THE OFFSET TOE ADJUSTING PIN CAN FRACTURE UNDER CONDITIONS SUCH AS TORSIONAL LOADS, FLEXING MOTION, IMPACT LOADS, AND OVERTORQUING.
THE ROLL PINS SECURING THE IGNITION LOCK IN THE STEERING COLUMN HOUSING CAN SEPARATE OR MOVE OUT OF POSITION.
FATIGUE CRACKS CAN DEVELOP IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED AT THE TOP OF THE FUEL TANK.
TL* THE CONTACT OWNS A 1991 MERCURY TRACER. AFTER THE VEHICLE WAS FILLED WITH FUEL AND PARKED IN THE GARAGE, THE CONTACT SMELLED A FUEL ODOR AND NOTICED FUEL LEAKING ONTO THE GARAGE FLOOR. ALL AMERICAN FORD (3306 BRIDGE AVE, POINT PLEASANT, NJ 08742, (732) 451-3582) WAS CONTACTED AND STATED THAT THE VEHICLE WAS TOO OLD AND THEY DID NOT HAVE PARTS. THE VEHICLE WAS THEN TAKEN TO ALL AMERICAN MAZDA (575 BURNT TAVERN RD, BRICK TOWNSHIP, NJ 08724, (732) 451-6848) WHERE A DIAGNOSTIC AND REPAIR APPOINTMENT WAS SCHEDULED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.
No injuries · No fire · No crash
(1) SHOULDER BELT WOULD NOT MOVE TO DRIVING POSITION, COOLANT FAN WOULD NOT RUN WHEN NEEDED WITH ENGINE RUNNING ONLY WHEN THE IGNITION WAS TURNED OFF, OIL LIGHT STAYED ON AND ALTERNATELY FLASHED WITH THE RIGHT TURN SIGNAL INDICATOR. (2) A SHORTING CONNECTOR TO THE FUEL PUMP BURNED THE WIRE BUNDLE TO THE FUEL PUMP IN THE TANK. IT ALSO BURNED WIRES BEHIND THE FUSE BLOCK AND UNDER THE DASH!!! (3) THE CONNECTOR, HARNESS UPDATE, FUEL PUMP/PUMP ASSEMBLY, LOCK RING, WERE REPLACED, BURNED WIRES WERE REPLACED BEHIND THE FUSE BLOCK. THE CAR CANNOT BE DRIVEN BECAUSE THERE ARE MORE BURNED WIRES TO REPAIR UNDER THE DASH. UPDATED01/09/06. *JB
I HAD TO REPLACE TWO IGNITION SWITCHES ON MY 1991 MERCURY 1.9 TRACER TO THE TUNE OF $360.00. THE FIRST ONE THEY INSTALLED, THE TUMBLERS FELL APART AFTER ONE DAY, I HAD TO BE TOWED BACK TO THE MECHANIC TO INSTALL A SECOND IGNITION SWITCH. I WAS INFORMED THAT FORD HAD A RECALL ON TRACER IGNITION SWITCHES. HOW DO I RECOVER MY EXPENSE? *JB
No injuries · No fire · No crash
THERE WAS A FATIGUE FRACTURE IN FUEL TANK AND FUEL WAS LEAKING. CONTACTED DEALER, AND THE DEALER STATED THAT VEHICLE WAS NOT INCLUDED IN RECALL.*AK
No injuries · No fire · No crash
CAR WILL NOT REMAIN AT SPEED FOR MORE THAN 25 SECONDS. *AK
No injuries · No fire · No crash