Chevrolet · Model Report
Showing safety data for the 2004 model year only.
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE PASSENGER-SIDE REAR SAFETY BELT MAY HAVE BEEN INSTALLED WITH AN INCORRECT NUT AND BOLT.
The whole steering column is loose The pins are all backed out I’m afraid to drive it I think this is a manufactured design flaw
No injuries · No fire · No crash
The vehicle failed to pass pa. state inspection due to a severely rusted frame over the rear axles. The estimate to repair the frame was @$3000.
No injuries · No fire · No crash
The contact owns a 2004 Chevrolet Cavalier. The contact stated while driving 10 MPH, the front driver’s side tire had detached. The vehicle was towed to the contact's residence. An independent mechanic went to the contact's residence and diagnosed that the lower control arm rusted and detached from the subframe. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000.
No injuries · No fire · No crash
IN THE PARKING LOT WHERE I WORK MY CAR WOULD NOT START. WHEN MOVING THE AUTOMATIC TRANSMISSION LEVER IT DID NOT CATCH ON TO ANYTHING. THE CAR JUST ROLLED BACKWARDS AND I HAD TO IMMEDIATELY PRESS ON THE BRAKES PREVENTING AN ACCIDENT. MY CAR HAD TO BE TOWED TO THE AUTO SHOP. DIAGNOSIS: SHIFTER CABLE WAS DETACHED FROM TRANSMISSION. PREVIOUSLY ON 09/13/2011 THE SAME THING HAPPENED TO MY CAR. THE SHIFTER CABLE BROKE AND I HAD TO BE TOWED TO LOU BACHRODT CHEVROLET BOTH TIMES. THE 2ND TIME INVOICE NO. CWCS692729 $502.24 AND $477.55 INVOICE NO.CWCS149491 THE FIRST TIME. THIS CAR SHOULD BE RECALLED. TWO TIMES IS TOO MANY.
No injuries · No fire · No crash
CAN'T SAFELY INSTALL A CAR SEAT BECAUSE THE SAFETY BELTS DO NOT PROPERLY RETRACT. THEREFORE THE CAR SEAT IS NOT STABLE. THE VEHICLE WAS STATIONARY.
No injuries · No fire · No crash