Volvo S80 Complaints (2000)

318 consumer complaints on file.

#10251455December 11, 2008
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2000 VOLVO S80. THE CONTACT STATED THAT SHE WAS A BENEFICIARY OF A CLASS ACTION SETTLEMENT REGARDING A DEFECTIVE THROTTLE MODULE IN THE ENGINE. THE VOLVO DEALER WOULD NOT REPAIR THE FAILURE DUE TO THE WARRANTY LAWSUIT. THE LAWSUIT WILL EXPIRE WHENEVER THE VEHICLE BECOMES TEN YEARS OLD OR REACHES 200,000 MILES. THE FAILURE CAUSES THE ENGINE TO SURGE FROM FAST TO SLOW OR VICE VERSA. THE CONTACT STATED THAT THERE WAS NO DEALER NEARBY TO REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY STATED THAT THE COMPUTER WOULD NOT DIAGNOSE THE FAILURE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP AND THEY DETERMINED THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 108,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10248573November 12, 2008
ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED SMOKE AND PULLED THE VEHICLE OFF THE ROAD. HE OPENED THE HOOD AND NOTICED FLAMES. HE WAS UNSUCCESSFUL AT EXTINGUISHING THE FIRE AND CALLED THE FIRE DEPARTMENT, WHO STATED THAT THE COOLING FAN CAUSED AN ELECTRICAL FIRE. THE CONTACT'S MECHANIC INFORMED HIM OF A RECALL REGARDING THE COOLING FAN. THE VIN AND NHTSA CAMPAIGN ID NUMBER WERE UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 78,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10248364November 10, 2008
POWER TRAIN:AUTOMATIC TRANSMISSION, UNKNOWN OR OTHER
LAST YEAR MY S80 VOLVO STALLED ON THE HIGHWAY DUE TO AN ETM DEFECT. TWO DAYS, I EXPERIENCED ANOTHER SERIOUS SAFETY ISSUE WITH THE VOLVO. I WAS DRIVING THE CAR ON A BUSY STREET. SUDDENLY, AN ELECTRONIC MESSAGE CAME UP INDICATING A PROBLEM WITH THE AIR BAG. THEN TWO SECONDS LATER, A 'CHECK ENGINE MESSAGE' CAME UP. WITHIN ANOTHER MINUTE ANOTHER MESSAGE INDICATED 'TRANSMISSION SERVICE REQUIRED URGENTLY'. THEN WITHIN TWO MINUTES THE CAR WENT TO A LIMP MODE. THEY WERE CARS BEHIND ME. IT WAS A MIRACLE THAT WE WERE NOT INVOLVED IN AN ACCIDENT. I SEARCHED THE INTERNET AND FOUND OUT THAT MANY PEOPLE HAVE EXPERIENCED SIMILAR PROBLEMS. I FOUND MANY COMPLAINTS ONLINE RELATED TO VOLVO SUDDEN TRANSMISSION FAILURE. SOME WERE EVEN INVOLVED IN ACCIDENTS WHEN THEIR CARS SUDDENLY STOPPED. I AM WONDERING WHETHER THE GOVERNMENT HAD LOOKED AT THIS SERIOUS SAFETY HAZARD. VOLVO MUST BE AWARE OF THE DEFECT. I AM VERY CONCERNED THAT NO ONE HOLDS THEM ACCOUNTABLE AND THAT NO RECALL HAS BEEN MADE THUS FAR TO ADDRESS THIS ISSUE. I HAD THE CAR TOWED TO THE NEAREST VOLVO GARAGE. I WAS TOLD THAT THE TRANSMISSION NEEDS TO BE REPLACED. IT WILL COST $5000 TO FIX THE CAR. I CALLED VOLVO NORTH AMERICA TO REPORT THE PROBLEM. THEY DID NOT HELP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10244220October 2, 2008
SERVICE BRAKES, ELECTRIC, ENGINE AND ENGINE COOLING:COOLING SYSTEM
