Chevrolet · Model Report
Showing safety data for the 1992 model year only.
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1992-1994 CHEVROLET AND GMC SUBURBANS EQUIPPED WITH VACUUM POWER-BRAKE ASSIST AND EBC4 ANTI-LOCK BRAKE (ABS) MODULES. THESE VEHICLES EXHIBIT POOR BRAKE SYSTEM PERFORMANCE.
SEVERE CORROSION DUE TO ROAD SALT AT THE JOINT OF THE STAMPED STEEL CENTER SECTION AND THE CAST OUTER SECTION CAN CAUSE THE SECTIONS TO SEPARATE.
UNANTICIPATED HEAT IN THE TRANSMISSION CAN FORCE THE TRANSMISSION FLUID OUT OF THE VENT TUBE.
THE PIVOT BOLT HOLDING THE BRAKE PEDAL TO ITS SUPPORT BRACKET MAY BE IMPROPERLY TIGHTENED AND MAY NOT HAVE ENGAGED THE LOCKING MATERIAL ON THE BOLT. THE BOLT CAN DISENGAGE FROM THE NUT.
WHEN DRIVING IN RAINY WEATHER THE WINDSHIELD WIPERS WOULD COME ON AND OFF INTERMITTENTLY. THE DRIVER WAS ABLE TO DRIVE TO THE DEALER. THE MECHANIC INFORMED THE DRIVER THAT THE WINDSHIELD WIPER NEEDED REPLACEMENT. PLEASE PROVIDE ADDITIONAL INFORMATION. *NM
No injuries · No fire · No crash
THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION, AND NONE OF THE AIR BAGS DEPLOYED. THE DRIVER SUFFERED INJURIES.*JB
CONSUMER STATES WHILE DRIVING VEHICLE ON WET SURFACE THE BRAKE PEDAL WILL GO TO THE FLOOR CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. *NLM
No injuries · No fire · No crash
1992 CHEVROLET SUBURBAN. *AK *PH *NLM **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT OVER TO ARTEMIS**765494
No injuries · No fire · No crash
2 TIRE FAILURES OF TIRE TREAD SEPARATION: INCIDENT DATES 6/15/02 AND 8/10/02. *AK
No injuries · No fire · No crash