Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2007-2010 S80 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE AND LOADING INFORMATION LABEL AND A PAGE IN THE OWNER'S MANUAL CONTAIN INCORRECT MAXIMUM PERMISSIBLE INFLATION PRESSURE AND THE TIRE PRESSURE MONITORING SYSTEM (TPMS) SOFTWARE HAS AN INCORRECT TRIGGER LEVEL.
VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.
VOLVO IS RECALLING 17,614 MY 2008-2009 S80, V70, AND XC70 VEHICLES. THE ENGINE COOLING FAN MAY STOP WORKING DUE TO A SOFTWARE PROGRAMMING ERROR IN THE FAN CONTROL MODULE (FCM). DEPENDING ON DRIVING CONDITIONS, THE CUSTOMER MAY EXPERIENCE REDUCED AIR CONDITIONING PERFORMANCE, AND/OR RAPID INCREASE IN ENGINE COOLANT TEMPERATURE.
The headlight system malfunctioned. It is available for inspection upon request. The low beam failure error occurred, which led to an inspection of the headlight system. The wiring inside the headlight assembly failed. The insulation on bulb wires is crumbling everywhere and causing short circuits from exposed wire conductors. This causes a safety issue because the bulbs stop functioning, impairing visibility of the car, visibility of the road, and disabling motion intent lights like the turn signals. Bare wires touching can also lead to overheating and fires or failures of the headlight electrical system. Humidity may damage the exposed wires and cause bulb failure or wire overheating. The wiring harnesses may also overheat. The wire insulation problem was confirmed by an independent service center on multiple cars of this model.
No injuries · No fire · No crash
For the last several years I’ve been complaining about my TPMS ALWAYS reflecting a “Low Tire Pressure “ response. Recently I went in for a oil change but indicated the my tire pressure light was on again. I take the Volvo to a shop I trust. Global AutoWorks in GrandHaven. They took care of my previous owned BMW without any issues. I put in Volvo S80’s recall site and found that there was a recall on 10/07/2010. The vehicle was a private purchase made in January 8, 2018 from the original owner. Upon purchase I made the decision to put new tires on the vehicle to see if that would fix the problem. $1200.00 later and the problem was not resolved. I do not feel that I should pay for safety issue that the company knew about. I spoke to the previous owner and she did not receive a letter from Volvo. The Volvo is in very good condition with low mileage for a 14 year old car. 69,815. Second issue: Seat belt issue. Reason for recall: Volvo car investigations have identified a problem regarding the front seat fastening. All I can tell you if I lean forward abruptly the seat belt will not tighten or secure itself. Recall R10029 Again we have safety issue. I would like Volvo to fix both issues At Their Expense not mine. Both owners have maintained this vehicle in beautiful condition and these issues were not the result of the owners.They are Volvos issues. I would greatly appreciate someone at Volvo looking into these issues and bringing forward a resolution.
No injuries · No fire · No crash
At night, when a direct strong light (headlight) from behind shines on the car, the BLIS system stop working. The only way to reset the system is to stop and restart the car, instead of turning the system button OFF and then back ON. This is unsafe since when you are on the highway, it is unsafe to do so. A simple fix is a software update that will RESET the system when you turn it OFF and then ON again
No injuries · No fire · No crash
The contact owns a 2009 Volvo S80. The contact stated that the seat belt warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the seat belt assembly to be replaced. The vehicle was not repaired but was pending repairs. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20V378000 (Seat Belts) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 188,000.
No injuries · No fire · No crash
SEVERE SUBFRAME RUST DUE TO THE EXHAUST ON VOLVO S80 V8 BEING TOO CLOSE AND MELTING THE PAINT OFF. CAR IS VERY CLEAN AND WE'LL TAKEN CARE OF. APPEARS TO BE A VERY COMMON PROBLEM ON THE V8 S80S.
No injuries · No fire · No crash