Ford Expedition Complaints (2022)

111 consumer complaints on file.

#11758376August 20, 2026
STEERING, SUSPENSION, WHEELS
1. There was front suspension failure where the lower ball joint has separated, causing the steering knuckle and wheel assembly to detach and collapse while driving- yes it is available to inspect if done tomorrow 2. Driver could not control car, passengers and other cars on road in immediate danger. Car was swerving with loss of control 3 Independent service center looked-this should have not have happened. 4 No happened yesterday was going to bring to dealer after Ind looked at it 5. No warning
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757260August 16, 2026
VISIBILITY/WIPER
I am reporting a potential safety defect involving the HVAC air vent assemblies in my 2022 Ford Expedition. I have now had TWO separate vent directional-control/deflector handles break during normal use. The plastic attachment points are extremely thin and fragile and appear inadequate for a component specifically designed to be routinely adjusted. This does not appear to be an isolated incident. Broken HVAC vent controls/deflectors have been reported MULTIPLE times by Ford owners across various online Ford forums and owner discussions. The number of similar consumer reports raises concern that this may be a recurring design or material defect rather than normal wear or accidental damage. When the control breaks, the vent can no longer be properly aimed. This creates a potential visibility issue because HVAC airflow is necessary to clear condensation and fog from the windshield and front side windows. In hot humid climate, windows can fog rapidly. Losing the ability to properly direct airflow can delay clearing the glass and reduce driver visibility. The defect also prevents proper A/C airflow from being directed toward the driver. Florida vehicles can reach extremely high interior temperatures when parked. Reduced ability to direct cold air toward the driver can contribute to excessive heat exposure, discomfort, fatigue, dehydration, and potentially heat-related illness, which may impair safe vehicle operation. Having two separate vent controls fail under normal use, combined with numerous similar reports from other Ford owners, suggests a possible systemic durability defect. I am requesting that NHTSA review complaints involving 2022 Ford Expeditions and other Ford vehicles using the same vent assemblies to determine whether an investigation or corrective action is warranted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755911August 10, 2026
POWER TRAIN
The contact owns a 2022 Ford Expedition. The contact stated that while driving 20 MPH, the transmission was sticking. The failure was a recurring failure. The dealer was contacted, and the vehicle received a software update; however, the failure persisted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754890August 5, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, LANE DEPARTURE: BLIND SPOT DETECTION, FORWARD COLLISION AVOIDANCE: WARNINGS
Unknown
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754394August 3, 2026
LANE DEPARTURE: WARNING, LANE DEPARTURE: ASSIST
The ipma module which controls the lane keep assist has stopped working permanently. The dealership has quoted the cost to replace the ipma at over $1,000. The warning light stating that the front camera module and lane keep assist are unavailable appears each time the vehicle is started up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750075July 13, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
ABS break lights and Service Advanced Trac lights flashing and beeping. Eventually Break fluid low lights came on and car would not break when driving . Leaked break fluid on driveway. Car was unable to be driven, no breaks .all happened very quickly and without any reason .i had it towed to a break mechanic and he said it was the ABS modular break line that was broken and there was no more break fluid and it had leaked out . He suggested I send it to the dealership. It sounds like the exact same issue as the recall # 25S47 on campaign 25V314 but my vin number does not fall under they but shows it is the same Kentucky plant and year so I do believe it is the same issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749999July 13, 2026
FUEL SYSTEM, GASOLINE, VISIBILITY, STRUCTURE
The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline), 26V204000 (Visibility), and 26V368000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743375June 10, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
While driving on the highway, my 2022 Ford Expedition suddenly lost acceleration. The gas pedal stopped responding completely and the vehicle gradually lost power until it shut off. It had to be towed and the battery was fully drained afterward. It was later diagnosed as a fuel pump failure. This was a sudden loss of propulsion in traffic and created a serious safety concern. Police pulled over and were able to get me towed to the nearest safe stop as my car stopped on a bridge with no shoulder.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742078June 4, 2026
SEAT BELTS, FORWARD COLLISION AVOIDANCE: WARNINGS
The collision avoidance system repeatedly faults and becomes unusable. Also, the 2nd row bench seat belt locks without warning. This posses a great risk in a crash.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734256April 28, 2026
POWER TRAIN
Transmission randomly hard down shifts erratically. It feels like i lose control of the vehicle. Shifting is so violent, it's like I were driving over a man hole with a missing cover. These are under normal operating conditions. Not towing, not hard braking. Not extreme cold or hot climate. There are no warning laps on the dash board. This issue has been reviewed at 2 different FORD dealer / repair shops. The first location changed the transmission fluid. The second one changed the transmission torque converter. Documentation can be provided. There is no computer data that indicated an issue when hooked up to the Ford mechanic computer diagnostic tool. The problem continues to happen after repair. The vehicle is still under FORD warranty. 2 Ford mechanics have test driven the vehicle after repair. They recognize the problem, and provide no remedy other than what has already been done. This vehicle feels unsafe to drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734069April 27, 2026
AIR BAGS, ELECTRICAL SYSTEM, STEERING
The contact owns a 2022 Ford Expedition. The contact stated that while the vehicle was parked, it failed to start with several unknown warning lights illuminated. The vehicle was jump-started. The dealer was contacted, but the vehicle was not repaired. The manufacturer was notified of the failure. Additionally, the contact stated that the air bag warning light continuously remained illuminated. The failure was associated with NHTSA Campaign Number: 23V847000 (Steering, Air Bags); however, the VIN was not associated with the recall. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733754April 25, 2026
SERVICE BRAKES
I am submitting a formal consumer complaint regarding a persistent brake issue—specifically a loud squeal when coming to a stop in a 2022 Ford Expedition Max Limited purchased as a Certified Pre-Owned vehicle through Ford’s Blue Advantage Program. At the time of sale, I was assured the vehicle met certification standards, had no unresolved safety concerns, and that any recalls had been addressed. However, I later learned that Safety Recall 25S47 (NHTSA Campaign 25V-314) had been issued in May 2025—one month prior to purchase—for a front brake line defect that may cause brake fluid leaks, reduced braking performance, and increased crash risk. Despite this, the vehicle was certified and sold with representation that the recall showed “no concern.” Since purchase, the vehicle has exhibited constant brake squealing, worsening stopping performance, and reduced responsiveness. The issue occurs at every stop and persists despite replacement of front and rear brake pads and rotors. Timeline: • Apr 2024 – Prior brake-related service • May 9, 2025 – Recall issued • June 4, 2025 – Brake service prior to sale • June 14, 2025 – Purchased as certified • Within 1 week – Issue reported • June 25, 2025 – Inspection found “no concern” • July 2025 – Pads/rotors replaced • Within 2–3 months – Issue returned • Ongoing – Condition deemed “within guidelines” Multiple attempts to resolve this through the dealer, a consumer complaint organization, a state regulatory complaint, and a manufacturer repair case have not resulted in a fix. This raises concern that a vehicle with a known safety-related defect was certified and sold without proper resolution. I request investigation into whether certification standards were properly followed and whether consumer protection requirements were violated. I am seeking a permanent manufacturer-backed repair, repurchase, or other appropriate relief.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733250April 23, 2026
STRUCTURE
The contact owns a 2022 Ford Expedition. The contact stated that while driving approximately 75 MPH, the sunroof windscreen flew off and landed on the highway. The vehicle was taken to a dealer, where it was determined that the sunroof windscreen needed to be replaced. The vehicle was repaired; however, the failure reoccurred approximately five months later. The contact stated that while driving approximately 75 MPH, the sunroof windscreen flew off onto the highway again. The vehicle was taken to the same dealer, where it was determined that the sunroof windscreen needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 32,065.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732792April 21, 2026
VISIBILITY
The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 26V204000 (Visibility); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729302April 5, 2026
POWER TRAIN
Harsh shifting in relation to TBS 23-2250 causing the vehicle response to be unpredictably unsafe merging or suddenly stopping or accelerating.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727497March 27, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Expedition. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while depressing the accelerator pedal, the vehicle hesitated before accelerating to the intended speed. The dealer was contacted and confirmed that the part to do the recall repair was not available. The manufacturer was not made aware of the issue. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726375March 23, 2026
FUEL/PROPULSION SYSTEM
My vehicle shutters like it’s is going to die/shit off. When will this issue be resolved with the fuel pump system failure? I will be doing some research with the BBB to find out if this will be an actionable lawsuit. Most consumers who own these types of SUVs are mothers! This needs to be resolved asap!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725500March 19, 2026
FUEL/PROPULSION SYSTEM
Ford has a recall on the low pressure fuel pump but no fix yet. My fuel pump failed and I am being charged to fix it. But that also puts me back on the road with an unsafe vehicle. They will not provide me a rental until the recall has a solution or fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725446March 19, 2026
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Receiving Front Camera Malfunction Service required warning. Also receiving pre-collision assist, adaptive cruise control and automatic emergency break system warnings. Other systems likely disabled. Found that there was a TSB issued for the same year but on the F-150. DTC's C1001:31, U3000:89, U3000:49. This issue is likely caused by faulty cable connections where condensation has caused corrosion making the system inoperable thus creating a major safety issue for owners. I took the Expedition to SawGrass Ford in Sunrise FL and they confirmed that the issue was due to the electronics/cables. The camera itself was not dirty or blocked. They charged me $250 for a diagnostic and then wanted to charge me $2500+. For the safety and security of all owners please investigate and hold FORD accountable for this.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722789March 8, 2026
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
All of the Advanced Drivers Assistance Systems are not functional. Ford is aware of problem and the fix is continuing to be delayed--over 1 year now. Vehicle has been to dealership multiple times without solution.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition