Mazda CX-30 Complaints (2020)

34 consumer complaints on file.

#11769418October 6, 2026
ENGINE
Multiple fixes and repairs on a P0421 code. Repaired by Mazda with a new catalytic converter but then refused to replace it when the code came back saying it was not covered by the warranty. Mazda says it is not a common issue but they have had issues in the past with the same P0421 code repeatedly showing up on a healthy car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761957September 3, 2026
POWER TRAIN
My car was squeaking and lurching around 3/4 gear. I took it in to the Mazda dealership (Northtowne Mazda in Kansas City) and they told me it was a "well-known issue" with this year and make of a Mazda. There is a problem with the torque converter lock-up clutch which sheds iron particles into the transmission fluid. The torque converter needs to be replaced. After further research, it appears that Mazda has a well-documented manufacturing defect that is outlined in Mazda TSB 05-005/23. My car has a 60,000 mile/5 year warranty on it. It currently only has 48,600 miles on it (well under the warranty limit). I called the Mazda Corporation Customer Care and they opened a ticket but I was told today that they will not extend any assistance with this, even though it is below the warranty limit on mileage and with them knowing about this issue and publishing a bulletin about it. I asked about the Good Will extension and the Customer Service Case Manager told me it didn't qualify. Even with it being under the warranty mileage, because it's over the year limit, they won't cover it. I asked what the criteria was to qualify for the Good Will extension and he told me it was "confidential" and there is nothing they can do about it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751262July 18, 2026
EXTERIOR LIGHTING
The front passenger side headlight is making a whirring noise whenever the light is turned on. Based on the NHTSA safety reports for this model, this indicates the fan is failing, and soon the headlight will also fail. Intact headlights are essential for driving safety at night. No warning messages have appeared on the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710048January 10, 2026
ELECTRICAL SYSTEM
My 2020 Mazda CX-30 has an intermittent no-start condition caused by a complete electrical failure. This occurs randomly, often overnight and after long or short trips. When it happens: The car does not respond to the key fob or ignition Dashboard warning lights are off Vehicle cannot be started, creating a safety risk if it occurs during travel or in an emergency The defect began during car's full warranty period and has persisted despite multiple service visits and battery replacement. The dealer has been unable to diagnose or correct the issue, and Mazda Corporate is aware of the defect under case Case Number 00398310. After about two years of these intermittement failures, and parasitic draws ruled out, I paid to have the Battery replaced, independently of Mazda and the battery failed yet again. Routine diagnostics have not resolved the defect Issue is intermittent and unpredictable This is a Safety Risk as the Car has failed to start when needed on numerous occasions, and has left me stranded. ALL of these Failures have occured without warning Mazda Corporate is aware and has requested dealership diagnostics. Dealership has not reproduced the problem. Issue remains unresolved as of 1/10/2026 Video documentation exists showing dealer inspection and inability to find failure source. I am submitting this complaint to NHTSA because the defect: Impairs the vehicle’s safe operation Has not been reliably repaired Represents a potential safety risk to the driver and public I request that this complaint be recorded for investigation and included in any potential recall or safety evaluation. Service records available on request Emails with Mazda Corporate als available Video of dealer inspection showing intermittent failure avaialble
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702067November 30, 2025
SERVICE BRAKES, FUEL/PROPULSION SYSTEM, EXTERIOR LIGHTING
The front camera didn't operate properly The brakes have an elongated stopping distance
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11700042November 18, 2025
STRUCTURE:BODY
There is a module that should connect to the hatch door to open. That module in no longer available. Without the hatch door opening, in case of side impact and being pushed into something else, there is no way to get out of the car. This poses a serious safety hazard. I have contacted the Mazda dealership and I am told that the part is "retired" and there is no replacement part at this time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674592July 18, 2025
POWER TRAIN
I OWN 2020 MAZDA CX 30 WITH 66000 MILES. THE TRANSMISSION WAS SHIFTING WITH JERKY MOTIONS. ON JULY 14, 2025 I BROUGHT THE CAR TO PALISADES MAZDA IN ROCKLAND COUNTY NEW YORK TO HAVE TRANSMISSION LOOKED AT AND TO CHANGE TRANSMISSION FLUID CHANGED. AFTER I DROPPED THE CAR OFF LATER THAT DAY I GOT A CALL THAT THE TRANSMISSION WAS CONDEMNED. I LOOKED ON THE INTERNET WITH SAME YEAR MAKE AND MODEL AND SEE THERE IS A BIG PROBLEM WITH THE TRANSMISSIONS ON THESE CARS AND MAZDA IS AWARE OF THE PROBLEM. TSB 05-002/20 IS A BULLETIN ABOUT TRANSMISSION FAILURES IN THIS VEHICLE. MAZDA IS WELL AWARE OF THE TRANSISSION PROBLEMS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665901June 9, 2025
POWER TRAIN, SEAT BELTS, UNKNOWN OR OTHER
The initial sensor alarm indication was low oil pressure and within less then an hour engine malfunction was detected and the vehicle stopped functioning. This incident occurred on [XXX] in SanAntonio and thereafter it was towed to the Mazda Dealership for inspection upon request. I was driving from Dallas to SanAntonio with my [XXX] and [XXX] children when the vehicle started making strange noise and It the notification on dashboard stated I need to immediately stop the vehicle for safety. Middle of nowhere I had to find a nearest safe place for my children. This vehicle put me and my kids in an unsafe environment due to the faulty engine that was installed by the Mazda company. I was afraid thinking the car will start on fire because it was an engine alert. Yes the vehicle has been inspected by the North Park Mazda dealership on 5/12/25 with an initial quote of engine repair for $7905.88. The first time I noted which was few weeks back prior to this incident when the vehicle stalled at me while I arrived and stopped the vehicle at UT Southwestern Medical Center were I work as a nurse to badge into my parking lot. I got worried for a moment thinking could it be battery issue? I turned off the vehicle and turned it back on and the vehicle starting working. I parked the car and completed a 12 hr shift and thereafter did few weeks of work without any alerts or issue on the vehicle until the day off [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661587May 17, 2025
POWER TRAIN
I am reporting a repeated and potentially dangerous transmission failure in my 2020 Mazda CX30. At 6 months old, the original transmission failed. Mazda confirmed it was defective and replaced it with a refurbished unit with 10,000 miles on it. That replacement is now also failing—within 4 years of the first failure. This means the car has experienced two transmission failures before reaching 5 years of service. This raises concerns about: •The reliability of Mazda’s factory parts •The quality and safety of refurbished transmissions Mazda uses in warranty repairs •A potential pattern of premature transmission failures on this model Repeated transmission failure can cause loss of power and control, posing serious safety risks to drivers and passengers. Mazda has all service records confirming both incidents. I am submitting this to alert NHTSA to a possible defect pattern that may warrant investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631587December 19, 2024
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
The contact owns a 2020 Mazda CX-30. The contact stated that after starting the vehicle, the instrument panel made an abnormal sound. The contact then noticed that the odometer had inadvertently rolled back to 9,999 miles. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628495December 3, 2024
ENGINE
Low Engine Oil Light keeps appearing at seemingly random intervals. I will heat up my vehicle, begin driving, and sometimes after 10 minutes, sometimes after 20 minutes it will come on. I drove 2.5 hours and it did not come on at all. It first started Friday 11/29 and was driven to and from a few places and came on 50% of the time. The 2.5 hour drive occurred on Saturday 11/30 and the light did not come on at all.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625683November 16, 2024
SUSPENSION
Rear coil spring broke at ~33,000 miles under normal driving conditions. No warnings given in vehicle safety system and not included in recommended maintenence. Seen when inspected by independent service center. Cannot safely drive vehicle until replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623146November 1, 2024
UNKNOWN OR OTHER
I am experiencing sharp edge on the Driver Side window up button. The Nicle plating is wearing off and causing safety concern. I have images of the concern. Will send upon request. Mazda is suggesting that I take the vehicle in for diagnostics and service. Their diagnostic cost is extremely high, and I am trying to avoid paying the diagnostic fee. Copy of the contents of my email sent to Mazda. I am experiencing sharp edge on the Driver Side window up button. I am wondering if this can be repaired under warranty or, should I report the abnormally to NHTSA to pursue a possible recall to have this switch replaced. I recall NHTSA had a recall on Hyundai vehicles a few years ago for the same issue. Can you please advise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11615251September 18, 2024
VISIBILITY/WIPER
Defective windshield. There is visible warping in the windshield and Mazda won't cover the cost of the replacement. This is a known issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596869June 26, 2024
SERVICE BRAKES, SUSPENSION
Front and rear brakes premature wear, would have failed safety inspection under 30,000 miles but brakes were inspected just outside of warranty with metal on metal. RIGHT rear coil spring snapped lower middle of coil while driving on flat even ground. Just outside of warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11585002April 24, 2024
UNKNOWN OR OTHER
My sunroof spontaneously shattered/exploded during a standstill at a stoplight while waiting to enter a freeway. The glass sunroof panel appeared slightly curved upwards (caused by built up interior pressure?) and the shattered hole is right below my roof crossbar. There is no damage to metal roof surface or crossbar. My interior roof slider was closed when my sunroof shattered as it could have compromised my family's safety. After the incident, I drove my vehicle to the nearest dealership (Capistrano Mazda) but they didn't lift a finger besides taking a couple pics and suggested I call their 800 customer experience center number. Since it was a Saturday, I reached out through Mazda's customer experience email. I didn't hear back from Mazda until 4 days later on [XXX] requesting additional information (address, VIN # & mileage). After providing requested information, I didn't hear back from Mazda until [XXX] suggesting I bring my vehicle back to Capistrano Mazda dealership for a diagnosis. Almost 10 days had passed with no action from Mazda while I still had to commute to/from work dealing with loud incessant cabin noise from shattered sunroof open cavity. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11563320January 3, 2024
SERVICE BRAKES, ENGINE, UNKNOWN OR OTHER
The car was running in parking garage without ignition being turned on. When I entered the car, the motor wouldn't catch at all, and message popped up saying the there was a brake malfunction. All the lights were on, so it did not seem to be a battery problem, but the drive function was dead. Several months ago the car started racing while i was driving and i couldnt get it to stop. I finally, while still driving, turned off the ignition and rolled off the road. After a few minutes, i restarted the engine. it had stopped racing and i drove it to the Mazda dealership. They didnt find anything wrong. So this latest incident, Jan. 3rd, involved an uninitiated running vehicle that was parked, and the brake malfunction console notice that said "brake malfunction". Again, the prior incident involved the same vehicle racing on a roadway and necessitated the turning off the ignition while on a major road and rolling the car onto the shoulder. There is something wrong with this car involving the engine and brakes. Triple A came to tow it to the dealership and utilized an alternator to start it, which enabled them to drive it to the tow truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11528975June 26, 2023
STEERING
The contact owns a 2020 Mazda CX-30. The contact stated while driving out of the driveway, the steering wheel became firm. The contact stated that the power steering warning light was illuminated. The vehicle was towed to the dealer. The dealer diagnosed the vehicle and determined that the power steering unit needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was 66,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11513156March 22, 2023
ENGINE
Every 1000 miles the low oil light comes on. I have 24000 miles on the car and this only started about 4000 miles ago. I have to add a quart of oil every 1-2000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11506136February 7, 2023
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
I bought Mazda CX30 in 2020 and the battery already starts to fail. The engine light and the battery light are on suddenly when I was driving. Then, after a while, when I restart the engine and it starts to work again. However, it happens for two times within a week. I have sent the car to the Auto Zone and the nearby car auto repair company to check the car. However, they said they cannot detect anything as the engine light and the battery light are on again this time. It is so dangerous when the car suddenly stop in the middle of the road when I was driving. I am so lucky that this accident happened during rush hour and there were heavy traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mazda CX-30