Hyundai Sonata Service Bulletins
1,006 manufacturer communications on file.
- July 26, 2021•Document ID: 10200077Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21-EM-009H
- Date Added:
- August 7, 2021
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides additional service diagnostic information and repair procedures related to Electric Waste Gate Actuator (EWGA) equipped vehicles listed below. Refer to the applicable Engine Control / Fuel System sections in the Shop Manual, and then follow the procedures outlined in this bulletin whenever a vehicle with the following symptom(s) are being diagnosed: ⢠Check Engine Light illumination with EWGA related DTC. ⢠Intermittently high/low turbocharger boost pressures. ⢠Abnormal noise from the turbocharger. ⢠Reduced engine power.
Associated Products (21)2022 Hyundai Veloster2021 Hyundai Veloster2020 Hyundai Santa Fe2020 Hyundai Veloster2019 Hyundai Santa Fe2019 Hyundai Sonata2019 Hyundai Veloster2018 Hyundai Santa Fe Sport2018 Hyundai Sonata2017 Hyundai Santa Fe Sport2017 Hyundai Sonata2016 Hyundai Santa Fe Sport2016 Hyundai Sonata2015 Hyundai Santa Fe Sport2015 Hyundai Sonata2014 Hyundai Santa Fe Sport2014 Hyundai Sonata2013 Hyundai Santa Fe Sport2013 Hyundai Sonata2012 Hyundai Sonata+ 1 moreAssociated Documents - July 13, 2021•Document ID: 10200075Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 21-AT-009H
- Date Added:
- August 7, 2021
- Manufacturer:
- HYUNDAI
SummaryThis TSB provides a procedure to diagnose the push button shifter operation.
Associated Products (8)Associated Documents - June 30, 2021•Document ID: 10199095Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21-01-035H
- Date Added:
- July 9, 2021
- Manufacturer:
- HYUNDAI
SummaryCertain 2011 2015 Sonata Hybrid vehicles (YF HEV) may experience check engine light illumination with Evaporative System (EVAP) leakage related DTC P0442 Small Leak, P0455 Large Leak or P0456 Very Small Leak stored. These conditions primarily occur in the California coastal areas that are subject to marine layer cloud cover. Salt particulate deposit can form inside the Natural Vacuum Leak Detection (NVLD) sensor which may cause intermittent operation prompting the DTC P0442, P0455 or P0456 and check engine light illumination. This bulletin provides the procedure to install a new Air Filter Kit with an updated filter to help prevent entry of the salt particulates. In addition, replace NVLD sensor if DTC P0442, P0455 or P0456 is stored in the Engine Control Module (ECM).
Associated Products (5)Associated Documents - June 22, 2021•Document ID: 10199099Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21-01-051H
- Date Added:
- July 9, 2021
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides information related to an Electronic Control Module (ECM) software update which revises the OBD Air Fuel Ratio Imbalance (AFRI) monitor function frequency and cylinder imbalance diagnosis logic.
Associated Products (2)Associated Documents - June 14, 2021•Document ID: 10199101Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 21-AT-007H
- Date Added:
- July 9, 2021
- Manufacturer:
- HYUNDAI
SummaryIf you are servicing an 8-speed front-wheel-drive vehicle with the DTC or symptoms listed below, refer to the Service Procedure to diagnose the condition. ï· DIAGNOSTIC TROUBLE CODES: ï P070500 - Transmission range sensor circuit malfunction ï P070512 - Transmission range sensor circuit malfunction ï P070514 - Transmission range sensor circuit malfunction ï P07051C - Transmission range sensor circuit malfunction ï P070600 - Transmission range sensor circuit range/performance ï P070661 - Transmission range sensor circuit range/performance ï P070696 - Transmission range sensor circuit range/performance ï· SYMPTOMS: ï Malfunction Indicator Light (MIL) illuminated ï 5th gear fail-safe ï No gear indication in cluster ï Intermittently wonât shift into D or R ï Intermittently wonât shift out of Park ï Intermittent ly no engine cr ank/no start in âPâ or âNâ with or without MIL or DTC.
Associated Products (7)Associated Documents - June 10, 2021•Document ID: 10199106Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21-EM-007H
- Date Added:
- July 9, 2021
- Manufacturer:
- HYUNDAI
SummaryThis bulletin describes the procedure to diagnose and repair the Engine Electric Water Pump (EEWP) on certain Sonata Hybrid (LF HEV) and Sonata Plug-In Hybrid (LF PHEV) vehicles with DTC P2600, causing an HEV and/or MIL warning lamp illumination.
Associated Products (4)Associated Documents - June 8, 2021•Document ID: 10199107Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21-EM-008H
- Date Added:
- July 9, 2021
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides additional service diagnostic information and repair procedures related to Variable Charge Motion Controllers (VCM) equipped in the applicable vehicles listed below. This bulletin also provides information on the use of the Service Kit for 2.4L equipped engines, which enables replacing the VCM Lever Arm without replacing the complete Intake Manifold Assembly. Refer to the applicable Engine Control / Fuel System sections in the Shop Manual, and then follow the procedures outlined in this bulletin whenever a vehicle with the following symptom(s) are being diagnosed: ï Check Engine Light illumination with VCM related DTC. ï Unstable engine RPM and reduced engine power. ï Abnormal noise from the intake manifold whenever engine RPM is raised from idle speed.
Associated Products (17)2022 Hyundai Veloster2021 Hyundai Tucson2021 Hyundai Veloster2020 Hyundai Santa Fe2020 Hyundai Tucson2020 Hyundai Veloster2019 Hyundai Santa Fe2019 Hyundai Sonata2019 Hyundai Tucson2019 Hyundai Veloster2018 Hyundai Santa Fe Sport2018 Hyundai Sonata2018 Hyundai Tucson2017 Hyundai Santa Fe Sport2017 Hyundai Sonata2016 Hyundai Sonata2015 Hyundai SonataAssociated Documents - June 3, 2021•Document ID: 10199108Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21-FL-002H
- Date Added:
- July 9, 2021
- Manufacturer:
- HYUNDAI
SummaryCertain 2011 2015 Sonata Hybrid vehicles (YF HEV) may experience a check engine light illumination with an Evaporative System (EVAP) leakage related DTC P0442 Small Leak, P0455 Large Leak, or P0456 Very Small Leak stored. Salt particulate deposits can form inside the Natural Vacuum Leak Detection (NVLD) sensor, which may cause intermittent operation, prompting the check engine light illumination and DTC P0442, P0455, or P0456.
Associated Products (5)Associated Documents - May 24, 2021•Document ID: 10196472Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 21-01-040H
- Date Added:
- June 10, 2021
- Manufacturer:
- HYUNDAI
SummaryThis bulletin describes the procedure to update the Shift Control Unit (SCU) for Shift-by-Wire vehicles (SBW). The update improves the display in the cluster.
Associated Products (1)Associated Documents - May 21, 2021•Document ID: 10196546Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 21-AT-006H
- Date Added:
- June 10, 2021
- Manufacturer:
- HYUNDAI
SummaryHyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicleâÂÂs ownerâÂÂs manual. ï· Use of other ATF may result in improper shift quality or other drivability conditions. ï· Use of other DCT and IVT gear oil may result in reduced durability. Hyundai does not approve the use of any aftermarket ATF or gear oil additives.
Associated Products (88)2012 Hyundai Elantra Touring2011 Hyundai Accent2011 Hyundai Elantra Touring2010 Hyundai Accent2010 Hyundai Azera2010 Hyundai Elantra2010 Hyundai Elantra Touring2010 Hyundai Sonata2009 Hyundai Accent2009 Hyundai Azera2009 Hyundai Elantra2009 Hyundai Elantra Touring2009 Hyundai Santa Fe2009 Hyundai Sonata2009 Hyundai Tucson2008 Hyundai Accent2008 Hyundai Azera2008 Hyundai Elantra2008 Hyundai Entourage2008 Hyundai Santa Fe+ 68 moreAssociated Documents - May 10, 2021•Document ID: 10196571Service Bulletin/Repair InstructionsLATCHES/LOCKS/LINKAGES
- Mfr Comm. #:
- 21-BD-005H
- Date Added:
- June 10, 2021
- Manufacturer:
- HYUNDAI
SummaryThe trunk latch base can be ordered separately from the trunk latch assembly. This bulletin describes the procedure to replace the trunk latch base.
Associated Products (19)2021 Hyundai Accent2020 Hyundai Accent2019 Hyundai Accent2018 Hyundai Accent2018 Hyundai Sonata2017 Hyundai Accent2017 Hyundai Azera2017 Hyundai Sonata2016 Hyundai Accent2016 Hyundai Azera2016 Hyundai Elantra2016 Hyundai Sonata2015 Hyundai Accent2015 Hyundai Azera2015 Hyundai Elantra2015 Hyundai Sonata2014 Hyundai Accent2014 Hyundai Elantra2013 Hyundai ElantraAssociated Documents - May 5, 2021•Document ID: 10196580Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- 21-BE-008H
- Date Added:
- June 10, 2021
- Manufacturer:
- HYUNDAI
SummaryCertain vehicles may experience 504 Time Out errors when using the Blue Link Mobile App. When asked to provide Modem Information (IMEI/USIM), the Head Unit (HU) displays all zeros. This bulletin describes the procedure to update the Head Unit Software to correct this condition.
Associated Products (4)Associated Documents - March 30, 2021•Document ID: 10190049Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; POWER TRAIN; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21-EM-005H
- Date Added:
- April 7, 2021
- Manufacturer:
- HYUNDAI
SummaryThe Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage, defect, or failure is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners.
Associated Products (12)Associated Documents - March 30, 2021•Document ID: 10190047Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT
- Mfr Comm. #:
- 21-01-025H
- Date Added:
- April 7, 2021
- Manufacturer:
- HYUNDAI
SummaryConsult the Hyundai Warranty Policy & Procedures and the below tables to determine New or Reman engine usage. Please note that a Reman engine may not be available for certain vehicle models/model years listed in this TSB.
Associated Products (7)Associated Documents - March 30, 2021•Document ID: 10190045Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21-01-024H
- Date Added:
- April 7, 2021
- Manufacturer:
- HYUNDAI
SummaryCertain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based on the inspection results.
Associated Products (7)Associated Documents - March 30, 2021•Document ID: 10190044Service Bulletin/Repair InstructionsEQUIPMENT; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 21-EM-004H
- Date Added:
- April 7, 2021
- Manufacturer:
- GENESIS
SummaryThis bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps.
Associated Products (245)2021 Genesis G702021 Genesis G802021 Genesis GV802021 Hyundai Accent2021 Hyundai Elantra2021 Hyundai Kona2021 Hyundai Palisade2021 Hyundai Santa Fe2021 Hyundai Sonata2021 Hyundai Tucson2021 Hyundai Veloster2021 Hyundai Venue2020 Genesis G702020 Genesis G802020 Genesis G902020 Hyundai Accent2020 Hyundai Elantra2020 Hyundai Elantra GT2020 Hyundai Ioniq2020 Hyundai Kona+ 225 moreAssociated Documents - March 23, 2021•Document ID: 10190038Service Bulletin/Repair InstructionsSERVICE BRAKES; EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- 21-BR-002H
- Date Added:
- April 7, 2021
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides best practice recommendations when performing brake service procedures.
Associated Products (232)2021 Hyundai Accent2021 Hyundai Elantra2021 Hyundai Kona2021 Hyundai Palisade2021 Hyundai Santa Fe2021 Hyundai Sonata2021 Hyundai Tucson2021 Hyundai Veloster2021 Hyundai Venue2020 Hyundai Accent2020 Hyundai Elantra2020 Hyundai Elantra GT2020 Hyundai Ioniq2020 Hyundai Kona2020 Hyundai Nexo2020 Hyundai Palisade2020 Hyundai Santa Fe2020 Hyundai Sonata2020 Hyundai Tucson2020 Hyundai Veloster+ 212 moreAssociated Documents - March 16, 2021•Document ID: 10189991Service Bulletin/Repair InstructionsEQUIPMENT; ELECTRICAL SYSTEM
- Mfr Comm. #:
- 21-BE-004H
- Date Added:
- April 6, 2021
- Manufacturer:
- HYUNDAI
SummaryWhen using Wireless CarPlay, the system may intermittently auto disconnect. When Wireless CarPlay is disconnected, a pop up message âPhone Not Responding. Please reconnect it and try againâ will appear on the radio screen.
Associated Products (13)Associated Documents - March 10, 2021•Document ID: 10189989Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; EQUIPMENT
- Mfr Comm. #:
- 21-EM-003H
- Date Added:
- April 6, 2021
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
Associated Products (260)2021 Hyundai Accent2021 Hyundai Elantra2021 Hyundai Kona2021 Hyundai Palisade2021 Hyundai Santa Fe2021 Hyundai Sonata2021 Hyundai Tucson2021 Hyundai Veloster2021 Hyundai Venue2020 Genesis G702020 Hyundai Accent2020 Hyundai Elantra2020 Hyundai Elantra GT2020 Hyundai Ioniq2020 Hyundai Kona2020 Hyundai Nexo2020 Hyundai Palisade2020 Hyundai Santa Fe2020 Hyundai Sonata2020 Hyundai Tucson+ 240 moreAssociated Documents - February 11, 2021•Document ID: 10188246Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- 21-01-009H
- Date Added:
- March 5, 2021
- Manufacturer:
- HYUNDAI
SummaryThis bulletin provides information related to an Electronic Control Module (ECM) software update which revises detection logic for DTC P2422: EVAP System Restricted Vent Valve logic.
Associated Products (1)Associated Documents