Ford Explorer Complaints

917 consumer complaints on file.

#11580558April 1, 2024
STEERING, LANE DEPARTURE: ASSIST, LANE DEPARTURE: WARNING
The lane assist system put the vehicle into a skid on snowy road with no markings on roadway. The vehicle is available to inspect but insurance company is pushing to pickup vehicle as it was totaled. The system put vehicle into a skid that resulted into going into the ditch and hitting a power pole. As far as we know nobody has looked into system failure we did report it to sheriff and insurance company. This is the first time the lane departure turned on a snow covered road
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11580499April 1, 2024
STRUCTURE:BODY
For a week before 3/19/24, the driver door made increasing crunching noises when opened and closed. On 3/20/24 the driver door would not open and was subsequently left at Dean Sellers Ford for diagnosis and repair. The dealer relayed that there was a repair advisory on this issue which related to closed investigation / action PE23-013. On 3/21/24, the repair was completed and paid even though Ford Motor has previously agreed to announce a recall by March 2024. As on 4/2/24, no recall notification has been announced or received.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579092March 23, 2024
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
The vehicle looses power occasionally. When the accelerator is pressed it can take a second or 2 to start moving again. It happens when turning, changing lanes or going straight. I could be pulling into traffic and it will stop moving, even if the gas pedal is pressed down all the way. It will happen in every drive mode and when the traction control is off. The only time it hasn't happened yet is when I turn off the AdvaneTrac stability control. I have to hold down the traction control button for 5 seconds every time I start the vehicle. The dealer said they couldn't find the problem. The associate said it's a common issue with the Explorer's. It is very dangerous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11578894March 22, 2024
ELECTRICAL SYSTEM
The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the audio connection failed to function as intended. The contact stated that there was no audio power. The vehicle was taken to the dealer and the contact was informed that the radio audio connection was in the rear hatch of the vehicle and that water had been leaking into the rear hatch of the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure and agreed to assist with sixty-five percent of the repair cost. Additionally, the contact was advised to report the failure to the NHTSA Hotline. The failure mileage was 33,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11578835March 22, 2024
ELECTRICAL SYSTEM
Vehicle wouldn't start using push button start, several modules/components reported errors: traction control, parking break, steering, shifting. The vehicle drove fine less than 24 hours prior to 3/3/2024. Following a week at the dealership, Ford Motor Company and the Ford dealership determined the main wiring harness was the culprit. If the wiring harness fails while the vehicle is in motion/operation, that could result in a serious safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11578706March 21, 2024
POWER TRAIN
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11578156March 18, 2024
POWER TRAIN
25,000 miles on it, transmission failed on my husband and I as we were pulling out onto a busy street. The car jerked forward and shot us out half way before locking completely as a semi truck was coming and almost smashed into the side of us. Luckily we were on a hill and were able to put the car into neutral & was able to roll back at the last second before we were severely injured. Car was towed to dealer as it would not drive at all. Dealer had for 3 weeks before coming back and saying the fluid was low and discolored and had several burnt clutches..again only has 25,000 miles on it..replaced the clutches and told me I was good to go. 7,000 miles later car AGAIN jerks me as im on a busy street and then completely loses all power and will not accelerate, I was barely able to pull over into a business parking lot before almost getting rear ended because I was going 30mph UNDER the speed limit!!! I didn’t even have to exit my vehicle because I could smell the burnt trans fluid from inside the cabin! Getting towed to dealer in 2 days.. this is a MAJOR SAFETY CONCERN! I have almost gotten hurt TWICE by this defect with the 10r80 transmissions! This is serious and ford needs to start addressing this problem before someone seriously gets hurt!!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11578136March 18, 2024
PARKING BRAKE
The contact owns a 2022 Ford Explorer. The contact stated that while attempting to reverse, the vehicle failed to move, after which the contact became aware that the parking brake had failed to properly disengage. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11577936March 18, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was parked on an incline, and with a quarter tank of fuel in the vehicle, the vehicle failed to start. There was no warning light illuminated. The vehicle was towed to the local dealer. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11577479March 14, 2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
While driving around 45 miles per hour the vehicle braked on its own without any vehicle in front and dropped to 5 miles per hour, the dash displayed Brake Assistance. While that happened a car behind me came close to rear-ended my car. At this time the vehicle is at the dealer, it was towed. This is the first time this happened, the vehicle showed no warning before the incident. The fact the vehicle behind came so close to rear-ending my car makes this a safety concern, if this happened at a higher rate of speed the consequences could have been more serious.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576785March 12, 2024
POWER TRAIN:AXLE ASSEMBLY
See attached document for complaint
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576489March 10, 2024
POWER TRAIN
When shifting from drive to reverse, there is a significant lag in shifting (3-5 seconds). This is especially dangerous when needing to back into a driveway from a busy road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11575750March 6, 2024
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2022 Ford Explorer. The contact stated that while driving at an undisclosed speed, the reverse mode did not function as needed. The contact stated that when the gear shifter was shifted to reverse mode, the vehicle rolled either forward or backwards and then hesitated. The vehicle was taken to the dealer, however the failure was not diagnosed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11575531March 5, 2024
ELECTRICAL SYSTEM
The contact owns a 2022 Ford Explorer. The contact stated the vehicle would not restart at a gas station with high technical security. No warning lights was illuminated. The contact was able to enter and exit and lock the vehicle, but not restart the vehicle. The contact spoke with the dealer who felt as if there was a radio frequency interrupting with the computer in the vehicle causing the vehicle to shutoff. The failure recurred an additional time. The manufacturer was notified of the failure. The approximate failure mileage was 1,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11575463March 5, 2024
SERVICE BRAKES, POWER TRAIN, SUSPENSION
I hope this letter finds you well. I am writing to you regarding a persistent issue I have been experiencing with my 2021 Ford Explorer For some time now, I have noticed a loud sound when braking and when navigating obstacles such as speed bumps or when entering and exiting the ramp of my parking lot. Concerned about this situation, I took my vehicle to the service department at your dealership, where I was informed that there was a recall to replace a part related to this issue. I appreciate that you have identified and committed to addressing this problem through the recall. However, I am concerned that despite more than one or two months having passed since my initial visit, I have still not received any notification regarding the availability of the necessary part for the repair. This delay has been particularly frustrating as the problem persists and even seems to have worsened over time. The loud sound when braking and navigating obstacles is becoming increasingly pronounced, significantly affecting the driving experience and my safety on the road. I understand that manufacturing and distribution processes can be complicated, but I need an urgent solution to this problem. As a loyal customer of your dealership, I trust that you will take the necessary steps to resolve this situation quickly and effectively. Since my vehicle is my primary means of transportation, I strongly request that you expedite the repair process and keep me informed of any developments related to the recall and the availability of the necessary part. I look forward to receiving a prompt response and a satisfactory solution to this problem. I appreciate your attention and prompt action in addressing this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11575332March 4, 2024
SUSPENSION, STEERING
The contact owns a 2023 Ford Explorer. The contact stated there was an unknown part loosened at the front of the vehicle. While driving at unknown speeds, there was an abnormal rattling noise detected from the strut that had become louder over time. There were no warning lights illuminated. The vehicle was taken to the local dealer, where the front-end bolts were tightened. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline. The contact related the failure to NHTSA Campaign Number: 24V091000 (Suspension, Steering). The approximate failure mileage was 3,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11575207March 3, 2024
ENGINE, POWER TRAIN
My vehicle started to put up messages regarding going into power saver mode. The vehicle then said all wheel drive not available. After that electrical components started going unavailable such as power steering, brake assist, blind spot monitoring, cameras, and traction control. The vehicle then shut down while driving and all I could do was brake. When I attempted to restart the vehicle it did not restart. I jumped it and was able to safely pull it off the road. This is the 2nd time in three weeks this happened. Ford looked at the vehicle and tightened the battery cables. Then told me it was fine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11574936March 1, 2024
STRUCTURE:BODY, VISIBILITY:SUN/MOON ROOF ASSEMBLY
Roof trim blew off. Moon roof- yes Luggage rack- no Driver side
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11574291February 27, 2024
POWER TRAIN
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time to for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11573973February 26, 2024
POWER TRAIN
The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, an appointment to repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was made aware of the issue but disconnected the call without scheduling an appointment. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Explorer