSA RECALL NUMBER: 00V424000 - FUEL PRESSURE REGULATOR ISSUES - TRUCK LOSES POWER DUE TO LACK OF FUEL AND NOW IT IS TRANSFERRING FUEL BETWEEN TANKS WHILE DRIVING. I TOOK TRUCK TO LOCAL DEALERSHIP IN AUGUST 2017 WHEN I DISCOVERED THE RECALL AND WAS TOLD THAT THE TRUCK IS PART OF THE RECALL BUT THAT THE PART IS ON BACK ORDER FROM FORD. IT IS NOW JANUARY 2018 AND STILL NO PART. I HAVE REPLACED BOTH FUEL TANKS AND FUEL PUMPS WHEN I FIRST BOUGHT THE TRUCK ALONG WITH HAVING THE ENGINE REBUILT. THE TRUCK IS UNSAFE TO DRIVE DUE TO THESE ISSUES BUT I AM AT LOSS OF WHAT TO DUE AT THIS POINT SINCE FORD IS NOT PROVIDING THE PARTS. I FEEL THAT THE FUEL CHECK VALVES SHOULD BE REPLACED BY FORD SINCE I HAVE ALREADY REPLACED THEM MYSELF. I DISCOVERED THE RECALL ON MY OWN IN AUGUST 2017. I PURCHASED THE TRUCK EARLY IN 2014 FOR MY SON AS A HIGH SCHOOL GRADUATION PRESENT AND TO DRIVE TO COLLEGE. HE IS NOW A SENIOR IN COLLEGE AND HAS NOT BEEN ABLE TO DRIVE IT TO COLLEGE DUE TO THESE ISSUES. FORD RECALL: 00S57
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11024238September 19, 2017
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1993 FORD F-150. WHILE REFUELING THE VEHICLE, IT EXPERIENCED LEAKING FROM THE FILLER TUBE. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS APPROXIMATELY 157,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11003918July 9, 2017
FUEL/PROPULSION SYSTEM
FUEL CROSS FLOWS BETWEEN TANS. I WAS DRIVING ON FRINT TANK. WHEN I STOPPED FUEL WAS GUSHING OUT REAR GAS CAP CAUSED $790.00 DAMAGE TO CUSTOM PAINT JOB. THIS TRUCK WAS FRAME OFF RESTORATION JUL, 08.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11000866June 23, 2017
FUEL/PROPULSION SYSTEM
FUEL CROSSFLOW: UNUSED FUEL FROM REAR TANK RETURNS TO FRONT TANK, CAUSING FUEL OVERFLOW AND FUEL SPILLAGE. VEHICLE WAS RECALLED FOR THIS CONDITION IN 1994. RECALL #93S68 WAS PERFORMED BY SELLING DEALER IN 1994. PROBLEM WITH FUEL CROSSFLOW BEGAN IN DECEMBER, 2016. FORD HAD ISSUED AN EXTENDED RECALL #01M05 FOR THIS CONDITION FOR 12 YEARS OR 150,000 MILES, WHICHEVER COMES FIRST. VEHICLE HAS ONLY 75,600 MILES, BUT IS NOW 24 YEARS OLD, SO IS NOT STILL COVERED. HOWEVER, I FEEL THIS IS A DANGEROUS CONDITION, RISKING A FIRE WHILE VEHICLE IS RUNNING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10967111March 20, 2017
FUEL/PROPULSION SYSTEM
MAKE : FORD MODEL : F150 YEAR : 1991 NHTSA CAMPAIGN ID NUMBER : 93V125000 RECALL DATE : JUL 14, 1993 COMPONENT: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY POTENTIAL NUMBER OF UNITS AFFECTED : 1131000 SUMMARY: A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE. CONSEQUENCE: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION. REMEDY: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES. NOTES: SYSTEM: FUEL; FUEL TANK ASSEMBLY.VEHICLE DESCRIPTION: LIGHT TRUCKS AND CHASSIS CABS WITH GASOLINE ENGINES ANDDUAL FUEL TANKS.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED SERVICEDATE AND THE REMEDY IS NOT CORRECTED WITHIN A REASONABLE TIME WITHOUT CHARGEOR THE REMEDY DOES NOT CORRECT THE SAFETY-RELATED DEFECT OR NONCOMPLIANCE,PLEASE CONTACT FORD'S CUSTOMER ASSISTANCE CENTER, 300 RENAISSANCE CENTER,P.O. BOX 43360, DETROIT, MI 48243. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFICSAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10905834September 12, 2016
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1993 FORD F-150. WHILE THE VEHICLE WAS STATIONARY, THE REAR FUEL TANK POURED FUEL ONTO THE GROUND. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 135,600. UPDATED 11/07/16*LJ THE CONSUMER STATED A DESIGN DEFECT IN THE FUEL PUMP CHECK VALVE CAUSED THE FUEL TO OVERFLOW. UPDATED 11/30/16.*JB THE CONSUMER STATED SAFETY RECALL 00S57 REPLACEMENT OF FUEL PRESSURE REGULATOR AT THE INJECTION RAIL CAN NOT RESOLVE DESIGN IN FUEL PUMPS. UPDATED 7/07/2017*JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10883656July 8, 2016
FUEL/PROPULSION SYSTEM
1993 FORD F150 XLT WITH DUAL FUEL TANKS. THE FUEL SYSTEM DELIVERS RETURN FUEL FROM THE REAR TANK TO THE FRONT INSTEAD OF THE TO THE REAR CAUSING THE FRONT TANK TO OVERFLOW FUEL OUT OF THE VEHICLE. MAJOR FIRE AND SAFETY HAZARD. THIS OCCURRED WHILE DRIVING AND CONTINUED AFTER VEHICLE WAS TURNED OFF. FORD HAD A SAFETY RECALL ON SOME VEHICLES FOR THIS EXACT ISSUE BUT REFUSED TO REPAIR MINE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10850353March 18, 2016
FUEL/PROPULSION SYSTEM
TAKATA RECALL: I JUST BOUGHT A MY TRUCK TWO YEARS AGO AND EVEN SINCE I BOUGHT IT, ITS BEEN RUNNING RICH AND ACTING LIKE IT DOESN'T HAVE ENOUGH FUEL PRESSURE. I HAVE EXPERIENCED BOGGING, HESITATION WHILE DRIVING AND FUEL LIKE SMELLS COMING FROM UNDER THE TRUCK. I SEE THERE IS A RECALL FROM 2001 ABOUT THE FUEL PRESSURE REGULATOR OR SOMETHING BUT I DON'T KNOW MUCH ABOUT IT. I THINK THE NHTSA RECALL NUMBER WAS 00V424000 FROM WHAT I FOUND ONLINE. I AM JUST WONDERING IF THAT'S SOMETHING I CAN STILL GET FIXED FOR FREE BY THE DEALER SINCE THE PREVIOUS OWNER DIDN'T GET IT DONE. THE TRUCK ONLY HAS 112,000 MILES ON IT AND IS IN MINT CONDITION. ANY MORE INFORMATION ON THE MATTER WILL HELP, THANKS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10821986January 25, 2016
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1993 FORD F-150. WHILE ATTEMPTING TO REFUEL THE VEHICLE, THE FUEL CAP WAS UNSCREWED AND FUEL SPILLED OUT OF THE TANK. IN ADDITION, WHILE REFUELING THE FIRST TANK, FUEL SPILLED INTO THE SECOND TANK. WHILE REFUELING THE SECOND TANK, FUEL SPILLED INTO THE FIRST TANK. THE VEHICLE WAS TAKEN TO A DEALER WHO REPAIRED THE VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 00V424000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE FAILURE RECURRED AND THE CONTACT INDEPENDENTLY REPLACED THE FUEL PRESSURE REGULATOR, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 168,000. UPDATED 03/16/16*LJ *CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10748754August 14, 2015
FUEL/PROPULSION SYSTEM
STOPPED AT SERVICE STATION TO FUEL VEHICLE. THE VEHICLE HAS DUAL TANKS. THE TANK SELECT SWITCH WAS IN THE REAR TANK POSITION. WAS GOING TO ADD FUEL TO REAR TANK BECAUSE THE FRONT TANK WAS INDICATING 'FULL' AND THE REAR TANK WAS NEARLY 'EMPTY'. OPENED THE FRONT TANK GAS CAP BY MISTAKE AND FUEL SHOT OUT AS IF UNDER PRESSURE ALL OVER THE SIDE OF MY VEHICLE AND ONTO THE GROUND WITH ENOUGH FORCE TO WET MY SHOES AND THE BOTTOM FRONT OF THE LEFT REAR TIRE. THERE WAS ABOUT A QUART OF FUEL EJECTED. I PUT THE CAP BACK ON AND CLOSED IT UNTIL IT CLICKED, AS USUAL. THEN I PROCEEDED TO PUT FUEL IN THE REAR TANK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10725710June 17, 2015
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1993 FORD F-150. WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE CONTACT ATTEMPTED TO PLACE FUEL IN THE FUEL TANK BUT IT SPILLED OUT WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CONNECTOR VALVE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 183,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150