Ford · Model Report
Showing safety data for the 2003 model year only.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN POLI-AUTO COMBINATION HEADLAMP ASSEMBLIES, P/NOS. 11-728, 11-728D, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708P, 11-735, 11-725, 11-726, 11-716 (P&C), 11-721-1, 11-733, 11-729, 11-730, AND 11-732, SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
My truck stopped working in November 2025. I was told I needed fuel pump and filter. I replaced those and still didn't crank. I was then told I needed a circuit box. Purchased a circuit box and had it put on. Got my truck back February 2026. March 08,2026, truck went out again. I kept my truck maintenance and don't understand what's going on with it. I was told it is a recall on electrical parts and engine coils and spark plugs.
No injuries · No fire · No crash
The contact owns a 2003 Ford Expedition. The contact stated that while operating the vehicle, the check engine warning light illuminated and the front end of the vehicle was shaking abnormally, vibrating, and the vehicle stalled. The contact stated that while driving approximately 50 MPH, there was a loud booming sound coming from the engine compartment and the vehicle stalled. The vehicle was towed to the local mechanic who diagnosed that the spark plug had ejected from the engine cylinder. The engine cylinder was rethreaded, and the spark plug was installed; however, the failure reoccurred. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 230,000.
No injuries · No fire · No crash
Fuel leaking from emissions vents on fuel tank. Non reparable part.
No injuries · No fire · No crash
My Ford Expedition started randomly stalling and it stalled in the highway. The engine just shut down in the middle of the highway and it was such a scary a life endangering experience. This total loss of power in the middle of the highway when vehicles are traveling at highway speeds can cause death very, very easily to the occupants of the Ford Expeditions suffering this defect. I have been reading in many forums ( I have included the link to one of many forums) this is a common defect [XXX] ) many have Ford Expedition owners have experienced and have been very concerned and shocked that there was not recall. The issue is that the R303 relay (non serviceable fuel pump relay) fails very commonly on Ford Expeditions. In my Ford Expedition, the relay was melted. The fuel pump relay fails and cuts all current going to the fuel pump causing the engine to stall. This is a life-threatening risk caused by a defective fuse box with a defective fuel pump relay (R303). There were no warnings, the Ford Expedition just stalled randomly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The brakes are burning while driving & the emergency brakes are not applied. The power windows are failing 1 by 1.