CERTAIN TRW DRIVER'S SIDE SEAT BELTS MANUFACTURED ON DECEMBER 6 AND 9, 2002, FOR USE AS REPLACEMENT EQUIPMENT FOR 1997 FORD ESCORT 4-DOOR AND STATION WAGON PLATFORM VEHICLES, FORD'S P/N F7CZ54611B09AAC. THE SEAT BELT ASSEMBLIES EXHIBIT A NO-LOCK CONDITION WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, SEAT BELT ASSEMBLIES.
ON CERTAIN PASSENGER VEHICLES, THE INTEGRATED AIR BAG MONITOR (IABM) CAN BE CONTAMINATED WITH WATER OR OTHER LIQUIDS AND COULD EXPERIENCE INTERNAL ELECTRICAL SHORTING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.9L ENGINES, BUILT AT THE HERMOSILLO OR WAYNE ASSEMBLY PLANTS AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN NEVADA, FLORIDA, HAWAII, TEXAS, CALIFORNIA, LOUISIANA, GEORGIA, SOUTH CAROLINA, MISSISSIPPI, OKLAHOMA, ALABAMA AND ARKANSAS. CRACKS CAN DEVELOP IN THE FUEL TANK NEAR THE HEAT SHIELD ATTACHMENT RESULTING IN FUEL LEAKAGE IF THE CRACKS GO THROUGH THE FUEL TANK WALL.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.9L ENGINES, BUILT AT THE HERMOSILLO ASSEMBLY PLANT AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN ARIZONA. CRACKS CAN DEVELOP IN THE FUEL TANK NEAR THE HEAT SHIELD ATTACHMENT RESULTING IN FUEL LEAKAGE IF THE CRACKS GO THROUGH THE FUEL TANK WALL.
THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
AFTER 27 YEARS THE RUBBER FUEL FILLER PIPE ON THE CAR CRACKED AND BEGAN LEAKING FUEL. THE FUEL FILLER PIPE WAS REPLACED WITH A NEW FUEL FILLER PIPE FROM FORD MOTORCRAFT, PART #KFL-22, FOCZ-9324-AA. THE NEW FUEL FILLER PIPE LASTED ONLY 6 MONTHS BEFORE CRACKING AND SPILLING GAS ON MY DRIVEWAY CREATING A HAZARDOUS SITUATION. THE CAR WAS REPAIRED WITH A NEW THIRD PARTY [NOT FORD] FUEL FILLER PIPE. I'M BRINGING THIS TO YOUR ATTENTION BECAUSE NUMEROUS AUTO REPAIR WEB SITES HAVE HUNDREDS OF COMPLAINTS REGARDING DEFECTIVE REPLACEMENT FORD FUEL FILLER PIPES [ALL FORD MODELS]. FUEL FILLER PIPES SHOULD LAST MORE THEN 6 MONTHS. FORD'S REPLACEMENT FUEL FILLER PIPES ARE DEFECTIVE AND SHOULD BE RECALLED FOR REPLACEMENT BY FORD TO PREVENT A VERY HAZARDOUS SITUATION SHOULD A VEHICLE BE PARKED IN A GARAGE, I.E., NEAR A WATER HEATER OR OTHER IGNITION SOURCE, CREATING A LIFE-THREATENING SITUATION. THE LEAK FROM THE FUEL FILLER PIPE OCCURS WHETHER OR NOT THE VEHICLE IS PARKED OR MOVING WHEN THE FUEL TANK IS MORE THEN 3/4'S FULL. THE PIPE DETERIORATES FROM THE OUTSIDE WITH CRACKS RUNNING THE LENGTH OF THE PIPE. THE NYLON WEBBING ON THE INSIDE OF THE PIPE DOES NOT PREVENT IT FROM LEAKING. THE ATTACHED PHOTO SHOWS THE DEFECTIVE PIPE, BUT THE HUNDREDS OF HAIRLINE CRACKS IN THE PIPE CANNOT BE SEEN IN THE PHOTO BECAUSE OF PHOTO RESOLUTION. THE PIPE HAS ONLY BEEN IN USE ON THE CAR FOR JUST SIX MONTHS. I USE 91 OCTANE GASOLINE IN THE CAR. *TR
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1991 MERCURY TRACER. AFTER THE VEHICLE WAS FILLED WITH FUEL AND PARKED IN THE GARAGE, THE CONTACT SMELLED A FUEL ODOR AND NOTICED FUEL LEAKING ONTO THE GARAGE FLOOR. ALL AMERICAN FORD (3306 BRIDGE AVE, POINT PLEASANT, NJ 08742, (732) 451-3582) WAS CONTACTED AND STATED THAT THE VEHICLE WAS TOO OLD AND THEY DID NOT HAVE PARTS. THE VEHICLE WAS THEN TAKEN TO ALL AMERICAN MAZDA (575 BURNT TAVERN RD, BRICK TOWNSHIP, NJ 08724, (732) 451-6848) WHERE A DIAGNOSTIC AND REPAIR APPOINTMENT WAS SCHEDULED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.
No injuries · No fire · No crash
THERE IS A STALLING PROBLEM, EVEN WHEN DRIVING! THE WERE A NUMBER OF TIMES THAT I HAD TO BE PUSHED OF A MAIN ROAD. IT TOOK HOURS TO RESTART. IF I WAIT OVER 10 HOURS, MOST TIMES THE CAR WILL RESTART. THE PROBLEM SEEMS TO BE IN THE IGNITION MODULE AND /OR THE MAGNET AND/OR THE ROTOR. I HAVE SPENT NEARLY $2,300.00 REPLACING PARTS. THE CAR STILL STALLS OUT EVEN WHEN DRIVING! IT IS POSSIBLE THE PROBLEM IS WITH THE DISTRIBUTOR OR THE IGNITION MODULE. THE CONTACTS TO THE RELAY IN THE FUSE BOX WERE CLEANED BUT IT STILL STALLS RANDOMLY. I BELIEVE THERE WAS A RECALL WITH THE IGNITION MODULE, ROTOR AND MAGNET SET. IS THAT TRUE?
No injuries · No fire · No crash
TL* THE CONTACT OWNED A 1993 MERCURY TRACER. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY. THE BRAKE PEDAL TRAVELED TO THE FLOOR WHEN IT WAS DEPRESSED. AS A RESULT, THE VEHICLE STRUCK ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THERE WERE THREE INJURIES REPORTED THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. MAILED 10/16/14*LJUPDATED 11/13/14*LJ UPDATED 4/29/2015 *JS
TL* THE CONTACT OWNS A 1995 MERCURY TRACER. WHILE DRIVING 30 MPH, THE CONTACT SMELLED FUEL INSIDE THE VEHICLE. ONCE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A LEAK ON THE GROUND AND THE FUEL GAUGE DECREASED FROM A FULL TANK TO HALF OF A TANK. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 97V144000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
No injuries · No fire · No crash