I AM HAVING AN ISSUE WITH MY BRAKE WARNING LIGHT/ENGINE LIGHT. I HAVE NOT HAD THE CAR A MONTH. THE WARNING MESSAGE SAYS BRAKE FAILURE STOP IMMEDIATELY. I TOOK BACK TO DEALERSHIP AND THEY SAID THAT I HAD NO FLUID. BUT IT IS STILL HAPPENING. I NOTICED THE RECALL ON THE 2000 VOLVO S-80. NOT SURE IF IS THE SAME THING, BUT IF IT IS SHOULD THE VOLVO DEALERSHIP FIX FOR FREE. THE RECALL WAS SENT OUT MARCH OF 07. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10241309September 8, 2008
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE, ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2000 VOLVO S80. WHEN APPROACHING A COMPLETE STOP, THE VEHICLE LUNGES FORWARD. SECONDLY, THE VEHICLE WOULD STALL WHILE IDLING AND THEN RESTART IMMEDIATELY. THE ENGINE LIGHT WOULD ILLUMINATE SIMULTANEOUSLY. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE EXHAUST MANIFOLD, TURBO BACK FIELD, AND TORQUE MOUNT NEEDED TO BE REPLACED, AS WELL AS PERFORM A TC-B SERVICE ALL AT THE COST OF OVER $3,320. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 193,008. UPDATED 10/07/08.*LJ UPDATED 10/08/08. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10238860August 19, 2008
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2000 VOLVO S80. WHENEVER THE VEHICLE IS AT A STOP, IT WILL SURGE FORWARD UNLESS THE CONTACT APPLIES A GREAT AMOUNT OF PRESSURE ON THE BRAKE PEDAL. ALSO, WHILE DRIVING AT ANY SPEED, THE ENGINE WILL SUDDENLY STALL AND SHUT OFF. THE VEHICLE IS ABLE TO BE RESTARTED IMMEDIATELY AFTER THE FAILURE. THE VEHICLE HAS BEEN DIAGNOSED BY THE DEALER SEVERAL TIMES, BUT THE FAILURE STILL PERSISTS. THE CURRENT MILEAGE WAS 50,300 AND FAILURE MILEAGE WAS 44,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10238890August 19, 2008
ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE, VEHICLE SPEED CONTROL
ETM (ELECTRIC THROTTLE MODULE INTAKE MANIFOLD) NEEDS TO BE REPLACED! (VOLVO ONLY HAS A VERY LIMITED EXTENDED WARRANTY ISSUED ON 4/2006. THE ETM WAS CLEANED 3 DIFFERENT TIMES SINCE 8/8/02; AND A SOFTWARE UPGRADE WAS COMPLETED ON 10/19/06. MY LAST 2 COMPLAINTS TO MY VOLVO DEALERSHIP MECHANIC HAS RESULTED IN DENIAL ON 10/19/06 AND REFUSAL TO REPAIR UNDER THE EXTENDED WARRANTY ON 8/18/08 DUE TO UNRETRIEVABLE COMPUTER CODES (VOLVO ADMITS THE PROBLEM WAS STILL AN ETM PROBLEM). [THIS HAS OCCURRED EVERY YEAR FOR THE LAST 6 YEARS!!!] ON SEVERAL OCCASIONS, ACCIDENTS ALMOST HAPPENED BECAUSE THE VEHICLE EITHER STALLS ON THE FREEWAY AT 55-60MPH, OR VEHICLE SUDDENLY SURGES AT A RED LIGHT OR STOP SIGN. ACCORDING TO VEXEDVOLVO.COM, THE REAL CAUSE IS DUE TO A WEARING OUT OF THE "POTENTIOMETER FILMS IN THE THROTTLE POSITION SENSORS". A SIMPLE ETM "CLEANING" WILL NOT SUFFICE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10238348August 15, 2008
SERVICE BRAKES, HYDRAULIC
2000 VOLVO S80 2.9L HAD ABS MODULE FAILED TWICE AT 25K MILES (2006) AND 50K (8/2008) MILES. GOTTEN CLOSE TO ACCIDENTS ESPECIALLY DURING RAIN, SNOW, OR HUMID WEATHER. COMPLAINED TO AUTHORIZED DEALER/MECHANIC AT LEAST OVER THE LAST 4 YEARS WITHOUT ANY HELP UNTIL IT REQUIRES REPAIR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10235780July 25, 2008
FUEL SYSTEM, GASOLINE
AT THE END OF JUNE OF 2008 I NOTICED THAT MY 2000 VOLVO S-80 SMELLED OF GAS. SUBSEQUENTLY, ON 06/20/2008 ABBY CAR CARE (559-438-7181) MECHANIC KEVIN DETERMINED, PER MY RECEIPT, THAT 'DIAGNOSE FUEL LEAK-FUEL LEAKING FROM THE TOP TANK FOUND DEFECTIVE AT FLANGE FOR EVAP SYSTEM LEAKING WERE IT ATTACHES TO TOP OF THE FUEL TANK NOT REPAIRABLE.' I WAS ALSO ADVISED BY KEVIN THAT THE LEAK WAS NOT CAUSED BY WEAR AND TEAR BUT WAS 'DEFECTIVE / NOT REPAIRABLE' IN NATURE. ABBY CAR CARE REPLACED THE FUEL TANK. AFTER LEARNING OF THIS LEAK AND DOING SOME RESEARCH ON THE INTERNET 'GOGGLE SEARCH ENGINE', IT APPEARS THAT OTHER VOLVO OWNERS HAVE EXPERIENCED SIMILAR PROBLEMS WITH LEAKS TO THE GAS TANKS. I DID CALL MY LOCAL VOLVO DEALER (FRESNO LINCOLN MERCURY VOLVO ' 5200 N. BLACKSTONE AVENUE FRESNO, CA 93710 TELEPHONE NUMBER 559-226-5175) AND ADVISED THEM OF MY LEAKY GAS TANK AND THEY ADVISED ME THAT THERE WAS NO RECALL AND DIDN'T SEEM TO CONCERNED WITH MY PROBLEM OTHER THAN GIVING ME THERE CUSTOMER SERVICE TOLL FREE NUMBER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10235247July 22, 2008
ENGINE AND ENGINE COOLING, ENGINE AND ENGINE COOLING:COOLING SYSTEM
PAPERWORK WAS COMPLETED, I WAS ON MY WAY OUT, THE SALESMAN SAID, "MAKE SURE YOU PUT SOME OIL IN THE ENGINE, IT HAS NO OIL, WE DIDN'T HAVE A CHANCE TO INSPECT THE CAR." HE WENT ON TO SAY, "BRING IT IN SOMETIME NEXT WEEK AND WE'LL INSPECT IT."CAR WAS BROUGHT IN FOLLOWING WEEK, THEY HAD NO TIME TO INSPECT IT. IT WENT ON FOR THREE WEEKS. THE ENGINE TEMPERATURE WOULD RISE VERY QUICKLY, I PULLED OVER AND TURNED OFF THE CAR. THIS HAPPENED FIVE TIMES. IT WAS BROUGHT TO A SEPARATE CAR REPAIR SHOP AND THEY CONCLUDED THAT THE CARS ECM (ELECTRONIC COMPUTER MODULE) ISN'T WORKING CORRECTLY. NONE OF THE GAUGES ARE CORRECT, INCLUDING THE GAS AND ENGINE TEMPERATURE GAUGE. THEY SAID THAT THE ENGINE COULD BE OVERHEATING AND IT WOULDN'T SHOW UP ON THE COMPUTER, OR IT MIGHT NOT BE OVERHEATING AND IT MIGHT SHOW UP AS OVERHEATING. THEN THE DEALER DID THEIR INSPECTION AND SAID THAT THE CAR WAS "FINE." I ASKED FOR DIAGNOSTIC RESULTS AND THEY SAID THAT THEY HAVE NO WAY OF PRINTING THEIR DIAGNOSTIC RESULTS. LATER, THE CAR STARTED SAYING "HIGH ENGINE TEMP" AGAIN. I ARRIVED AT THE DEALERSHIP AND TOLD THEM THE PROBLEM. ONE OF THE SALES MEN TOOK THE CAR ON A TEST DRIVE. ON THE FREEWAY, THE CAR WAS DOING JUST FINE. ONCE THE CAR WAS GOING ABOUT 35MPH IT STARTED SIGNALING OVERHEATING. BACK AT THE DEALERSHIP THE SALESMAN LEFT THE CAR RUNNING WHILE THE CAR WAS STATING IN THE DASH "HIGH ENGINE TEMP." THEY PROCEEDED TO LET THE CAR RUN. THE SALESMAN SHUT OFF THE VEHICLE, OPENED THE HOOD AND SMOKE WAS RISING OUT OF EVERYWHERE AND ALL THE COOLANT PIPES BLEW AND COOLANT WAS LEAKING EVERYWHERE. I WAS IN SHOCK. THEY BASICALLY BLEW UP MY CAR. I WALKED INSIDE AND THE SALESMAN COMMENTED TO ME, "I DID THAT SO HE [THE DEALER] WOULD GIVE YOU ANOTHER CAR."THE DEALER REFUSED TO TAKE THE CAR BACK. THEY STATED THAT THE ONLY THING THAT NEEDED TO BE FIXED WAS A "FAN CONTROL" BECAUSE THE FAN WASN'T WORKING PROPERLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10234702July 17, 2008
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE, ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2000 VOLVO S80. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD SPONTANEOUSLY DECELERATE. PRIOR TO THE FAILURE, THE ENGINE AND BRAKE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE DEALER STATED THAT THE ABS MODULE NEEDED TO BE REPLACED AT THE COST OF $1,500. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 107,000. UPDATED 09/23/08. *LJ UPDATED 09/24/08. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10234275July 14, 2008
SERVICE BRAKES, HYDRAULIC
MY WIFE LEFT FOR WORK & GOT TO THE END OF THE DRIVEWAY & HAD NO BRAKE ASSIST IE VERY HARD PEDAL. THIS OCCURRED WITHOUT WARNING(NO WARNING LIGHTS,ETC).SHE PARKED THE VEHICLE&TOOK ANOTHER TO GET TO WORK(RN).I LATER DROVE THE CAR,BRAKES WORKED FINE. THE NEXT DAY I DROVE IT AGAIN & NO POWER BRAKES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10229936June 4, 2008
ELECTRICAL SYSTEM
AS I UNDERSTAND IT, THE ELECTRONIC THROTTLE MODULE (ETM) ON MY 2000 VOLVO S80 IS IN THE PROCESS OF FAILING. TWO YEARS AGO, I HAD MY VEHICLE SERVICED WHEN IT BEGAN SURGING FORWARD WHEN IDLING, EVEN WHEN I WAS BRAKING. AN ETM SOFTWARE UPGRADE WAS DONE AT THAT TIME AND THE ETM WAS CLEANED. NOW, JUST SHORT OF TWO YEARS LATER, I AM HAVING EXACTLY THE SAME PROBLEM AGAIN. AS I AM COMING TO A STOP, MY VEHICLE WILL SUDDENLY AND UNEXPECTEDLY SURGE FORWARD, EVEN WHEN MY FOOT IS ON THE BRAKE. I AM PETRIFIED THAT I AM GOING TO STRIKE THE BACK OF ANOTHER VEHICLE BEFORE I CAN ARRANGE TO GET MY CAR IN FOR SERVICE. FURTHER, WHEN I PUT MY CAR IN PARK OR USE THE AC SYSTEM, MY CAR COMES TO A NEAR STALL AND JUST LURCHES ALL OVER THE PLACE. IT SIMPLY CANNOT MAINTAIN AN EVEN IDLE WHEN IN PARK. LAST WEEK, FOR THE FIRST TIME, I BECAME AWARE OF THE NOVEMBER 2006 RECALL CONCERNING ETMS. THIS LED ME TO LOOK AT MY OLD SERVICE RECORDS, SINCE I WAS HAVING THE SAME FRIGHTENING PROBLEM THAT I HAD TWO YEARS AGO. SURE ENOUGH, THERE IT WAS AGAIN - "CUSTOMER STATES AT IDLE REVS UP AND SURGES." I HAVE ALREADY PAID FOR THIS REPAIR ONCE. THIS IS AN EXTREMELY SERIOUS MATTER AND MY VEHICLE SIMPLY IS NOT SAFE TO DRIVE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10228654May 22, 2008
VEHICLE SPEED CONTROL, SUSPENSION
TL*THE CONTACT OWNS A 2000 VOLVO S80. THE CONTACT EXPERIENCED TWO FAILURES LISTED AS RECALLS FOR THE SUSPENSION AND VEHICLE SPEED CONTROL. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN THE RECALLS. HE IS VERY UPSET WITH BEING EXCLUDED FROM THE RECALLS BECAUSE THE FAILURES ARE IDENTICAL. WHILE PROCEEDING TO MAKE A LEFT TURN AT APPROXIMATELY 5 MPH, THE TIRE DETACHED FROM THE FRONT DRIVER SIDE OF THE VEHICLE. THE CONTACT FELT THAT THIS WAS A VERY SERIOUS SAFETY HAZARD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND THE WHEEL AXLE, LOWER CONTROL ARM, AND UPPER BALL JOINT WERE REPLACED. THE CONTACT ALSO OBSERVED THE FAILURE OF THE SPEED CONTROL MECHANISM. WHILE DRIVING BETWEEN 55-60 MPH AND APPLYING PRESSURE TO THE ACCELERATOR PEDAL, THE VEHICLE DECELERATED AND HESITATED. THIS FAILURE OCCURS ONLY DURING HIGHWAY DRIVING. THE VEHICLE HAS NOT BEEN REPAIRED FOR THIS FAILURE. THE RECALL NUMBERS WERE UNKNOWN. THE FAILURE MILEAGE WAS 53,000 AND THE CURRENT MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10224770April 16, 2008
