Dodge Grand Caravan Complaints (1997)

583 consumer complaints on file.

#11340809July 22, 2020
SERVICE BRAKES, ELECTRICAL SYSTEM, EXTERIOR LIGHTING
MY VAN WAS PARKED OUT SIDE LUCKYS ON MITALDA NEAR W MAUDE AVENUE IN SUNNYVALE CA 94086 I WAS USING THE WATER REFILLING STATION AND STARTED TO SMELL SMOKE WHEN I TURNED AROUND I IMIDEATLLY NOTICED THAT THE DRIVERS SIDE REAR TAILLIGHT WAS ON FIRE. NOT HAVING A FIRE EXTINGUISHER I TOOK THE BOTTLE OF WATER I HAD IN MY HANDS AND STARTED TO THROW WATER ON IT UNTIL THE FLAMES WENT OUT. WHAT IN THE HELL WOULD MAKE THAT HAPPEN? IS MY VAN UP FOR RECALL? I JUST PURCHASED THE VAN JUST A WEEK AGO. IT HAS BEEN A NIGHT MARE FOR ME NOT TO MENTION EXTREMELY COSTLY REPLACING EVERYTHING'S THAT'S BEEN GOING OUT. THE A/C CLUSTER THE DASH CLUSTER THE POWER WINDOW MOTOR. THE REAR VENT MOTOR. COUNTLESS BULBS AND FUSES.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11282502November 26, 2019
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
CAR SUDDENLY LOST POWER WHILE DRIVING ON THE FREEWAY AT 60MPH; ENGINE REMAINED ON. I PULLED OVER, TURNED OFF THE CAR, AND IT STARTED BACK UP AGAIN AND DROVE FINE FOR ABOUT 2 MILES. 'SERVICE ENGINE SOON' LIGHT CAME ON. WHEN IT LOST POWER AGAIN, I SLOWED AND THEN TRIED TO REACCELERATE, AND IT DROVE FINE FOR ABOUT 5 MILES, ENOUGH TO GET ME OFF THE FREEWAY AND TO A SAFE LOCATION. I CHECKED THE OIL AND TRANSMISSION LEVELS, WHICH WERE OK, AND THERE WAS NOTHING LEAKING UNDER THE CAR. WENT TO AN APPOINTMENT, AND CAME BACK TO THE CAR, WHICH STARTED UP AND DROVE OK FOR ABOUT A HALF MILE, THEN IT SHUT DOWN COMPLETELY AT A TRAFFIC LIGHT. THIS TIME IT WOULDN'T START BACK UP AGAIN, SO I PUSHED IT ONTO A SIDE STREET, WHERE IT STARTED UP FINE AND DROVE TO THE NEAREST GAS/REPAIR STATION. NOW, THE VAN WON'T START AGAIN. VAN WAS PROCEEDING STRAIGHT IN ALL SITUATIONS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10935387December 15, 2016
STEERING, ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
SERPENTINE BELT COMES OFF WHILE DRIVING IN SNOW CAUSING LOSS OF POWER STEERING ON SLIPPERY ROAD SURFACES. LOSS OF VEHICLE CONTROL AND ABILITY TO REGAIN VEHICLE CONTROL WAS COMPROMISED BY LACK OF STEERING ASSIST CAUSING THE VEHICLE TO LEAVE THE ROADWAY. I CONTACTED CHRYSLER AND THEY SAID THERE IS NO RECALL FOR MY VEHICLE.THIS WAS A VERY DANGEROUS SITUATION AS A SCHOOL BUS WAS NEAR MY VEHICLE WHEN THIS INCIDENT HAPPENED. THIS ISSUE NEEDS TO BE ADDRESSED AND A RECALL SHOULD BE MANDATED. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10735625July 21, 2015
SERVICE BRAKES, STEERING
