Chrysler 300 Complaints (2006)

1,051 consumer complaints on file.

#11727411March 27, 2026
ENGINE, FUEL SYSTEM, GASOLINE
The contact owns a 2006 Chrysler 300. The contact stated that while driving at undisclosed speeds, the vehicle shut off unexpectedly. The contact stated that the vehicle sputtered and stalled after refueling. There was an abnormal rumbling sound coming from the vehicle. The contact waited for 30 minutes to restart the vehicle. The accelerator pedal was depressed; however, the vehicle failed to respond as needed. While driving and making a turn, the vehicle stalled. There were unknown warning lights illuminated. The contact associated the failure with NHTSA Campaign Number: 14V002000 (Fuel System, Gasoline). The local dealer was contacted and informed the contact that the vehicle could not be repaired. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695818October 27, 2025
FUEL/PROPULSION SYSTEM
I have had issues with fueling the vehicle as when I fuel it I am only able to get a few cents in at a time before the gas pump clicks off or gas starts coming out of the fuel filler neck itself. At most I have been able to fill up my tank halfway but when I try to fill it a few cents worth of gas above halfway, I have engine stalling issues. To try to solve this issue I replaced all the external fuel vapor parts (charcoal cannister, EGR valve, PCV valve, purge solenoid, gas cap, and leak detection pump). The issue is clearly a problem with the internal components of the fuel tank itself. Chrysler has a X53 lifetime warranty for my type of vehicle but only for 19 gallon fuel tanks and my car has an 18 gallon tank. However, NHTSA investigation PE13-016 has shown that the defect (a swollen vent valve) affects both sizes of tanks. Chrysler said that the X53 lifetime warranty on the defective tank is VIN specific and would not cover my vehicle because it has a 18 gallon tank. Now my vehicle dashboard is saying that the gas cap is leaking but the gas cap was just replaced thus this further points to a pressure issue within the tank. Chrysler dealerships will not help me and contacting FCA resulted in them just telling me to contact a dealer to check if the warranty is available for me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626545November 21, 2024
ENGINE, FUEL/PROPULSION SYSTEM
2006 Chrysler 300 Touring 3.5L V6 engine. Car has intermittent stall at slow speeds or at complete stop. Sometimes feels like it stumbles, other times it dies suddenly and unable to tell the engine shut down. I have to put car in park and completely switch the ignition fully off and turn back on to start position. When it stalls while rolling, I have to brake and bring car to full stop, with no power steering, and go through the same start procedure. No trouble codes are generated, and no check engine light indicator illuminated. Car usually starts right up, but sometimes I have to keep cranking starter, stumbles to catch as if starving for fuel. A/C was on first two times but also happens with A/C off. Research online reveals an open recall for the fuel tank on the 300C model with a 5.7L or 6.4L engine. Problems described on the 300C model are nearly identical to what my 300 Touring is experiencing. PCM replacement does not correct problem. Some noticed it happening only with a full tank. Stopgap measure is to only fill no more than 3/4 tank. I am currently testing this idea. The safety issue is significant and twofold; three times I have had one other adult and two children in the car. While stalled at a major intersection traffic signal trying to restart the engine, other vehicles approached from the rear at 50-55 MPH. A rear end collision with children in the back seat would likely be fatal. Secondly, during a stall event while the car is moving, it is extremely difficult to steer the vehicle to a safe place, and braking takes significant pedal pressure once power assist bleeds off. This is a serious concern and obvious collision hazard, as I may not be able to stop or steer to a safe location or avoid a hazard. I had the car at the dealer for over three weeks in July 2024 and they were unable to duplicate the issue. Their answer was to drive car until it happens more frequently. This is unacceptable. No other solution or repair was provided.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11595681June 21, 2024
ENGINE AND ENGINE COOLING
The contact owns a 2006 Chrysler 300. The contact stated while driving approximately 35 MPH, the vehicle started losing motive power. The contact stated there was smoke coming from under the hood. The contact stated no warning light was illuminated. The contact pulled over and observed that the temperature gauge indicated that the engine was HOT. The contact turned the vehicle off and waited for about 30 minutes and the vehicle restarted after several attempts. The contact had taken the vehicle to an independent mechanic where it was diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 133,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579151March 24, 2024
UNKNOWN OR OTHER
While driving at speed limit car dash lights all light up and car stops running. You loose steering, brakes all electrical lights. Car may restart and power restored and if not must stop car if possible to restart. Happens randomly! This is a continued problem. Has happened more than 10 times and seems to be having this problem more and more often. No one knows how to fix problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515857April 6, 2023
UNKNOWN OR OTHER
Car traction light pops on and the engine raves up high. I turned it off and pump brakes but it continues. When I backup traction pops on. I got coils and brackets put on prior to it doing this. If I lock the car door a lot of times I can't get in. I've called tow truck so many times. Even after replacing battery. Once it's opened with the jimmy and I crank it up. The key remote will work. When I try remote a few hours later it won't work. I don't leave important items in the car due to someone coming in my lot and rummaging through it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11493718November 15, 2022
AIR BAGS
On 11/15/2022, the consumer had a scheduled service appointment at Hendrick Chrysler motor vehicle dealership located at 1628 Montgomery Hwy, Hoover, Alabama, regarding stop drive recall ZD1, S43, and R25. The consumer was directed to sign insurance related paperwork to have the recall service performed. The consumer explained that the service was related to a recall and would not sign any insurance related paperwork. The consumer was advised by service personnel that the recall service would be performed and the motor vehicle was left with the service department to have the recall service performed. Shortly thereafter, the consumer was advised via telephone call that the recall service would not be performed. The consumer does not believe that any insurance paperwork is applicable to have recall service performed. Because the motor vehicle dealership and/or the motor vehicle manufacturer have been unwilling to provide service regarding the stop drive recall(s), the consumer is requesting guidance from the National Highway Traffic Safety Administration for resolution.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11493362November 13, 2022
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
i’ve been reading about the issues regarding the lights exterior/interior-so many customer complaints about how over the past few decades problems with the interior (dash) and exterior lights blinking, dimming & “ completely going out” while of course driving-how hasn’t this major issue been addressed & recalled, this is a VERY DANGEROUS & SERIOUS PROBLEM, I am currently experiencing this while on the road at night-what can be done? Our safety is at risk!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11492007November 2, 2022
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
The contact owns a 2006 Chrysler 300. The contact stated that the TMPS and another unknown warning light was illuminated. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 174,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11485671September 21, 2022
POWER TRAIN
The contact owns a 2006 Chrysler 300. The contact stated that the transmission shifter seized in park(P) and failed to shift to drive(D) or reverse(R). The contact stated that the vehicle was undrivable. After turning off and restarting the vehicle, the gear shifter operated normally. The contact stated that over time the failure became progressively worse and more frequently. The cause of the failure was not yet determined. The contact was informed that the vehicle was not included in the NHTSA Campaign Number: 05V460000 (Power Train). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11484646September 15, 2022
POWER TRAIN
Gear shift gets stuck in park. Cannot shift from park to reverse.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472087July 2, 2022
AIR BAGS
My car poses a safety hazard to me and any others who ride in the car with me, due to the defective Takata airbags that were placed in my vehicle under the Takata airbag recall. Without my consent or knowledge, Dominion Chrysler of Bedford, VA replaced both front Takata airbags (driver and passenger side) with 2 more defective Takata airbags! How is this legal or safe!? I only found out about this dirty trick, by reading an article online, and then I called my dealership and they confirmed that they did indeed replace my defective Takata airbags with 2 more defective Takata airbags and that I would get safe, non-Takata airbags in the future, under the recall. When? They did not know. I had the first airbag replaced in 2016 and the second one replaced in 2017. When will I actually receive safe, non-Takata airbags under this recall? My vehicle is NOT SAFE TO DRIVE and yet Chrysler and The United States government purposely put defective and potentially fatal Takata airbags in my car, not once but twice? I don't have another vehicle to drive and I can't afford to discard this one and buy another potentially dangerous vehicle. I am nervous about driving this vehicle every time. So what am I supposed to do? What are millions of others supposed to do? Neither the FCA or NHTSA ever informed me that I would be getting a second set of defective Takata airbags under this recall. How many others are just as unaware as I was? It is now July 2022 and I need safe non-Takata airbags, like I was promised, under this nationwide recall, NOW. All unsafe Takata airbags need to be replaced today under this recall. How many more people need to be injured or die, due to these defective Takata airbags? No amount of money can compensate for loss of health or life. Please do what is right and what you promised the American People you would do! UPHOLD AND ENFORCE THE LAW AND GIVE US SAFE NON-TAKATA AIRBAG REPLACEMENTS!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11470784June 23, 2022
EXTERIOR LIGHTING, ELECTRICAL SYSTEM
My vehicle has experienced ecm/ throttle body issues, lights flickering hard to drive vehicle at night because the lights aren't working properly. Transmission and motor problems. Why isn't the electrical issues on recall? I've been on several forums with hundreds of electrical issue complaints. This is not fair
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11417651May 18, 2021
FUEL/PROPULSION SYSTEM
I here to report what seems to be an on-going issue with the older model Chrysler 300's. I have an 2006 and just recently started smelling gas fumes or an gas odor inside my car. I had a mechanic look at the problem. He assumes it was a cracked or damaged seal. He took the backseat out and looked. The ring was intact but the fuel filter had a small crack in it. We fixed it and thought the problem was over. He said the car would have a heavy fuel smell for a couple of days but would go away once the car was aired out. 3 DAYS go by and though the fumes remained. Now,i see that gas isactually leaking from the underside of the rear passenger side. And the smell is still there. I am taking the car to another repair shop to do a more through exam of the car. Leaking gas should be the least of my problems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11405386March 29, 2021
FUEL/PROPULSION SYSTEM
EVERY TIME I FILL MY CAR WITH GAS I GET A GAS SMELL INSIDE MY CAR AND GARAGE FOR THE NEXT FEW DAY. I CALL ABOUT A RECALL FOR MY CAR AND WAS TOLD THAT MY CAR WAS TOO OLD TO BE SERVICED AT THE DEALERSHIP WHERE I BOUGHT IT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11363761October 11, 2020
AIR BAGS, SEAT BELTS
* [XXX] * [XXX] * [XXX] * [XXX] * [XXX] * [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#11362722October 4, 2020
AIR BAGS, SEAT BELTS
I WAS HIT FROM BEHIND ON FREEWAY BY DRUNK DRIVER AND PUSHED INTO SIDE WALL ON HIGHWAY. IN THE PROCESS MY SEATBELT UNLOCKED AND NONE OF THE AIR BAGS DEPLOYED EVEN THOUGH HE HIT ME GOING CLOSE 100MPH.*DT*JB*DT THE CONSUMER PROVIDED PHOTOS. *TR
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#11340194July 19, 2020
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
I WENT TO THE GAS STATION, 2-ISH MILE DRIVE AND CAME BACK HOME. ABOUT 20 MINUTES LATER WE DECIDED TO GO SEE MY MOTHER IN LAW, 34 HIGHWAY MILES AWAY. COOL, SO WE GO, EVERYTHING IS FINE, BEASTIE (THAT'S THE NAME OF MY 2006 CHRYSLER 300), IS RUNNING GOOD, MY HUSBAND AND 3YR OLD ARE JAMMIN OUT TO METALLICA, AND WE GET TO MY MOTHER IN LAWS HOUSE.. STAY A COUPLE HOURS AND DECIDED TO HEAD HOME.. SO WE SAY BYE ECT ECT.. WE GET ABOUT 9.5 MILES DOWN OUR 34 MILE RIDE HOME... AWW CRAP, THERE IS A TRACTOR ON THE ROAD, SO WE GO TO PASS HIM... OR SO WE THOUGHT... MAKE SURE COAST IS CLEAR, TURN ON BLINKER AND STEP ON THE GAS PETAL MORE FIRMLY.. OK IN THE OTHER LANE.. AND BAM!! CAR DIES IN MOTION AT 60 MPH!! MY HUSBAND JUST CASUALLY SAYS "HEY BABE, I THINK THE CAR JUST DIED" AND I LOOK LIKE "HAHA WHATEVER" AND I COULDN'T BELIEVE IT.. SO WE PULL OVER AND TRY TO GET IT STARTED, HAD MY MIL COME JUMP US.. AN HOUR LATER AND WE STILL DON'T HAVE BEASTIE STARTED.. NO CLICKING, NO NOTHING.. SO UNFORTUNATELY BEASTIE HAD TO SIT ON THE SIDE OF THE ROAD UNTIL THE NEXT DAY... THE NEXT DAY WE GOT HER TOWED TO MY MILS HOUSE... THAT WAS 3 DAYS AGO... AND BEASTIE STILL HASN'T STARTED UP FOR ME...
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11317697March 12, 2020
ENGINE
TL* THE CONTACT OWNS A 2006 CHRYSLER 300. THE CONTACT STATED WHILE DRIVING AT A VERY LOW SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO YEMM CHEVROLET BUICK GMC CHRYSLER DODGE JEEP RAM LOCATED AT (2195 N HENDERSON ST, GALESBURG, IL 61401) TO BE DIAGNOSED. THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11311809February 27, 2020
FUEL/PROPULSION SYSTEM, POWER TRAIN, ENGINE
CAR SHUT OFF IN THE MIDDLE OF HIGHWAY, STALLING, I WAS ALMOST HIT FROM BEHIND. NOW IT WON'T EVEN START. EVERY ISSUE IS RELATED TO THE FUEL ISSUE RECALL. BUT MY BECAUSE MY VIN ISN'T INCLUDED, I HAVE TO DEAL WITH THIS. YOU GUYS AREN'T PERFECT AND MISSED ADDING MY CAR TO THE RECALL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chrysler 300