Ford Expedition Complaints

512 consumer complaints on file.

#11633649January 2, 2025
POWER TRAIN
Transmission issues: Sudden loss of power while driving 2021 Expedition on interstate when transmission disengaged at approximately 75 MPH in passing lane. This occurred most recently AFTER transmission was re-built at Ford dealership. Transmission has been having these issues for years and they have gotten worse (more frequent) with time. Last time occurred on Thanksgiving day 2024. Large red wrench indicator warning light appeared on dash advising to consult owner's manual. Small wrench indicator light remained at bottom of screen after the larger one disappeared. Dealership has not been able to reproduce the event which occurred about an hour into the trip on the interstate when proceeding up a slight grade. Vehicle is not safe to drive. Work requires frequent travel on interstate day trips. Loyal to Ford. Love Expeditions. Have owned several. No confidence in this one. Value adversely affected since cannot in good faith sell vehicle without disclosure of transmission issues. No response from Ford to notice letter sent to them after most recent incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633544January 1, 2025
VEHICLE SPEED CONTROL
On [XXX] my 2024 Ford Expedition had a malfunction that could have had serious consequences. This was the second time that this malfunction had occurred. On both occasions, I was parked in my driveway. When I started the 2024 Ford Expedition and put it in gear, before touching the gas, the throttle immediately went to full speed and the vehicle took off. On both occasions, I used extreme brake pressure to keep the vehicle from launching across my driveway while I reached for the "Start/Off" button. With the brakes heavily applied, the front tires were skidded 4-5 feet in the gravel. I re-started the Expedition and, with the gearshift in "Park", the engine again raced to full RPM. I immediately hit the "Start/Off" button. For a third time, I pressed "Start" and, again, the engine roared to full RPM. I hit the "Start/Off" button. A fourth time the engine started at normal RPM. The gas pedal was never touched, only the brake pedal. The dealership picked up the 2024 Ford Expedition on November 11, 2024 and has the vehicle to this day - January 1, 2024. The dealer has attempted multiple times to replicate the incident to no success. They advised me that there are no Service Bulletins nor diagnostics in the vehicle to explain the two events. There are eyewitnesses to attest to what happened. The Expedition has 3,100 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632591December 27, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
The “handless” rear hatch opening activates when not intended. This has caused a concussion to a driver while loading a vehicle. While this is not a “driving” system, it causes injuries to occupants immediately prior to driving. It is entirely possible that a driver could suffer a head injury without knowledge, then begin driving. This causes a dangerous driving environment. In particular the system is supposed to operate when the key is in a persons pocket and the foot is waived in the air by the hitch receiver area. The issues exists because it activates even if an object moves under the vehicle when key is in the correct proximity. This can even pin a driver down with the door over thier back while loading. Again this causes injuries and issues that may not be discovered until driving. In this particular incident the driver was loading the cargo area, when the door activated to close unknown to driver. At the same time the driver was leaning back and standing back up hitting his head on the door while it was closing on him. Approximately 10 to 15 minutes later after finishing loading, the driver drove away (sole occupant). After another 10 to 15 minutes later driver was feeling dizzy and un able to focus. The driver stopped the vehicle and sought medical attention. The driver was diagnosed with a minor concussion. While this had a good result, it could have easily escalated or caused a serious accident. It is recommended that a safety advisory about the potential risks of automatic door opening/closing is released. In addition it is recommended that the manufacturer enable the ability to disable the automatic function in the vehicle system in a manner where it only comes back on after a user turns it on.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11632416December 26, 2024
STRUCTURE:BODY
The right tail lamp on my 2021 Ford Expedition was loose, and the tail lamp completely fell off while I was driving. My safety and the safety of other drivers was put at risk when the tail lamp fell off because my tail lamp was not visible to other drivers. The vehicle was not involved in any accident, and the tail lamp is in perfect condition. My car is at the dealership currently to get it fixed, and the technician stated that the tabs are broken on the backside of the tail lamp so it is not able to lock into place. The tail lamp has to be completely replaced. There were no warning lamps, messages, or any other type of indication that the tail lamp was loose. I believe this was caused by a manufacturer defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632146December 23, 2024
SUSPENSION
The contact owns a 2024 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle was shaking and vibrating. The contact stated that the failure was present at various speeds. The vehicle was taken to the dealer several times regarding the failure, however the failure was not duplicated. The contact stated that the dealer replaced and balanced all four tires, however the failure reoccurred. The vehicle was not repaired. In addition, the dealer requested that the vehicle be inspected by the engineer, however, the request was denied by the manufacturer. The manufacturer was made aware of the failure but did not assist. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 150. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632024December 22, 2024
UNKNOWN OR OTHER
Extremely loud/deafening loud pop and static noise coming from the speakers. Scared me so bad while I was driving had to throw the hazard on and stop the vehicle in road. The volume would not adjust and radio would not turn off. Had to turn off the vehicle and open the door for the loud static turn off. At restart deafening static immediately came back. Ears were ringing and felt numb in the inside. No recalls found for this and feel this is extremely dangerous while driving. Had vehicle serviced at dealer and no mention it offer to update the known issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631881December 20, 2024
ENGINE, TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS, SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
The contact owns a 2022 Ford Expedition equipped with Hankook, Tire Line: Dynapro, Tire Size: 275/55/R20, DOT Number: (N/A). The contact stated that while the vehicle was parked, the contact became aware that the tire pressure was low. Additionally, the check engine warning light was illuminated. The contact drove to Discount Tire to inflate the tire. The contact stated that there was an abnormal sound coming from the brake pedal. The vehicle was taken to a dealer where it was diagnosed and determined that the battery needed to be replaced, and the brake pedal needed to be cleaned. The battery was replaced, and the brake pedal was cleaned. The vehicle was driven back to the dealer where it was diagnosed, and the failure was linked to the brake pads and rotors. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 8,065.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630632December 13, 2024
VEHICLE SPEED CONTROL, STEERING, WHEELS
At highway speeds, the car shakes/vibrates. It's scary. Took vehicle to Ford service. They identified the problem, acknowledged that it exists and was unable to fix it. Now, I'm stuck with this car that shakes and seems unsafe as it shakes. Additionally, was told by the Ford dealer that other Ford Expeditions have come in with the same problem and have been unable to remedy. Even with a case open with the Ford engineers, they were unable to fix. Ford Motor company has been contacted about the issue along with the executive offices of Ford and the CEO.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630431December 12, 2024
AIR BAGS, SERVICE BRAKES
I was in an accident on December 9 at 2 pm it was slightly wet out & 51 degrees i was making a left turn out of a business went into the middle lane and gave some gas to merge into the lane and the back end of the vehicle locked up and swung into a tail spin to the right as I applied the brakes it locked up worse and the vehicle spun around twice. Went into oncoming traffic and was hit. Had to exite the vehicle on the passenger side because i could not open the drivers door. When the police and tow truck came the both could not believe the airbags did not deploy . The car was found to be totaled by my insurance Co. AAA The fact that not one of the airbags didn’t deploy is very disturbing to me!!! This was my first Ford and dont think i will ever own anther.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11630149December 11, 2024
STEERING
The contact owns a 2021 Ford Expedition. The contact stated that the vehicle was difficult to steer and was pulling to the left and to the right. There was no warning lights illuminated. The EPAS system was turned off by the owner. The vehicle was taken to an independent mechanic for an alignment. The vehicle was repaired but the failure recurred. The contact received notification of NHTSA Campaign Number: 24E055000 (Steering); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact requested a buy back, but the vehicle failed to meet the requirements. The approximate failure mileage was 24,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630110December 11, 2024
VEHICLE SPEED CONTROL
The contact rented a 2024 Ford Expedition. The contact stated that while driving 60 MPH with the Adaptive Cruise Control activated, upon passing a speed limit sign the vehicle independently accelerated to 80 MPH. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer nor an independent mechanic. The vehicle was not repaired. The rental agency was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 24,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629636December 9, 2024
ENGINE, POWER TRAIN
The contact owns a 2021 Ford Expedition. The contact state while driving 55 MPH, there were abnormal sounds coming from the engine and the transmission. The temperature gauge warning light was illuminated. The vehicle was taken to a Chevrolet dealer twice to be diagnosed. The contact was informed that the transmission needed to be replaced. The transmission was replaced, and the vehicle was repaired. After the second repair the contact noticed that the engine was overheating. The vehicle was taken to a Ford dealer and the transmission was replaced another time. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 89,035.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628143December 1, 2024
VEHICLE SPEED CONTROL, POWER TRAIN
Service engine light illuminated indicating different occurrences. The vehicle was taken to a Ford dealership for repair since it's under factory warranty. The service representative, after taking control of the vehicle, he wrote the following in the repair work order: "When Brandon went to park the vehicle, vehicle did not want to go, barely pressed the throttle pedal and it took off like it was floored, foot was off the pedal and it was accelerating in the lot, put vehicle in neutral and applied brakes - see line 2" Line two (2) in the work order states the following: "Customer states the service engine light is still on it shows two different occurrences and reasons in oasis - customer stated wrench light on and no power verified concern checked for dtcs found p2ABA in pcm checked for tsb ssm fsa found tsb 23-2353 reprogrammed pcm oer tsb road tested all okay at this time" Clearly a vehicle with an unexplained acceleration issue poses a real safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627259November 25, 2024
ELECTRICAL SYSTEM
My car continues to have electrical problems since 14 months after my purchase. I have reported it to Ford service multiple times as well as Corporate. Each time the same problem happens, I report it here as well. This is the 5th time that this has happened. Each time it has happened, I am at a red light and while waiting, my car just shuts off completely. In the beginning I could press my start button after 1-2 minutes and my car would restart. However, the 4th time it took 9 minutes before my car would start up. It happened again this past week. It took no longer than a minute for my car to start up again. I went to my local dealership and after they took a look, they just think the button with the "A and an arrow circling it" just triggered something and thats why it shut off. They told me there was nothing that they could do. My battery looked fine. This has happened so many times to my vehicle and its the same response, "my car is fine," it just triggered because it's "cold outside." Just tired of the Ford Corporation not fixing this problem in the Expedition. I have read stories on here with the same issue. Be aware if you drive this vehicle because one day someone will seriously get hurt.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625916November 18, 2024
EXTERIOR LIGHTING
Passenger side front headlight failure. The LED turns purple. Appears this is a common problem on vehicle with this type of headlight assembly F series as well. Dealers claim they don't know about it but a quick search to find its a common issue. Available for inspection. Light failure, confirmation is it is now always that way. Was inspected at the dealership and informed it was $3000 to replace the light assembly. No warning driver in front of me informed me to the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625709November 16, 2024
ELECTRICAL SYSTEM, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING, LANE DEPARTURE: BLIND SPOT DETECTION
My vehicle doesn’t alert me of incoming vehicles and the reverse camera stays on. When I turn on my vehicle the dash stays on with ford sign so when I put on reverse my back up camera doesn’t turn on at all. I have to use all my mirrors to back out of parking. This feature hasn’t been working properly for a year. They keep telling me ford is working to fix this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625431November 15, 2024
WHEELS, POWER TRAIN
The contact owns a 2023 Ford Expedition. The contact stated that there was an abnormal metal-to-metal sound coming from the front end of the vehicle while driving at slow speeds and downshifting. The contact stated there was something loose in the driver's side front wheel. There were no warning lights illuminated. The vehicle was taken to the local dealer four times, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The vehicle was taken to another local dealer, Gorno Ford Quick Lane (21111 Allen Rd., Woodhaven, MI 48183); on two occasions however, the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case, but no additional assistance was provided. The failure mileage was approximately 10.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625267November 14, 2024
POWER TRAIN
The contact owns a 2021 Ford Expedition. The contact stated that while driving at various speeds, the vehicle would hesitate upon the depression of the accelerator pedal without warning. During one failure, the contact shifted the vehicle from drive(D) to park(P) and the vehicle began to roll backward as though the vehicle were in neutral(N). The contact then shifted the vehicle back to drive(D) and the vehicle resumed normal operation. The vehicle was taken to a dealer where the contact was informed that the only way to diagnose the problem would be to duplicate the failure. The manufacturer was also notified of the failure and the contact was given the same information as the dealer. The contact was then referred to the NHTSA Hotline to file a complaint. The vehicle had yet to be diagnosed or repaired. The failure mileage was approximately 41,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623733November 5, 2024
TIRES
285/45/22 None of the tires will balance leading to terrible vibrations at highway speeds. Dealer tried several times to balance and also road force balance them. Vibrations can be dangerous at highway speeds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623483November 4, 2024
ELECTRICAL SYSTEM, SERVICE BRAKES, UNKNOWN OR OTHER
I was on my way to my daughter's school. We got off the on ramp to her school and while waiting at the red stop light, my car stalled. The wheels locked. My brake pedal and gas pedal were not working when the stop light turned green. The car dashboard was showing the power to be on but nothing was working. After a minute, the battery light and the a light with the arrow that kind of circles around it started blinking. I put my hazards and waved people behind me to go around me. After a few minutes, my car started to go backwards on the on-ramp. I looked back and could feel and see my car going backwards toward the cars behind me. The traffic behind me on the on-ramp started to honk at me. They could see what was happening too. I put the car from drive to park and put my emergency brake and the car stopped. I called 911 and explained what was happening. After a few more minutes, two men in two different vehicles came and offered to help push my car. One of them asked me to put my car in neutral but my car was not allowing me to turn to the different shifts. All of a sudden my car starts blinking again. One of the guys told me to try to press the power again. All of a sudden my car starts powering up again. I thanked the two men and finished dropping off my daughter to school. From the time my car stalled and turned back on was about 8-9 minutes. This car has shown problems over and over with Ford. I have had 3 new car batteries since owning this vehicle in the 3 years I've had it. I've reported all the different car issues on the NHTSA website. I just had my oil changed a few months ago. My car just had a few things fixed in June. I have never been so shaken up like this before. My legs and hands could not stop shaking. I couldn’t stop crying. I’ve never been so scared in my life in this vehicle. This was the first time my kid was with me when my car has stalled like this. For my car to lose complete function was the scariest moment in my life with my kid.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition