Ford Bronco Sport Complaints (2024)

103 consumer complaints on file.

#11759822August 26, 2026
POWER TRAIN, ENGINE
Unresolved/unrepairable safety recall Engine RPM's revving abnormally high without corresponding acceleration; extremely slow and delayed acceleration. Sudden and unexpected jolts or surge of power following periods of inadequate acceleration. Significant difficulty safely accelerating and merging onto a freeway. Loss or lack of expected power when accelerating. Rattling and vibrating at the front of the vehicle when it is hot outside or car is hot. Inaccurate fuel gauge at times when hot All concerns above have been discussed and worked on by Walnut Creek Ford Service Center, California. I was told that the recall remedy is not ready, to drive the car in Sport Mode and that they lowered power in the fuel area. The safety recall concerns me due to the risk of fire and the lack of acceleration is definitely a hazard on the road. There were no warning lights, only the feel of the loss of acceleration. Copies of all documents and service records have been sent for a formal complaint to the NHTSA. They will not be uploaded to this complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759471August 25, 2026
POWER TRAIN
I am experiencing severe drivetrain binding and violent shuddering/chatter from the Rear Drive Unit (RDU) during low-speed turns in both directions. The vehicle hesitates and can stop violently on its own while turning. When the vehicle is parked and shut off, it also violently jerks backward, indicating the RDU is binding and storing mechanical tension. This is a significant safety hazard. The symptoms match the current Ford Technical Service Bulletin TSB 26-2328 (Chatter/Shudder During Low Speed Turning Events), which supersedes earlier bulletins including 26-2194 and 25-2351. I first reported the RDU issue along with a rear brake noise at the dealership and provided the relevant TSB numbers. The dealership stated the RDU was fine, performed only the brake TSB, and attributed the shudder to the brakes. After the vehicle was released, the RDU symptoms returned approximately 100 times worse within two days. On the return visit the dealership said they could not reproduce the concern and initially documented it as “just a noise.” I have repeatedly asked Ford (case management and Business Operations) whether the vehicle is considered safe to drive or sell in its current condition. I have not received a clear written answer. The original dealership has also refused to give a direct safety answer. I am requesting that this safety-related RDU condition be properly investigated and repaired.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757676August 18, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
I purchased a new 2024 Ford Bronco Sport on XXX from Sayville Ford in [XXX]. They failed to disclose an unremedied safety recall (24V-267) on the vehicle that was issued on XXX and still sold me the vehicle. When I went back to them after seeing that there was a recall on the car, they denied the existence of the recall despite me showing them the recall notice on both the NHTSA and Ford websites. Last year there was another safety recall for leaking fuel injectors (25V-467) that I brought my car in for service, and they claimed to have done a software fix. Upon checking the recall checked on the NHTSA website (6 months after service) it lists that the safety recall work was never performed, despite the dealership keeping my car for the entire day and telling me the work was performed. This dealership has been evasive and deceptive when I have confronted them about these issues and should be examined and fined for their practices. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756679August 13, 2026
STRUCTURE:BODY:HOOD
The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the hood independently unlatched and flew open. The front windshield was cracked, and other damage to the vehicle was sustained. The vehicle was taken to the dealer; however, the failure was not duplicated. The contact stated that the failure was a known failure with similar vehicles. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that an inspector had inspected the vehicle. The contact was informed that the failure was not a manufacturer defect and the case was denied. The failure mileage was approximately 31,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756497August 12, 2026
UNKNOWN OR OTHER
I am reporting ongoing infotainment and electrical failures in two 2024 Ford Bronco Sport vehicles (same trim), unresolved after two years of ownership on both. Apple CarPlay/Android Auto frequently freezes, disconnects, or becomes unresponsive while driving, forcing the driver to interact with the screen to restore functionality — a distraction hazard that can cause loss of navigation or hands-free operation while driving, increasing collision risk. Recovery often requires powering the vehicle off for several minutes. The center display screen also becomes hot to the touch during normal use, and the wireless charging pad overheats connected phones after 10–30 minutes, suggesting a hardware thermal design defect, not a software/app compatibility issue. Both vehicles have been to the dealership multiple times; only brief diagnostic scans were performed, with no reproduction of the overheating and no repair. Staff repeatedly claim they are "waiting on an iOS update," which does not explain hardware symptoms like screen heat or the multi-minute power-cycle required. Ford's 2025–2026 Bronco Sport received major hardware/software upgrades (larger screens, updated SYNC, standard wireless CarPlay), consistent with a redesign — leaving 2024-and-earlier owners stuck with hardware Ford has since replaced, with no recall or retrofit offered. Separately, Ford's July 2025 recall (25S76) for cracked fuel injectors/underhood fire risk on 2021–2024 Bronco Sport has only received an interim software alert update; the permanent hardware fix remains incomplete. This pattern of infotainment instability, overheating, and an unresolved fire-risk recall reflects unaddressed hardware/design defects warranting investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755937August 10, 2026
FUEL/PROPULSION SYSTEM
On August 10, 2026, I conducted a recall search on NHTSA website for my 2024 Bronco Sport Big Bend edition. The search showed the following recall : JUL 16, 2025 Manufacturer Recall Number 25S76 NHTSA Recall Number 25V467 Recall Status Recall Incomplete, remedy not yet available Summary ON YOUR VEHICLE THERE IS A POSSIBILITY THAT A FUEL INJECTOR MAY CRACK, WHICH MAY RESULT IN FUEL ACCUMULATING ON THE TOP OF THE ENGINE. Safety Risk LIQUID FUEL AND OR FUEL VAPOR THAT ACCUMULATES NEAR A HOT SURFACE, SUCH AS HOT ENGINE OR EXHAUST COMPONENTS MAY IGNITE RESULTING IN AN UNDER-HOOD FIRE, INCREASING THE RISK OF INJURY. Remedy PARTS ARE NOT CURRENTLY AVAILABLE. FORD MOTOR COMPANY IS WORKING TO PROVIDE PARTS FOR THIS REPAIR. WHEN THE REMEDY BECOMES AVAILABLE, FORD MOTOR COMPANY WILL NOTIFY YOU VIA MAIL TO SCHEDULE A SERVICE APPOINTMENT WITH YOUR DEALER FOR REPAIRS TO BE COMPLETED FREE OF CHARGE. Ford Motor Company has had more than a year to identify and implement a solution to address the above-mentioned recall. As a Ford consumer, I believe this issue should have been treated as a higher priority, particularly given the amount of time that has passed since the original recall was issued. I understand that developing a safe and effective solution can take time; however, waiting more than a year without a resolution is unacceptable. As a consumer, I expect Ford Motor Company to take this matter seriously and provide a timely solution to affected customers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755195August 6, 2026
UNKNOWN OR OTHER
My car began experiencing overheating and kept disabling 4WD while I was driving, smoke began to come out of the front hood and tailpipe. Took to repair shop and they stated my transfer case and harness was burned completely with unknown reason why this could occur. I see there is a recall for other bronco models for the same exact issue
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11754968August 5, 2026
SERVICE BRAKES
The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed and making a right turn, there was an abnormal sound coming from the rear of the vehicle. The vehicle remained at the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754430August 3, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving approximately 30-60 MPH, the accelerator pedal was depressed; however, the vehicle shuddered and stalled. No warning lights were illuminated. The vehicle was taken to a dealer to be diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 15,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753552July 29, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and referred the contact to the dealer for assistance. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753141July 27, 2026
ELECTRICAL SYSTEM
The contact owned a 2024 Ford Bronco Sport. The contact stated that while driving into the driveway and coming to a complete stop, the contact became aware of steam coming from underneath the hood and believed that the engine was overheating. No warning light was illuminated on the instrument panel prior to the vehicle catching on fire. The contact and his wife were inside the vehicle were in the vehicle during the failure. The driver and the passenger exited the vehicle safely. There was grey and white odorless smoke coming from the vehicle. The contact stated that the fire originated in the engine compartment. There was significant concrete damage to the driveway and a tree by the residence. The fire was extinguished by the local Fire Department. A fire report was filed but was unavailable. No police report was filed. The vehicle was destroyed. No injuries were sustained. The leasing company of the vehicle was notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 15,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11752776July 25, 2026
VISIBILITY/WIPER
The wiper will be on and if I turn it on high it will just be low or medium
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752770July 25, 2026
ENGINE, FUEL/PROPULSION SYSTEM
Vehicle has had a fire recall for over one year with no remedy or fix available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752499July 23, 2026
POWER TRAIN
The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. Additionally, the transmission was lagging. No warning lights were illuminated. The vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The failure was a persistent failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 19,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749844July 12, 2026
UNKNOWN OR OTHER, ENGINE
This is not a complaint against the dealership, but against the individual that was in charge of compliance. I am an attorney in Maine and it started with the fact that under main law, a dealer has to give two keys and if they don’t have it for free calibrated, and I got one key in the master key was not given, and there was issues with that and the compliance guy and finance a warranty guy whose name I forget, but they know who he is cause I’ve talked to them. He told me he had never heard of it and I showed him the statute and I just didn’t argue but then February 7 six days after the recall for the 25V685000 engine block heater, recall compliance date was over with the first visit that occurred of cooling overheating because of that and I know about the recall from researching it, but this compliance finance warranty guy search his computer, so he looked like even though it’s the second one that pops up on my vin and lied to my face saying that there’s no recall about coolant systems and heater blocks, and not liking to be pissed on and until it’s raining I just said OK so it’s another problem occurs and there is a recall. You do understand that I like the family that owns this place. I’m going to come after you because if there’s any engine damage or whatever you have. To comply with recalls, and I didn’t let him know I knew about it.. well 30 days after suspension of my license when my boat battery goes down, I will clean the boat both cars sitting in the parking lot to start driving it and I turned on the coolant overheating again and as the heater block does cause a crack I fixed crack please do not come down with the dealership. It’s only a good family. Please ask for the Man office straight out the door with gray hair. That’s the one that I’m don’t know what I’m talking about. I don’t know if he has any license or anything, but he should be fined if anybody. Because there are two incidences because it was their opportunity to cure under law 7 of Feb 1st
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748577July 6, 2026
SEATS, FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Front seats Cause back and hip pain and fatigue on trips over 30 mins- head rest don’t adjust to help compensate putting in awkward positioning. The automatic braking or whatever signifies your close to objects in the front has randomly breaked hard with nothing near me almost resulting in being rear rear ended.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745204June 19, 2026
SEAT BELTS, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Passenger seatbelt doesn’t loosen up driven normal. Adaptive cruise control doesn’t work, never has. I didn’t know about it until Monday I am taking it to a ford dealership today at Ken Garff Ford. .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745103June 18, 2026
ENGINE, FUEL/PROPULSION SYSTEM
How long does Ford have to fix a recall for fuel injection that could cause a fire? I was notified 11 months ago and there still is no word of a correction to the issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744032June 14, 2026
ELECTRICAL SYSTEM
I am reporting ongoing electrical and infotainment system failures in my 2024 Ford Bronco Sport that present a potential safety risk to the driver and others on the road. The vehicle’s infotainment system, specifically Apple CarPlay and Android Auto, does not operate reliably. Connections frequently fail, freeze, disconnect, or become unresponsive during normal driving. When this occurs, navigation, hands‑free communication, and other driver‑assistance functions become unavailable or require repeated attempts to reconnect. This malfunction creates a driver distraction hazard, as the driver is compelled to look at and interact with the center display while the vehicle is in motion in an attempt to restore CarPlay functionality. Loss of navigation guidance or hands‑free operation while driving may increase the risk of a collision. In addition, the wireless charging pad causes excessive heat buildup. After approximately 10–30 minutes of continuous contact, mobile devices become abnormally hot, and the infotainment display screen itself also becomes noticeably hot to the touch. This suggests a potential thermal management or hardware design defect. Overheating electronics raise concerns about equipment damage, device shutdown, or further system instability while driving. The vehicle has been taken to a Ford dealership multiple times for these issues. The dealership performed only brief diagnostic scans and did not attempt to reproduce the overheating condition under real‑world operating time. No repairs or corrective actions were performed, and the issues remain unresolved. Based on repeated failures, overheating, and lack of corrective action, I believe this may be a design or hardware specification issue affecting the infotainment and charging systems, rather than an isolated incident. The combination of infotainment instability, overheating, and driver distraction presents a potential safety concern that warrants investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743378June 11, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
I was driving my 2024 Bronco Sport, my car started stalling, power was being lost, got stuck on railroad tracks, lights on dash board of icons appeared & engine was shutting down mid drive with no warning or issues. 13,500 miles on the car
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco Sport