Ford Five Hundred Complaints (2005)

510 consumer complaints on file.

#11681667August 19, 2025
POWER TRAIN
The contact owns a 2005 Ford Five Hundred. The contact stated that while driving at various speeds, the vehicle made an abnormal knocking sound. The vehicle was taken to two independent mechanics, where the flywheel was replaced twice with used parts because the part had been discontinued. The contact stated that while her son was driving approximately 20 MPH, the vehicle stalled. The check transmission warning light, the check engine warning light, and other unknown warning lights were illuminated. The driver was able to pull over to the side of the road. The vehicle was able to restart but was undrivable. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576414March 9, 2024
ENGINE, ELECTRICAL SYSTEM
I am having problem with the reset button in my 2005 five hundred ford, the oil light stays on after oil changes, no one does not know how to reset, the reset button does not work, several mechanic told me not to worry about it , but the car can't pass the smog, it reads not ready, they told my to take a ride for about 50 miles and drive up to sixty miles per hour. . On going problem and I am running out of money, can you help, please
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11540215August 22, 2023
ENGINE, SUSPENSION
I have 2 very serious and dangerous issues. The 1st issue, the car will shut off while driving and without warning. I'll be cruzing down the highway and out of no where it shuts off. I then do not have breaks or power stearing. This last Winter my daughter was driving it and it shut off while she was on black ice. The car flew into the ditch and the snow was so deep it was compacted in the entire engine so it was impossible to restart the car. It was akso -37 below temperature. It took me almost a half hour to get to her and she almost froze to death. She sustained frost bite on her hands, toes, ears, and cheeks. She almost died. Issue 2, my daughter was driving and all of the sudden a loud noise and she couldn't steer. The rear control arm bracket that is part of the subframe busted causing the control arm to no longer be attached to the frame. She almost flipped the car when that happened. I looked into it and many cars this year make and model had the exact same thing happen in the exact same spot. So that tells me that it is a manufacturer defect. I had this looked at and inspected by Trusted Tires & Auto. Neither of these issues had any warning at all. So now the car sits unable to be driven. Even if it was fixed I won't drive it or let my daughter drive it and I can't sell it because I don't want anyone else to drive it period. It is a death trap literally and puts everyone's life in dangernear that come near the car. It needs to be recalled immediately. This is absolutely unacceptable and Ford needs to stand behind their product. If this car continues to stay on the roads Many people will die because of all the defects on the car.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11531091July 8, 2023
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
The engine keep going into limp mode. The car stalls out while at lights an stop signs, power steering goes out on highway an other roads making it impossible to steer or steer out of others ways, limp mode causes car to not be able to keep up with traffic on highway and other roads. Engine jerks forward an shifts irractically an shifts an downshifts hard.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11531095July 8, 2023
SUSPENSION, STEERING, WHEELS
While driving the front end suspension slips, bounces up and down very harshly, tires slip, squeak, and slide in an hard to control way, sometimes into oncoming traffic when in slightly damp conditions an on roads with any amount of bumps, to the point that I need to drive extremely slow to avoid danger which in turn puts my and my passengers and my kids in danger by goin to slow in regards to the traffic around us. When hitting relatively small bumps the suspension bounces the car severely up and down and across the road into harms way.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11473538July 12, 2022
POWER TRAIN
While waiting at the light in traffic, my car all of a sudden Accelerated, and decelerates, I have to push hard on the breaks in order for it to not slam into the cars infront of me.. this is really dangerous, from what I have been reading this is a wide spread issue that ford has ignored for years..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11470129June 20, 2022
VEHICLE SPEED CONTROL
while we are in idel for a period of time the car wants to surge forward without pushing on the gas. it wants to rev withough the has pedal being pushed. It does it at red lights, stop signs, and if Im in a drive through.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11429929August 20, 2021
ENGINE
The contact owns a 2005 Ford Five Hundred. The contact stated that while starting the vehicle, the "fail safe engine mode" and check engine warning lights were illuminated. The vehicle stalled with the RPM revved up. The vehicle jerked while driving at an undisclosed speed. The dealer nor the independent mechanic was not made aware of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure and referred the contact to a dealer for assistance. The failure mileage was approximately 122,832.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11396488February 16, 2021
ELECTRICAL SYSTEM, ENGINE, VEHICLE SPEED CONTROL
I WAS AT RED LIGHT PERSON CROSSING ROAD I WAS I. DRIVE FOOT ON BRAKE, RPMS SHOT UP ENGINE REEVES CAT LUNGED FORWARD I PRESSED HARDER IN BRAKE ALMOST HIT PERSON. AT THE TIME NO WARNING LIGHTS. THEN AT PHARMACY DRIVE THRU W CAR I. FROM AND I. BACK OF ME CAR DID SAME THING. I HAD TO PRESS BRAKE HARD TO PREVENT MOVING HITTING CAR IN FROM OF ME. I WAS IN DRIVE BUT FOOT ON BRAKE! NO WARNING LIGHTS AT TIME. HAD THROTTLE BODY REPLACED STILL HAD SIMILAR PROBLEMS PROGRESSING LITTLE DID I KNOW WHEN THROTTLE BODY IS REPLACED HAS TO BE REPROGRAMMED BY FORD! SPENT SO MUCH MONEY AND TIME TRYING TO FIGURE OUT PROBLEM. THIS IS A FLAW W FORD 500 2005 THROTTLE BODY MANY COMPLAINTS AND TEST DOES NEVER ISSUES RECALL, UNSAFE. I COULD HAVE KILLED SOMEONE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11366459October 26, 2020
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
I PURCHASED THE CAR USED WITH THE UNDERSTANDING THAT IT HAD SOME ISSUES WITH A MISFIRE. UPON INITIAL INSPECTION I FOUNT THE CAR WAS THROWING THE CODE P0351 I CLEARED ALL FAULTS AND PROBLEM WENT AWAY WEKS WENT BY AND PROBLEM STARTED AGAIN BUT MORE SEVER DURING NORMAL OPERATION THE CAR STARTED SHAKING AND SHIFTING ERRATIC I THEN CAME UPON SOME K FORMATION AS TO A RECALL FORD PUT IN PLACE STATING IMPROPER CALIBRATION OF PCM AND TCM CAUSE UNNECESSARY INTERACTION I THE ELECTRICAL SYSTEM AND MALFUNCTION OF THE VEHICLE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11365936October 23, 2020
POWER TRAIN, VEHICLE SPEED CONTROL
TRANSMISSION HAS VERY HARD AND DELAYED UPSHIFT AND DOWNSHIFT MAKING IT DIFFICULT TO CONTROL SPEED WHEN ACCELERATING AND DECELERATING. RPM GETS STUCK AROUND 3000 AT LOWER SPEEDS AND UPON ENGAGING INTO GEAR HAS MADE MY TIRES SQUAWK WITH A SUDDEN LUNGE IN SPEED AND SAME PROBLEM WHEN TRYING TO STOP, THE CAR LUNGES FORWARD. IT ACTS AS THOUGH IT IS IN NEUTRAL BUT THEN WHEN IT ENGAGES INTO GEAR SUDDEN CHANGES IN SPEED OCCUR CAUSING RAPID ACCELERATION OR DECELERATION. THE PROBLEM GETS WORSE AFTER THE CAR IS UP TO NORMAL OPERATING TEMPERATURE. IT DOESN'T OCCUR AS OFTEN AT COLDER OPERATING TEMPERATURE. THIS PROBLEM MAKES IT DIFFICULT TO GET BACK UP TO SAFE HIGHWAY SPEEDS AFTER HAVING TO STOP FOR TRAFFIC OR RED LIGHTS AS WELL AS HARD TO GET UP TO SPEED TO SAFELY MERGE INTO TRAFFIC FROM AN ON RAMP. AS FAR AS "WHEN" THIS HAPPENED IT IS EVERY DAY AS I DRIVE DAILY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11348696August 11, 2020
POWER TRAIN
RECEIVED A CODE STATING THAT I HAVE A FAULTY PCM. WHEN I DRIVE ALL THE LIGHTS COME ON AND THE SPEED GAUGE SHUTS DOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11322586April 28, 2020
FUEL/PROPULSION SYSTEM
WHEN I BOUGHT THE CAR HAD ENGINE LIGHT ON SO REPLACE THE SPARK PLUGS AND PUT NEW BATTERY PROBLEM STILL THERE. HAD A MECHANIC CHECK OUT AND HE SAID CODES READING FUEL PROBLEM SO CHANGE OUT THE FUEL PUMP AND PUT INJECTOR CLEANER. PROBLEM STILL THERE HE SAID MAYBE THE COMPUTER SO NOW I DON'T KNOW WHAT TO DO. THE PROBLEM IS CHECK ENGINE LIGHT ON AND WHEN YOU STEP ON THE THROTTLE DOES NOT GO PASS 3000 RPM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11322158April 24, 2020
FUEL/PROPULSION SYSTEM
THE FUEL SYSTEM IS MALFUNCTIONING. THE FUEL TANK HAS A CRACK CAUSED BY A WELDING POINT ON THE FUEL TANK WAS BROKEN LOOSE. OVER TIME I SAW MY FUEL GAUGE DROP DRAMATICALLY. THIS CAUSES ME TO GET GAS MORE OFTEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11309959February 18, 2020
ELECTRICAL SYSTEM, SUSPENSION, UNKNOWN OR OTHER
I WAS DRIVING MY CAR IT STARTED TO SHAKE VERY HARD WELL I HEARD A SNAP SOUND AND MY CAR STARTED TO DRAG I GOT OUT MY FRAME ABOVE MY RIGHT LOWER CONTROL HAD SNAPPED IVE READ THAT MANY OTHER PEOPLE ARE HAVING THE SAME PROBLEM I CONTACTES FORD ABOUT THE ISSUE AND THEY SAID THERE IS NOTHING THEY CAN DO WELL I'M OUT OF A VEHICLE BUT VEFORE ALL OF THIS I KEPT GOING THROUGH FUEL RELAY ISSUES AND EVENTUALLY STARTED LOSING MY INSTRUMENT CLUSTER SO NOW I'M FIGHTING WITH THEM TO DO THE REPAIRS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11306524February 2, 2020
FUEL/PROPULSION SYSTEM
THE CAR JERKS WHEN ACCELERATED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11244759August 18, 2019
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
(ETB) ELECTRONIC THROTTLE BODY ON MY CAR CAUSES AN ACCELERATION THAT MAKES THE CAR JERK FORWARD. I'VE ALMOST HIT A WALL, AND GOD FORBID THIS HAPPENS ON THE HIGHWAY I COULD CAUSE AN ACCIDENT. ITS UNSAFE AND SHOULD BE RECALLED. POOR DESIGN I GUESS BUT IT'S NOT WORTH MY LIFE. THIS HAPPENED WHILE IDLING IN DRIVE THRU WHEN I TRIED TO GO FORWARD IT IDLED REALLY HIGH THEN DROPPED DOWN. WOULD BOT ACCELERATE AFTERWARDS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11234627July 24, 2019
FUEL/PROPULSION SYSTEM
ELECTRONIC THROTTLE BODY A MAJOR COMPLAINT AND CAUSES THE CAR TO HAVE NO THROTTLE RESPONSE. ELDERLY MOTHER GOT STUCK ON A HILL AND COULD NOT GET CAR REST OF THE WAY UP THE HILL TO SAFETY. PAGE AFTER PAGE OF THIS COMPLAINT ON INTERNET. FORD AWARE OF THESE ISSUES AND STILL REFUSES TO LAUNCH A RECALL. PART COST $500+ FOR THE PART AND DEALER WANTS ANOTHER $300+ FOR INSTALL. ABSOLUTELY DISGUSTING TO HAVE ELDERLY OR WOMEN WITH INFANT CHILDREN STUCK ON ROADWAYS WITH THIS ISSUE. WILL NEVER BUT FORD AGAIN BASED ON MY EXPERIENCE WITH THIS ISSUE AND THEM TURNING THEIR BACK ON THIS KNOWN PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11229975July 8, 2019
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
TAKATA RECALL MY CAR HAS A FUEL LEAK PROBLEM AND FUEL TANK IS DAMAGE TO WELD DEFECT CIDE: P04442. ALSO PREVIOUS OWN INSTALLED A AFTERMARKET REMOTE CAR STARTER. NOW MY CAR HAS TROUBLE STARTING EVER AFTER I REPLACED THE STARTER. PROBLEM MIGHT BE THE (ECU) ENGINE CONTROL UNIT NOW WORKING PROPERLY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11209461May 23, 2019
UNKNOWN OR OTHER
AS WE WERE DRIVING ON THE FREEWAY OUR SUNROOF EXPLODED CRACKING ALL THE GLASS. LUCKLEY THE PROTECTOR WAS CLOSED. IT SHOWED A BUMP LIKE SHAPE WITH THE CENTER CRACKED OPEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Five Hundred