SAAB IS RECALLING 57,389 MY 2002-2008 9-5 SERIES VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING COMPLIANCE TESTING, ONE OF THE UPPER INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD'S REQUIREMENTS.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP RETAINING TABS HOLDING THE FUEL LINES WERE DAMAGED DURING PRODUCTION.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH B308 6-CYLINDER GASOLINE ENGINES MAY EXPERIENCE OVERHEATING AND BURNOUT OF THE ISOLATED GATED BIPOLAR TRANSISTOR (IGBT) WITHIN THE IGNITION DISCHARGE MODULE (IDM) DUE TO INCREASED SUSCEPTIBILITY TO ELECTRICAL LOADS.
ON CERTAIN PASSENGER VEHICLES, IF AN OWNER CHANGES THEIR WHEELS/TIRES BETWEEN SUMMER AND WINTER USING A STEEL WHEEL IN THE WINTER AND AN ALLOY WHEEL IN THE SUMMER, IT IS POSSIBLE FOR RUST AND CONTAMINATION TO BUILD UP ON THE WHEEL HUB DURING THE STEEL WHEEL USAGE. IF THIS OCCURS AND THE CONTAMINATION IS NOT REMOVED, IT IS POSSIBLE THAT AFTER THE TIRE CHANGE SERVICE, SOME OF THIS CONTAMINATION COULD FLAKE OR GRIND AWAY RESULTING IN REDUCED CLAMPING FORCE OF THE WHEEL TO THE HUB. OVER SEVERAL SEASONS, IT IS POSSIBLE THAT THIS REDUCED FORCE COULD RESULT IN FRACTURES DEVELOPING IN THE WHEEL BOLTS DUE TO WHEEL TO HUB MOVEMENT.
I HAD TO REPLACE FUEL PUMP 3 TIMES IN 4 YEARS. IT SMELLED LIKE FUEL IN MY CAR.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1993 BUICK REGAL. THE CONTACT STATED THAT ALL DOOR LOCKS WOULD BECOME STUCK WHEN ACTIVATED BY THE ELECTRONIC DOOR LOCK SYSTEM. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 41,000.
No injuries · No fire · No crash
AFTER DRIVING MY CAR TO MY DESTINATION, I PUT THE CAR IN PARK BUT THE CAR WON'T STAY IN PARK. THE CAR POPS OUT OF PARK INTO REVERSE, THEN IT WON'T START WHEN I GET BACK INTO MY CAR. *TR
No injuries · No fire · No crash
TL* THE CONTACTS OWNS A 2003 SAAB 9-5. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE DIRECT IGNITION CASSETTE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 125,000.
No injuries · No fire · No crash
I WAS DRIVING THE CAR WHEN SUDDENLY THE CAR WHEN DEAD WHILE I WAS DRIVING IT.I WAS LUCKY THAT I WAS ABLE TO RESTART IT AND THERE WAS A GAS STATION RIGHT NEAR BY. IT DID NOT START UP NORMALLY AND WAS VERY SLUGGISH. I WAS IN THE MIDDLE OF TRAFFIC WHEN THIS HAPPENED BUT FORTUNATELY NOT HEAVY TRAFFIC AND IN THE RIGHT LANE. IT WAS VERY SCARY. THEY TOWED MY SAAB TO A SAAB DEALER FOR ME WHO HAD TO INSTALL A NEW IGNITION. THIS HAPPENED ABOUT 4-5 YEARS AGO ON MY SAAB 2003 9-5 STATION WAGON WHICH WAS BUILT BY GM. I BELIEVE IT WAS BUILT ON THE SAME PLATFORM OF ONE OF THE CADILLACS THAT IS UNDER RECALL. *TR
No injuries · No fire · No crash