Ford C-Max Complaints

510 consumer complaints on file.

#11415510May 7, 2021
WHEELS
REAR TIRES REPEATEDLY WEARING OUT. THIS COULD CAUSE A BLOWOUT CAUSING HARM TO MYSELF AND OTHERS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11413334April 22, 2021
FUEL/PROPULSION SYSTEM
GAS LINE LEAK UNDER CAR LEADING FROM TANK TO ENGINE. REQUIRES REMOVAL OF EXHAUST SYSTEM AND TANK TO REPLACE NEW LINE. COULD HAVE CAUSED FIRE W/ FUEL LEAKING ON TO EXHAUST SYSTEM (HAVE HAD TWO PREVIOUS FIRES IN DIFFERENT VEHICLES CAUSED BY FUEL LEAKING ONTO HOT EXHAUST SYSTEM). NO APPARENT PHYSICAL CAUSE FOR LEAK - DOES NOT SEEM TO BE COMPONENT ONE WOULD EXPECT TO LEAK OR NEED REPAIR REGARDLESS OF AGE OR MILEAGE. POTENTIAL TO CAUSE SERIOUS PERSONAL AND PHYSICAL DAMAGE IF I HAD NOT SMELLED AND NOTICED LEAK. SEEMS TO ME THAT MANUFACTURER OR SUPPLIER OF APPARENT DEFECTIVE LINE WOULD BE RESPONSIBLE FOR REPLACEMENT REPAIR. LEAK COULD RESULT IN UNANTICIPATED CATASTROPHIC EVENT. VEHICLE HAD BEEN RECENTLY DRIVEN AND PARKED WHEN GAS SMELL WAS NOTCED AND MOVED ENOUGH TO SEE FUEL PUDDLE ON DRIVEWAY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11413387April 22, 2021
ELECTRICAL SYSTEM
VEHICLE FINISHED CHARGING, AND THEN WAS UNPLUGGED. VEHICLE'S WARNING SYSTEM SAYS VEHICLE WAS STILL PLUGGED IN AND AND WOULDN'T MOVE. VEHICLE WAS TOWED INTO DEALERSHIP AND DIAGNOSED CHARGING PORT NEEDED TO BE REPLACED. CHARGING PORT IS UNATTAINABLE AND VEHICLE SITS AT DEALERSHIP WITH NO LIGHT AT THE END OF THE TUNNEL. CHARGING PORT UNATTAINABLE, TELLS ME FORD HAS A SERIOUS PROBLEM WITH THIS ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11412756April 18, 2021
STRUCTURE:BODY
THE AUTOMATIC LIFTGATE WILL UNLOCK AND OPEN WHEN THE BUTTON IS NOT PRESSED AND WHEN NO ONE IS OUTSIDE THE BACK OF THE CAR. THE LIFTGATE WILL NOT FULLY CLOSE SOME OF THE TIME. WHEN THE LIFTGATE CLOSES, IT DOES NOT LOCK PROPERLY AND I CAN HEAR THE LATCH TRYING OVER AND OVER AGAIN. I HAVE VIDEO OF THESE SITUATIONS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11407258April 9, 2021
ENGINE
THE CRANK SHAFT POSITION SENSOR HAS FAILED FIVE TIMES AND REQUIRED REPLACEMENT. ON TWO OCCASIONS WHEN THIS SENSOR FAILED IT RESULTED IN TOTAL LOSS OF POWER WHILE THE CAR WAS ON THE ROAD AND IN TRAFFIC. THIS COULD HAVE RESULTED IN CRASHES AND INJURY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11406320April 4, 2021
SERVICE BRAKES, VEHICLE SPEED CONTROL, STEERING
TURNED THE CAR ON IN A PARKING LOT AND SAW THE CHECK ENGINE LIGHT WAS ON. HAD TOTALLY LOST POWER STEERING AND ACCELERATION, AND BRAKING WAS EXTREMELY DIFFICULT. ROLLED DOWN THE PARKING LOT AND WAS ABLE TO STOP THE CAR WITH THE PARKING BRAKE AND TURN IT OFF. TURNED IT BACK ON AND THE POWER STEERING AND BRAKES AND ACCELERATOR WERE BACK. DROVE THE CAR HOME AND TRIED TURNING IT ON AND OFF A FEW MORE TIMES. POWER STEERING SEEMS TO BE COMPLETELY GONE. CHECK ENGINE LIGHT IS ON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11405595March 30, 2021
POWER TRAIN
TL* THE CONTACT OWNS A 2013 FORD C-MAX ENERGI. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40-50 MPH, THERE WAS AN ABNORMALLY LOUD SOUND COMING FROM UNDER THE HOOD OF THE VEHICLE. THE CONTACT STATED THAT THERE WAS NO WARNING LIGHT BEFORE OR AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER TO BE DIAGNOSED. THE MECHANIC STATED THAT THE TRANSMISSION BEARING FAILED, WHICH CAUSED THE TRANSMISSION FLUID TO LEAK FROM THE VEHICLE. THE CONTACT PERFORMED HIS OWN INSPECTION AND NOTICED THE BEARING HAD CREATED A HOLE IN THE TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11404102March 21, 2021
POWER TRAIN
THERE IS A GRINDING OR RUBBING SOUND EMANATING FROM THE TRANSMISSION WHILE DRIVING, AT ANY SPEED (GENERALLY NOT WHILE STATIONARY BUT SOMETIMES), AND THE CHECK ENGINE LIGHT TURNS ON. THE LOCAL FORD DEALERSHIP (METRO MOTORS, ST. CROIX, U.S. VIRGIN ISLANDS) FOUND "TRANSMISSION VARIATOR TO DRIVE CHAIN LOOSE CAUSING NOISE" AND "[N]O INTERNAL SERVICEABLE COMPONENTS" AND RECOMMENDED "[R]EPLACEMENT OF HYBRID CVT TRANSMISSION." THE DEALERSHIP SPECIFICALLY RECOMMENDS REPLACEMENT OF THE TRANSMISSION PART, JM5Z-7000-ARM, WHICH IS THE SAME PART INDICATED IN THE TECHNICAL SERVICE BULLETIN 20-2219, PUBLISHED ON JUNE 29, 2020, ON THIS SAME ISSUE OF GRINDING/RUBBING NOISE EMANATING FROM TRANSMISSIONS IN 2014 FORD C-MAX (AMONG OTHER VEHICLES). THE TSB FURTHER PROVIDES THE PART IS "ELIGIBLE UNDER PROVISIONS OF NEW VEHICLE LIMITED WARRANTY," HOWEVER, THE LOCAL DEALERSHIP HAS STATED FORD MOTOR COMPANY DENIED THE CLAIM, AND THE FORD MOTOR COMPANY HAS SAID IT AGREES WITH THE DEALERSHIP THAT THE CLAIM SHOULD BE DENIED. HOWEVER, THE VEHICLE (MILEAGE: 86,225 MILES; YEARS: NOT YET 7) IS UNDER AN ACTIVE NEW VEHICLE LIMITED WARRANTY AS THE TERMS HAVE NOT EXPIRED. THE LOCAL DEALERSHIP IS WILLING TO REPLACE THE DEFECTIVE PART, HOWEVER, IT SAYS IT NEEDS WRITTEN CONFIRMATION FROM FORD MOTOR COMPANY, WHICH FORD MOTOR COMPANY HAS NOT PROVIDED, DESPITE TWO LETTERS OF NOTICE OF DEFECTIVE PART AND MULTIPLE PHONE CALLS WITH THE CUSTOMER RELATIONSHIP CENTER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11402854March 14, 2021
UNKNOWN OR OTHER
THE CAR WAS IN REVERSE. MY INTENTION WAS CLEARLY TO BACK OUT OF A PARKING STALL. HOWEVER I HIT THE BRAKE, PUT THE CAR IN PARK, ATTEMPTED TO GET OUT OF THE VEHICLE BUT THE CAR KEPT GOING BACK, AT AN ACCELERATED RATE. IT WAS AS IF IT WAS GOING FULL SPEED, IN REVERSE. I COULDN'T STOP IT IN TIME BEFORE HITTING A SIDEWALK AND STAIR CASE BEHIND ME; AS WELL AS SIDE SWIPING A PARKED CAR IN THE STALL TO THE LEFT OF ME. MY DRIVER DOOR WAS DESTROYED BECAUSE IT WAS OPENED. THE AIRBAGS DID NOT DEPLOY.*DT
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11397307February 22, 2021
STEERING
POWER STEERING FAILS WITHOUT WARNING MAKING IT MORE DIFFICULT TO STEER THAN MANUAL STEERING. TURNING CAR OFF RESETS ELECTRONIC CONTROL MODULE BUT THAT IS NO GUARANTEE THAT THE POWER STEERING WON'T FAIL AGAIN WHILE ON THE HIGHWAY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11389184January 21, 2021
POWER TRAIN
FAILED TRANSMISSION BEARING AS DESCRIBED BY TSB 14B07. DIAGNOSED BY FORD, DOCUMENT ATTACHED CONFIRMING THE FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387894January 13, 2021
ELECTRICAL SYSTEM, POWER TRAIN
I BOUGHT THIS 2013 FORD C-MAX ENERGI USED IN 2017, RIGHT OFF THE BAT AFTER CHECKING OUT VEHICLE, THE TOYOTA DEALERSHIP HAD TO JUMPSTART THE CAR. NOW, THE CURRENT ISSUE IS THAT THIS VEHICLE HAS TO BE JUMP-STARTED EVERY TIME I TRY TO START THE CAR. THIS HAS BEEN OCCURING SINCE NOVEMBER 2020. THESE ISSUES HAD OCCURED SPORADICALLY, EVEN AFTER REPLACING THE BATTERY IN 2018 WITH OTHER BRAND BATTERY, THOUGH NOT AS FREQUENTLY, AND EVERY DAY AS IT DOES NOW. SOMETIMES THE VEHICLE WOULD NOT START AFTER SIRIUS SOFTWARE UPDATE GOT STUCK AT 0%, THIS OCCURED A FEW TIMES IN 2018. IN LATE 2018 I BOUGHT A PORTABLE JUMP STARTER BECAUSE THIS VEHICLE BECAME UNTRUSTWORTHY TO START. THOUGH, IF I HAD KNOWN ABOUT SERVICE BULLETINS AND NOT JUST RECALLS I WOULD HAVE TAKEN THE CAR IN TO HAVE IT REPAIRED EARLIER WHEN ISSUES PRESENTED THEMSELVES. SO I FINALLY TOOK IN MY C-MAX IN TO A LOCAL HYBRID REPAIR SHOP, BUT THE TECHNICIANS WERE NOT ABLE TO REPLACE THE SPECIFIC PART, THEY REFERRED ME TO THE DEALERSHIP TO REPLACE IT. THEY PRINTED OUT MATERIALS THAT STATED THERE HAD BEEN A FEW TECHNICAL SERVICE BULLETINS FOR DISCHARGED BATTERIES. I UNFORTUNATELY MISSED THE REPAIR WINDOW BY 6 MONTHS AND WILL INCUR THE COSTS. MY CAR AS OF 1/13/2021 HAS BEEN IN THE SHOP FOR TWO WEEKS NOW AT DEALERSHIP WAITING FOR PARTS. THE MANUFACTURER DEFECT WILL COST ME AROUND $1,100. IT SEEMS THERE HAS BEEN MANY BATTERY DISCHARGE BULLETINS FOR THIS MODEL THROUGHOUT THE YEARS FOR THIS YEAR, MAKE AND MODEL. THE FORD DEALERSHIP AT MANAHAWKIN, NJ EVEN STATED THIS VEHICLE IS NOT AS COMMON, SO PARTS WERE NOT AVAILABLE IMMEDIATELY. I FEEL FORD SHOULD ISSUE A RECALL TO BE REIMBURSED FOR THE TROUBLE THIS CAR HAS CAUSED. THESE ISSUES SHOULD HAVE BEEN FIXED BY FIRST OWNER OF VEHICLE. THERE ARE SEVERAL REPORTED ISSUES ON CARCOMPLAINTS.COM FOR THIS ISSUE. THIS SHOULD BE INVESTIGATED IF RECALL CAN BE MADE ON THIS YEAR AND MODEL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387933January 13, 2021
ELECTRICAL SYSTEM, ENGINE
CAR WILL STALL AND BRAKES AND STEERING LOCK UP. THIS HAS OCCURRED IN WHEN PULLING INTO TRAFFIC. IT ALWAYS OCCURS WHEN ON A HILL. VERY DANGEROUS BUT FORD DENIES ANY PROBLEMS. IT HAS OCCURRED SINCE 2014. LAST TIME WAS AS BELOW
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387934January 13, 2021
EXTERIOR LIGHTING
THE TAIL LIGHTS HAVE TO BE MANUALLY TURNED ON WHEN LOW BEAM HEADLIGHTS ARE ON. THE LOW BEAM HEADLIGHTS ARE ON AUTOMATICALLY AT ALL TIMES. WHAT THIS MEANS IS IF I PARK THE CAR DURING DAYLIGHT HOURS AND COME BACK WHEN DARK I OFTEN DRIVE WITHOUT TAILLIGHTS. PEOPLE HAVE YELLED AT ME AND HONKED AT ME TO TURN ON MY TAILLIGHTS WHEN DARK BECUASE THERE ARE NONE! THIS OCCURS BECAUSE I GET IN THE CAR AND START THE ENGINE AND THE LOW BEAM FRONT LIGHTS COME ON AUTOMATICALLY. THE TAIL LIGHTS HAVE TO BE TURNED ON. BUT, AS THE CMAX DOES NOT ACT TO THE STANDARD METHOD OF HEADLIGHTS MUST BE TURNED ON TO SEE IN DARK, THE TAILLIGHTS ARE FORGOTTEN. I AM NOT THE ONLY DRIVER OR MAKE OF CAR WITH THIS PROBLEM. WE HAVE TRAINED OURSELVES TO TURN ON TAILLIGHTS IN MY FAMILY BUT STILL OCCURS OCCASIONALLY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11386803January 6, 2021
POWER TRAIN
TRANSMISSION BEARING FAILURE, AS SPECIFIED BY RECALL TSB 14B07. LEFT STRANDED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11386428January 4, 2021
UNKNOWN OR OTHER
THE HATCHBACK DOOR WILL NOT CLOSE PROPERLY. IT WAS CLOSE, BUT THEN NOT LATCH. AT TIME, IT SEEMS IT HAS CLOSED AND LATCHED, AND THEN AT ODD TIMES, THE LATCH MAY NOT HOLD AND WILL OPEN THE HATCHBACK. THIS HAS HAPPENED REPEATEDLY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11385461December 29, 2020
STEERING
WHILE STOPPED FOR GAS IDIOT LIGHT FOR POWER STEERING FAILURE CAME ON. COULDN'T STEER CAR. TOOK TO FORD DEALER AND THEY SAID POWER ASSIST WAS BROKEN AND NEED TO BE REPLACED, AND THIS WOULD COST $2800. THIS HAS BEEN RECALLED PREVIOUSLY ON FORD TAURUS AND FUSION, BUT WAS NOT EXTENDED TO C-MAX. IT SHOULD HAVE BEEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11383829December 16, 2020
UNKNOWN OR OTHER
I HAVE RECEIVED 3 SAFETY RECALL NOTICES REGARDING THE DOOR LATCHES, ONE IN JANUARY 2017 (RECALL NOTICE 16S30), ONE IN AUGUST 2020 (NOTICE 20S30), AND NOW AGAIN IN DECEMBER 2020 (NOTICE 20S30). I HAVE RESPONDED TWICE AND SUPPOSEDLY THE LATCHES WERE FIXED OR REPLACED BY THE DEALER. NOW THAT I HAVE RECEIVED THE THIRD NOTICE OF REQUIRED DEALER INSPECTION, I AM VERY WORRIED THAT THE PREVIOUS REPAIR HAD NOT BEEN DONE , OR HAD BEEN DONE INCORRECTLY. FORD WILL NOT RESPOND, OTHER THAN STATING I MUST BRING THE CAR TO THE DEALER. THIS IS VERY CONCERNING FROM A SAFETY POINT OF VIEW AND IS TIME CONSUMING AND EXPENSIVE WHEN MISSING TIME FROM WORK. THEY PROVIDE A WEBSITE TO CHECK THE LATCH NUMBERS ON EACH DOOR, HOWEVER, AFTER ENTERING THE NUMBERS, THE WEBSITE STATES THAT THE VEHICLE MUST BE INSPECTED BY THE DEALER. THE REPRESENTATIVE ON THE PHONE SAID TO REFER TO THE WEBSITE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11383202December 13, 2020
AIR BAGS, UNKNOWN OR OTHER
DRIVERS SIDE AIRBAG COVER UNDER STEERING COLUMN IS NOT ATTACHED
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11377393December 1, 2020
ELECTRICAL SYSTEM
SEVERAL TIMES NOW THE VEHICLE HAS COMPLETELY SHUT OFF WHILE DRIVING. AT FIRST, IT WAS DRIVING UPHILL ON THE FREEWAY AND WHEN IT HIT A SMALL BUMP IT WOULD SHUT OFF. I FIGURED IT WAS JUST AT HIGH SPEEDS THAT THIS OCCURRED. RECENTLY, IT WAS JUST DRIVING UP A DRIVEWAY INCLINE AT 5 MPH, AND GOING OVER A SMALL SPEED BUMP TRIGGERED IT TO SHUT OFF. I HAVE TAKEN THE VEHICLE IN TO HAVE SERVICE FIX IT AND THEY CAN'T DUPLICATE THE ISSUE. IT IS VERY DANGEROUS TO BE DRIVING 65MPH ON THE FREEWAY AND THE CAR JUST SHUTS OFF. IT DOES NOT GO INTO A SAFE MODE, JUST COMPLETELY SHUTS DOWN. IN ORDER TO CONTINUE DRIVING, YOU MUST PRESS THE PUSH-BUTTON START AND LET THE CAR SIT FOR A FEW MINUTES. AFTER YOU WAIT, PUSH THE BUTTON AGAIN AND IT WILL ALLOW YOU TO CONTINUE DRIVING AS NORMAL. I BELIEVE IT IS A WIRING ISSUE BUT MULTIPLE SERVICE LOCATIONS HAVE NOT BEEN ABLE TO LOCATE IT. I HAVE PAID HUNDREDS IN LABOR ATTEMPTING TO FIX IT. VERY DANGEROUS!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford C-Max