Ford · Model Report
Showing safety data for the 2000 model year only.
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
On XXX my 2000 Ford Expedition caught on fire at around 2am. It had not been driven or turned on since XXX, and was sitting parked that whole time. It was parked in the parking lot of my apartment building, right outside of my unit. I was woken up by a loud pop which I believe was the tire exploding, and the flames were tall enough to see outside my second story bedroom window. My entire apartment building was evacuated by the fire department, and some doors were kicked in by them, including mine. After they put the fire out, the fire inspector looked for two hours to determine a cause and were only able to determine that the fire started under the hood, on the drivers side, close to the dashboard area. The vehicle was completely totaled in the fire, and my other car parked next to it was damaged from the fire as well, and the apartment building had a lot of damage from the fire and heat spreading to it. Multiple residents were displaced for a few days at the advice of the fire department, to let units air out from the carcinogenic fumes. The vehicle has been towed and signed over to AutoMoto Salvage yard. I was researching what could have started this fire and found this article where the NHTSA investigated over 600 spontaneous Ford vehicle fires including year 2000 Ford Expeditions, caused by cruise control deactivation switches, which are located in the same place under the hood that the fire department determined my fire originated. [XXX] My vehicle was not listed in any recall, but that article states that over 200 vehicles that caught fire were not either. I'm unsure if the salvage yard still has it available for inspection. It has not been reproduced or confirmed by a dealer. It was inspected by the fire department and police department - insurance did not do their own inspection. There were no warning signs and the vehicle was running like normal. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
while driving smoke came from under my hood by the time i opened it was a full blown fire on the passenger side near the fuel injectors and spark plugs. we called 911 police and fire department came a nearby business owner loaned a fire extinguisher and we got the fire out. the fire men say it was caused by a spark plug that had came out caught spark with oil or gas it damaged hoses electrical and not sure what else yet.
The contact owns a 2000 Ford Expedition. The contact stated while driving 30 MPH, the contact became aware that the electronic power steering was not functioning properly, requiring increased effort to prevent oversteering. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the steering shaft. The vehicle was repaired, but the failure reoccurred because the aftermarket replacement part was too short. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 315,000.
No injuries · No fire · No crash
The contact owns a 2000 Ford Expedition. The contact stated that the vehicle would not start-up. The contact attempted to jump start the vehicle with assistance, but he was not successful. The check engine warning light was illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 300,000.
No injuries · No fire · No crash
MY 2000 FORD EXPEDITION WAS PARKED AT MY JOB PARKING LOT FOR 3HRS, WHEN IT CAUGHT FIRE UNDERNEATH THE HOOD NEAR THE MASTER CYLINDER, DRIVERS SIDE, NEAR THE FIREWALL. I CONTACTED FORD MOTOR COMPANY, BBB, AND CONSUMER AFFAIRS, WHICH ALL ATTEMPTS WERE IGNORED.