Volvo XC90 Complaints

162 consumer complaints on file.

#11709427January 7, 2026
LATCHES/LOCKS/LINKAGES:DOORS:LATCH PLATE, LATCHES/LOCKS/LINKAGES:DOORS:LOCK
To Whom It May Concern, I am submitting this complaint to report a repeated and unresolved safety defect in my leased Volvo vehicle involving rear passenger door lock failure, which has resulted in minor children being trapped inside the vehicle on multiple occasions Vehicle Safety Issue: The left rear passenger door fails to open from both inside and outside, despite the child lock not being engaged. This creates a serious safety risk, particularly during emergencies when occupants must exit the vehicle quickly. Incident History: [XXX]: Rear door would not open from inside or outside, trapping my two children (ages [XXX] and [XXX] ). At the same time, the infotainment system froze and the backup camera was not functioning. I reported this to Volvo service. [XXX]: The same issue occurred again, resulting in my children being locked in the rear seat. One child was experiencing leg pain, and it was extremely difficult and unsafe to remove him through the front door. The dealer stated the rear lock assembly was replaced. [XXX]: Despite prior repair and assurances, the rear door failed again, trapping my child inside the vehicle. I have video evidence showing the door cannot be opened from outside. In addition, on a separate occasion, the vehicle completely froze and could not be unlocked using either key. AAA was required to jump-start the vehicle, and I was informed that a required software installation had not occurred. Safety Concern: A rear passenger door that cannot be opened from inside or outside presents an immediate safety hazard, especially involving children, medical emergencies, accidents, or fire. A non-functional backup camera further increases the risk of injury while reversing. This issue has occurred three times, including after a component replacement, indicating a recurring defect rather than an isolated incident. I am reporting this issue so it can be reviewed for potential safety investigation and corrective action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707902December 30, 2025
UNKNOWN OR OTHER, LANE DEPARTURE: ASSIST, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
SPEED LIMIT indicator incorrect (example: indicator shows 80 mph speed limit on a small road in Alabama where it should be 35 mph; also, there is no road in Alabama greater than 75mph.) LANE DEPARTURE ASSIST has a hard time identifying lanes in some construction zones (this is extremely dangerous as the car is constantly trying to over-correct me) - infotainment system randomly reboots, presents a problem mostly when navigating - I have reported this issue way too many times and the infotainment system has been replaced once. REAR CAMERA comes on randomly, often when no car or object is near INFOTAINMENT system touch sensitivity is unacceptable
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707882December 30, 2025
LANE DEPARTURE: LANE KEEP: STEERING ASSIST
The contact owns a 2025 Volvo XC90. The contact stated that while driving through a construction zone at an undisclosed speed, the lane-keeping assist malfunctioned, causing the vehicle to become erratic, which required the contact to forcefully engage the steering wheel to regain control of the vehicle. There was no warning light illuminated. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 18,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706558December 22, 2025
LANE DEPARTURE: BLIND SPOT DETECTION, FORWARD COLLISION AVOIDANCE: WARNINGS
I was driving on the internstate and my blind spot indicator came on and stayed on even though there were no cars in my blind spot. I needed to change lanes and tried to despite the blind spot indicator being on and the automatic collision avoidance system put me back into the lane I was in. I had to fight the vehicle to get over to be able to exit the interstate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705607December 17, 2025
ELECTRICAL SYSTEM
I am extremely disappointed with my 2025 Volvo XC90. The vehicle’s interface shuts down frequently, which is extremely dangerous—especially at highway speeds. On several occasions, including at night, the entire system has gone completely blank. This creates a serious safety hazard and puts lives at risk. Despite repeated complaints, the dealership has been ineffective and has provided no meaningful fix. In addition, when exiting a parking position, the exterior side mirrors deploy very slowly, making it unsafe to merge into traffic or assess surrounding vehicles. This delay is another clear hazard. Most concerning, the vehicle has shut down entirely while driving on multiple occasions. This is a life-threatening defect and completely unacceptable in a vehicle of this class. I paid over $90,000 for my XC90, expecting the highest standards of safety and reliability. Instead, I regret this purchase every day. Volvo’s failure to address these critical safety issues has severely undermined my confidence in the vehicle and the brand.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704030December 9, 2025
WHEELS
Two wheels have cracked in the span of a few weeks. There was no accident or incident that could have caused the cracks. There are mentions online of this issue in several countries but Volvo has not issued a recall or warning regarding the wheel's propensity to crack. First crack was found on one wheel on 11/03/25. The second crack was found on a different wheel on 12/07/25. This vehicle was purchased from McDonald Volvo in Littleton CO on August of 2023.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701862November 28, 2025
SERVICE BRAKES, HYDRAULIC, SERVICE BRAKES
