Chevrolet · Model Report
Showing safety data for the 2003 model year only.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IN HOT AMBIENT CONDITIONS, THE ACCELERATOR PEDAL ARM MAY STICK AT THE ATTACHMENT TO THE BRACKET AND NOT RETURN TO THE ENGINE IDLE POSITION WHEN THE OPERATOR LIFTS HIS FOOT FROM THE ACCELERATOR PEDAL.
The contact owns a 2003 Chevrolet Malibu. The contact discovered that while driving at various speeds, the key could be removed from the ignition while the engine was still running. The contact later received notification of NHTSA Campaign Number: 14V400000 (ELECTRICAL SYSTEM). The vehicle was taken to the dealer for service, and the vehicle was returned in less than 30 minutes. The contact was suspicious about the work that was performed on the vehicle. The contact stated that soon after the recall repair, the key remained stuck in accessory mode while attempting to turn off the vehicle. Due to the failure, the contact was forced to remove the key from the ignition while the engine was running and used pliers to unhook the battery to turn off the vehicle. Additionally, while driving 20 MPH over a bump in the road, the key was knocked out of the ignition, causing the vehicle to abruptly shut off. The contact lost control of the vehicle, and the vehicle veered off into the grass before coming to a complete stop. Despite the failure, the contact was able to restart the vehicle and drove to the residence and parked the vehicle. The contact alerted the dealer of the failure and that the recall was not properly serviced. The contact was given an estimate for a diagnostic test, and the contact refused to pay for the diagnostic test. The manufacturer was notified of the failure, and the contact was informed that a representative would give a follow-up call. The vehicle was not repaired. The failure mileage was approximately 220,000.
No injuries · No fire · No crash
Unknown
No injuries · No fire · No crash
Multiple times, the vehicle, while driving, electrically shuts down. security light comes on, sometimes, many attempts to restart will work. These shutdowns cause me to revet to manual bakes and steering.
No injuries · No fire · No crash
The contact owns a 2003 Chevrolet Malibu. The contact stated that the ignition switch was inoperable and had been replaced three times by the dealer; however, the failure recurred. The vehicle was towed to an independent mechanic where it was diagnosed with ignition switch failure. The contact was informed that the ignition switch needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 170,000.
No injuries · No fire · No crash
Car shuts off while driving.Will start up when fuel gauge gets power also windows ,radio,lightening work airbag light&service engine soon light on
No injuries · No fire · No crash