Volvo V70 Investigations

8 ODI actions on file.

• EAEA05021RECALLOpened 12/6/2005
  THROTTLE CONTROL MALFUNCTION
  VEHICLE SPEED CONTROL

  ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.

• PEPE05041CLOSEDOpened 7/26/2005
  THROTTLE CONTROL MALFUNCTION
  VEHICLE SPEED CONTROL

  PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.

• RQRQ04004RECALLOpened 6/8/2004
  HEADLIGHT FAILURE
  EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

  ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.

• PEPE02029CLOSEDOpened 3/7/2002
  PASSENGER COMPARTMENT FIRES
  ELECTRICAL SYSTEM
• PEPE00031RECALLOpened 8/15/2000
  TURN SIGNAL
  EXTERIOR LIGHTING

  There is no summary currently available

• PEPE99040CLOSEDOpened 6/7/1999
  INADVERTENT SIDE AIR BAG DEPLOYMENT
  AIR BAGS:SIDE/WINDOW
• PEPE99005CLOSEDOpened 1/15/1999
  FUEL LEAKAGE
  VEHICLE SPEED CONTROL:LINKAGES

  There is no summary currently available

• PEPE98043RECALLOpened 8/5/1998
  EXHAUST PIPE BURNS
  VEHICLE SPEED CONTROL:LINKAGES

  ODI OPENED THIS INVESTIGATION BASED ON TWO REPORTS OF CHILDREN RECEIVING BURNS ON THEIR LEG FROM THE HOT EXHAUST PIPE WHILE EXITING 1998 MODEL YEAR V70 WAGONS VIA THE REAR LIFTGATE.THESE VEHICLES WERE EQUIPPED WITH A DEALER INSTALLED REAR FACING CHILDREN'S AUXILIARY SEAT (AUXILIARY SEAT).ENTRY TO ANDEXIT FROM THE AUXILIARY SEAT IS ONLY AVAILABLE THROUGH THE REAR LIFTGATE.THE END OF THE EXHAUST PIPE, OR EXHAUST PIPE EXTENSION, ON THE V70 MODEL PROTUDES BEYOUND THE REAR BUNPER FASCIA THRUS INCREASING THE LIKELIHOOD THAT AUXILIARY SEAT OCCUPANTS WILL BURN THEMSELVES WHEN EXITING THE VEHICLE.ADDITIONALLY, A THIRD CHILD WAS ALSO BURNED ON IT'S LEG WHILE WALKING AROUND THE REAR OF THE VEHICLE.VOLVO'S ANALYSIS OF THIS ISSUE REVEALED 14 ADDITIONAL REPORTS RESULTING IN 18 INJURIES.VOLVO HAS AGREED TO CONDUCT A SAFETY RECALL ON THE AFFECTED VEHICLES.ALL REGISTERED OWNERS OF THE SUBJECT VEHICLES WILL NOTIFIED VIA FIRST CLASS MAIL, AS VOLVO CANNOT DETERMINE WHO MAY HAVE HAD AN AUXILIARY SEAT INSTALLED IN THEIR VEHICLE.THE NOTIFICATION TO ALL SUBJECT VEHICLE OWNERS WILL ALSO EFFCTIVELY INFORM THOSE OWNERS WHO MAY WISH TO HAVE AN AUXILIARY SEAT ADDED TO THEIR VEHICLES IN THE FUTURE.