Ford F-150 Complaints

2,276 consumer complaints on file.

#11666327June 11, 2025
TIRES
The contact owns a 2025 Ford F-150 equipped with Hankook Tires, Tire Line: Dynapro A/T 2, Tire Size: 275/60/R20, DOT Number: (N/A). The contact stated that upon inspection, it was discovered that the rear passenger’s side tire had a 3/4-inch sized tread separation. A replacement tire was installed. The contact later discovered that the same failure had occurred with the front passenger’s side tire. The cause of the failures were not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 5,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666130June 10, 2025
PARKING BRAKE
The contact owns a 2023 Ford F-150. The contact stated while driving at slower speeds, the vehicle would immediately brake independently without depressing the brake pedal. The Brake warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed at the owner’s expense; however, the cause of the failure was not determined. The vehicle was not repaired. Upon further investigation, the contact related the failure NHTSA Campaign Number: 23V509000 (Parking Brake); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 46,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665918June 9, 2025
POWER TRAIN
Sudden unexpected downshifts to first, third or fifth gear causing sudden deceleration, very high rpm, and tire lockup. Occurred at any speed. Sudden deceleration in traffic. Loss of directional control. No warnings. No alerts. It is not safe to drive. It has been at the dealer for 2 weeks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665639June 8, 2025
ELECTRICAL SYSTEM
Related to TECHNICAL SERVICE BULLETIN Various Gear Shift Module Concerns 25-2045 I experienced an issue where my truck was stuck in drive and the engine off. The truck could not be turned on if it wasn't in park, but couldn't be shifted unless it was on. This appears to be a very common issue as I made a post on Reddit [XXX] ) and many other users noted the same issue (low milage, relatively new tucks) with the same fix - a tow to a ford dealer and a $1000+ replacement of the shift module. The service manager told me it was "a common issue". It should be categorically impossible for a $70k+ tuck with less than 40K miles to be unable to shift gears due to faulty computer components. Ford didn't consider this issue under warrantee. Ford should have this module recalled - it is unfair for consumers to foot the bill to replace what should be a life time/never fail component. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665468June 7, 2025
SERVICE BRAKES
The same brake booster that allegedly only had 51 vehicles included in it? Same exact issue as this link: [XXX] not working seems like a pretty big safety issue. DTC Code: C0594 Brake Booster Motor "A" Performance DTC Code: C0594 Right rear solenoid circuit INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665320June 6, 2025
PARKING BRAKE
The contact owns a 2023 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V509000 (Parking Brake); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665261June 6, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated while driving 60 MPH, the transmission unexpectedly downshifted. There was no warning light illuminated. The vehicle was taken to several dealers but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665029June 5, 2025
POWER TRAIN
The contact owns a 2012 Ford F-150. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the contact stated that the transmission shifted hard, and the vehicle jerked while moving forward. The contact stated the vehicle jerked extremely hard and the contact's head jerked forward. The dealer was made aware of the failure. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 62,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664909June 4, 2025
POWER TRAIN, ENGINE AND ENGINE COOLING
The contact owns a 2021 Ford F-150. The contact stated that while driving approximately 60-65 MPH, there was fluid leaking from the vehicle, and the engine was overheating. There were no warning lights illuminated. The contact checked the Ford Pass App and became aware that the transmission had been serviced four times. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664790June 4, 2025
POWER TRAIN, ELECTRICAL SYSTEM
Transmission harsh shifting, jerking, sudden loss of power, and unexpected downshifts. Goes into power saving mode every time I shut vehicle off. Remote start never available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664696June 3, 2025
POWER TRAIN
The Ford 10R80 transmission in my 2021 F-150 removes all confidence in the dependability of this truck. The transmission will slip and not engage for about 3-5 seconds and then lurch forward after finally finding the gear. This happened multiple times now and the 2 most dangerous were while taking an unprotected, but authorized left turn on a busy highway. Vehicles in the opposing lane had to slow down because as I started to turn, the truck hardly moved as I hit the accelerator. The gear finally engaged and I was able to get out of the way before being hit. Many technicians have told me this is almost certainly due to the widely known faulty CDF drum on 2021-2022 F-150's. Ford has since revised the CDF drum, but anyone who owns a 2021-2022 will have to pay out of pocket after this part inevitably fails and causes catastrophic damage. This is a VERY dangerous and serious fault with an essential part of the vehicle. Ford needs to address this issue as soon as possible.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664614June 3, 2025
UNKNOWN OR OTHER
Since my truck was brand new, the infotainment screen very often blacks out so that I can not see navigation, back up camera, radio, etc. It keeps resetting itself until it comes back on. A couple of times when I brought it in for service I asked them to check it out and it was always "Seems to be working fine". Today I backed into a sign as the back up camera was frozen and I did not notice that it was not real time. After I hit the sign, the screen went black and then the Ford insigna came up and it repeated 3 times and then everything was fine. Ford service has never been able to fix it as the don't see it when they start the vehicle. I will start taking videos with my phone. Anyway now that the extended warranty just ran out, it is getting worse where it happens almost all the time. I talked to some friends and they tell me they have the same issue so you need to be aware that this dangerous situation might be a common problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664607June 3, 2025
POWER TRAIN
Transmission consistently shifts hard, both up and down gears, and has a constant vibration in overdrive gears at 45-55 MPH. Transmission was inspected and found to have a bad valve body which was replaced. Vibration did not subside. Within 6 months, rough shifting returned and increased in frequency and force. Down shifting at braking becomes stuttered and can cause the vehicle to continue further along due to increased torque from the down shift. Up shifting can cause sudden acceleration due to inconsistent pause between hard shifts leading to unintended acceleration.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664511June 3, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact stated while driving and making a turn to pull out of the driveway, the rear passenger's side wheel started sliding. The contact stated that upon straightening up the wheel to drive forward, the rear passenger's side wheel responded as needed. The contact stated while driving 30 MPH, the rear passenger's side wheel spun and slid. The contact was able to pull over to the side of the road temporarily. The contact stated that the failure recurred while turning and while driving straight. The contact was able to drive to the nearby residence. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 23V896000 (Power Train); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 125,700.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664487June 3, 2025
ENGINE, FORWARD COLLISION AVOIDANCE: WARNINGS
While stopped at a traffic light or in an intersection preparing to make a turn, the vehicle’s engine will randomly shut off. Simultaneously, a pre-collision warning appears on the display. This causes the vehicle to become temporarily disabled, even as oncoming traffic approaches. To recover, the driver must shift the vehicle into park, restart the engine, and quickly accelerate out of the way to avoid a potential collision.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664339June 2, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM
Loss on all braking systems. Multiple warning lights including on dash. Brakes will become spongy and not stop or lock up all 4 wheels at slightest touch. Taken to dealer who provided a service memo SSM 53683 which basically says vehicle unable to power down and no fix available. Ford is aware of the problem and has done nothing to fix this despite multiple phone calls and emails. This is a significant safety issue Vehicle is also brand new will less than 1000 miles on it
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664287June 2, 2025
ENGINE, ELECTRICAL SYSTEM
The contact owns a 2023 Ford F-150. The contact stated that when the vehicle was started, the check engine and other unknown warning lights illuminated. Additionally, the contact stated that while driving the vehicle, the vehicle was driving rough. The vehicle was towed to a dealer where to was diagnosed and determined that rodents had eaten through the wires, and all the wiring harnessed in the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 7,400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664273June 2, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 24V635000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664210June 1, 2025
VEHICLE SPEED CONTROL, LANE DEPARTURE: ASSIST
Thank you for a chance to file this information. The cruise speed control and lane keeping systems are not working consistently and properly. They fail every week when tested. So far - the dealer-warranty fixes have not been the remedy needed. The cruise control system on steeper slopes doesn't provide braking to stay at the set speed - and at times it doesn't provide any braking resistance - so the vehicle takes off full speed with gravity. The lane keeping system doesn't provide consistent drivers' assistance to prevent departing the lane - even with new/freshly painted center-lanes/side of the road lanes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11664001May 30, 2025
WHEELS
Rear Axle Hub Bolt Breakage - the rear axle hub bolt sheared off.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150