BMW 535i Complaints

536 consumer complaints on file.

#10549497October 25, 2013
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2009 BMW 535I. THE CONTACT STATED THAT THE REAR DRIVER'S SIDE TAIL LIGHT FAILED. THE VEHICLE WAS NOT TAKEN FOR INSPECTION AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT LISTED UNDER NHTSA CAMPAIGN NUMBER: 13V407000 (EXTERIOR LIGHTING). THE APPROXIMATE FAILURE MILEAGE WAS 68000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10549587October 25, 2013
ELECTRICAL SYSTEM, STEERING
THE CAR HAS BEEN IN AND OUT OF THE SHOP FOR VARIOUS PROBLEMS FROM THE MOMENT WE BOUGHT IT. THE CAR STARTED MAKING WHISTLING SOUNDS AND ENGINE LIGHTS WOULD COME ON AND HAS BEEN SEEN BY BMW RTS ALREADY 4 TIMES. BUT MOST RECENTLY MY HUSBAND WAS WAITING AT THE LIGHT TO MAKE A LEFT TURN WHEN HIS STEERING WHEEL ALL OF A SUDDEN LOCKED AND HE COULD NOT DRIVE IT. SO WE TOOK IT IN TO GET IT SERVICED AND WAS TOLD TO IMMEDIATELY CONTACT BMW OF NORTH AMERICA . 3 WEEKS LATER I FINALLY RECEIVED MY CAR AND CAUSE OF THIS STEERING ERROR READS: EPS CONTROL UNIT IS FAULTY. THE REPLACED THE EPS CONTROL UNIT, BASICALLY THE STEERING RACK, AND THE EPS CONTROL UNIT FAILED AGAIN! THEY DISCONNECTED THE BATTERY TO RESET THE CONTROL MODULES REPROGRAMMED THE EPS CONTROL UNIT, ADJUSTED THE STEERING ANGELS, INITIALIZED ALL WINDOWS AND SUNROOF, PERFORMED ACTIVE 4 WHEEL ALIGNMENT. BASICALLY THE CARS A DUD AND BMW REFUSES A BUY BACK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10548750October 21, 2013
ENGINE, EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2008 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, SMOKE EMITTED FROM THE OUTSIDE REAR OF THE VEHICLE AND THE ENGINE COOLANT WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN INFORMED THE CONTACT THAT THE REAR PASSENGER'S SIDE TAIL LIGHT WIRES HAD FAILED AND WERE COMPLETELY BURNED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBERS: 13V407000 (EXTERIOR LIGHTING) AND 12E029000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN EITHER OF THE RECALLS. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10547626October 11, 2013
VEHICLE SPEED CONTROL, FUEL SYSTEM, GASOLINE
DRIVING ON HIGHWAY, PANEL INDICATES THAT THE TEMPERATURE IS HIGH, AND ADVISES TO DRIVE MODERATELY. PULLED OVER ONE LANE. BEFORE BEING ABLE TO PULL OVER COMPLETELY, A NEW INDICATION SHOWS ON THE PANEL, INSTRUCTING THAT THE ENGINE IS OVERHEATED. VEHICLE QUICKLY POWERS DOWN IN THE MIDDLE OF THE HIGHWAY. UNABLE TO PULL OFF TO THE SIDE BEFORE THE CAR IS TRAVELING UNDER 20 MPH. LIMPED TO THE ROAD SIDE WITH OTHER CARS BUZZING BY AT DANGEROUSLY DIFFERENT SPEEDS AS COMPARED TO MY OWN. I WAS FINALLY ABLE TO PULL OFF TO THE SIDE OF THE HIGHWAY WHILE GOING LESS THAN 5 MPH, CAUSING OTHER DRIVERS TO SLAM THEIR BRAKES AND HONK PROFUSELY AT ME. THE DECELERATION HAPPENED VERY QUICKLY. WITH LOTS OF TRAFFIC, THIS CREATED A DANGEROUS AND DIFFICULT SITUATION TO MANAGE IN THE MIDDLE OF RUSH HOUR. THE FACT THAT A CRASH DID NOT OCCUR IS A MATTER OF LUCK. AFTER PULLING OFF TO THE SIDE AND LETTING THE CAR COOL FOR SEVERAL MINUTES, I WAS ABLE TO RESTART AND DRIVE SLOWLY, LONG ENOUGH TO GET OFF THE HIGHWAY AT THE NEXT EXIT, ABOUT 500 FEET AWAY. CALLED FOR A TOW TRUCK. CAR IS NOW AT DEALER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10546199September 30, 2013
ENGINE
FAN RAN TOO FAST, ENGINE HOT MESSAGE, REDUCE SPEED MESSAGE, CAR LIMPED TO A STOP. OVER HEATED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10543622September 14, 2013
ENGINE, FUEL SYSTEM, GASOLINE
WHILE DRIVING ON THE HIGHWAY, THE CAR INDICATED AN ENGINE MALFUNCTION AND WITHIN SECONDS THE MESSAGE CHANGED TO ENGINE OVERHEATING AND THAT ENGINE IS OPERATING AT REDUCED OUTPUT. IT ALSO ADVISED TO STOP THE CAR IMMEDIATELY AND CALL THE NEAREST BMW DEALER. I HAD THE CAR TOWED TO A BMW DEALER AND THEY IDENTIFIED ISSUE AS A FAILED WATERPUMP. THE WATER PUMP WAS REPLACED FOR ABOUT $1,400. 3 MONTHS LATER, A SIMILAR ISSUE OCCURRED WHERE ENGINE WAS HAVING ISSUES AND THE MESSAGE SAID THAT THE ENGINE IS OPERATING AT REDUCED SPEED BUT THAT IT IS SAFE TO CONTINUE. TOOK THE CAR BACK TO DEALER AND THEY COULD NOT FIND ANY ISSUES; BUT JUST TO BE SAFE (WHATEVER THAT MEANS) THEY REPROGRAMMED THE BATTERY AND THE BILL WAS $126. AGAIN, WITH NO SPECIFIC ISSUE IDENTIFIED OR RESOLVED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10541692September 3, 2013
STEERING
TL* THE CONTACT OWNS A 2012 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STARTED TO PULL TO THE RIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10532515July 31, 2013
SERVICE BRAKES, HYDRAULIC
2012 BMW 535XI. CONSUMER WRITES IN REGARDS TO VEHICLE BRAKE SYSTEM FAILURE. *SMD THE CONSUMER STATED THE VEHICLE SAT IN HIS GARAGE FOR 3-4 WEEKS DURING THE WINTER. APPARENTLY, THE CRITICAL BRAKE COMPONENTS, CORRODED TO THE POINT WHERE BMW FELT REPLACEMENT WAS NEEDED, AT A COST OF $2,000. BMW REFUSED TO COVER THE REPAIRS UNDER WARRANTY, UNLESS HE SIGNED A LIABILITY RELEASE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10532440July 29, 2013
TIRES, TIRES:SIDEWALL
GOODYEAR EAGLE LS2 ROF TIRES. ONLY 4700 MILES ON MY 2013 BMW 535 ACTIVEHYBRID. BUBBLE ON RF TIRE, I AM THE ONLY DRIVER. NO POTHOLES EVER HIT OR CURBS RUBBED INTO. I AM IN THE AUTO INDUSTRY. CAREFUL EXAMINATION OF THE TIRE SHOWED NO SIGNS OF IMPACT ON THE OUTSIDE OF THE TIRE OR THE WHEEL. NO DAMAGE TO THE INSIDE EITHER. OBVIOUS DEFECT IN THE TIRE. LOOKING AT THE NUMEROUS COMPLAINTS ABOUT THIS TIRE ONLINE THERE IS A PROBLEM. IT NEEDS TO BE ADDRESSED BEFORE SOMEONE KILLS THEMSELVES WITH A BLOWOUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10525656July 18, 2013
TIRES, TIRES:SIDEWALL
THREE GOODYEAR EXCELLENCE 245/40R19XL RUN-FLAT TIRES HAVE FAILED WITH SIDEWALL BUBBLES ON MY 2011 BMW 535I. THE FIRST WAS ON 8-31-11 AT 7,317 MILES. THE SECOND ON 1-15-13 AT 20,158 MILES AND THE MOST RECENT ON 7-16-13 AT 23,433 MILES. THE FACTORY ORIGINAL RIGHT-FRONT TIRE AND ITS REPLACEMENT TIRE BOTH FAILED. THE THIRD FAILURE (ON 7-16-13) WAS ON THE LEFT FRONT. THIS IS MY WIFE'S CAR AND IT IS DRIVEN VERY CONSERVATIVELY. NO WRECKS, NO HITTING CURBS, ETC. NEVER IN MY LIFE HAVE I HAD THIS TYPE OF TIRE FAILURE. THESE RUN-FLAT TIRES ARE TRULY DEFECTIVE. IN EACH CASE, I HAD TO PAY FOR A NEW REPLACEMENT TIRE. OLD TIRES ARE NOT AVAILABLE UNLESS I COULD RECLAIM THE LATEST TIRE AT MY LOCAL TIRE SHOP BEFORE THEY DISCARDED IT. COMPLAINED TO GOODYEAR THE LAST TIME AND THEY AGREED TO PAY PART OF THE COST OF THE REPLACEMENT TIRE. THESE NEED TO BE TAKEN OFF THE ROAD BEFORE SOMEONE GETS KILLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10525178July 16, 2013
ENGINE
TL* THE CONTACT OWNS A 2013 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING 3 MPH THROUGH TWO INCHES OF WATER, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE CONTACT WAS INFORMED THAT THE ENGINE HAD HYDRO-LOCKED AND WOULD NEED TO BE REPLACED. THE REPLACEMENT ENGINE WAS UNAVAILABLE AND THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 3,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10520412June 18, 2013
ENGINE, VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
I JUST HAD TO HAVE MY WATER PUMP AND THERMOSTAT REPLACED ON MY 2008 535I. I WAS TOLD THAT IT HAPPENS SO OFTEN, THEY KEEP THE PART ON THE SHELF! ARE THERE REALLY NO RECALLS ON THIS PROBLEM?? ALSO, MY RIGHT TAIL LIGHT SHORTED OUT. I ASKED THE SHOP WHY...HE SAID THIS ALSO HAPPENS ALL THE TIME. THE WIRES FRY! NOT COOL.I REALLY THINK SOMEONE NEEDS TO INVESTIGATE THIS. WHEN I WAS TOLD THEY REPLACE THEM ALL OF THE TIME, I WAS SHOCKED. THAT COST ME $1102.62 TO FIX. THE GUY WHO TOWED ME SAID HE MAKES SEVERAL TRIPS A WEEK FOR PEOPLE WITH THE SAME PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10519870June 14, 2013
ELECTRICAL SYSTEM
AS I WAS DRIVING HOME ON THE HIGHWAY MY ENGINE OVERHEATED VERY QUICKLY. IT WENT INTO SERIOUS LIMP MODE AND SLOWED DOWN TO UNDER 30MPH IN THE MIDDLE LANE OF A WIDE FREEWAY. I LET IT COOL FOR OVER 20 MINUTES, AND IT OVERHEATED WITHIN 1 MINUTE OF TURNING IT BACK ON. I HAD TO HAVE IT TOWED TO MY MECHANIC AND HE DETERMINED THE WATER PUMP HAD FAILED. I STARTED DOING SOME RESEARCH ONLINE AND IT TURNS OUT TO BE A VERY COMMON ISSUE. I READ MANY MANY COMPLAINTS OF PEOPLE HAVING ELECTRICAL WATER PUMP FAILURES BEFORE 75,000 MILES. WITHOUT A WATER PUMP YOU MUST HAVE THE CAR TOWED AND ITS A VERY EXPENSIVE FIX. BMW/MINI HAVE HAD MANY CARS WITH PROBLEMATIC WATER PUMPS IN THE PAST AND THEY NEVER DO ANYTHING ABOUT IT. THIS ISSUE NEEDS TO RESULT IN A RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10510846May 6, 2013
POWER TRAIN
MY CAR HAVE ABOUT 1/2 SECOND DELAY FROM THE TIME YOU PRESS THE ACCELERATOR AND THE CAR RESPONDS, SO YOU PUSH HARDER, BECAUSE (I GUESS) IS TURBO THE KICK IN IS VERY STRONG, ALMOST HIT A CAR IN FRONT OF ME AT LEAST TWICE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10508026April 16, 2013
ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
2009 BMW 535I. CONSUMER WRITES IN REGARDS TO ENGINE MALFUNCTION THAT CAUSED VEHICLE FIRE. *SMD THE CONSUMER STATED THE VEHICLE WAS IN THE PROCESS OF BEING TOWED, WHEN IT CAUGHT ON FIRE. THE CONSUMER STATED THERE WAS NO UNUSUAL SERVICE HISTORY. THE HIGH PRESSURE FUEL PUMP WAS REPLACED TWICE, ONCE AS A RECALL. THE VEHICLE WAS SERVICED FOR STALLING PROBLEMS, WHICH WAS THE SAME ISSUE THAT OCCURRED ON THE DAY OF THE FIRE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10508209April 14, 2013
TIRES
I HAVE A 2011 BMW 535I IS PURCHASE NOV 2010 FROM BMW MILITARY SALES, THREE WEEKS AFTER RECEIVING CAR, MY RIGHT FRONT TIRE FORM A BUBBLE AND WAS REPLACED BY BMW OF LANDSTUHL, I SHIPPED THE CAR TO THE US MAY 2011. JUNE 2011 MY RIGHT FRONT TIRE FORM A BUBBLE; TOOK CAR TO DEALER AND WAS TOLD TIRE WAS NOT COVER IN WARRANTY; BOTH NEW TIRE, AUG 2011 FRONT LEFT TIRE FORM BLISTER; TOOK BACK TO DEALERSHIP AND WAS TOLD I NEED TO CONTACT GOODYEAR; I EMAIL THE MANUFACTURE NO RESPONSE; APRIL 2013 I HAD CURBSIDE REAR TIRE TOOK TO DEALERSHIP AND WAS TOLD THAT EL PASO HAD ROUGH ROADS AND THAT THE BLISTERS FORM FROM WEAR AND TEAR; SO I REPLACE ALL FOUR RUN FLAT TIRES AND NO MORE BUBBLES FORMING ON TIRES. NOT COUNTING THE TIRE REPLACE BY BMW LANDSTUHL I HAVE REPLACED 3 TIRES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10505615April 9, 2013
WHEELS, TIRES
THE GOODYEAR RUN FLAT TIRES ON THE VEHICLE CONTINUOUSLY DEVELOP BUBBLES ON THE SIDEWALL. I HAVE HAD THE TIRES REPLACED SEVERAL TIMES AND BMW REPLACED BECAUSE I HAD A TIRE/WHEEL PACKAGE. NOW THAT THE TIRE/WHEEL PACKAGE HAS EXPIRED I HAVE BEEN REFERRED TO GOODYEAR REGARDING THIS MATTER. I DO FEEL THAT THIS IS A GOODYEAR ISSUE BUT ALSO A BMW ISSUE BECAUSE THEY ARE INSTALLING A DEFECTED PRODUCT ON THEIR VEHICLES. FROM MY RECENT RESEARCH I SEE THERE HAVE BEEN NUMEROUS COMPLAINTS AND THE PROBLEM HAS YET TO BE RECTIFIED. THESE TIRES ARE UNSAFE AND ARE A HAZARDS. WILL IT TAKE SOMEONE BEING KILLED BEFORE SOMETHING IS REQUIRED OF BOTH BMW AND GOODYEAR TO CORRECT THIS PROBLEM AT THEIR EXPENSE AND NOT THE CONSUMERS???? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10505304April 1, 2013
WHEELS, TIRES
WHILE DRIVING MY 2011 BMW 535I ON THE INTERSTATE, ON A CONSTRUCTION ZONE, AT 11:00 PM, I HIT A POT HOLE WITH MY FRONT DRIVER SIDE TIRE. ALMOST IMMEDIATELY NOTICED FRONT END VIBRATION. PULLED OVER, DID NOT NOTICE DAMAGE TO THE WHEEL/ TIRE AND CONTINUED DRIVING UNTIL ARRIVED AT HOME WITHOUT TIRE PRESSURE MONITORING ACTIVATION. UPON INSPECTION OF THE FRONT DRIVER SIDE TIRE, NOTICED AN APPROXIMATELLY A 3 INCH LONG "BUBBLE" ON THE SIDE WALL OF THE TIRE. FOLLOWING MONDAY, BROUGHT THE CAR TO THE GOOD YEAR SHOP FOR INSPECTION AFTER OPENING UP A CASE VIA THE 800 NUMBER WITH GOODYEAR. UPON INSPECTION BY THE GOODYEAR MECHANIC, THERE WAS A LARGE 3-4 INCH TEAR IN THE INSIDE LAYER OF THE SIDEWALL. UNABLE TO DETERMINE HOW MANY LAYERS INVOLVED. MOST LIKELY THAT THE OUTSIDE LAYER NOT INVOLVED BECAUSE TIRE MAINTENED PRESSURE AT ALL TIMES. BASED ON A WEB SEARCH, IT APPEARS THAT THERE HAVE BEEN MULTIPLE FAILURES OF THE SIDEWALL OF THESE TIRES. TIRE INVOLVED, GOODYEAR EAGLE LS2 ROF, DOT NE66 JP1R 2011. WHEN ARE YOU GOING TO INVESTIGATE THE ISSUE? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503756March 20, 2013
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
ONCE AGAIN NEARLY A MONTH AFTER MY 2013 535I HAD ITS HIGH PRESSURE FUEL PUMP REPLACED BY BMW. THE CAR DECIDES TO LOSE ALL POWER AND NOT WANT TO ACCELERATE AGAIN WHILE TRAVELING ON THE FREEWAY. THE CHECK ENGINE LIGHT AND DRIVETRAIN MALFUNCTION LIGHTS CAME ON AND THE VEHICLE BEGAN SHAKING AND SPUTTERING. THIS CAR IS NOT SAFE AT ALL. THE SERVICE ADVISOR IMMEDIATELY RECOGNIZED THIS PROBLEM AND KIND OF BLEW IT OFF BY JOKING ABOUT HOW HE THOUGHT BMW CORRECTED THIS PROBLEM FOR ALL OF THEIR 135, 335, AND 535, WHICH IS DISTURBING TO NOW BMW HAS THIS PROBLEM AND IS STILL SELLING THESE VEHICLES. ALL IT TAKES IS FOR ONE TIME TO HAVE THE WRONG PERSON TRAVELING BEHIND YOU AND WHO KNOWS IF I WOULD BE HERE TO EVEN MAKE A COMPLAINT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10500202February 19, 2013
ENGINE AND ENGINE COOLING
CPSC:I1320310A. 2011 BMW 535I. CONSUMER STATED ON TWO SEPARATE OCCASIONS, WHILE DRIVING, THE ENGINE SUDDENLY STOPPED. *LN THE FIRST TIME THE CONSUMER TOOK THE VEHICLE TO THE DEALER, THEY INFORMED HIM, THE PROBLEM WAS MINOR AND SUPPOSEDLY FIXED IT. THE SECOND TIME, THE INCIDENT OCCURRED, THE DEALER STATED IT WOULD TAKE 10 DAYS TO FIX THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to BMW 535i