The contact owns a 2021 Volvo XC90. The contact stated that upon starting the vehicle and shifting to drive(D), the vehicle failed to respond unless the brake pedal had been released for 2-3 seconds. Additionally, the contact stated that upon starting the vehicle and releasing the brake pedal to reverse out of the driveway, the vehicle rolled back at a faster speed, and the vehicle failed to respond as intended upon depression of the brake pedal. The contact noticed a pattern with the brakes malfunction. The contact stated that the brake pedal required to be depressed 2-3 seconds after the first depression for the brakes to operate as intended. The contact stated that he was a master mechanic and had concluded that the failure was considered a safety issue because the vehicle was only designed with electronic braking, which left the driver with no manual option for braking. The contact stated that the failure had only occurred upon starting the vehicle. The contact related the failure to NHTSA Campaign Number: 25V392000 (Service Brakes, Hydraulic, Service Brakes); however, the VIN was not included. The vehicle was taken to the dealer, where it was diagnosed that the brakes had failed and Software Update Number: 3.5.14 was needed. The vehicle was not repaired. The manufacturer was informed of the failure, and it was confirmed that the repair was not covered under the recall or under warranty. The failure mileage was approximately 78,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701532November 25, 2025
VISIBILITY/WIPER
The rear passenger windows have a defective haze in the glass that distorts and reduces clarity of visibility. Issue reported to dealership and VOLVO USA yet no resolution. Research indicates that this is a concern with various models - some dealers are replacing the glass, others claim this is normal.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700143November 18, 2025
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
While driving in a parking lot going around 15 mph my drivers side door opened. No warning, no alarms just fully ajar swung open. Fortunately I was going 15 mph, Im glad I had my seatbelt on and that no one was crossing or passing when the door flung open. Ive documented and recorded my ability to begin driving and open the door including ability to open the door while reversing. I took the suv to volvo and the electrical wiring was replaced along with the door hinges.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698134November 7, 2025
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Odometer Fraud. The contact purchased a 2023 Volvo XC90 on [XXX]. The vehicle was purchased from Guaranteed Motor Cars in Palos Hills, IL. The contact discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 39,019. The contact took the vehicle to the dealer for repairs. When the instrument cluster was installed, it was discovered that the mileage was 111,914. The contact filed a complaint with the State Attorney General's Office. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697931November 6, 2025
VISIBILITY/WIPER, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
We lease this car from Volvo and are the first and only owners of the vehicle. No history of collision or accidents. The vehicle has a rear backup camera. The camera system also allows the option to select a 360-degree, top down "birds-eye" view of the entire vehicle. The backup camera turns on automatically when the car is shifted into reverse and originally provided a normal view directly behind the vehicle that extended at least a car length or more. At some point, we noticed that the rear backup camera view changed and was angled sharply down to the ground, including a partial view of our rear license plate and back bumper. The view now extends less than 7 feet behind the vehicle, angled down from the height of the camera (40-inches) so we can only see inches above the ground just a few feet behind the car. We can no longer see approaching vehicles, pedestrians, or any obstacles. The service technicians suggested this change in camera angle resulted from a routine system software update that was automatically downloaded to the vehicle. I don't know exactly when that occurred. On June 27, 2025 we received a safety recall notice from Volvo - Recall R10320 - warning us that the rear-view camera image may not show during the start of a backing event. We installed the recommended "Over the Air" software update, but that did not resolve our problem. I took the car to a local Volvo dealership on 9/26/25. They tried software upgrades and reboots, confirmed that the camera hardware was operating correctly, and told me that they could not fix it. They suggested I file a complaint with Volvo. I did that on 10/3/25. The only response to my claim was to "contact your dealer to make an appointment," which I told them I had already done. I have followed up twice since and Volvo has not responded further to this complaint ID #: 251002-000556. The incident date provided below is approximate. I don't recall when exactly the camera view changed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697846November 6, 2025
VISIBILITY/WIPER, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I was backing out of my drive. It was an early morning and it was very foggy. The windows were foggy and not totally defrosted yet. My camera wasnt showing everything around but we were having constant upgrade issues during this week of October 5th through the 10th. My automatic braking never activated even though it was turned on. I ran into a cattle feeder overhang. I never seen it in my camera view. The windows seem to have a really bad fog to them. My back driver tail-light got broken and back driver panel got dented and scratched. There are probably more things involved as its in the shop as I am typing this out. The adjustor had to send another estimate to my insurance company for more damages done. I haven't gotten word back from them yet. But, it's over $3,000. All of the issues seemed to resolve after the update was finished after that week. My automatic braking worked after that.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11696466October 29, 2025
UNKNOWN OR OTHER
There is a flaw in Volvo sunroof drains. There are class action lawsuits because of this. 6 months after purchasing my car, there was a leak into my car due to a clogged sunroof drains causing damage to electronics and potentially to computers within the car. I fixed it at a quote of over $2k. Volvo refused to cover it under my warranty. Now, 6 months after the fix, the SAME issue is happening.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691939October 7, 2025
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
My 2023 Volvo xc90 was recalled for issues with the backup camera. Software update was installed twice without success. Finally camera was replaced. No success either.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691492October 5, 2025
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, AIR BAGS
Safety Complaint – Volvo XC90 Electrical and Airbag Malfunction Issues I am reporting ongoing safety concerns with my Volvo XC90 related to electrical malfunctions and unexpected engine shutdowns while driving. The vehicle has suddenly turned off multiple times, including: •Once before merging onto a highway, •Once while entering a roundabout, and •Once while driving in traffic. Each incident occurred without warning and created a hazardous situation with the potential for a collision. Additionally, the vehicle displayed an airbag malfunction warning once, raising concern about the reliability of the vehicle’s safety systems. The vehicle has been serviced multiple times, but the issues persist. I am requesting a formal investigation into these failures, as they pose a significant safety risk to the driver, passengers, and others on the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690759October 1, 2025
UNKNOWN OR OTHER
There was always an issue with the car software. On several occasions while driving the entire screen will black out. I would need to pull over immediately so that the screen can be reset manually. Other times the screen is on, but there is no sound, such as my signal lights when switched to left or right will not have any sound, just blinking. Other times, when I back up the car, the cameras will blackout making it impossible to know if there are cars approaching or any pedestrians behind the car. This has happened on multiple occasions since I took the car on Oct 15 2023. These issues were brought to the attention of the Volvo dealership where the car is leased, but the problem was never fixed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688979September 22, 2025
UNKNOWN OR OTHER, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
My car is a 2022 Volvo hybrid T8, 6-passenger XC90. I purchased the SUV in August of 2023 as a "certified pre-owned" vehicle with only 17,923 miles on it at the time of purchase. This SUV has been fine until within the last two to three months (July-Sept. 2025). Now, in Sept. of 2025, my SUV only has 30,795 miles and we have had it serviced regularly, as required, and taken care of it as responsible vehicle owners. Beginning around June or July of 2025, I began seeing the "check engine" light, so I called the dealership where I purchased the vehicle and took it in for servicing. After a day, they said it was fixed and that it was a blown fuse or two, and it was good to go. Not even 3 weeks to a month later, the "check engine" light came on again. I called and took it back to the dealership. Same story, after less than a day they called me back after fixing something else (don't remember off the top of my head what they said it was, but it was allegedly minor). Now, about 3 days ago, Sept. of 2025, I began seeing the "check engine" light again, so for the 3rd time in less than 3 months I arranged for it to be serviced by the dealership again on 9/30. A day later, another "Propulsion System/maintenance required!!!" light came on as well, so I called to get servicing sooner because obviously the message is scary. I was told to bring it in, they would "work me in" but had no loaners I could use to get to and from work. So, at that point, I got my husband involved and now no one from the dealership is returning either of our calls, AND I'm being told there is no recall on my car, even though a simple google search reveals there is a recall on my same make/model/year SUV. I'm getting the same messages people got about the recall, so no clue why my vehicle isn't considered as part of the recall when I am having the SAME issues as the recalled vehicles are having. I am beyond frustrated and ready to dump this SUV if they are unable to properly repair it!!!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688622September 20, 2025
SERVICE BRAKES
The button to initiate the parking brake frequently does not work. With my foot firmly on the brake, I have had to push the Park button many times to put the vehicle in park. I have video of this incident. Other times, when not expecting it or recording video I have pressed the park button and not realized the vehicle didn’t go into park. When I released my foot on the brake the vehicle rolled forward. Thankfully no one or other vehicle was directly in front of the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687839September 17, 2025
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: WARNINGS, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
Interior car speakers stopped working which made collision audio cues not operational. During driving no blind spot audio, turn signal, and other audio was playing
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687349September 15, 2025
POWER TRAIN, ELECTRICAL SYSTEM
Some critical functions on the center display console instrument panel are freezing up while driving - we are unable to change the drive mode while the car is in motion. This has not happened before, and it is glitching a lot lately. The display has been extremely slow and unresponsive, and the problem is multiplied as all critical functions of the car are controlled through the display panel. There were no warnings issued when we tried to change the drive mode. We had to pull over to the roadside, turn off the car for 30 seconds, then restart the car to fix the issue. We have [XXX] and [XXX] ) in the car, so this is becoming increasingly risky to drive this "safe" car by Volvo. We have reported such issues with the display to our Volvo service unit multiple times, and the car has been returned to us with such issues still lingering (despite the service reloading/updating the software multiple times) for the last 6 months since March of this year. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC90