Toyota Tundra Complaints (2022)

434 consumer complaints on file.

#11772716October 21, 2026
EXTERIOR LIGHTING
The contact owns a 2022 Toyota Tundra. The contact received notification of NHTSA Campaign Number: 25V322000 (Exterior Lighting); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11770560October 12, 2026
ENGINE
My 2022 toyota tundra was part of an engine replacement recall. The original engine was replaced Oct 3 2025 at around 38,200 miles. The replacement engine broke down while driving on the street (could have happened on the freeway) on October 10 2026 at around 50k miles. Im waiting on how toyota will solve this problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11769899October 8, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2022 Toyota Tundra. The contact stated that the vehicle hesitated while driving. The contact was concerned about driving the vehicle long distance. The contact received notification of NHTSA Campaign Number: 24V381000 (Engine and Engine Cooling). The vehicle was taken to a local dealer to be inspected. The dealer inspected the vehicle and informed the contact that parts were on back order. The failure mileage was approximately 21,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11769025October 5, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2022 Toyota Tundra. The contact stated that the vehicle was taken to a local dealer for maintenance, where it was discovered that the vehicle had an oil pressure failure. The local dealer associated the failure with NHTSA Campaign Number: 24V381000 (Engine and Engine Cooling). The vehicle was previously repaired under the recall at another dealer. The local dealer advised the contact to contact the original servicing dealer about the failure. The original servicing dealer was contacted but stated that any additional repair would be out of pocket. The failure mileage was approximately 37,049.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763374September 10, 2026
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL, POWER TRAIN
On September 1, 2026, my 2022 Toyota Tundra experienced a serious loss of accelerator response while I was leaving a gas station and entering traffic. I pressed the accelerator, but the truck provided effectively no acceleration, leaving me partially in the roadway. An approaching vehicle had to swerve into the opposing traffic lane to avoid a collision. I had experienced a similar low-speed loss of accelerator response within the prior two weeks. On September 2, while traveling on I-70 at approximately 70 mph, the truck experienced a separate loss-of-power event. Engine RPM dropped considerably and the vehicle felt as though it were coasting. I pressed the accelerator firmly, but it did not respond normally for approximately 5-10 seconds before power returned. Radar/adaptive cruise control was not engaged. I immediately took the truck to Western Slope Toyota. Technicians checked for codes, performed multiple road tests and recorded vehicle data but could not reproduce the intermittent failure. The issue was escalated to Toyota technical assistance under TAS Case 262460664. This problem has been documented by Western Slope Toyota since 2023. Toyota's applicable TSB repairs were performed on prior occasions in an attempt to correct the throttle/hesitation problem, but they did not resolve it. In 2025, the dealer again documented the condition after the earlier TSB had already been performed. According to the September 2026 repair documentation and my discussion with the Western Slope Toyota service manager, Toyota's specialist technical team is aware that the condition can remain despite the TSB work. The repair order states that Toyota identified a known hesitation concern that remains under investigation and that there was no repair to be made at that time. The condition is intermittent and unpredictable and can cause loss of accelerator response or motive power at low and highway speeds. I believe it creates a serious crash risk. Current mileage: 58,735.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762486September 6, 2026
ENGINE
This is a follow-up to my NHTSA complaint tracking #11742382, filed June 5, 2026, before my recall repair. I'm filing again because the repair is now complete and it has raised two new concerns: undocumented warranty coverage on the replacement engine, and an unresolved question about whether a second, broader recall applies to that replacement engine. 1. Recall repair completed. Under NHTSA Campaign 24V381000 (Toyota internal 24TA07, filed 2024-05-30), my original engine was replaced with a new OEM assembly (part 04004-23370, serial [XXX], 2026 manufacture date, incorporating the post-April-2024 revised bearing design) at Teton Toyota, Idaho Falls, ID, June 19 to 22, 2026 (repair order [XXX], mileage in/out 28,252/28,281). Toyota's own recall record states the replacement unit was inspected clean. I have no reason to doubt that specific finding; my concern is what happens after. 2. Replacement engine's warranty terms were left undocumented. The repair order lists the warranty "Policy Number" covering the new engine as TBD. As of this filing, Toyota National (1-800-331-4331) has not given me a written answer to a direct question: does the replacement engine carry a new 5-year/60,000-mile powertrain warranty starting from the June 22, 2026 install date, or only the remainder of my original factory warranty? A safety recall remedy that leaves the owner without documented knowledge of what protection they actually received is, in my view, an incomplete remedy under 49 CFR Part 573's recordkeeping and notification requirements. Owners should not have to chase this down themselves months after the repair. 3. A second, broader recall may or may not apply to my replacement engine, and Toyota has not said which. NHTSA Campaign 25V767000 (Toyota internal 25TA14, filed 2025-11-06) expands the same underlying defect population to additional 2022-2024 Tundra, Lexus LX, and 2024 Lexus GX vehicles, with a remedy of inspecting the #1 main bearing via inspection software and INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762388September 5, 2026
ENGINE
REPEATED CATASTROPHIC ENGINE FAILURE / FAILED RECALL REMEDY. My 2022 Toyota Tundra suffered a complete engine seizure and sudden loss of motive power August 30, 2026, creating an immediate traffic hazard. This is the SECOND time this vehicle has experienced a catastrophic main bearing failure of its twin-turbo V6 engine. The original factory engine was replaced by an authorized Toyota dealership under Safety Recall 24V-381 / 24TA07 in March 2025. The defect should have been resolved. However, the replacement crate engine provided by Toyota carried the exact same engineering vulnerability as the original engine. It was manufactured prior to Toyota's mid-2026 engineering revision, which finally introduced a redesigned #1 main bearing to address localized crankshaft pressure stack-up (as noted in subsequent NHTSA filings like 26V-320).Furthermore, the previous engine replacement due to a federal safety recall was entirely withheld and not disclosed to me at the point of sale. Because Toyota replaced a recalled, defective engine with an identically flawed engine block, the initial recall remedy completely failed, leaving the vehicle dangerous and prone to repeated mechanical failure. The vehicle has driven approximately 16 months since the March 2025 replacement. I am demanding that Toyota provide a permanent remedy using the updated, structurally revised 2026 engine components. It is at the Toyota dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761613September 2, 2026
ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES
The contact's husband owns a 2022 Toyota Tundra. The contact stated that the key fob failed to unlock the front driver’s side door. Due to the failure, the contact was forced to lock the front driver’s side door manually after exiting the vehicle. The contact was forced to enter the vehicle through the front passenger’s side door and crawl over to the front driver side seat. The vehicle was taken to the dealer, and an estimate was provided for the repair. The vehicle was not repaired. The failure mileage was approximately 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761432September 1, 2026
ENGINE
I am filing this complaint regarding my Toyota Tundra and Toyota Safety Recall 24TA07. My vehicle was previously affected by this engine recall, and Toyota replaced the engine as the recall remedy. The replacement engine has now failed with the same or substantially similar engine issue that resulted in the original recall and engine replacement. I am very concerned that a replacement engine installed as the remedy for a safety recall has experienced the same type of failure. This vehicle has now experienced engine failure involving two separate engines: the original recalled engine and the replacement engine installed by Toyota under Recall 24TA07. The Vehicle is at the Toyota dealer. I am requesting that NHTSA investigate whether replacement engines being installed under this recall may also be susceptible to the same or a similar defect. I would also like this complaint documented because I am concerned about the safety and reliability of the vehicle and whether Toyota's recall remedy adequately corrected the original safety issue. I am requesting that Toyota provide a permanent remedy for my vehicle at no cost to me. I would also like information regarding my rights and available remedies given that the engine replaced under the safety recall has now failed, including whether this repeat failure may qualify for additional manufacturer remedies or protections under applicable warranty or state lemon law.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760872August 31, 2026
WHEELS, SUSPENSION, STEERING
This 2022 Toyota Tundra TRD Pro is subject to Limited Service Campaign 24TD01 for premature tire wear, caused by a factory front toe/camber angle defect acknowledged by Toyota. The vehicle received the campaign remedy (front alignment adjustment and tire replacement) in May 2024, but the same wear pattern on the front tires reappeared and has continued for over a year, documented across multiple dealership visits. A dealership technician found abnormal front tire wear on three separate occasions (August 2025, September 2025, and March 2026) but never recommended a front-end alignment despite Toyota's own campaign identifying alignment/camber as the root cause. As of August 2026, the right front tire tread had worn down to approximately 1/32 inch, an unsafe condition, and only then was an alignment finally recommended in writing for the first time. The vehicle also had a documented brake rotor warping issue (front rotors) as early as November 2024, causing a braking vibration above 40 mph that has persisted. The recurring tire wear presents an ongoing safety risk due to reduced traction and control, particularly relevant given the near-bald tire condition reached before any alignment correction was recommended by the servicing dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760653August 29, 2026
ENGINE
"I am writing to report a latent safety concern regarding my 2022 Toyota Tundra Hybrid equipped with the V35A-FTS engine. Non-hybrid 2022–2024 Tundras sharing this exact V35A engine block architecture are subject to active safety recalls (NHTSA Campaign IDs: 24V381, 25V767, and 26V320) due to crankshaft main bearing failure caused by manufacturing debris and oil film disruption. My hybrid model utilizes the same V35A internal engine short-block assembly and suffers from the exact same potential for main bearing contamination and catastrophic internal engine lockup. Although the hybrid battery provides limited low-speed auxiliary power, a sudden internal combustion engine failure or lockup while operating at highway speeds or under heavy towing loads creates a severe safety hazard, including immediate loss of throttle response, power steering loss, and high risk of rear-end collisions. My engine has not failed yet, but the presence of known, unaddressed manufacturing debris within the V35A assembly presents an ongoing safety risk. I request that NHTSA expand its safety defect investigation into the V35A engine architecture to explicitly include the i-FORCE MAX Hybrid models." Toyota has been lacking in taking responsibility that these exact same engines manufactured on the same assembly line are also subject to the same issues. I believe it is a significant safety issue especially since in the event of an engine failure the hybid system will NOT be strong enough to move the vehicle to the side of the road safely. In addition, when the powertrain warranty expires next year for the 2022 models, owners will be left holding the bag for a $30,000 dollar engine replacement when toyota knows this could and has happened. Currently, Toyotas way of evaluating engines consist of hitting the engine with a hammer to check if its affected or not. What?? Please investigate this and hold toyota responsible, all engines manufactured on that assembly line in AL should be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759434August 25, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2022 Toyota Tundra. The contact previously received notification of NHTSA Campaign Number: 24V381000 (ENGINE AND ENGINE COOLING). The contact stated that at start-up there was an abnormal knocking sound coming from the engine, and the engine idled, with the RPM fluctuating. While accelerating from a stop, the RPM fluctuated, and the vehicle hesitated and jerked. There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that no failure was found. The vehicle was taken to an independent mechanic where it was diagnosed, and the contact was advised that further diagnostic tests were required to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 58,848.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758940August 23, 2026
ELECTRICAL SYSTEM, ENGINE, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I am 99% sure my vehicle is compromised via a cybersecurity incident. My emergency brake will sometimes slam for no reason, no multi media system updates have occurred for over two years, and the vehicle will randomly beep on its own, unlocking the doors. Another major issue is a recent electric harness failure that the mechanics have no idea how it happened. It cost me over 8,000. Warning lights also turn on for no apparent reason such as parking, sensors, and other traction control. I am extremely concerned with my safety. I also believe the odometer has been altered to register higher mileage.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11757267August 16, 2026
ENGINE
This is a repeat engine failure on a vehicle that already received the manufacturer's recall remedy. On XXX, at 69,420 miles, the original engine was replaced under Toyota's recall for the V35A 3.4L twin-turbo V6 (manufacturing debris contaminating crankshaft bearings), at Capital Toyota in [XXX]. On XXX, at 109,367 miles — approximately 39,947 miles after the recall replacement engine was installed — the replacement engine failed catastrophically. We first heard knocking in the engine while the truck was idling. The vehicle lost the ability to be driven and had to be towed to Savannah Toyota in Savannah, GA, where it currently remains. This failure raises serious safety concerns because the same recall-related symptoms (knocking progressing to failure) can occur while driving at highway speed, creating a risk of sudden loss of power, stalling in traffic, and a crash. This indicates that Toyota's recall remedy (engine replacement) did not correct the underlying manufacturing defect. We have opened a case with Toyota's Brand Engagement Center (case/file number XXX) requesting a third engine replacement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754438August 3, 2026
ENGINE, POWER TRAIN
Manufacturer Recall Number25TB06 NHTSA Recall Number25V322 In regards to the above mentioned recalls. The vehicle's reverse camera began flashing while driving forward. The R light on the gearshift was also flashing. While driving forward about 15 mph out of a parking lot, the vehicle suddenly went into reverse on it's own, locked up and would not move. I had to have the vehicle towed to the dealership. This happened around the week of June 8. The dealership says that they reset the electrical recall, we picked up the truck and it ran fine for about a week. The reverse camera and R light on the gearshift began flashing again on June 17. It did not shift itself into reverse, but the dealership requested that we bring the vehicle back. The dealership stated that Toyota has "grounded" the vehicle and does not have a fix for the recall to date and continuing to drive it is a safety hazzard. It has been sitting at the dealership since June 18 with no end in sight. The dealership and Toyota Corporate continues to tell me every few days that they do not have a fix for the issues/recalls.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752744July 24, 2026
ENGINE
Summary of Complaint I am submitting this complaint to report what I believe may be a safety-related defect involving the twin-turbocharger system on my 2022 Toyota Tundra (VIN: [XXX]). The driver’s side turbocharger failed at approximately 58,000 miles and had to be replaced. Approximately 6,000 miles later, at around 64,000 miles, the passenger-side turbocharger also failed. The vehicle has been properly maintained and serviced by authorized Toyota dealerships. A failed turbocharger causes a significant loss of engine power, which can create a hazardous condition when merging onto highways, overtaking other vehicles, or driving in traffic where acceleration is necessary to avoid a collision. Toyota requested that I return the vehicle to an authorized dealership for an additional diagnosis, which confirmed the failure of the second turbocharger. I paid $250 for this diagnosis at Toyota’s request. Despite the repeated failure of both turbochargers at relatively low mileage, Toyota declined to provide further assistance and informed me that its decision was final. Based on the failure of both turbochargers within only 64,000 miles, I believe this may represent a manufacturing or design defect rather than normal wear. I respectfully request that NHTSA review this issue and determine whether similar failures are occurring in other 2022 Toyota Tundra vehicles equipped with the same twin-turbo engine, and whether a safety-related defect investigation is warranted. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751685July 20, 2026
UNKNOWN OR OTHER
Traveling on the highway with no cars near us and our panoramic sunroof exploded showering myself and my passenger with glass at highway speed. There are no over hanging trees or over passes in this area.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751034July 17, 2026
EXTERIOR LIGHTING, ELECTRICAL SYSTEM, STRUCTURE:BODY
Water is leaking into the cab of my 2022 Toyota Tundra Platinum 4x4 through the high-mounted third brake light. The leak allows water to enter the headliner and interior, creating the potential for mold, damage to the interior, and electrical issues. After troubleshooting, the third brake light gasket appears to be the source of the leak. Toyota does not appear to offer the gasket as a replacement part, requiring owners to replace the entire third brake light assembly despite the failure being limited to the seal. Numerous owners have reported similar water intrusion issues on 2022+ Tundras, suggesting this may be a common defect rather than an isolated incident. I believe Toyota should investigate the failed gasket design and consider a recall or service campaign to replace the defective seal or assembly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750077July 13, 2026
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Driving on the interstate and the truck surged very hard. The truck began to surge very hard and went into decreased speed mode. We were told by the dealer there is a TSB for the PCM. This decreased power caused the truck to not be able to travel over 25 MPH in a 70 MPH zone. This caused an unsafe situation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744266June 15, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM
The regain from brake for the hybrid system jerking when go to full stop
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra