Toyota Tundra Complaints

6,958 consumer complaints on file.

#11278126November 4, 2019
STRUCTURE:BODY, SERVICE BRAKES, WHEELS
THREE STUDS OR LUGS BROKE OFF MY RIGHT FRONT WHEEL WHILE DRIVING, CAUSING IT TO COMPLETELY BREAK OFF AND DAMAGE THE RIGHT FRONT PART OF MY TRUCK. THANKFULLY I WASN'T DRIVING VERY FAST OR IT WOULD OF BEEN MUCH WORSE. I'VE TAKEN IT TO THE SHOP AND HAD IT REPAIRED. THE MECHANICS SAY THIS SHOULD NOT HAVE HAPPENED. I'M AFRAID MY OTHER WHEELS MY DO THIS AS WELL. MY TRUCK IS A 2014 TOYOTA TUNDRA PLAT 4X4
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11278173November 4, 2019
UNKNOWN OR OTHER
REPLACED BALL JOINTS 4 TIMES IN 10 YEARS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11277359October 31, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2002 TOYOTA TUNDRA. WHILE THE VEHICLE WAS AT AN INDEPENDENT MECHANIC FOR MAINTENANCE, THE CONTACT WAS INFORMED THAT THE REAR CROSS MEMBERS ON BOTH SIDES AND THE FRAME WERE SEVERELY CORRODED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11277396October 31, 2019
VISIBILITY:SUN/MOON ROOF ASSEMBLY
TL* THE CONTACT OWNS A 2019 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 70 MPH, AN EXPLOSION WAS HEARD. THE VEHICLE WAS PULLED OVER AND THE CONTACT NOTICED THAT THE SUN ROOF EXPLODED WITHOUT AN IMPACT OR WARNING. THERE WERE NO INJURIES. THE CONTACT CALLED OAKBROOK TOYOTA AT 630-789-9600 (LOCATED AT 550 E OGDEN AVE, WESTMONT, IL 60559) AND WAS INFORMED THAT THE FAILURE HAD TO BE CAUSED BY SOMETHING STRIKING THE SUN ROOF. THE DEALER DENIED ALL RESPONSIBILITY. THE MANUFACTURER WAS CALLED, BUT THERE WAS NO RESPONSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 4,800. *LN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11276894October 29, 2019
SUSPENSION
ON SEPTEMBER 30, 2019, MY 2005 TOYOTA TUNDRA (PURCHASED NEW IN 2004) DID NOT PASS INSPECTION DUE TO RUST HOLES ON THE FRAME; MILEAGE WAS 81,147. I LOOKED UP VIN NUMBER ON NHTSA AND THERE IS ONLY ONE RECALL DATED OCTOBER 2019 NOT FULFILLED FOR MY VEHICLE. A LOCAL DEALER INVESTIGATED MY VIN NUMBER, AND TOLD ME THERE WAS A D ZERO D/LIMITED SERVICE CAMPAIGN (EXPIRED 2015) REGARDING RUST PROBLEMS WITH THIS VEHICLE. I WAS NOT NOTIFIED BY TOYOTA ABOUT THIS. I HAVE NOT MOVED/CHANGED ADDRESS SINCE I PURCHASED THIS VEHICLE, AND I DID RECEIVE AND FULFILL THE 2016 AND 2007 RECALL NOTICES. I CALLED NHTSA AND TOLD THE WOMAN ON PHONE ABOUT THE D0D/LSC AND SHE FOUND IT FOR ME UNDER 'MANUFACTURER COMMUNICATIONS'. I HAVE TAKEN GOOD CARE OF IT AND HAVE ALL OF MY SERVICE RECORDS. I EXPECTED IT TO LAST AND AM DISAPPOINTED TOYOTA DID NOT NOTIFY ME. I AM REQUESTING NHTSA MAKE THESE LIMITED SERVICE CAMPAIGNS FOR VEHICLES VISIBLE WITH THE OTHER RECALLS. I LOOK FORWARD TO HEARING BACK FROM YOU AND A RESOLUTION OF THIS PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11271729October 28, 2019
STRUCTURE:BODY, STEERING
WHILE DRIVING IN THE CITY MY POWER STEERING WENT OUT AND MADE DRIVING DIFFICULT. UPON TAKING MY 2006 TUNDRA TO THE NEAREST DEALER TO GET IT FIXED THEY INFORMED ME THE FRAME HAD A HOLE IN IT AND THAT THE VEHICLE WAS NOT SERVICEABLE. IT APPEARS MULTIPLE RECALLS FOR MULTIPLE MODELS WERE ISSUED BUT NOT 2005 AND 2006. THIS IS SOMETHING THAT TOYOTA SHOULD LOOK AT AND EXTEND THE RECALL TO THESE VEHICLES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270967October 25, 2019
STRUCTURE:BODY, UNKNOWN OR OTHER
THE ENTIRE FRAME IS RUSTED - TO MY SHOCK AND I JUST FAILED INSPECTION BUT THE TRUCK IS GORGEOUS AND RUNS GREAT WITH ALL NEW TIRES. I'M CURRENTLY LOW INCOME AND WONDER HOW THE FRAME RECALL WAS MISSED BUT THE AIRBAG WAS REPLACED. PLEASE ADVISE AND THANK YOU.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270720October 24, 2019
STRUCTURE:BODY, SERVICE BRAKES, POWER TRAIN
TL* THE CONTACT OWNS A 2000 TOYOTA TUNDRA. WHILE THE BRAKE PEDAL WAS DEPRESSED TO THE FLOORBOARD, THE VEHICLE FAILED TO STOP. THE VEHICLE WAS PLACED INTO NEUTRAL IN ORDER TO BE STOPPED. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND NOTICED THAT THE FRAME WAS RUSTED. THE CONTACT ALSO MENTIONED THAT THE SHIFTER WAS NOT FUNCTIONING PROPERLY. THE CONTACT MENTIONED THAT THE GEAR SELECTOR WOULD NOT MOVE TO THE DESIRED GEAR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SAFE TO DRIVE DUE TO THE RUST, AND THAT THE BRAKE LINE AND SHIFTER CABLE NEEDED TO BE REPLACED. GRAHAM TOYOTA (1515 W 4TH ST, MANSFIELD, OH 44906, (419) 529-1800) WAS CALLED AND STATED THAT THE FRAME WAS PREVIOUSLY REPAIRED PER AN UNKNOWN RECALL. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 117,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270630October 24, 2019
STRUCTURE:BODY
INFORMED THAT FRAME HAS DEVELOPED RUST ISSUES. VEHICLE WAS COATED BY DEALER IN 2014 WITH CORROSION RESISTANT COMPOUND FOLLOWING A LETTER INDICATING TOYOTA WAS AWARE OF THIS ISSUE.TODAY MY MECHANIC FOLLOWING ROUTINE MAINTENANCE SHOWED ME THE RUSTING FRAME.10/24/19. I TOOK VEHICLE TO THOMPSON TOYOTA SERVICE AND WAS INFORMED THERE IS NO RECALL ON THIS YEARS MODEL. I CALLED TOYOTA AND WAS INFORMED IT'S NOT COVERED. IT IS UPSETTING THAT PREVIOUS YEARS WERE COVERED AND SEQUOIA MODELS ARE COVERED. .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270503October 23, 2019
AIR BAGS
IN RESPONSE TO THE RECENT RECALL, I SCHEDULED AN APPOINTMENT AT ROUND ROCK TOYOTA. I WAS TOLD THEY WOULD NOT COMPLETE THE REPAIR BECAUSE "THE NEW ONES HAVE BEEN RECALLED ALSO" AND TO WAIT UNTIL NEXT YEAR. THEY REFUSED TO REMEDY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270110October 22, 2019
AIR BAGS
AIRBAG LIGHT CAME ON DURING A LONG HWY DRIVE HOME, HAD VEHICLE CHECKED OUT AND PULLED CODE B1863. CODE WAS CHECKED AND EVERYTHING CHECKED GOOD, SO CODE WAS RESET. IT'S BEEN OVER A MONTH AND AIRBAG LIGHT JUST CAME BACK ON DURING A DRIVE HOME. TAKING IT IN TO SEE IF IT'S THE SAME ODE OR A DIFFERENT ONE THIS TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270271October 22, 2019
STEERING
TL* THE CONTACT OWNS A 2011 TOYOTA TUNDRA. WHILE DRIVING 35 MPH, THERE WAS AN ABNORMAL WHINING NOISE COMING FROM THE STEERING WHEEL. AFTER A FEW MOMENTS, THE STEERING SEIZED WITHOUT WARNING. THE CONTACT MANAGED TO DRIVE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE STEERING PUMP AND BELT FAILED AND NEEDED TO BE REPLACED. THE PUMP AND BELT WERE REPLACED; HOWEVER, THE RACK AND PINION NEEDED TO BE REPAIRED BY A DEALER. THE VEHICLE WAS TOWED TO PEORIA TOYOTA (7401 N ALLEN RD, PEORIA, IL 61614, (309)-354-3894) WHERE IT WAS DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE VEHICLE WAS CURRENTLY BEING REPAIRED BY THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT NO WARRANTIES WERE AVAILABLE AND THE TSB HAD EXPIRED. THE MANUFACTURER PROVIDED CASE NUMBER: 1910213072. THE CONTACT REFERENCED TSB NHTSA ID NUMBER: 10134363. THE FAILURE MILEAGE WAS APPROXIMATELY 83,694.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11270073October 21, 2019
UNKNOWN OR OTHER
TRUCK WAS BROUGHT IN FOR FRAME RECALL, HAD SOME RUST CORROSION PUT ON IT. WAS A BAND AID ON THE PROBLEM FRAME IS RUSTED BADLY AS WELL AS SUSPENSION PARTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11269322October 18, 2019
SEAT BELTS
DRIVER SEAT BELT UNLATCHES ON IT'S OWN, RANDOMLY WHILE DRIVING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11269177October 17, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE AT AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED THAT THE FRAME WAS RUSTED. THE CONTACT STATED THAT THE BRAKES AND POWER STEERING RACK WERE RUSTED BEFORE AND PREVIOUSLY REPAIRED. THE CONTACT CALLED LIA TOYOTA OF NORTHAMPTON (LOCATED AT 280 KING ST, NORTHAMPTON, MA 01060, (413) 341-5299) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11269172October 17, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE VEHICLE WAS TAKEN TO DUNNING TOYOTA (877-356-9318, LOCATED AT 3745 JACKSON RD, ANN ARBOR, MI 48103) WHERE IT WAS STATED THAT THE VEHICLE WAS TOO DANGEROUS TO BE REPAIRED DUE TO EXCESSIVE CORROSION. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND STATED THAT THE DEALER WOULD NOT BE FORCED TO REPAIR THE VEHICLE IF THE VEHICLE WERE FOUND TO BE UNSAFE TO BE REPAIRED OR DRIVEN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 260,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11269284October 17, 2019
STEERING
I WAS FINISHED DOING MY OIL CHANGE AND NOTICED MY RACK AND PINION BOOT HAD AN OIL LEAK ON THE PASSENGER SIDE, I WIPED IT OFF AND IT SEEMS LIKE A SMALL LEAK FOR NOW. THE TRUCK ON HAS 73.2K MILES ON IT AND IT'S COMPLETELY STOCK, NO MODIFICATIONS AT ALL. IT'S A DAILY DRIVER AND IS STRICTLY STREET DRIVEN, NO OFF ROADING. THE RACK AND PINION SHOULDN'T LEAK AT ALL WITH THIS LOW MILEAGE AND BEING STOCK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11268636October 15, 2019
ENGINE
* ONGOING MANUFACTURE DEFECT / SAFETY CONCERN WITH 2012 TOYOTA TUNDRA 4.6. CODE P2440, SECONDARY AIR INJECTION. BANK ONE OPEN.---CHECK ENGINE / TRAC OFF LIGHTS / ENGINE IN "LIMP MODE" * DOCUMENTED RECURRING INCIDENTS ON 4-2-19 AND AGAIN ON 10-12-19 AFTER COSTLY OUT OF POCKET REPAIR. * MY 2012 TOYOTA TUNDRA 4.6 MOTOR DOUBLE CAB HAS EXPERIENCED THE AIR INJECTION PUMP FAILURE TWICE IN A SIX MONTH PERIOD. THIS FAILURE IS A SAFETY HAZARD LEADING TO LOSS OF POWER AND VEHICLE CONTROL. THE FIRST OCCURRENCE WAS AFTER A 2,000 MILE TRIP. DRIVING DOWNHILL THE DASH LIGHTS (CHECK ENGINE / TRAC OFF) CAME AT HIGHWAY SPEED AND IMMEDIATELY VEHICLE POWER REDUCED AS WE TRIED TO POWER UP THE NEXT HILL. WE WERE ABLE TO AVOID BEING RUN OVER BY FOLLOWING VEHICLES BY PULLING OFF THE ROAD, AND LIMPED TO THE NEAREST MECHANIC SHOP. CONTACTED 3 DEALERS AND TOYOTA CORPORATE WITH NO POSITIVE OUTCOME. ALL PARTIES ACKNOWLEDGE THE ONGOING DEFECT BUT WILL NOT PAY OR OFFER A SOLUTION TO END THE PROBLEM. PAID OUT OF POCKET FOR EXPENSIVE REPAIR. THE 2ND OCCURRENCE SIX MONTHS LATER FOUND US AGAIN UNABLE TO REACH OR MAINTAIN SAFE HIGHWAY SPEEDS. AVOID DANGEROUS HIGHWAY SITUATIONS, OR ABILITY TO CLIMB HILLS. BOTH INSTANCES OCCURRED WITHOUT WARNING. * THIS EMISSION CONTROL DEFECT THAT TOYOTA HAS KNOWN ABOUT SINCE THE 2007 MODELS. THEY EVEN EXTENDED THE WARRANTY THROUGH THE 2011 MODEL YEAR. TOYOTA ALSO CLAIMS THE PROBLEM IS NEITHER DRIVE-TRAIN NOR EMISSIONS RELATED. AFTER MANY ATTEMPTS AT THE DEALER AND CORPORATE LEVEL, TOYOTA REFUSES TO EXTEND REPAIRS FOR THIS WELL DOCUMENTED DEFECT BEYOND THE 2011 MODEL. TOYOTA SUGGESTS THAT WHEN ENOUGH COMPLAINTS ARE RECORDED, THEY WILL EXTEND THE WARRANTY ON NEWER MODELS. THE LACK OF SUPPORT FROM DEALERS AND CORPORATE TOYOTA IS ALARMING. THE REPAIR OUT OF POCKET IS EXPENSIVE (FROM $500 FOR A TEMPORARY REPAIR TO $4000 FOR A REPLACEMENT FROM THE DEALER.)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11268168October 13, 2019
STRUCTURE:BODY
VISIBLE CRACK IN FRAME ON THE "C" WHERE IT MEETS THE FRONT AXLE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11268570October 13, 2019
UNKNOWN OR OTHER
FRAME RUST ROT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra