Ford F-150 Complaints

2,276 consumer complaints on file.

#11738865May 19, 2026
ENGINE, POWER TRAIN
In the second year of ownership I noticed that occasionally I would get no throttle response from the gas pedal when trying to accelerate. After several occurrences I began to pay close attention as to when this was occurring. I found that this occurs mostly, not exclusively, when I am slowing the vehicle to a near stop, not a full stop and then accelerating to continue, like slowing to round a corner on a green light and getting into traffic. For example, I was exiting a Home Depot parking lot, the driveway exits to the roadway. As I approached the driveway to enter the roadway I slowed, preparing to stop. Seeing no traffic on the roadway I then pushed the accelerator to enter the roadway. The pedal was dead, I got absolutely no acceleration. I pushed the pedal down slowly, nothing. I pushed the pedal to the floor, nothing. The truck rolled out onto the road, I coasted to the side of the road. Had there been traffic I'd have been hit. This has happened 20 times in two years and 80K miles. The most recent event was this week with my wife present, very scary, dead pedal, not throttle response. If you research "Dead Pedal" on GOOGLE, you will get the following response: The "dead pedal" in the Ford F-150 PowerBoost—a dangerous lag or total loss of throttle response—is a widely reported issue, particularly when accelerating from low speeds, turning, or right after starting. [1, 2, 3] The cause can range from a software glitch to transmission issues or failing sensors. Ford said there was a TSB, however the work performed had no effect on the dead pedal on my truck. Invoice attached from March 2026, it just occurred again this week. I am going to trade the vehicle in but I doubt that Ford will disclose this flaw to the next buyer, it will be their's to discover, hopefully not by "accident". I am going to trade this vehicle in and I'm sure the new buyer will have no idea of this potentially deadly flaw.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738747May 19, 2026
STEERING
The contact owns a 2021 Ford F-150. The contact stat3ed while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The steering assist failure warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed with a failed rack and pinion. The contact was informed that the rack and pinion needed to be replaced. The vehicle was not repaired. The contact was informed that the parts were in back order. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 73,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738729May 19, 2026
POWER TRAIN
The contact owns a 2023 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V512000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer, who inspected the vehicle and informed the contact that the rear axle hub bolt was broken; however, parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738717May 19, 2026
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS
My wife was parking our F150 in a parking lot with landscaped dividers I was a passenger. The vehicle was in one foot driving mode. As she approached the curb going 1 to 3 mph, she moved her foot from the accelerator to the brake. As soon as she left the accelerator the vehicle rocketed off. She put her foot down on the brake, but the power of the vehicle was so great and so fast the vehicle went over the curb and a 4 inch landscaping tree. Luckily we were facing a drive on the other side and not a car. The vehicle stopped in the drive. The surge possibly lasted 1-2 seconds, but that was enough to lose complete control. If we were facing another car we would have landed on top of it. We were not injured and no pedestrians were in the vicinity. The body shop and the Ford dealership were unable to tell us what occurred. Ford needs to access the EDR module. Online research shows this event has happened to other owners.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11738640May 18, 2026
UNKNOWN OR OTHER
Traveling on 2 lane road with no vehicles ahead or behind—full roof sun roof glass exploded, loud gunshot sound and broken glass. Remaining glass bowed up and a lot of glass blow back on to bed cover. I walked several hundred feet on both sides of road and no cause apparent—no lawn or weed trimming happening. Clearly this exploded inside out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738623May 18, 2026
POWER TRAIN
The contact owns a 2025 Ford F-150 The contact received notification of NHTSA Campaign Number: 25V512000 (Power Train) however, the part to do the recall repair was not yet available. The dealer was contacted and then the vehicle was taken to the dealer. The vehicle was not diagnosed or repaired. The dealer confirmed that the remedy parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738503May 18, 2026
POWER TRAIN
The contact owns a Ford F-150. The contact stated that during cold start up, there is a delay when reversing and resistance in backward movement. The vehicle moves slowly despite full throttle. The vehicle also intermittently experienced harsh shifting. The vehicle was taken to th The approximate failure mileage was 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738411May 17, 2026
SERVICE BRAKES
I was on the highway doing 70mph and went to break and I had no brakes. I was terrified. I kept trying and I got it to break and pressed again and lost them again. Eventually the pressure on the breaks returned. The remaining ride home was just scarey.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738393May 17, 2026
UNKNOWN OR OTHER
My 2022 Ford F150 B&O Unleashed Sound System 18SPK explodes from time to time with a deafening noise (pop, then static) that makes you jump. Turning off the radio does not stop the deafening noise. In the past, at times, I was able to stop the deafening noise by switching from satellite to AM radio. This last time, nothing I tried stopped the deafening noise and I could not pull off the road to turn off the truck for 10 minutes. My ears were still hurting the next day. During the 10 minutes I had to wind down the windows which did not help much. The speakers were getting hot to the touch, especially the little tweeter speaker, with a plastic burning smell. Each subsequent time I turned the truck back on (after waiting about a half minute) the deafening noise started again. Then I waited 10-15 minutes before starting the truck and the noise stopped. My truck is available for inspection upon request. My safety and the safety of others are put at risk because you jump when the problem occurs and are distracted when endeavoring to stop the problem. The Ford dealership cannot diagnose the problem unless the deafening noise appears at the time of service. The sound system has not been inspected by the manufacturer. There were no warning lamps, messages or other symptoms of the problem prior to the start of the deafening noise (pop, then static).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738319May 16, 2026
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
On 4/22/2026 while flat towing this vehicle behind my motorhome, it burst into flames. The trip began in [XXX] . Driving south on XXX, I stopped about 120 miles later at a rest stop near XXX. I did a complete walk around inspection. There were no issues, everything looked fine. We continued on and about 20 miles later another vehicle driver was telling me frantically to pull over. I looked at my rear camera and saw the Ford was smoking. This was not due to an improper neutral tow setting. The truck would have burned in the first 20 miles. I have towed this vehicle many times. I know the importance of doing it properly., Thankfully there was a good place to pull over. I tried to extinguish the fire with my extinguisher but it was too hot. I was unable to disconnect from the motorhome. Both are a total loss. I think of all the places this could have happened and how trapped we could have been. By the grace of God, nobody was injured. Yes there is a police report and an insurance claim. There were no warning signs. My braking system runs on its own battery so there was no draw on the Ford battery. Ford did an update on the computer the night prior. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11738123May 15, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
The recall is 10 months old and no remedy offered. Every time I get behind tge wheel I'm risking an injury or death of myself or someone else. I can't sell my vehicle because it would put the next owner at risk. Do I have to wait until there's an injury or death to have something done about this?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737918May 14, 2026
EXTERIOR LIGHTING
Both of the Daytime Running Lamps (DRLs) on my 2021 F150 have failed. They cost `$2,000 each to replace. They are LEDs, and were billed as never needing replacement, and certainly not under 50k miles. A quick search shows that this is a common issue with 2021+ F150s, and looking around on the road, I notice many with the same issue. This failure of safety equipment reduces visibility and could contribute to accidents.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737864May 14, 2026
POWER TRAIN
I received Safety Recall 23S65 in May of 2025. As of now, May 14,2026 parts are still NOT available for repair. Ford was aware of this safety issue well before May of 2025, yet they do not seem concerned at all to make parts available to dealers to repair this defect. This should be considered well beyond any reasonable time frame for Ford to have corrected this problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737813May 14, 2026
FUEL/PROPULSION SYSTEM
I have a 2023 f150 powerboost. I slowed down to a yielding sign to turn right onto the state highway. The engine was in electric mode, I went to push the acceleration pedal and nothing happened. The truck would not accelerate for 4-5 seconds. I then put the accelerator pedal to the floor and it finally engaged and the truck flew. I’ve had it happen once before but for only a second so I thought nothing of it. It was a scary experience as I could have been hit if another drive wasn’t paying attention. I’m scared to drive it now, and have made an appointment with the local ford dealership to diagnose. No engines lights are on. Only happens when stopping briefly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737760May 14, 2026
SERVICE BRAKES
When I'm driving my truck, usually when I have come to a stop on an incline, the parking/emergency brake will engage on its own. For example, most recently I was pulling out of a driveway with an incline. I was stopped at the bottom of the driveway to wait for the roadway to clear before I pulled out. When I hit the gas to go, the rear wheels skidded and the truck came to a stop in the oncoming traffic lane. I looked at the dashboard and saw that the parking brake symbol was on, indicating that the parking brake had engaged. I did not engage the parking brake- the truck did it on it's own.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737751May 14, 2026
STRUCTURE:BODY, ELECTRICAL SYSTEM
The passenger door lock/latch actuator is failing. The passenger door will not open from the outside at all. The door has to be opened from the inside. The power lock button and key fob do not unlock the passenger door. I can hear the lock/actuator trying to operate, but the door does not unlock or release from the outside handle. This issue started shortly after we had a historic/unusual cold freeze in Florida. The vehicle is kept outside, so it was exposed to the freezing temperatures. This creates a safety and security concern because the passenger door cannot be opened from the outside in an emergency, and the power lock system does not work properly. The issue has not yet been inspected by a dealer or independent repair shop. No warning lights or messages appeared before the failure. The component is still installed on the vehicle and available for inspection upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737648May 13, 2026
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
This is a continuation/escalation of NHTSA complaint 11689917. My 2021 Ford F-150 has experienced repeated fuel-system/electrical fuel-pump failures. The vehicle previously stalled and later cranked but would not start, returning code P0627 “Fuel Pump A Control Circuit / Open.” The in-tank fuel pump was replaced at owner expense for approximately $1,400 at an independent service center in September of 2025, but the repair did not permanently resolve the issue. The vehicle has now again lost fuel pressure/propulsion while traveling approximately 50 mph on a two-lane highway in a similar manner to prior failures. I was able to get the vehicle off the roadway, and it required towing back to my residence. This is approximately the fourth or fifth fuel-related failure, including stalls at low speed and non-start conditions related to fuel in parking lots. The symptoms appear consistent with Ford/NHTSA recall 25V455 / Ford recall 25S75, but my VIN was not included in the affected group. I am concerned that the recall population may be too narrow or that the remedy does not address the full defect pattern.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737490May 13, 2026
POWER TRAIN
My 2021 Ford F-150 with the 10-speed transmission has started shifting very hard and making grinding noises while accelerating. The truck will sometimes hesitate between gears and then slam into gear unexpectedly. I have also experienced sudden hard downshifts while driving at normal speeds. The issue seems to be getting worse over time. The grinding noise and harsh shifting are most noticeable during acceleration, but the transmission also feels rough during normal driving. At times it feels like the transmission is slipping before catching again. This creates a safety concern because the truck can unexpectedly jerk, hesitate, or downshift hard in traffic and at highway speeds. I have seen many similar complaints online involving the Ford 10R80 transmission, including issues related to harsh shifting and internal transmission problems. Ford has also issued technical service bulletins related to this transmission. No warning lights consistently appeared before the issue started. The problem has happened multiple times and can be reproduced during regular driving. The vehicle has not yet been fully repaired or diagnosed at the time of this report. The transmission and vehicle are available for inspection upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737445May 12, 2026
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM, ENGINE
Dash said look for safe place to pull over. When turned engine off, it would not start again. Had to wait hours to get it towed to dealership. Been there over 5 weeks and they still don't know what's wrong but suspect hybrid battery problem. Only about 21k miles and 18 mo old. No loaner provided.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737423May 12, 2026
SEAT BELTS
Seat belt sensors do not work correctly for back seat passenger. Seat doesn’t register people sitting in it or when seat belt is buckled sometimes. Issue was reported to dealer and taken for repairs u see warranty, but never completed. Causes issues when carrying passengers because i can’t tell if people are buckled. Sometimes driving down road it alerts randomly that seat belt was unbuckled and causes risk that could lead to an accident when I have to adjust it for a child while driving down the road. This is a wide spread reported issue for these trucks and should be recalled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150