Mazda Mazda6 Service Bulletins
1,417 manufacturer communications on file.
- January 25, 2016•Document ID: 10100889Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- 05-002-16-3129
- Date Added:
- May 26, 2017
- Manufacturer:
- MAZDA
SummaryTHE NEW SKYACTIV-DRIVE FW6A-EL AT USES AUTOMATIC TRANSMISSION FLUID (ATF) TYPE: FZ. ONLY USE ATF-FZ TO FILL OR TOP OFF THE FLUID LEVEL. ATF-FZ IS SPECIALLY DESIGNED FOR USE IN THE SKYACTIV-DRIVE SERIES AT. IT IS A LOW VISCOSITY FORMULA WITH LESS FRICTION FOR BETTER FUEL ECONOMY. NOTE: ATF-FZ IS COLORED BLUE FOR EASY IDENTIFICATION. TO CHECK THE FLUID LEVEL, REMOVE THE BOLT, THEN REMOVE THE DIPSTICK. THE DIPSTICK IS MARKED WITH A FZ ON SKYACTIV-DRIVE FW6A-EL AT. WHEN FINISHED, INSERT THE DIPSTICK AND INSTALL THE BOLT.
Associated Products (14)Associated Documents - January 25, 2016•Document ID: 10100888Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:HEADLIGHTS; EXTERIOR LIGHTING:TAIL LIGHTS
- Mfr Comm. #:
- 09-003-16-3130
- Date Added:
- May 26, 2017
- Manufacturer:
- MAZDA
SummarySOME CUSTOMERS MAY COMPLAIN OF CONDENSATION/FOG INSIDE THE FRONT (HEADLAMP/HEADLIGHT) OR REAR (TAILLAMP/TAIL-LIGHT) COMBINATION LIGHTS. THE RECENT NEW MODELS HAVE BEEN FITTED WITH A CLEAR LENS WHICH CAN CAUSE THE SYMP-TOM TO BE MORE NOTICEABLE, HOWEVER, IT DOES NOT AFFECT THE PERFORMANCE OF THE LIGHT. THIS CONDENSATION/FOG IS A NATURAL PHENOMENON THAT OCCURS WHEN THERE IS A FAIRLY LARGE TEMPERATURE DIFFERENCE BETWEEN THE INSIDE AND THE OUTSIDE OF THE LIGHT HOUSING. IT IS NORMAL FOR VERY SMALL WATER DROPS TO APPEAR IN CERTAIN LOCATIONS ON THE LIGHT UNITS WHERE THE AIR IS STAGNANT (CONDENSATION), MAKING THE LENS LOOK WHITISH (FOG). THIS HAPPENS MOSTLY IN THE CORNERS AND NARROW SPACES, AND WILL TYPICALLY CLEAR DURING WARMER AMBIENT TEMPERATURES, OR WHEN THE LIGHTS HAVE BEEN ON FOR SOME TIME. EXPLAIN TO THE CUSTOMER THAT THIS IS A NATURAL PHENOMENON AND NOT A QUALITY DEFECT. DO NOT ATTEMPT REPAIRS AS THIS IS CONSIDERED NORMAL, AND IS NOT COVERED UNDER WARRANTY. REPLACING THE LIGHT UNIT WILL NOT CORRECT THIS SYMPTOM.
Associated Products (81)2016 Mazda CX-32016 Mazda CX-52016 Mazda CX-92016 Mazda Mazda32016 Mazda Mazda62016 Mazda MX-52015 Mazda CX-52015 Mazda CX-92015 Mazda Mazda32015 Mazda Mazda52015 Mazda Mazda62015 Mazda MX-52014 Mazda CX-52014 Mazda CX-92014 Mazda Mazda22014 Mazda Mazda32014 Mazda Mazda52014 Mazda Mazda62014 Mazda MX-52013 Mazda CX-5+ 61 moreAssociated Documents - January 14, 2016•Document ID: 10213325Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- 0000116
- Date Added:
- June 6, 2022
- Manufacturer:
- MAZDA
SummarySpecial service tool shipment Janaurary 2016
Associated Products (15)Associated Documents - January 14, 2016•Document ID: 10105849Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 00-001-16-3127
- Date Added:
- June 9, 2017
- Manufacturer:
- MAZDA
SummaryIN SUPPORT OF IMPROVED ELECTRICAL DIAGNOSIS ON SKYACTIV VEHICLES, MAZDA WILL SHIP A TERMINAL TEST KIT TO ALL DEALERS. THE TEST KIT IS DESIGNED PECIFICALLY FOR SKYACTIV MODULE TERMINALS. THE SST WILL BE SHIPPED BY MAZDAS TOOL VENDOR BOSCH STARTING JANUARY 15, 2016. PROCEDURES FOR USAGE ARE FOUND IN THE SKYACTIV WIRING TERMINAL TEST KIT WBT, COURSE #1649. THE FOLLOWING SST IS THE LATEST ADDITION TO THE MAZDA REQUIRED TOOL (MRT) LIST:
Associated Products (15)Associated Documents - January 11, 2016•Document ID: 10213448Service Bulletin/Repair InstructionsLANE DEPARTURE; AIR BAGS
- Mfr Comm. #:
- 1500116
- Date Added:
- June 6, 2022
- Manufacturer:
- MAZDA
SummaryLDWS or ALH warning light on with DTC C1001:92
Associated Products (1)Associated Documents - January 11, 2016•Document ID: 10105853Service Bulletin/Repair InstructionsVISIBILITY:WINDSHIELD; EXTERIOR LIGHTING:HEADLIGHTS; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 15-001-16-3126
- Date Added:
- June 9, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXPERIENCE ONE OF THE FOLLOWING 2 SYMPTOMS, EVEN THOUGH THE WINDSHIELD IS CLEAR: 1. LANE DEPARTURE WARNING SYSTEM (LDWS) WARNING LIGHT TURNS ON AT IDLE. DTC C1001:92 (POOR FUNCTIONING OF FORWARD SENSING CAMERA (FSC)) IS STORED IN MEMORY.2.ADAPTIVE LED HEADLIGHTS (ALH) WARNING LIGHT TURNS ON WHILE DRIVING. DTC C1001:92 (POOR FUNCTIONING OF FORWARD SENSING CAMERA (FSC)) IS STORED IN MEMORY.UNDER CERTAIN DRIVING CONDITIONS, THE FORWARD SENSING CAMERA (FSC) MAY DETECT A DIRTY WINDSHIELD (NOT CLEAR).
Associated Products (3)Associated Documents - January 11, 2016•Document ID: 10076692Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 15-001/16
- Date Added:
- July 14, 2016
- Manufacturer:
- MAZDA
SummaryLDWS OR ALH WARNING LIGHT ON WITH DTC C1001:92. SOME VEHICLES MAY EXPERIENCE ONE OF THE FOLLOWING 2 SYMPTOMS, EVEN THOUGH THE WINDSHIELD IS CLEAR. LANE DEPARTURE WARNING SYSTEM (LDWS) WARNING LIGHT TURNS ON AT IDLE; DTC C1001:92 (POOR FUNCTIONING OF FORWARD SENSING CAMERA (FSC)) IS STORED IN MEMORY. ADAPTIVE LED HEADLIGHTS (ALH) WARNING LIGHT TURNS ON WHILE DRIVING; DTC C1001:92 (POOR FUNCTIONING OF FORWARD SENSING CAMERA (FSC)) IS STORED IN MEMORY.
Associated Products (3)Associated Documents - January 8, 2016•Document ID: 10213385Service Bulletin/Repair InstructionsWHEELS
- Mfr Comm. #:
- 0200216
- Date Added:
- June 6, 2022
- Manufacturer:
- MAZDA
SummarySTAINS APPEAR ON WHEELS
Associated Products (44)2016 Mazda Mazda22016 Mazda Mazda32016 Mazda Mazda52016 Mazda Mazda62015 Mazda Mazda22015 Mazda Mazda32015 Mazda Mazda52015 Mazda Mazda62014 Mazda Mazda22014 Mazda Mazda32014 Mazda Mazda52014 Mazda Mazda62013 Mazda Mazda22013 Mazda Mazda32013 Mazda Mazda52013 Mazda Mazda62012 Mazda Mazda22012 Mazda Mazda32012 Mazda Mazda52012 Mazda Mazda6+ 24 moreAssociated Documents - January 8, 2016•Document ID: 10105855Service Bulletin/Repair InstructionsWHEELS
- Mfr Comm. #:
- 02-002-16-3124
- Date Added:
- June 9, 2017
- Manufacturer:
- MAZDA
SummarySOME AUTOMOTIVE CLEANING PRODUCTS CONTAIN STRONG ACID OR ALKALI. WHEN THESE TYPES OF CLEANERS ARE USED TO CLEAN THE WHEELS ON MAZDA VEHICLES, THE CHEMICALS CONTENTS PENETRATE THE CLEAR COATING OF THE WHEEL SURFACE AND DAMAGE THE PAINT UNDER THE CLEAR COATING. THE DAMAGED AREA HAS THE APPEARANCE OF DARK STAINS.
Associated Products (67)2016 Mazda Mazda22016 Mazda Mazda32016 Mazda Mazda52016 Mazda Mazda62016 Mazda MX-52015 Mazda Mazda22015 Mazda Mazda32015 Mazda Mazda52015 Mazda Mazda62015 Mazda MX-52014 Mazda Mazda22014 Mazda Mazda32014 Mazda Mazda52014 Mazda Mazda62014 Mazda MX-52013 Mazda Mazda22013 Mazda Mazda32013 Mazda Mazda52013 Mazda Mazda62013 Mazda MX-5+ 47 moreAssociated Documents - January 1, 2016•Document ID: 10186917Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SA51
- Date Added:
- February 8, 2021
- Manufacturer:
- MAZDA
SummaryMazda connect software version 59.00.441 available - Important Update. Used the Labor Op Code in the TSB to update these vehicles with a customer concern until an updated TSB is published.
Associated Products (4)Associated Documents - December 30, 2015•Document ID: 10118484Service Bulletin/Repair InstructionsSTRUCTURE; EQUIPMENT
- Mfr Comm. #:
- SSPA0
- Date Added:
- October 4, 2017
- Manufacturer:
- MAZDA
SummaryMazda Motor Corporation is extending the warranty coverage for dashboard crash pads on certain 2009-2013 Mazda6 vehicles produced from February 4, 2008 through August 24, 2012. For certain 2009-2013 Mazda6 vehicles, the warranty coverage for sticky dashboard upper panel (crash pad) replacement only is extended to 10 years (120 months) from the original warranty start date, with no mileage limitation. Any other condition for dashboard replacement, such as discoloration, warping, or material splitting, is covered only for 36 months or 36,000 miles. On certain Mazda6 vehicles that are exposed to severe environmental conditions including high ambient temperature and humidity, the material used in the crash pad may deteriorate over time. If there is prolonged exposure and deterioration, the crash pad could develop a sticky surface. If a sticky surface condition exists, the crash pad must be replaced. The warranty extension only applies to the sticky surface condition. It does not apply to crash pads that are discolored, warped, or split.These conditions are covered under Mazda?s New Vehicle Limited Warranty for the first 36 months or 36,000 miles, whichever comes first.
Associated Products (5)Associated Documents - December 22, 2015•Document ID: 10213440Service Bulletin/Repair InstructionsVEHICLE SPEED CONTROL
- Mfr Comm. #:
- 0904615
- Date Added:
- June 6, 2022
- Manufacturer:
- MAZDA
SummaryWhite door armrest(s) pink discoloration
Associated Products (3)Associated Documents - December 22, 2015•Document ID: 10213409Service Bulletin/Repair InstructionsPARKING BRAKE
- Mfr Comm. #:
- 0500715
- Date Added:
- June 6, 2022
- Manufacturer:
- MAZDA
SummaryIgnition does not turn off when pressing start/stop button
Associated Products (2)Associated Documents - December 22, 2015•Document ID: 10213379Service Bulletin/Repair InstructionsENGINE; ELECTRICAL SYSTEM
- Mfr Comm. #:
- 0102315
- Date Added:
- June 6, 2022
- Manufacturer:
- MAZDA
SummaryRough Idle with MIL on and DTC P0015/P0524
Associated Products (7)Associated Documents - December 22, 2015•Document ID: 10105639Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 01-023-15-3084B
- Date Added:
- June 8, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXPERIENCE A ROUGH IDLE WITH THE MIL ON AND DTC P0015 / P0524 STORED IN MEMORY. P0015:00 - EXHAUST CMP TIMING OVER-RETARDED P0524:00 - ENGINE OIL PRESSURE TOO LOW THIS IS CAUSED BY A DROP IN ENGINE OIL PRESSURE DUE TO A PIECE OF FOREIGN OBJECT STUCK ON THE OIL PUMP PRESSURE RELIEF VALVE OR OCV. THE TEMPORARY ENTRY OF THE FOREIGN OBJECT TRIGGERS A MIL ILLUMINATION, BUT ROUGH IDLE WILL NOT BE PRODUCED UNTIL A LATER TIME.
Associated Products (12)Associated Documents - December 22, 2015•Document ID: 10105638Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR
- Mfr Comm. #:
- 09-046-15-3111
- Date Added:
- June 8, 2017
- Manufacturer:
- MAZDA
SummarySOME CUSTOMERS MAY COMPLAIN ABOUT A WHITE DOOR ARMREST(S) PINK DISCOLORATION. THE DISCOLORED ARMREST DOES NOT MATCH THE OTHER WHITE PARTS OF THE DOOR PANEL. REPLACE ALL 4 DOOR PANELS.
Associated Products (3)Associated Documents - December 22, 2015•Document ID: 10105637Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:IGNITION; POWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- 05-007-15-3115
- Date Added:
- June 8, 2017
- Manufacturer:
- MAZDA
SummaryWHEN PRESSING THE START/STOP BUTTON, THE IGNITION MAY NOT TURN OFF ON SOME VEHICLES EQUIPPED WITH A GATE TYPE AT SHIFTER. ALTHOUGH THE SHIFT LEVER IS IN P POSITION AND THE ENGINE SHUTS OFF NORMALLY, THE IGNITION MAY STAY ON (IN ACCESSORY MODE). THIS CONCERN MAY BE CAUSED BY A WORN SWITCH UNIT. TO ELIMINATE THIS CONCERN, THE SWITCH UNIT MATERIAL HAS BEEN CHANGED TO IMPROVE WEAR RESISTANCE. MODIFIED SWITCH UNITS HAVE BEEN ESTABLISHED AS NEW SERVICE PARTS.
Associated Products (2)Associated Documents - December 22, 2015•Document ID: 10076691Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR; STRUCTURE
- Mfr Comm. #:
- 09-046/15
- Date Added:
- July 14, 2016
- Manufacturer:
- MAZDA
SummaryWHITE DOOR ARMREST(S) PINK DISCOLORATION. SOME CUSTOMERS MAY COMPLAIN ABOUT A WHITE DOOR ARMREST(S) PINK DISCOLORATION. THE DISCOLORED ARMREST DOES NOT MATCH THE OTHER WHITE PARTS OF THE DOOR PANEL.
Associated Products (3)Associated Documents - December 22, 2015•Document ID: 10076663Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:IGNITION
- Mfr Comm. #:
- 05-007/15
- Date Added:
- July 14, 2016
- Manufacturer:
- MAZDA
SummarySUMMARY TO BE PROVIDED ON A FUTURE DATE.
Associated Products (2)Associated Documents - December 17, 2015•Document ID: 10213386Service Bulletin/Repair InstructionsSUSPENSION
- Mfr Comm. #:
- 0200315
- Date Added:
- June 6, 2022
- Manufacturer:
- MAZDA
SummaryKNOCKING/SQUEAKING NOISE FROM FRONT SHOCK ABSORBER
Associated Products (3)Associated Documents