PART 2 I'VE READ ON HERE THAT GATES HAS A BELT/PULLEY FIX FOR THIS PROBLEM. IF THEY HAVE ONE, CHRYSLER CAN MAKE ONE. THIS IS A DANGEROUS PROBLEM THAT CAN HAPPEN ANY TIME TO MANY DODGE VANS, IT RESULTS IN OTHER DAMAGES, SUDDEN LOSS OF POWER STEERING CONTROL, POSSIBLE INJURY EVEN DEATH TO MANY PEOPLE AT ONE TIME. MANY OTHER VEHICLES HAVE SERPENTINE BELTS WITHOUT THIS PROBLEM SO IT CAN BE FIXED. IT'S A REPEATED DESIGN FLAW & SHOULD BE CORRECTED IMMEDIATELY. A NTSB RULE GOES SOMETHING LIKE THIS "A COMPANY IS RESPONSIBLE FOR ANY FORESEEABLE PROBLEMS IN THEIR PRODUCT" THE SAME GOES FOR THE BRAKE LINES CORRODING ENOUGH FOR FAILURE TO OCCUR IN JUST A FEW YEARS, THIS IS ALSO UNACCEPTABLE. THIS IS A $29,850 VEHICLE NOT A $2,000 1967 VOLKSWAGEN BEETLE, MY BEETLE HAS THE ORIGINAL BREAK LINES. AND IN GOOD SHAPE. ALL BREAK LINES ARE TO BE STAINLESS STEEL TO RESIST RUST AND CORROSION. THIS IS PURELY LACK OF QUALITY IN MATERIALS USED TO MAKE THESE LINES AND THE COMPANY ALSO SHOULD BE MADE TO CORRECT THE PROBLEM BY WARNING ALL OWNERS ABOUT THE PROBLEM AND REPLACING ALL DEFECTABLE LINES WITH GOOD QUALITY LINES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10735643July 21, 2015
SERVICE BRAKES, FUEL/PROPULSION SYSTEM, SUSPENSION
PART 1 1/2 THE GAS LINE DECAYING AND THE SUSPENSION STRUT MOUNTS RUSTING AWAY, BOTH OF THESE ARE DEADLY, A RUSTY/CORRODED BREAK LINE WILL JUST LEAK A DROP AT THE TIME, MOST PEOPLE JUST REFILL THE FLUID RESERVOIR AND NEVER THINK ABOUT AGAIN, EVENTUALLY THE BREAK LINE FAILS ALL AT ONCE, THIS IS BECAUSE YOU ACTUALLY PUT MORE PRESSURE ON THE LINES THAN USUAL AND THE WEAK SPOT RUPTURES LIKE A WEAK SPOT IN A BALLOON WOULD. THAT MEANS THAT YOU WERE IN A BAD SITUATION ALREADY AND NOW YOU DON'T HAVE ANY BREAKING POWER AT ALL. WHAT DO YOU THINK HAPPENS NEXT??? ALL BREAK LINES ARE STAINLESS STEAL SO AS TO RESIST RUST AND CORROSION, THE ONLY REASON A BREAK LINE FAILS IN THIS LITTLE AMOUNT OF TIME IS BECAUSE THE MANUFACTURE IS PRODUCING AN INFERIOR PRODUCT AND SHOULD HAVE ALREADY BEEN MADE TO CORRECT THE PROBLEM. NOW,, THE STRUT MOUNTS, AS SOON AS THE COMPANY FOUND OUT THAT THEY HAD A PROBLEM WITH THE MOUNTS RUSTING THEY SHOULD HAVE RECALLED THE VEHICLES AND SPRAYED $10 WORTH OF UNDERCOATING OVER THE PARTS AFTER REMOVING THE RUST TO STOP ANY MORE RUST FROM FORMING. IF THE STRUT MOUNT IS RUSTED ENOUGH, IT CAN FAIL AT ANY TIME "USUALLY WHEN AT HIGHER SPEEDS AND YOU HIT A BUMP IN THE ROAD,, THAT SENDS AN EXTRA AMOUNT OF FORCE TO THE SUSPENSION. THE STRUT COMES UP THROUGH THE HOOD AND THE WHEEL MAY GO ANY WAY AND HIT ANY PART OF THE WHEEL WELL AND SUSPENSION THE AXLE MAY COME OUT OF THE WHEEL OR TRANSMISSION , ALL OF THAT MEANS YOU MAY HAVE TOTAL LOSE OF BREAKS AND OR STEERING. ALL 3 OF THESE PROBLEMS COULD HAVE EASILY AND SHOULD HAVE BEEN CORRECTED WHEN FIRST REALIZED MANY YEARS AGO, INSTEAD THEY KEPT RIGHT ON MANUFACTURING VEHICLES THE SAME WAY WITH THE SAME IMPERFECTIONS AND IF YOU GO TO A DEALER TODAY WITH EITHER OF THESE PROBLEMS THEY WILL SAY IT IS THE FIRST TIME THEY HAVE HERD OF IT, IT OUT OF WARRANTY, ETC. AND WILL NOT EVEN THINK ABOUT FIXING IT UNLESS WE PAY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10735642July 21, 2015
SERVICE BRAKES, FUEL/PROPULSION SYSTEM, SUSPENSION
PART 1 1/2 THE GAS LINE DECAYING AND THE SUSPENSION STRUT MOUNTS RUSTING AWAY, BOTH OF THESE ARE DEADLY, A RUSTY/CORRODED BREAK LINE WILL JUST LEAK A DROP AT THE TIME, MOST PEOPLE JUST REFILL THE FLUID RESERVOIR AND NEVER THINK ABOUT AGAIN, EVENTUALLY THE BREAK LINE FAILS ALL AT ONCE, THIS IS BECAUSE YOU ACTUALLY PUT MORE PRESSURE ON THE LINES THAN USUAL AND THE WEAK SPOT RUPTURES LIKE A WEAK SPOT IN A BALLOON WOULD. THAT MEANS THAT YOU WERE IN A BAD SITUATION ALREADY AND NOW YOU DON'T HAVE ANY BREAKING POWER AT ALL. WHAT DO YOU THINK HAPPENS NEXT??? ALL BREAK LINES ARE STAINLESS STEAL SO AS TO RESIST RUST AND CORROSION, THE ONLY REASON A BREAK LINE FAILS IN THIS LITTLE AMOUNT OF TIME IS BECAUSE THE MANUFACTURE IS PRODUCING AN INFERIOR PRODUCT AND SHOULD HAVE ALREADY BEEN MADE TO CORRECT THE PROBLEM. NOW,, THE STRUT MOUNTS, AS SOON AS THE COMPANY FOUND OUT THAT THEY HAD A PROBLEM WITH THE MOUNTS RUSTING THEY SHOULD HAVE RECALLED THE VEHICLES AND SPRAYED $10 WORTH OF UNDERCOATING OVER THE PARTS AFTER REMOVING THE RUST TO STOP ANY MORE RUST FROM FORMING. IF THE STRUT MOUNT IS RUSTED ENOUGH, IT CAN FAIL AT ANY TIME "USUALLY WHEN AT HIGHER SPEEDS AND YOU HIT A BUMP IN THE ROAD,, THAT SENDS AN EXTRA AMOUNT OF FORCE TO THE SUSPENSION. THE STRUT COMES UP THROUGH THE HOOD AND THE WHEEL MAY GO ANY WAY AND HIT ANY PART OF THE WHEEL WELL AND SUSPENSION THE AXLE MAY COME OUT OF THE WHEEL OR TRANSMISSION , ALL OF THAT MEANS YOU MAY HAVE TOTAL LOSE OF BREAKS AND OR STEERING. ALL 3 OF THESE PROBLEMS COULD HAVE EASILY AND SHOULD HAVE BEEN CORRECTED WHEN FIRST REALIZED MANY YEARS AGO, INSTEAD THEY KEPT RIGHT ON MANUFACTURING VEHICLES THE SAME WAY WITH THE SAME IMPERFECTIONS AND IF YOU GO TO A DEALER TODAY WITH EITHER OF THESE PROBLEMS THEY WILL SAY IT IS THE FIRST TIME THEY HAVE HERD OF IT, IT OUT OF WARRANTY, ETC. AND WILL NOT EVEN THINK ABOUT FIXING IT UNLESS WE PAY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10735648July 21, 2015
SERVICE BRAKES, FUEL/PROPULSION SYSTEM, SUSPENSION
PART 1.... I USED TO BE A MECHANIC AND TOW TRUCK OPERATOR. MY MINI VAN "LIKE MOST OTHERS" IS USUALLY DRIVEN BY A FEMALE & WITH A LOAD OF CHILDREN. IF DRIVING IN RAIN OR THROUGH A WATER PUDDLE THE BELT JUMPS OFF CAUSING LOSS OF POWER STEERING OVERHEATING BATTERY DRAIN ETC, IS A DANGEROUS EVEN DEADLY PROBLEM, IF A TURN IS NEEDED AT THE TIME THIS BELT JUMPS OFF, EVEN A STRONG HEALTHY MAN CAN LEAVE THE LINE OF INTENDED TRAVEL AND HIT WHAT EVER IS IN THE WAY, A CURB, A PEDESTRIAN OR EVEN CAUSE A HEAD ON COLLISION. THIS MOSTLY HAPPENS DURING RAINY/NASTY DAYS & BECAUSE OF THE COMPLEXITY OF REPLACING THE BELT, AND THE DAMAGE THAT IS CAUSED WHEN IT COMES OFF, THE VEHICLE USUALLY REQUIRES A TOW 4 REPAIR. IT IS STATED THAT, WHEN A CONSUMER MAKES A COMPLAINT & IF THE SAME COMPLAINT IS REPEATED AN INVESTIGATION WILL BE STARTED. THIS IS AN OLD PROBLEM WITH MANY, MANY, MANY COMPLAINTS YET, I SEE "NO ACTION, NOT EVEN AN INVESTIGATION INTO THIS PROBLEM", WHY?? CONSUMERS ARE DEPENDING ON YOU "SAFECAR.GOV, NHTSA" ETC. WHAT WILL IT TAKE, "A DEATH" TO START AN INVESTIGATION? OR, SHOULD I SAY, HOW MANY??? I KNOW THERE HAS BEEN ACCIDENTS BECAUSE OF THIS, AND A LOT OF DAMAGE JUST FROM THE BELT AS IT JUMPS OFF AND GOES FLOPPING AROUND, NOT TO MENTION THE PEOPLE THAT BURNED UP THEIR MOTOR EVEN STARTED A FIRE TRYING TO GET HOME, TO A SHOP ETC. THIS PROBLEM HAS BEEN A PLAGUE SINCE DAY ONE AND SHOULD HAVE BEEN AT LEAST FIXED ON THE NEXT YEARS MODEL BUT CHRYSLER JUST IGNORED IT. THEIR HAVE BEEN MANY VEHICLES WITH THESE SERPENTINE BELTS,, CHRYSLER VANS IS THE ONLY ONES THAT I KNOW OF WITH THIS PARTICULAR PROBLEM. THIS IS A DEADLY PROBLEM THAT SHOULD BE REPAIRED BY THE CHRYSLER CORPORATION SINCE THEY KNEW ABOUT THE PROBLEM FROM THE START AND JUST FLAT OUT IGNORED IT. THE GAS LINE DECAYING AND SUSPENSION STRUT MOUNTS RUSTING AWAY ON THESE SAME MODELS WILL BE MY NEXT POST
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10732862July 9, 2015
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL, ENGINE
TL* THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. WHILE DRIVING AT 62 MPH, THE VEHICLE STALLED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INSTRUMENT CLUSTER AND THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 77,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10654235November 11, 2014
ELECTRICAL SYSTEM
AT RANDOM GAUGES WILL STOP WORKING ON THE DASHBOARD AND THE ABS LIGHT WILL TURN ON. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10649392October 23, 2014
ELECTRICAL SYSTEM
THIS IS ACTUALLY MY MOTHER'S VAN AND A VAN THAT I HAD PREVIOUSLY OWNED. IT SEEMS THAT THESE VEHICLES SEEM TO HAVE A PROBLEM WITH THE SECURITY SYSTEM NOT DISARMING AS YOU TRY TO ENTER THE VEHICLE. YOU CAN UNLOCK THE DOORS FROM THE OUTSIDE, BUT AS SOON AS YOU GET IN THE VEHICLE AND TRY TO START IT, IT IMMEDIATELY SHUTS BACK DOWN AS A SECURITY PRECAUTION. A SIMPLE SMACK ON THE DASH CURES IT RIGHT UP, BUT BEING AS HOW IT'S MY MOTHER'S VAN NOW; SHE DOESN'T HAVE THE STRENGTH TO SIMPLY "SMACK" THE DASH AND GET EVERYTHING WORKING AGAIN. IT SEEMS AS THOUGH, THIS IS NOT THE ONLY KNOWN ISSUE. I HAVE READ ABOUT IT THROUGH SEVERAL DIFFERENT PEOPLE AND HAVE EXPERIENCED IT MYSELF ON TWO SEPARATE VANS. I HONESTLY BELIEVE THAT DAIMLER/CHRYSLER SHOULD ADDRESS THIS ISSUE AND NOT HAVE THE CONSUMER FIX IT, SEEING AS HOW IT IS AND ISSUE THAT'S BURIED IN THE DASHBOARD AND NOT OUT IN PLAIN SIGHT, LIKE SOME MECHANICAL ISSUES. THEY FIXED THE PROBLEM WITH THE CLOCK SPRING IN THE STEERING WHEEL, BECAUSE IT COULD SET OFF THE AIRBAG AT ANY GIVEN MOMENT. WELL, WITH ME HAVING TO SMACK THE DASH SEVERAL DIFFERENT TIMES, HER SPEEDOMETER IS OFF BY 50 MPH NOW. I AM HOPING FOR A RECALL NOTICE ON THIS ISSUE, DUE TO THE FACT THAT ONE MORE GOOD WHACK COULD SET OFF THE AIRBAG AND REALLY INJURY SOMEBODY. THANK YOU. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10643688October 9, 2014
SERVICE BRAKES
TL* THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, ALL OF THE BRAKE FLUID DRAINED FROM THE BRAKE LINES AND THE BRAKES FAILED TO STOP THE VEHICLE. AS A RESULT, THE CONTACT CRASHED INTO A TREE. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10614903July 21, 2014
ELECTRICAL SYSTEM, AIR BAGS, VEHICLE SPEED CONTROL
I PURCHASED MY 1997 DODGE GRAND CARAVAN FROM A PRIVATE PARTY IN 2009, AND SHORTLY AFTER THE GAUGE CLUSTER STOPPED FUNCTIONING WHILE I WAS DRIVING. CHECK ENGINE AND ABS LIGHTS CAME ON WHICH ON CHECKING WITH MY MECHANIC SAID MY ABS SYSTEM IS NON-FUNCTIONAL AS IS ALL OTHER INSTRUMENT RELATED READINGS. A SHORT TIME LATER, THE PANEL CAME BACK ON AND WORKED FOR AWHILE THAN SHUT OFF AGAIN. SOMEONE SAID HIT THE PANEL FACE AND THE GAUGES SHOULD COME BACK ON. I DID AND IT DID. FOR AWHILE. OVER TIME THE GAUGE FAILURE INTERVAL GREW SHORTER AND SHORTER, AND HITTING THE PANEL FINALLY FAILED TO RETURN THE USE OF THE GAUGES. TO REPLACE THIS GAUGE CLUSTER IS AN $800.00 PLUS REPAIR IN A SHOP WITH A REBUILD PANEL COSTING OVER $200.00 BY ITSELF. I DON'T WANT TO KNOW WHAT A DEALER WILL CHARGE. UPON FURTHER INVESTIGATION, I HAVE LEARNED THE GAUGE FAILURE CULPRIT IS COLD SOLDER JOINTS ON THE BACK SIDE OF THE CIRCUIT BOARD OF THE GAUGE CLUSTER AND IS AN ALL TOO COMMON PROBLEM WITH THIS CLASS OF VEHICLE. THIS DEFICIENCY CAN EASILY BE AVOIDED BY BETTER QUALITY CONTROL FROM THE MANUFACTURER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10606794June 29, 2014
FUEL SYSTEM, GASOLINE, ELECTRICAL SYSTEM
CAR HAS FAULTY GAS GAUGE AND DESPITE HOW MUCH GAS I PUT IN, WILL TOGGLE BETWEEN HAVING GAS TO EMPTY AND SITS ON EMPTY, HAS RUN OUT OF GAS AS A RESULT, HARD TO START AND NOW WILL NOT START. ALSO HAS MANY ELECTRICAL QUIRKS, TURN HEADLIGHTS ON INBOARD DASH LIGHT GOES OFF AND VICE VERSA. HAD SOMEONE FIX FAN TO GO ON WHEN PLUGGED INTO BATTERY SINCE CANNOT GET INTO COMPUTER DASHBOARD AND INTERNAL HEAT FAN STOPPED WORKING, ALSO INDICATORS WORK SPORADICALLY (SO EVIDENTLY AN ELECTRICAL COMMUNICATIONS ISSUE). I'VE READ THAT THIS YEAR HAS HAD RECALLS DUE TO FAULTY FUEL HOSES/LINES AND WHEN USING AFTER MARKET FUEL FILTERS EVEN FROM NAPA WHICH WILL CAUSE FUEL LINES TO BECOME FAULTY. MY VAN FALLS WITHIN THIS YEAR, BUT I WAS TOLD MY SPECIFIC VIN # DIDN'T APPLY. VAN IS 3.3 LITER ENGINE, V6. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10598502June 16, 2014
ENGINE
TL* THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. THE CONTACT STATED WHILE DRIVING 40 MPH, THE ENGINE WARNING LAMP ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 107,000. THE CURRENT MILEAGE WAS 114,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10494980January 28, 2013
POWER TRAIN
