Chrysler 300 Complaints (2005)

837 consumer complaints on file.

#11731463April 15, 2026
AIR BAGS
The contact owns a 2005 Chrysler 300. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 16V352000 (Air Bags); however, after retrieving the vehicle the following day, the vehicle experienced several failures while driving. The A/C was inoperable, the vehicle was running rough, the check engine warning light was flashing, and the vehicle almost stalled while coming to a stop. Additionally, the contact became aware that there was a hole in the fuel tank. The dealer was notified of the failures, but no assistance was provided. The manufacturer was notified of the failure, and a case was filed. The manufacturer followed up with the dealer, and the contact was later informed that no assistance would be provided because the failures were unrelated to the recall, as per the dealer’s assessment. The vehicle was not diagnosed or repaired. The failure mileage was approximately 106,272.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11624858November 12, 2024
ELECTRICAL SYSTEM, POWER TRAIN
This is a serious safety concern regarding the shift interlock system on my 2005 Chrysler 300. When the vehicle is in Park, particularly in traffic, and the light turns green, I am forced to lift the coin attachment and manually press the pink interlock just to change gears or accelerate. This creates a dangerous situation where I am unable to move the vehicle promptly, potentially leaving me vulnerable to a rear-end collision. The issue stems from Recall 05V462000, which specifically addresses a shift interlock defect that Chrysler has failed to address despite my repeated attempts to have it repaired. Chrysler has not taken any action to resolve the recall issue, leaving me in a potentially life-threatening situation every time I drive. It is unacceptable that this recall has not been acted upon, and this critical safety defect must be corrected immediately.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11604911July 27, 2024
POWER TRAIN
The vehicle began to shutter in reverse. This went on for about a week. Transmission fluid level was checked and it was in the normal range. My husband and I were driving it and made a sharp turn to find us in a spot to continue forward and go off a cliff or back up and get out of traffics way. He backed up and we heard a clunk. The car continues to drive forward with no issues but it acts as of it’s in neutral when you put it in reverse. No codes are showing either.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11512289March 16, 2023
ELECTRICAL SYSTEM, POWER TRAIN, ENGINE
my engine blew, transmission is slipping. I’m having electrical and air bag problems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498307December 20, 2022
AIR BAGS
The contact owns a 2005 Chrysler 300. The contact stated while starting the vehicle, the front passenger’s side air bag warning light illuminated. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was contacted and stated there was no recall for the failure. The failure mileage was 19,641.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11495459November 30, 2022
FUEL/PROPULSION SYSTEM
Strong fuel smell in cabin and outside of car when gas tank is full. Discovered gas in the cabin sitting on top of the fuel tank under the passenger-rear seat. Multiple posts in online forums confirm this is a known issue. Vehicle owner ordered a new o-ring to attempt repair. Area around fuel pump under driver's-rear seat was not affected. No warning lights, notices or performance issues. Only indication is strong gas fumes in car after filling up the gas tank (auto shutoff at pump, not topped off) which persists for several days. Problem seems minimized if gas tank is shorted 2-3 gallons from max capacity on fillup (about 14 gallons when car is close to empty per the gas gauge in dashboard.) Car was not inspected by dealer, insurance agent, police, independent service center, or anyone else other than owner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11487307September 30, 2022
AIR BAGS
The contact owns a 2005 Chrysler 300. The contact stated that while the mother was driving at approximately 10 mph when suddenly the driver-side air bag erroneously deployed. During the incident, no crash had occurred and the vehicle had not driven over a pothole or bump in the road. The driver sustained a left-hand injury which included three fractured fingers. The local dealer and manufacturer were notified of the failure. The vehicle was towed away and examined by the manufacturer's engineer. The cause of the failure was not explained but the contact was informed that the manufacturer took no responsibility for the failure. The vehicle was not repaired. The failure mileage was 190,000
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11478250August 8, 2022
AIR BAGS
The contact's mother owns a 2005 Chrysler 300. The contact stated that while her mother was driving approximately 10 mph, the air bag deployed without a crash or impact. The driver sustained a fractured finger and medical attention was provided. The contact called the local dealer but the vehicle was not diagnosed or repaired. The contact stated the failure was due to NHTSA Campaign Number: 15V313000 (Air Bags). The manufacturer was notified but no additional assistance was provided. The approximate failure mileage was 190,366.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11474862July 20, 2022
POWER TRAIN, SUSPENSION, STEERING
Reverse gear went out after vehicle slipped once, acted as if in neutral when in reverse and pressing gas pedal down but would not move. Had local towing and mechanic shop in Gower Missouri check transmission fluid level in which was found to be a quart low on transmission fluid. Car had been extremely well maintained and all recommended maintenance services completed by previous owners. Able to drive car in all other gears, codes p0007 code appear with no check engine light or any type of warning or indication that a problem was present within my 2005 Chrysler 300 3.5l v6 rwd car with the 42rle transmission My vehicle also has issues occur suddenly regarding front end suspension has death shake and very loud clinking popping banging noises while driving at all speeds. Steering wheel has a weird squeek/creeking noise when turning the wheel at times and feels like steering is loose. Tie rod end and sway link bar on front passenger right side of vehicle is bent opposite direction it is supposed to and car also has higher rpm than normal and shifting at higher rpms. Went into limp mode twice which I reset myself due to having an emergency where I had to drive it. With the suspension and steering issues it causes a safety risk due to sway link and tie rod end breaking causing vehicle to crash and wheel to detach from vehicle. Transmission gear loss due to transmission fluid leaking and gear linkage issues causes safety risk due to the event of reversing to move out of the way and to avoid potential harm to passengers (my 5 young children) within the vehicle in the event the vehicle can't move from the place parked. The vehicle is available to be inspection and has been checked out by 3 different mechanic shops located in Gower, saint Joseph, and Savannah Missouri all in which stateed verbally that low fluid due to leak somewhere from transmission and poor linkage components within gear solenoid and possible pcm and mil issues to be at fault of vehicle mufacture
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463655May 6, 2022
FUEL/PROPULSION SYSTEM
ENGINE STALLS AFTER FUELING TANK. THIS HAS BEEN CONFIRMED BY AN INDEPENDENT SERVICE CENTER. SPENT MONTHS AND LOTS OF DOLLARS TRYING TO FIX PROBLEM. DID RESEARCH ON INTERNET AND FOUND CHRYSLER HAD ISSUED BULLETIN 14-002-14 SHOWING THERE A PROBLEM WITH CHRYSER 2005 AND 2006 300'S STALLING. THE FUEL PUMP IS IN THE TANK AND NOT MONITORED BY ENGINE COMPUTER. THE FUEL PUMP HAD GONE BAD CAUSING THE CAR TO STALL. CALLED CHRYSLER AND THEY SAID THAT THE BULLETIN DID NOT COVER MY MODEL. CAN NOT USE CAR NOW BECAUSE IT IS A SAFETY HAZARD. NEED HELP ON THIS ISSUE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11442071November 30, 2021
ENGINE, ELECTRICAL SYSTEM
The contact owns a 2005 Chrysler 300. The contact stated that while operating the vehicle, the check engine warning light would remain illuminated. Occasionally the lights on the dashboard and inside the vehicle would randomly blink off and on. The vehicle was taken to the local dealer who was unable to diagnose the cause of the failure. During the diagnostic test, the electrical fuses continued to malfunction. No further information was available. The manufacturer was not yet notified. The failure mileage was 137,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11421131June 16, 2021
FUEL/PROPULSION SYSTEM
Our 2005 Chrysler 300 stalls and will not restart for many minutes after we refuel it. Chrysler stated they have extended the warranty to a life time coverage if you are experiencing this issue you are able to get it covered under said warranty. We have contacted them and they state this one is not covered. How can we go about getting this covered. It obviously has the issue they have recalled and should be covered!! Thank you, Shannon Hainzlsperger
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11420210June 8, 2021
FUEL/PROPULSION SYSTEM
My 2005 Chrysler 300 has been having an issue with the fuel tank. When you get fuel in it then it won’t stay started. It keeps stalling out repeatedly. It also stalls out randomly under 25mph. Both are dangerous as it may cause you to get T-boned leaving gas station as it repeatedly stalls. Also it stalled out on the freeway on-ramp under 25mph. This is also dangerous as you lose your steering at the same time. Someone could have been injured or killed. And Chrysler needs to take this more seriously than they did just with the 2005 300c. It’s happening to more models of that year as well. Their offered remedy was telling me not to fuel it all the way up anymore past 3/4 of a tank. A dealership confirmed it needs a full fuel tank replacement and has had it since Memorial Day. They still have it currently. Chrysler told me and the dealership I’m on my own after treating me horribly most of the time on the phone calls with customer care center as I was jumping through hoops for them over and over for around 2 months. Whenever I get someone kind and helpful they won’t let me speak to them again. I have this all written down. And will get the estimate when I get my car back. But I don’t have $2800 ($2000 alone is just the fuel tank) to fix this on my own. Especially not when there is a known issue. Fuel tanks just don’t break and need full replacement as a common issue in vehicles. But Chrysler says my vehicle is too old. Which they knew the year of my vehicle when I called in the first place. And they know there is a known issue which is why they have lifetime fuel tank replacements on others of the same year. It’s too bad they weren’t pushed to do a total recall rather than just a safety bulletin. It left the rest of us that end up having issues with the fuel tanks in danger. It’s not just coincidental. It’s been acting up for awhile and I couldn’t find anyone that had ever heard of this until the Chrysler forums. It got worse in 2020 to present. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11408292April 15, 2021
POWER TRAIN
COULD NOT GET GEAR SHIFT OUT OF PARK. WE TOOK APART CASING, FOUND THE PINK PLASTIC BROKE. LOOKED AT YOUTUBE TO FIX. ORDER PART ON AMAZON. THE PLASTIC PIECE IS NOW MADE OF METAL!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11405871March 31, 2021
FUEL/PROPULSION SYSTEM
IN THE BEGINING MY CAR STALL AFTER FILLING THE TANK UP WITH GAS. IT WOULD STALL AT LOW IDLE LIKE FOR INSTANCE WHEN I COME TO A STOP. BUT IT ALSO HAVE DONE IT WHEN I'VE BEEN ON THE HIGHWAY WHEN I RELEASE THE GAS PEDAL WHICH IS VERY DANGEROUS TO ME AND EVERYONE AROUND ME. ESPECIALLY ON A MAJOR CITY HIGHWAY LIKE ATLANTA. I;VE BEEN TRYING TO GET THIS RESOLVE SINCE EARLY LAST YEAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11364836October 17, 2020
FUEL/PROPULSION SYSTEM, STEERING
I WAS DRIVING DOWN THE ROAD AND MY VEHICLE DIED. NOW IT DOES EVERY TIME I COME TO A COMPLETE STOP. THE STEERING MAKES A CLICKING NOISE WHEN I TURN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11354228September 10, 2020
LATCHES/LOCKS/LINKAGES:DOORS:LATCH, ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2005 CHRYSLER 300. THE CONTACT STATED THAT BOTH REAR DOORS FAILED TO LOCK SECURELY. THE CONTACT HAD TO MANUALLY UNLOCK THE DOORS. THE CONTACT STATED THAT THE ELECTRIC POWER SWITCH TO LOCK AND UNLOCK THE DOORS ONLY WORKED TO UNLOCK THE FRONT DOORS. ADDITIONALLY, THE KEY FOB ONLY UNLOCKED THE FRONT AND NOT THE REAR DOORS. THE CONTACT ALSO STATED THAT THE SPEEDOMETER FAILED TO FUNCTION AS DESIGNED. NEITHER THE DEALER NOR THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11350214August 19, 2020
POWER TRAIN
TL* THE CONTACT OWNS A 2005 CHRYSLER 300. THE CONTACT STATED THAT THE VEHICLE STALLED AND SHUTOFF WHILE DRIVING. THE CONTACT STATED THAT THE WHEEL LOCKED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE GREENWAY DODGE CHRYSLER JEEP RAM LOCATED AT 9051 E COLONIAL DR, ORLANDO, FL 32817, WHERE IT WAS DIAGNOSED THAT AN UNKNOWN PART WAS DAMAGED IN THE DASHBOARD WITH THE IGNITION AND NEEDED TO BE REPLACED. THE TECHNICIAN ALSO STATED THAT THERE WAS NO RECALL ON THE VEHICLE. THE CONTACT WAS INFORMED BY A RELATIVE THAT AN AIR BAG WAS REPLACED IN 2018 HOWEVER, THE TECHNICIAN STATED THAT THE AIR BAG REPAIR WOULD NOT HAVE CAUSED THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000. *LN THE CONSUMER STATES THAT VEHICLE IS INOPERABLE AND DANGEROUS TO TO DRIVE. *AS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11341745July 27, 2020
FUEL/PROPULSION SYSTEM
GAS TANK LEAKS. NO HOLES, CAR STALLS LOSES GAS TANK LEAKS CONTUINLY WAS CHECKED FOR HOLES NONE WE COULD SEE. SMELLS LIKE GAS ALL THE TIME. CAR HAS 101.000. MILES
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11297973January 8, 2020
AIR BAGS, POWER TRAIN, SEAT BELTS
THE AIRBAG LIGHT IS STAYING ON. HAVING A HARD TIME PUTTING CAR IN AND SOMETIMES OUT OF PARK. SEAT BELT ACTS LIKES IT DONT WANT TO FASTING ON DRIVERS SIDE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chrysler 300