Ford F-150 Complaints (1997)

2,758 consumer complaints on file.

#11582405April 11, 2024
POWER TRAIN
The contact owns a 1997 Ford F-150. The contact stated that while driving at undisclosed speeds, the transmission hesitated while shifting gears. The contact stated that when the gear changed, the vehicle would jerk. The contact replaced the control sensor however, the failure recurred. A dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was 245,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11552635October 30, 2023
SERVICE BRAKES
on two occasions now while traversing a slight downgrade (approx 8-10mph) applied brake (per pedal) and vehicle failed to stop! (felt as though it was sliding) which it wasn't. continued to roll! after re-gaining composer and control of the vehicle (avoiding any collision) brake system returned to normal !!!!!!!!! different circumstances could have resulted in collision damage,injury perhaps loss of life!! would appreciate any feedback your engineers have to offer in the matter!! i purchased the vehicle in 1998 and currently displays 87!!! k miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11541608August 30, 2023
POWER TRAIN
The contact owns a 1997 Ford F-150. The contact stated that while attempting to park the vehicle, the vehicle failed to shift into park(P). The contact stated that when he attempted to shift the vehicle into reverse(R), the vehicle shifted instead shifted into drive(D) and vice versa. Additionally, the contact stated that he had to turn the vehicle off and turn the steering wheel towards the direction of the curb in case the vehicle rolled away, increasing the risk of a crash or an injury. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the shifter cable assembly had detached from the bracket and needed to be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The contact referenced NHTSA Campaign Number: 97V171000 (Power Train). The manufacturer was notified of the failure and the contact was informed that the VIN was not included in the recall and advised the contact to call the NHTSA Hotline. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517479April 17, 2023
SERVICE BRAKES, VEHICLE SPEED CONTROL
1997 Ford F150, had recall 25527072 05S28 performed in March of 2006. The switch installed as part of the recall has failed and brake fluid has leaked from the switched and the harness. It is not apparent that the switch is leaking until the harness connector is removed from the switch. The integrity of the brake system is compromised and the previous recall was for fires because of brake fluid in the wire harness. UPDATE 5/11/23 BRAKE SWITCH HARMESS RECALL 05S28 WAS REPLACED WITH A MITORCRAFT PART SW6350 AND CONSUMER IS REQUESTUING REFUND FOR PARTS FROM FORD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11512219March 16, 2023
FUEL/PROPULSION SYSTEM
I filled the fuel tank and let the vehicle set in my drive over night. In the morning as I was approaching the vehicle in preparation to drive to work, I smelled a strong odor of gasoline. I looked under the vehicle and saw a wet spot about 3 feet in diameter. The wet spot was gasoline. As i was investigating the leak, I noticed the front fuel tank retaining band rusted in two and fuel tank hanging low. Further investigation revealed there was a leak from the fuel pump access seal and hose connecting the filler neck to the tank. I had just driven the vehicle 130 miles the day before filling the fuel tank. If it hadn't been for the leaking fuel, I would have not have discovered that the tank was only secured by one badly rusted retaining band and would have continued to operate the vehicle normally and probably ultimately the second band would have broken allowing the fuel tank to fall from the vehicle. Ford informed there was a recall and the vehicle had been repaired in 2011. I purchased the vehicle in Jan. 30, 2012 and drive it daily.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11467315June 3, 2022
ELECTRICAL SYSTEM
The contact owned a 1997 Ford F-150. The contact stated that while the vehicle was parked at the residence, the contact noticed smoke coming from the driver's side from the bottom of the front tire. The vehicle then caught on fire. The fire department came to extinguish the fire. A fire report was filed. The cause of the fire was an electrical engine component. There were no injuries and no medical attention needed. The vehicle remained at the residence and was not repaired. The vehicle was deemed a total loss. The manufacturer was notified of the failure. The approximate failure mileage was 200,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11435115October 1, 2021
STRUCTURE:BODY
The contact owns a 1997 Ford F-150. The contact stated that the rear passenger’s side subframe near the axle of the vehicle was severely corroded. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 134,788.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11389085January 20, 2021
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
MY INTERIOR AND BACK EXTERIOR LIGHTS COME ON AND GO OFF RANDOMLY SOMETIMES WHILE DRIVING ON THE ROADS. THE LIGHT IN THE BACK ABOVE THE TRUCK BED IS BOTHERSOME BECAUSE IT COULD CAUSE ATTENTION OF ANOTHER DRIVER CAUSING A ACCIDENT. MY MOTHER ALSO HAS A FORD F150 THAT DOES THE SAME, HOWEVER HER TRUCK ISN'T THE SAME YEAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387331January 9, 2021
STRUCTURE:BODY, ELECTRICAL SYSTEM, ENGINE
DECEMBER 3, 2020...MY HUSBAND DROVE THE TRUCK OVER TO A FRIENDS HOUSE. AFTER BEING THERE FOR APPROXIMATELY 2 HOURS HIS FRIEND WALKED IN THE BUILDING WHERE HE WAS AND SAID, 'HEY MAN, YOUR TRUCK IS ON FIRE!' EVERYONE RUSHED OUTSIDE TO SEE THE TRUCK WAS IN FACT ON FIRE. THEY CALLED THE FIRE DEPARTMENT WHO CAME AND FINISHED EXTINGUISHING THE FIRE. IT APPEARS THE FIRE STARTED ON THE DRIVERS SIDE NEAR THE TIRE, OR BEHIND THE DASH. I DID NOT EVEN THINK TO CHECK FOR A RECALL, BUT A FRIEND TOLD ME TO CHECK BECAUSE HE WAS AWARE THERE WAS A RECALL. SURE ENOUGH, THERE IS A RECALL AND IT DESCRIBES WHAT HAPPENED TO MY TRUCK EXACTLY. NHTSA RECALL NUMBER: 05V017000 DATE: JAN 27, 2005 FORD RECALL NUMBER: 05528
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11366311October 25, 2020
SERVICE BRAKES
1. SPONTANEOUS BRAKE FAILURE. PEDAL WENT TO FLOOR. 10-20-2020 2. SPONTANEOUS SKIDDING ON WET PAVEMENT AND LOSS OF BRAKING CONTROL. 2ND INCIDENT 0N 10-23-20.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11350429August 20, 2020
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1997 FORD F-150. THE CONTACT HAD TAKEN THE VEHICLE TO AN INDEPENDENT MECHANIC TO HAVE HIS BRAKES SERVICED. WHILE THERE, HE WAS INFORMED OF NHTSA CAMPAIGN NUMBER: 00V231000 (FUEL SYSTEM, GASOLINE). THE CONTACT TOOK THE VEHICLE TO VANCOUVER FORD, INC. (6801 NE 40TH ST, VANCOUVER, WA 98661) WHERE HE WAS INFORMED BY THE MECHANIC THAT THE RECALL REQUIRED FOR HIM TO CHECK THE PVC VALVE AND THE FUEL LINE. AS PER THE MECHANIC, THERE WERE NO ISSUES WITH THE VEHICLE AND NO REPAIRS WERE PERFORMED ON THE VEHICLE. THE RECALL WAS THEN REMOVED FROM HIS VIN. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP, THE VEHICLE STALLED AND SHUTOFF WITHOUT WARNING. THE CONTACT ALSO STATED THAT WHILE AT A COMPLETE STOP WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE ACCELERATED FORWARD WITHOUT WARNING. THE CONTACT REPLACED THE PCV VALVE AND THE PCV HOSE HIMSELF HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE AND THE PREVIOUS RECALL ON HIS VEHICLE. THE MANUFACTURER INFORMED HIM THAT THERE WERE NO RECALLS ON HIS VEHICLE AND OFFERED HIM NO FURTHER ASSISTANCE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 154,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11329436June 17, 2020
STEERING
STEERING WHEEL FRAME IS CRACKED AND ALLOWS FOR LARGE MOVEMENT BEFORE THE VEHICLE MAY RESPOND. ALUMINUM APPEARS TO HAVE SEVERAL HAIRLINE CRACKS AND WARPING AROUND THE COLLAR HOLDING THE STEERING COLUMN AND YOU MAY LOOSE CONTROL WHILE TURNING OR WHEN THE ROAD SURFACE IS UNEVEN AT MID TO HIGH SPEEDS. LOST CONTROL WHILE TRAVELING ON AN S SHAPED CURVE DUE TO LACK OF STEERING AND THEN OVER-STEERING. THIS HAPPENED ON A HIGHWAY IN NIGHT CONDITIONS, NO RAIN. VIDEO FOOTAGE IS AVAILABLE VIA A DASHCAM. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11317307March 10, 2020
EXTERIOR LIGHTING
LIGHTS DO NOT WORK
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11298962January 13, 2020
STRUCTURE:BODY
MY 3RD DOOR WON'T OPEN AND IT'S A SERIOUS SAFETY ISSUE. I HAVE KIDS AND IT'S THE ONLY VEHICLE I HAVE TO TRANSPORT THEM AROUND. I WENT TO YOUTUBE AND FOUND THAT SOME CHEAP PLASTIC RETAINERS THAT'S CLIPPED TO CABLES ARE BROKEN. THE RETAINERS OPEN THE TOP AND BOTTOM OF THE DOOR. PLEASE HELP. THANKS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11298839January 12, 2020
STRUCTURE:BODY
I WENT TO OPEN MY 3RD DOOR ON THE LEFT SIDE OF MY F 150 AND IT WOULD NOT OPEN. I TRIED BOTH LATCHES ON THE OUTSIDE AND IN INNER DOOR FRAME BUT NO LUCK. I WAS PARKED AT THE TIME WHEN I WAS TRYING TO GET SOME ITEMS OUT OF MY BACK SEAT. I HAVE NOTHING TO UPLOAD AT THIS TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11297409January 6, 2020
AIR BAGS, SERVICE BRAKES, SEAT BELTS
I WAS ON MY WAY TO WORK THE MORNING BEFORE THANKSGIVING. I SHIFTED FROM 2ND TO 3RD GEAR AND THE BACK TIRES HIT A PATCH OF WATER AND I STARTED FISHTAILING. I WENT OFF THE ROAD AND HIT A PATCH OF OAK TREES. ONE HEAD ON. ON IMPACT, THE SEATBELT DID NOT RETRACT AND I HIT THE STEERING WHEEL, THE DASH BROKE APART AND THE ENTIRE STEERING COLUMN MOVED WITH ME AND I HIT THE WINDSHIELD. AFTER HITTING THE WINDSHIELD, THEN THE AIRBAG DEPLOYED. WHEN THE DASH BROKE APART FROM THE STEERING COLUMN MOVING, IT CUT MY SHIN WHICH REQUIRED STITCHES. MY KNEE HIT AROUND THE EMERGENCY BRAKE RELEASE WHICH DROVE MY FEMUR INTO MY HIP FRACTURING IT IN 3 PLACES WHICH REQUIRED 3 TITANIUM PLATES AND SCREWS. I HAD AN OPEN FRACTURE ON MY ARM WHICH WAS THE HEAD OF MY RADIUS (ELBOW) BROKEN OFF WHICH HAD TO BE REPLACED WITH MORE TITANIUM PLATES AND SCREWS. I BROKE THE ORBIT OVER MY LEFT EYE AND SINUS CAVITIES BEHIND IT. I HAD STITCHES AND STAPLES IN MY FOREHEAD THAT WILL NOW LEAVE ME A SCAR FOR LIFE. I SPENT 15 DAYS IN THE HOSPITAL, I'VE MISSED A MONTH AND A HALF FROM WORK AND DON'T KNOW WHEN I CAN GO BACK, ACCUMULATED OVER$80,000.00 IN MEDICAL BILLS, AND I'M STILL IN A WHEELCHAIR. ALL OF THESE INJURIES ARE DUE TO FAULTY SEATBELTS AND AIRBAGS IN A FORD MOTOR COMPANY'S VEHICLE. THE VEHICLE WAS BOUGHT BRAND NEW BY MY FATHER AND HAS BEEN GARAGE KEPT SINCE IT WAS BOUGHT IN 1997. I WORK AS A RECEPTIONIST AND OFFICE MANAGER FOR A DOCTOR'S OFFICE. MY FACE IS THE FIRST ONE SEEN WHEN PATIENTS COME THROUGH THE DOOR. NOW, IT'S MANGLED AND SCARRED FOR LIFE.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11130058September 18, 2018
STRUCTURE:BODY, FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1997 FORD F-150. THE CONTACT STATED THAT THE FRONT TO REAR FUEL STRAPS FRACTURED ON THE DRIVER'S SIDE WITHOUT WARNING. THE FAILURE CAUSED THE FUEL LINES AND FUEL TANK TO FRACTURE. THE CONTACT REPLACED THE FUEL STRAPS, FUEL LINES, AND FUEL TANK DUE TO THE FAILURE. THE CONTACT WAS NOT NOTIFIED OF NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE VIN WAS INCLUDED. THE DEALER (REINEKE FORD LINCOLN OF LIMA, 419-223-3673, 1360 GREELY CHAPEL RD, LIMA, OH 45804) WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE NEEDED TO BE RESTORED TO ITS ORIGINAL CONDITION TO PERFORM THE RECALL REPAIR. THE DEALER REFUSED TO REPAIR THE VEHICLE, INDICATING THAT THE CONTACT WELDED THE DRIVER'S SIDE REAR FUEL STRAP. THE RECALL REPAIR WAS NOT PERFORMED. THE MANUFACTURER ALSO INDICATED THAT THE VEHICLE NEEDED TO BE RESTORED TO ITS ORIGINAL CONDITION TO PERFORM THE RECALL REPAIR. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11103487June 22, 2018
AIR BAGS
I WAS IN A WRECK TRAVELING 25 MO MAKING A TURN TO HEAD WEST AND I COLLIDED WITH A SIMI AND MY AIR BAGS DID NOT DEPLOY AT ALL I WAS TOLD BUT EMTS THAT THE WERE SHOCK THAT THE AIR BAGS DID NOT DEPLY THEY TOLD ME THAT THEY SHOULD HAVE.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10995112June 14, 2017
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1997 FORD F-150. WHILE THE VEHICLE WAS PARKED, THERE WAS A STRONG ODOR OF FUEL COMING FROM THE VEHICLE. IN ADDITION, FUEL LEAKED FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 258,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10957781March 1, 2017
STEERING
TL* THE CONTACT OWNS A 1997 FORD F-150. THE CONTACT STATED THAT WHILE AT A STOP SIGN AND ATTEMPTED TO MAKE A RIGHT TURN, THE STEERING WHEEL BECAME HARD AND A POP SOUND EMERGED FROM THE STEERING COLUMN. THE VEHICLE WAS DRIVEN FOR APPROXIMATELY A HALF A BLOCK THEN THE STEERING WHEEL SEIZED. THE VEHICLE WAS TOWED TO THE CONTACTS RESIDENCE AND THEN THE CONTACT CALLED THE DEALER THAT ADVISED HIM THAT THE VIN WAS NOT PART OF THE RECALL. THE VEHICLE WAS REPAIRED BUT THE PARTS REPLACED WERE UNKNOWN. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 207,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150