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
MY 2000 VOLVO S80 HAS FAILED TO ACCELERATE PROPERLY. IN IDLE, IT SOMETIMES WORKS FINE, BUT AT OTHER TIMES IT IDLES ERRATICALLY. SEVERAL TIMES RECENTLY, I'VE NEEDED TO ACCELERATE QUICKLY, BUT THE CAR HESITATED AND DISPLAYED THE CHECK ENGINE LIGHT. A FEW TIMES, I ATTEMPTED TO ACCELERATE ANYWAY, AND THE LIGHT WOULD BEGIN TO BLINK, AND THE CAR WOULD STILL SPUTTER. THIS CREATED A DANGEROUS SITUATION FOR ME AND MY FAMILY. I HAD THE SPARK PLUGS REPLACED BUT THAT DID NOT FIX THE PROBLEM. I LEARNED RECENTLY THAT THIS IS INDICATIVE OF A FAILED ETM (ELECTRONIC THROTTLE MODULE), WHICH HAS BEEN AN ISSUE WITH THIS MODEL CAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10223098April 2, 2008
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
THE DEALER ALSO MADE A LIFE THREATENING MISTAKE BY SCREWING IN THE POWER STEERING PIPE AND LOSING POWER STEERING. THIS CAUSED A BAD NOISE AND A LIFE THREATENING SITUATION WITH MY CAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10217634February 11, 2008
VISIBILITY:SUN/MOON ROOF ASSEMBLY
I OWN A 2000 VOLVO S-80. WHILE PROCEEDING THROUGH AUTOMATIC CAR WASH, THE SUNROOF SHATTERED DURING THE BLOWER/DRYER OPERATION. CAR WASH MANAGER INFORMED ME THAT THESE MODELS HAVE A PROPENSITY TO BREAK AT THE SAME SPOT IN THE CAR WASH PROCESS. HE STATED THAT VOLVO REPLACES THE SUNROOF UNDER WARRANTY, BUT WHEN I CONTACTED VOLVO, THEY DENIED ANY KNOWLEDGE OF THE PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10214883January 15, 2008
AIR BAGS, SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
SRS AIRBAG FAILURE AND ABS BRAKE WARNING LIGHTS AND ALERTS POSTED ON DASHBOARD DISPLAY. TURNS OUT THE PROBLEM WAS DEFECTIVE SOFTWARE AND WAS RESOLVED WITH A SOFTWARE UPDATE. THIS IS A CRITICAL SAFETY ISSUE SINCE THE FAILURE RESULTS IN THE DISABLING OF THE SYSTEMS. THE PROBLEM WAS DIAGNOSED AND FIXED IN ABOUT AN HOUR. VOLVO CLEARLY NEW ABOUT THIS PROBLEMS SINCE THE SOFTWARE UPGRADE (AKA A FIX) WAS ALREADY COMPLETED AND AVAILABLE - VOLVO HAD TO PAY SOMEONE TO FIX THE SOFTWARE, WHY PAY THEM IF THERE WAS NO DEFECT. I BELIEVE THIS SAFETY ISSUE SHOULD BE AT LEAST ADVISED IF NOT MANDATORY FOR ALL OWNERS OF THESE VEHICLES. IT IS A SIMPLE EASY WAY TO AVOID A TRAGEDY IF THESE SYSTEMS ARE DISABLED BY DEFECTIVE SOFTWARE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10213987January 6, 2008
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE, FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP, PARKING BRAKE, EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH, SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP, STRUCTURE:BODY, POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
1) ENGINE IDLES ROUGH, PROBLEM BECAME SO BAD THAT CAR STALLS AT LOW SPEEDS, LOST POWER STEERING & "ENGINE DIES" AT LOW SPEEDS (UNSAFE!). LOCAL MECH REFERRED TO ETM WARRANTY PROGRAM TO RE-PROGRAM FAULTY ETM MODULE. TOOK CAR TO DLR, RE-PROGRAMMED ETM CAR DIED AGAIN! TURNS OUT BAD BATTERY AS WELL: SEVERAL HUNDRED $$$ TO REPLACE BATTERY. CAR DOES NOT ACCELERATE SMOOTHLY, LARGE "SHUDDERS" PRESENT WHEN MERGING ONTO HWY, DURING TRANSMISSION/GEAR SHIFT. NOT GOOD! 2) AIRBAG "SRS-URGENT SERVICE" WARNING INDICATOR LIGHT IS ON. GOOD LOCAL MECH. STATES THIS IS A $1000 REPAIR. 3) "CHECK BRAKE LIGHT" WARNING INDICATOR LIGHT TURNS ON WHEN DEPRESSING ON BRAKE PEDAL: GOOD LOCAL MECH. STATES THAT THIS IS "NORMAL" REQUIRES EXACT MATCHING ELECTRICAL RESISTANCE OF ALL BRAKE LAMPS TO ENSURE THAT "CHECK BRAKE LIGHT" WARNING DOES NOT OCCUR (IN ACTUALITY THE BRAKE LIGHTS WORK FINE, THE BUILT-IN-TEST IS FAULTY). 4) "CHECK ENGINE LIGHT" COMES ON 2-3 TIMES IN LAST 3 MONTHS. MAJOR SERVICE WAS REQUIRED. ONE FAULT WAS ISOLATED TO FUEL TANK GAS CAP: IF NOT SECURED PROPERLY "ECM-4308 (LEAK DIAGNOSTIC) LARGE LEAK" OCCURS...REMEDIED BY TWISTING FUEL CAP 3 FULL ROTATIONS, AFTER RE-FUELING GAS TANK. GOOD LOCAL MECH. DIAGNOSED THE LOOSE GAS CAP PROBLEM, WARNED ME ABOUT IT, AND DIDN'T CHARGE ME (NICE!). 5) BODY PAINT IS VERY SUSCEPTIBLE TO CHIPPING & SCRATCHES. PAINT OR EXTERIOR PANELS ARE VERY SOFT AND EASILY DAMAGED. ANOTHER SHAME, THIS CAR LOOKS GREAT BUT DOES NOT HOLD UP VERY WELL UNDER TYPICAL PARKING LOT CONDITIONS (I.E. SOMEONE PARKED NEXT TO YOU OPENS THEIR CAR DOOR INTO THE SIDE OF YOUR CAR RESULTING IN A LARGE SCRATCH). SOLUTION: PURCHASE A FANCY CAR COVER AND PROTECT THE BODY PAINT, IF YOU CAN! 6) PARKING BRAKE "SEEMS LOOSE", UPON PARKING CAR AND ENGAGING PARKING BRAKE THE VEHICLE ROLLS ALMOST 30 CM BWDS OR FWD DEPENDING ON LEVEL OR INCLINED SURFACE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10212290December 19, 2007
VISIBILITY:SUN/MOON ROOF ASSEMBLY
MY WIFE WAS DRIVING THE VEHICLE AND I WAS A PASSENGER. WHEN ATTEMPTING TO OPEN THE SUNROOF AND WHEN IT WAS ABOUT 1/4 OPENED, A STEEL BAR, ABOUT 26 INCHES IN LENGTH CAME OUT OF THE ROOF OPENING AND HIT MY WIFE ON THE RIGHT SIDE OF HER HEAD WHILE SHE WAS DRIVING. THE GLASS DID NOT BREAK ONLY THE METAL BAR THAT WAS GLUED TO THE GLASS CAME LOOSE AND FELL OUT. HAD SHE TURNED HER HEAD IN MY DIRECTION, THE BAR COULD HAVE CAUSED SERIOUS INJURY AND EVEN COULD HAVE HIT ONE OF HER EYES. THIS METAL BAR WAS ATTACHED TO THE LEADING EDGE OF THE GLASS. NO ACCIDENT OR SERIOUS INJURY OTHER THAN BRUISED SKIN OCCURRED. ON NOV 29TH THE CAR WAS TAKEN TO THE DEALER TO BE EVALUATED AND SPOKE TO THE SERVICE MANAGER WHO SAID HE NEVER HEARD OF THIS HAPPENING BEFORE. WHEN HE CALLED A MECHANIC OVER TO ASK HIS OPINION, THE MECHANIC STATED THAT THEY JUST REPLACED A SUNROOF GLASS ON A SIMILAR CAR THE PREVIOUS WEEK WITH THE SAME PROBLEM. THE SERVICE MANAGER ONLY SAID THAT IF THE GLASS WAS REPLACED, IT WOULD BE VERY COSTLY. NO OFFER WAS MADE TO REPAIR OR REPLACE WITH A BETTER PART. THIS INCIDENT COULD HAVE CAUSED A SERIOUS OR DEADLY ACCIDENT. *TR
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0

← Back to Volvo S80