Ford Freestar Complaints

2,533 consumer complaints on file.

#10462165June 18, 2012
POWER TRAIN
I WAS DRIVING MY FORD FREESTAR ON A HIGHWAY AT 65MPH. ALL OF A SUDDEN IT LOST POWER AND MADE AN ODD NOISE. DROVE AS BEST I COULD TO AN EXIT. STOPPED AND IT WOULD NOT GO FORWARD OR BACKWARD. LUCKILY THERE WAS NO ACCIDENT AS I LOST POWER. TOWED TO LOCAL FORD DEALER. THEY REPLACED TORQUE CONVERTER, BUT SAID THEY COULD NOT GET IT IN 4TH GEAR. THE VAN HAD BEEN RUNNING FINE PREVIOUSLY.FORD COVERED COST OF CONVERTER ONLY. RECEIVED CALL THAT THE TRANSMISSION WAS SHOT AND IT MUST HAVE BEEN GOING BAD. I QUESTIONED THAT THERE WERE NOT PREVIOUS PROBLEMS AND HAVE ALWAYS HAD IT SERVICED EVERY 3000 MILES. EVEN HAD THE TRANSMISSION FLUID REPLACED LAST YEAR. PREVIOUS PROBLEMS WITH AIR CONDITIONING COMPRESSOR. THAT WAS OVER 1000 DOLLARS AND NOW THE LATEST IS OVER 1800 DOLLARS. WE GET THE VEHICLE SERVICED REGULARLY TO PREVENT EXPENSIVE REPAIRS, BUT OBVIOUSLY THIS MUST NOT BE OF ANY HELP. VERY UNHAPPY WITH TREATMENT BY SERVICE DEALER AND FORD (THEY HUNG UP ON ME). IT IS POSSIBLE THAT IT MAY HAVE COINCIDENTAL, BUT NOT THOROUGHLY CONVINCED. IT SHOULD HAVE BEEN RUNNING POORLY IF THAT WAS THE CASE. I BELIEVE THEY SHOULD HAVE SPLIT THE DIFFERENCE IN THE COST SINCE THEY DID NOT PREVIOUSLY FIND A PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461826June 15, 2012
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
I LEFT WORK, GOT 3 PARKING SPOTS AWAY, LOST STEERING, BRAKES AND GAS. ENGINE WAS STILL RUNNING. TRANSAXLE LIGHT CAME ON, SHUT OFF VAN, TRIED AGAIN AND IT DROVE MAYBE A FEW FEET AND IT WAS AS IF IT WAS IN NEUTRAL. ENGINE LIGHT, BATTERY LIGHT AND OIL LIGHT CAME ON. SHUT IT DOWN TRIED AGAIN, DROVE ABOUT 10 FEET AND IT DIED. HAD IT TOWED TO VIP WHO HAD NO ANSWERS, TOWED TO FORD WHO SAID IT THERE WAS WATER IN THE PCM. THEY DRIED IT OUT AND SAID GIVE IT A GO. GOT IT HOME DROVE IT ONE DAY AND THE NEXT(AFTER RAINING) IT WOULD NOT MOVE OUT OF DRIVEWAY. IT WOULD GO INTO GEAR BUT HITTING THE GAS WAS AGAIN LIKE IN NEUTRAL. IT WOULD MOVE MAYBE A FEW INCHES AND THEN NO LONGER. THE ENGINE LIGHT CAME BACK ON AND THE VAN BUCKED SOME. TOWED TO FORD AGAIN AND THEY SAID IT IS DEFIANTLY WATER GETTING IN THE PCM. I HAVE BEEN SEARCHING ONLINE AND I SEE MANY PEOPLE COMPLAINING ABOUT THIS ISSUE. I AM WORRIED BECAUSE THERE IS ANOTHER RECALL COMING IN A MONTH OR SO FOR THE TORQUE CONVERTER AND I HAVE 2 SMALL CHILDREN THAT RELY ON THAT VAN. I CAN'T TRADE IT IN CAUSE THEY ARE ONLY WILL TO GIVE US $1000 WHEN WE OWE 6. WE ARE WITHOUT VEHICLE AGAIN, WITH MY HUSBAND AND I HAVING JOBS AND TWO KIDS. I FEEL UNSAFE IN MY VAN, EVEN IF WE ARE TO GET IT FIXED, WE HAVE TO HOPE THE TORQUE CONVERTER DOES NOT GO WHILE WE ARE DRIVING BEFORE THE RECALL. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461866June 15, 2012
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
LAST MAY I HAD A PROBLEM WITH MY FORD FREESTAR 2005 WHEN I WAS LEAVING A HIGHWAY, I STOPPED AT A TRAFFIC LIGHT AND THEN ACCELERATED, ONLY TO HEAR THE ENGINE ACCELERATING BUT THE CAR STAYING STILL. IN MARCH 2012 I RECEIVED A LETTER FROM FORD COMPANY, WHERE I WAS INFORMED OF A SAFETY RECALL NOTICE 11S25/NHTSA RECALL 12V-006. I VISITED TWO AGENCIES TO REPORT THE PROBLEM, IN ONE THEY TOLD ME THAT THEY HAVE TO INVESTIGATE FURTHER AND DOING THAT IT WILL COST ME $100.00. IN THE SECOND, THEY TOLD ME THAT THEY DO NOT HAVE THE NECESSARY PARTS TO SATISFIED THE SAFETY RECALL. WHAT CAN I DO?, CAN YOU COULD HELP ME TO RESOLVE THIS PROBLEM? THANKS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461426June 13, 2012
POWER TRAIN
TL* THE CONTACT OWNS A 2006 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE JERKED WHILE SHIFTING GEARS. THE CONTACT ALSO STATED THAT THE VEHICLE STALLED WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT HE WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT STATED THAT SHE ALSO HAD TO HAVE THE VEHICLE TOWED ON A FEW OCCASIONS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 116,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461668June 13, 2012
POWER TRAIN, ENGINE, STEERING
1) SUDDEN UNEXPECTED LOSS OF POWER AND ALL GEARS. OCCURRED WHILE NORMALLY ACCELERATING FROM A STOP. VEHICLE TOWED TO FORD DEALER. DEALER STATED TO REPLACE ENTIRE TRANSMISSION AT COST OF $2900.00 PLUS CREDIT CARD INTEREST. 2) SUDDEN LOSS OF POWER. DEALER REPLACED PCM AT COST OF $900.00. 3) POWERING STEERING FLUID LEAK. 4) COOLANT LEAK. 5) PERSISTENT LOSS OF AIR FROM WHEEL AFTER REPLACING TIRE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461239June 11, 2012
POWER TRAIN, ELECTRICAL SYSTEM
DRIVING AND BATTERY LIGHT, ABS AND BRAKE LIGHT ALL ILLUMINATED. NO ISSUES WITH BRAKING. REPLACED PCM IN NOV 2011 FOR SIMILAR ISSUE. CAR AT DEALER FOR A WEEK SO FAR AND INDICATE NEEDS AN ALTERNATOR (MAYBE) AND PCM. MULTIPLE PCM ISSUES REPORTED ON THIS MAKE AND MODEL. TSBS, ETC. WHEN IS ACTION GOING TO BE TAKEN. DEALER INDICATES PART IS ON BACK ORDER FROM FORD. PLEASE TAKE SOME ACTION THIS IS IN ADDITION TO A TORQUE CONVERTER ISSUE ALREADY UNDER RECALL. THE PCM CONTROLS EVERYTHING AND COULD HAVE CAUSED THIS CAR TO FAIL AND HURT SOMEONE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461052June 8, 2012
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2007 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE WOULD UNEXPECTEDLY JERK FORWARD. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 90,258. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10461074June 8, 2012
SEATS, STRUCTURE:BODY
THE DRIVER SIDE WHEEL WELL IS RUSTING OUT AND THE FRONT MOUNT OF THE THIRD ROW SEAT IS DETACHING FROM THE BODY. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460909June 7, 2012
POWER TRAIN
TL* THE CONTACT OWNS 2004 FORD FREESTAR. THE CONTACT RECEIVED NHTSA CAMPAIGN ID NUMBER: 12V006000 (POWER TRAIN: AUTOMATIC TRANSMISSION: TORQUE CONVERTER). THE CONTACT STATED THAT THE RECALL EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR AND CAUSED FUMES TO RELEASE FROM THE TORQUE CONVERTER. THE CONTACT ALSO HEARD NOISES BEING RELEASING FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE FAILURE RECURRED FOR THE LAST SIX MONTHS. THE VEHICLE WAS TAKEN TO LOCAL A MECHANIC AND THE MECHANIC STATED THAT THE FUMES WERE EMITTED FROM THE TORQUE CONVERTER. THE APPROXIMATE FAILURE MILEAGE WAS 117,000 AND THE CURRENT MILEAGE WAS 127,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460646June 5, 2012
POWER TRAIN
TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 12V006000 (POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER) AND AN AUTHORIZED DEALER WAS CONTACTED. THE CONTACT WAS INFORMED THAT THE NECESSARY PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS ALSO CONTACTED AND WAS UNABLE TO PROVIDE A TIME FRAME AS TO WHEN THE PARTS WOULD BECOME AVAILABLE. THE CONTACT STATED THAT THE VEHICLE HAD BEGUN TO EXPERIENCE A FAILURE IN WHICH THE TRANSMISSION WOULD OCCASIONALLY HESITATE TO CHANGE GEARS. THE FAILURE MILEAGE WAS 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460303June 1, 2012
POWER TRAIN
05/07/12 AS THE BRAKE WAS APPLIED TO TURN A CORNER IN TRAFFIC, THE CAR JUST QUIT FORWARD MOTION! TURNED ENGINE OFF AND RESTARTED ENGINE, AND WAS THEN ABLE TO DRIVE FORWARD. 05/21/12 STARTED PARKED VAN , PUT IT IN REVERSE,APPLIED ACCELERATOR, THE ENGINE REVVED UP, BUT NO REVERSE MOTION(CAR ROLLED BACKWARDS AS WAS PARKED ON AN INCLINE), PUT IT IN DRIVE, APPLIED ACCELERATOR, AND AGAIN THE ENGINE REVVED UP, BUT NO FORWARD MOTION DRIVE(AGAIN VAN ROLLED BACKWARDS). VAN WAS TOWED TO GARAGE. ASSUMED THAT IT WAS THE TORQUE CONVERTER PROBLEM THAT A RECALL WAS ISSUED FOR 2004 AND 2005 FORD FREESTARS. DIAGNOSIS WAS INDEED A BAD TORQUE CONVERTER IN OUR 2006 FORD FREESTAR(NOT CURRENTLY RECALLED FOR THE TORQUE CONVERTER LIKE THE 2004 AND 2005 FORD FREESTARS). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460120May 31, 2012
POWER TRAIN
TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, SHE FELT THE TRANSMISSION SLIP WHILE ATTEMPTING TO ACCELERATE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THEY DID NOT HAVE THE NECESSARY PARTS TO PERFORM SERVICE ON THE VEHICLE. IN ADDITION, THE CONTACT WAS ADVISED THAT THE RECALL HAD NOT YET BEGUN AND WAS ADVISED THAT RECALL REPAIRS WOULD BEGIN IN THE NEAR FUTURE (NHTSA CAMPAIGN ID NUMBER: 12V006000 -POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459720May 26, 2012
SERVICE BRAKES
THE LEFT REAR CALIPER FROZE AND WORE OUT THE BRAKE AND ROTOR. THEN IN 2012 THE LEFT REAR CALIPER FROZE AND WORE OUT BRAKE AND ROTOR. AS WELL AS THE RIGHT REAR CALIPER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459754May 26, 2012
ENGINE, ELECTRICAL SYSTEM, STEERING
DRIVING DOWN ROAD CITY STREET (25 MPH SPEED LIMIT) ON WAY HOME. NOT RAINING OUTSIDE. TEMPERATURE WAS ABOUT 85 DEGREES. VERY HIGH HUMIDITY. AS APPROACHED INTERSECTION THE VEHICLE SUDDENLY SHUT ITSELF OFF. COMPLETE LOSS OF POWER, POWER STEERING, AND POWER BREAKING. WIFE HAD TROUBLE PULLING OVER, BUT BECAUSE WERE ONLY GOING 20 MPH AT THAT POINT, WE MANAGED TO PULL OVER AND STOP CAR. WE WERE ONLY 2 BLOCKS FROM HOME, SO WE RESTARTED ENGINE (WHICH TURNED ON WITHOUT TROUBLE) AND DROVE HOME SLOWLY (NOW WITH THE CHECK-ENGINE LIGHT ON). DANGEROUS SITUATION, AS IT IS INCREDIBLY DIFFICULT TO CONTROL THE VEHICLE WITHOUT POWER STEERING OR BRAKING. IF WE HAD TAKEN THE INTERSTATE HOME INSTEAD OF THE WAY WE WENT, WE COULD HAVE BEEN DRIVING AT 70 MPH ONTO AN OFF RAMP WHEN IT SHUT OFF. VERY DANGEROUS INDEED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459621May 25, 2012
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT WHILE ATTEMPTING TO ACCELERATE FROM A COMPLETE STOP, THE VEHICLE STALLED WITHOUT WARNING. THERE WAS AN ABNORMAL INCREASE IN ENGINE RPMS AND THE CONTACT CONTINUOUSLY PUMPED THE ACCELERATOR PEDAL. IN ADDITION, THE CONTACT COULD FEEL THE TRANSMISSION FAILING AND CAUSING THE VEHICLE TO BECOME SLUGGISH WHEN ACCELERATING. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 12V006000, (POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER). THE VEHICLE WAS TAKEN TO THE DEALER HOWEVER, THE CONTACT WAS DENIED RECALL REPAIRS BECAUSE SHE WAS ADVISED THAT THE TRANSMISSION WOULD HAD TO COMPLETELY FAIL BEFORE IT COULD BE REPAIRED UNDER THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 104,000. UPDATED 7/18/12 *CN UPDATED 07/25/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459684May 25, 2012
POWER TRAIN
TL* THE CONTACT OWNS A 2004 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 45 MPH, THE TRANSMISSION BEGAN TO JERK AND SUDDENLY THE ENGINE STALLED WITH AN ILLUMINATION OF THE ENTIRE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO COAST THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS AWAITING DIAGNOSIS. THE FAILURE RECURRED NUMEROUS TIMES AND HAD BEEN PREVIOUSLY TAKEN TO THE DEALER TEN TIMES WITHIN A TWO YEAR PERIOD. THERE WERE NUMEROUS REPAIRS MADE TO THE VEHICLE IN AN ATTEMPT TO CORRECT THE FAILURE HOWEVER, THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459042May 20, 2012
SEATS, STRUCTURE:BODY
WHILE TURNING A CORNER WE HEARD A LOUD NOISE COMING FROM THE LEFT REAR TIRE. AFTER GETTING HOME WE PULLED THE LEFT REAR TIRE OFF TO INSPECT THE BRAKES, WHICH WERE FINE. WE DID NOTICE THAT THE WHEEL WELL WAS RUSTING OUT AROUND THE THIRD ROW SEAT LATCH. THE LATCH WAS LOOSE AND UPON FURTHER INSPECTION DID NOT LOCK THE THIRD ROW SEAT INTO PLACE. WHEN CARRYING PASSENGERS IN THE BACK SEAT THE LATCH IS PUSHED OUT FAR ENOUGH THAT IT ACTUALLY RUBS ON THE REAR TIRE, WHICH COULD RESULT IN TIRE FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10458924May 18, 2012
POWER TRAIN
TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED AND WOULD NOT SHIFT INTO DRIVE OR REVERSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE TORQUE CONVERTER, THE BANNER KIT, AND VARIOUS OTHER COMPONENTS. THE TORQUE CONVERTER WAS REPLACED AT LEAST THREE TIMES. THE MANUFACTURER WAS NOTIFIED AND WOULD NOT OFFER ANY ASSISTANCE BECAUSE THE CONTACT INSTALLED AFTERMARKET PRODUCTS. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10458367May 17, 2012
POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
2004 FORD FREESTAR. CONSUMER REQUEST REIMBURSEMENT FOR VEHICLE TRANSMISSION REPAIR *TGW CONSUMER SENT ADDITIONAL CORRESPONDENCE *TGW THE CONSUMER STATED HE RECEIVED A RECALL NOTICE REGARDING A DEFECTIVE TRANSMISSION IN MARCH 2012. THREE YEARS AFTER THE TRANSMISSION FAILED. RECALL# 12V006000. *JB UPDATED 05/24/12 THE TORQUE CONVERTER WAS REPLACED. UPDATED 06/19/12 UPDATED 07/03/12.*JB UPDATED 10/04/12.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10458684May 16, 2012
POWER TRAIN
TL* THE CONTACT OWNS A 2004 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE STOPPED ACCELERATING AND WOULD NOT SHIFT GEARS. THE CHECK ENGINE WARNING LIGHT ALSO ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND THE DEALER STATED THAT THE WIRING SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE CONTACT ALSO RECEIVED THE RECALL NOTICE ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 12V006000 (POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER), BUT THE DEALER WOULD NOT REPAIR THE RECALL, STATING THAT IT WAS NOT RELATED TO THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE UNAVAILABLE. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Freestar