Chevrolet Tahoe Complaints (2021)

437 consumer complaints on file.

#11733633April 24, 2026
ENGINE
Vehicle is prompting a “decreased acceleration “ warning, will not shift past 3rd gear, and will not shift into reverse.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731896April 17, 2026
FUEL/PROPULSION SYSTEM
The car appeared to run out of gas. It had a half tank of gas. Lucky when it happened I was in the parking lot of my hotel for the night. I was pulling a boat at the time and was 50 miles from a Chevy dealership. Had the car towed to a repair shop where they determined the fuel control module failed. Chevy refused to cover the repair or my inconvenience. There was no previous indication there might be a problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731354April 15, 2026
POWER TRAIN
My Tahoe has 108,000 miles on it. It broke down in the middle of the road and refused to go into gear with zero symptoms prior to this. We had it towed to the dealership and were told it is the Transmission Valve Body. This is a known issue but our VIN isn't covered for some reason so we have to pay out of pocket for this costly repair that is a known problem!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731116April 14, 2026
ELECTRICAL SYSTEM
The backup camera quit working
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730757April 13, 2026
ENGINE, SUSPENSION
Suspension system failed- had to replaced, Car difficult to control when operating. Repaired by dealer- Country Chevrolet, Benton KY- owner paid for repair. [XXX] Engine failure- knocking and difficult to drive on returning trip from Louisville KY to Benton, KY. Taken to dealer on 4.6.2026 - made it without being towed- extremely slow- traffic hazard- Tahoe has lots of road miles- always repaired and serviced by dealer. There were no warning lights, symbols or indicators that there was a problem. Dealer still determining the extent of the damage. [XXX] Benton KY INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730632April 12, 2026
ENGINE, POWER TRAIN, FORWARD COLLISION AVOIDANCE: WARNINGS
The component at issue is the engine, which suffered a sudden and catastrophic failure due to unknown causes. At no time prior to this incident were there any warnings, symptoms, or indications of an underlying mechanical defect that would have allowed for preventative action. While operating the vehicle on the highway with my family present, multiple warning indicators activated simultaneously, including a blinking check engine light, traction control light, ESC warning, and a forward collision warning. Immediately thereafter, the vehicle experienced a rapid and significant loss of power accompanied by a loud and persistent engine knocking noise, rendering the vehicle unsafe to operate and placing the occupants at risk. It is important to emphasize that traction control and ESC systems are not causally related to an engine misfire condition, further supporting that this event was abrupt and not part of a progressive or diagnosable issue. A diagnostic scan performed at that time identified a misfire in cylinder 1. Upon delivery of the vehicle to the dealership for inspection, it was determined that the engine had suffered complete internal failure and was deemed “blown.” This finding confirms the occurrence of a catastrophic mechanical breakdown. Based on the sudden onset, absence of prior warning, and severity of the failure, there is no reasonable basis to attribute this condition to normal wear and tear, operator misuse, or neglect. Rather, the facts support the conclusion that this was the result of a latent defect or internal mechanical failure beyond the operator’s control. Accordingly, this matter should be addressed under applicable warranty coverage or consumer protection standards.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730499April 10, 2026
ENGINE, ELECTRICAL SYSTEM
During highway driving, alert on dashboard stated “electrical system failing enter idle mode”. Tahoe slowed down and then engine began knocking right as it shut off resulting in needing to coast to the shoulder of the highway safely since engine was off. Towed to dealership and then they came back saying needed a new battery, new alternator belt, pulley and water compartment. After those installed, additional call was made indicating the engine needed a full replacement as it keeps overheating despite no sensor alerts and codes are being tripped. Here we are asked to pay 16K for new engine install and unable to fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729654April 7, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving approximately 45 MPH, the check engine warning light illuminated, and the message “Reduced Acceleration - Drive Safely” was displayed. The vehicle then started shaking abnormally. The contact pulled into a nearby parking lot, turned off the vehicle, and waited for a while before restarting the vehicle. After restarting the vehicle, the warning lights remained illuminated, and the vehicle continued to shake abnormally. The vehicle was taken to Auto Zone, where a certified mechanic diagnosed the vehicle and determined that there was a bent rod inside the engine. The vehicle was not repaired. The vehicle was taken to the dealer, who confirmed the diagnostic result and that the failure was causing additional damage to the crankshaft. The dealer determined that there was a misfire in the engine and that the valve lifter was malfunctioning. The contact was informed that the lifter and the camshaft needed to be replaced, and the engine needed to be repaired. The vehicle was not repaired. The contact researched and became aware of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was informed of the failure and confirmed that the VIN was not included in the recall. The contact was referred to the dealer to inquire about a Goodwill Repair for which the contact could be reimbursed if the VIN was later added to the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729469April 6, 2026
ENGINE
Motor is not included in the 6.2 recall for some reason. It is consistently burning through 3 qts of oil every 2-3k miles. This is a major concern considering I travel a lot. I want to know why this specific motor isn’t covered in the recall considering it is having the same issues as the current recall. This has been an ongoing issue and I have been waiting for a recall notice. GM dealership says there is no recall and won’t ever be one.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729431April 6, 2026
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP:CONTROL/DRIVE MODULE
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while at a red light, the accelerator pedal was depressed; however, the vehicle stalled. The check engine warning light was illuminated. The contact researched and was made aware of an unknown NHTSA recall; however, the VIN was not under recall. The vehicle was towed to an independent mechanic, where it was diagnosed, and determined that the fuel pump control module needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 62,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729146April 4, 2026
FUEL/PROPULSION SYSTEM
Without warning my Tahoe would no start 60 miles from home due to a faulty fuel pump module. I was stranded and the vehicle needed to be towed to a GM dealership for repairs. Many 2021 Chevrolet Tahoes have been recalled for this problem and I believe my vehicle should be included in the recall and $787.50 should be reimbursed by including my vehicle (573 Safety Recall Report 21v-739. September 16,2021 GM part #13537053 Fuel Pump Control Module. I have paid receipts .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727248March 26, 2026
ENGINE
On March 14,2026 I was driving 80 MPH on the interstate and the vehicle shifted to Neutral and shutoff. Shortly before that the vehicle revved to 4000 RPM and you could feel rhythmic vibrations. The vehicle was towed to a Chevy dealership and diagnosed as loss of propulsion needing a new engine. Tahoe had 104,000 miles at failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726696March 24, 2026
ELECTRICAL SYSTEM
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, there was a breach in communication with the OnStar system. The contact believed that the brakes failed, and several other safety systems became inoperable due to a failure with the OnStar system. The dealer was notified of the failure, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the issue. The failure mileage was 114,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726587March 24, 2026
SEAT BELTS
Seat belt 3rd row dont work properly doesn’t lock
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725417March 18, 2026
ENGINE
I was driving down I-5 at 75mph and the truck shut off while driving. Couldn’t get to start. Paid over $1k for a new battery cause dealership couldn’t replicate problem. Next day doing 75mph on freeway engine through a rod.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724504March 15, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
Since March of 2025 I have identified a critical safety defect with my vehicle. When driving and without warning, the vehicle unexpectedly shifts to neutral, experiences a loss of propulsion, and the engine shuts off. This has occurred multiple times in which I narrowly escaped collisions with other vehicles or objects. If this would occur at a high rate of speed, it would certainly result in serious accident including possible fatality. I have experienced three near-accident scenarios when I had children in the vehicle. I have worked with Classic Chevrolet in Sugar Land, Texas who has made six attempts at repair. They have each time found a different component attribute to an error code and replaced that part. After each visit they tell me that the car is fixed and safe to drive. They have never been able to provide a clear explanation as to why I am experience this reoccurring issue, but attribute it to a different part each time. Within 5 days to 2 months, the incident repeats. I have recent video of the incident that I can share. Chevrolet Customer Care has been minimized my concern and informs me that their Service staff has found the vehicle to be fully operational and safe to operate. I have spent over $6,000 in failed repairs. I do not feel safe operating this vehicle. That list of repairs includes: March 7, 2025 - battery replacement March 28, 2025 - DC/DC power converter April 22, 2025 - ECM updates January 8, 2026 - •Throttle body replacement •Serpentine belt replacement •Engine air filter replacement •Transmission fluid flush •Coolant fluid flush •Fuel injection cleaning •Hydrogen carbon cleaning service January 23, 2026 - power control module (recall) January 30, 2026 - rear differential system replacement March 10, 2026 - • Replacement of the high-pressure fuel pump • Replacement of the DC power supply converter • Hydrogen carbon cleaning service I can share all invoices. Chevy is NOT TAKING THIS MATTER SERIOUSLY. Please support
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723551March 11, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2021 Chevrolet Tahoe. The contact stated that the engine was consuming an excessive amount of oil, and there was an abnormal knocking sound coming from the engine. Additionally, the vehicle hesitated and failed to accelerate as needed, with blue smoke coming from the exhaust pipes. The check engine warning light was intermittently illuminated. The vehicle was taken to the dealer, who determined that there were metal shavings in the engine oil and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 51,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723103March 9, 2026
POWER TRAIN
Driving down the highway and I lost all the gears it went from driving speed then wouldn’t go over 30 mph. When I got pulled into a business on the side of the road then tried to restart it it then wouldn’t go into reverse. It was dangerous because there was cars behind me going the speed limit then my car just lost speed. No warnings it’s not throwing any codes. Looking on the internet it seems it’s the transmission or valve body
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722698March 7, 2026
ELECTRICAL SYSTEM, ENGINE, FORWARD COLLISION AVOIDANCE: WARNINGS
My truck was driving perfect and I went to pull into a parking lot in Arkansas where I live in long story short it started acting funny trying to idle out and then I heard a knocking noise. It happened twice. Then my service ESV light come on next my motor light come on then my auto for a collision system failure light come on. It’s on the dash anyway my vehicle is not running around. It has hardly no power and I smell something under the hood from time to time burning it’s kinda like an electrical smell. I’m not sure. I’m not a mechanic. I’m a [XXX]. I’m a [XXX]!!! but I have to have a way back back-and-forth to work and I cannot drive this vehicle. I have been driving it to work and just straight to home and that’s only like a mile from the shop but I need a replacement vehicle I need to sell mine at wholesale value as you guys said you would that would be greatly appreciated. God bless you guys. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722487March 6, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at various speeds, the Forward Collision Avoidance message was intermittently displayed. The vehicle was taken to a dealer, where a computer module was replaced. While driving at various speeds, there was an intermittent knocking sound coming from the engine, with the check engine warning light illuminated. While driving at an undisclosed speed, the knocking sound became constant. The vehicle was driven to the dealer, and upon inspection, the mechanic discovered a bent engine rod inside the engine. The vehicle was diagnosed with engine failure, and the contact was provided an estimate for the repair. Upon investigation, the contact discovered the failure was associated with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was initially notified of the failure through the dealer, and the contact was later informed that the manufacturer agreed to cover half the cost of an engine replacement. Upon calling the manufacturer directly, the contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 72,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Tahoe