WAS DRIVING THE VAN ABOUT APPROX 35 MPH IN A SNOW STORM WHEN IT STARTED TO SLIDE, I ACCELERATED TO KEEP FROM SPINNING OUT AND THE TRANSMISSION LET GO..TOOK IT TO THE TRANSMISSION SHOP THAT PUT IT IN AND THEY SAID THE SPIDER GEARS WERE "WELDED" TO THE SHAFT AND IT CAUSED THE SHAFT TO BREAK..THIS IS THE SECOND TRANNY WE PUT IN THIS VAN FOR THE SAME THING. MANUFACTURE DEFECT..THEY SHOULD PAY FOR THE NEW TRANNY.. IT COST ME OVER $1950 TO PUT THIS TRANNY IN AND IT IS A REBUILD FROM ADVANCED AUTO..THEY SAID ITS A MANUFACTURE REBUILD..ALSO, THE SWITCH FOR THE HEADLIGHTS IS VERY LOOSE AND YOU HAVE TO PLAY WITH IT AND GET IT IN A CERTAIN POSITION TO GET THE LIGHTS TO STAY ON. YOU HAVE TO TURN THEM ALL THE WAY TO THE RIGHT THEN PULL IT OUT A LITTLE THEN IT WILL STAY ON.. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10486402November 28, 2012
SERVICE BRAKES
WHILE DRIVING RUSTED BRAKELINE RUPTURED AND LOST FLUID. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10474080September 6, 2012
ENGINE
TL* THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE HIT A SMALL POTHOLE AND THE CONTACT LOST POWER STEERING. ALSO, THE VEHICLE OVERHEATED AND THE ALTERNATOR WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSED THE FAILURE BUT DECIDED TO REPLACED THE SERPENTINE BELT AS A SAFETY PRECAUTION. THE FAILURE RECURRED SEVERAL TIMES MOSTLY WHEN IT RAINED OR HIT A POTHOLE. THE CONTACT STATED THAT THE SERPENTINE BELT CAME OFF SEVERAL TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 130,000 AND THE CURRENT MILEAGE WAS 143,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10462422June 20, 2012
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
TL* THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE CONTACT NOTICED A FUEL SMELL. THE CONTACT PARKED THE VEHICLE AND AFTER INSPECTING IT, HE NOTICED FUEL LEAKING FROM THE FUEL RAIL. THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 00V268000 (FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM) AND WAS PREVIOUSLY REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED A SECOND TIME. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. UPDATED 7/11/12 *CN UPDATED 07/17/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10446126February 1, 2012
ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING AT THE SPEEDS OF 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A LOCAL AUTOMOTIVE STORE, WHERE IT WAS DIAGNOSED THAT THE COIL PACK MALFUNCTIONED. THE DEALER WAS NOTIFIED AND THEY COULD NOT ASSIST THE CONTACT WITH THE FAILURE OF THE COIL PACK. THE VEHICLE EXPERIENCED THIS FAILURE A TOTAL OF SIX TIMES AND IT WAS REPAIRED. THE FAILURE MILEAGE WAS 122,000 AND THE CURRENT MILEAGE WAS 130,000. UPDATED 03/05/12*LJ UPDATED 03/08/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10414679July 22, 2011
SERVICE BRAKES, HYDRAULIC
BRAKE LINE FAILURE - BRAKE FLUID LEAKED OUT DUE TO CORROSION. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Dodge Grand Caravan