Toyota Tacoma Complaints

8,484 consumer complaints on file.

#11520665May 5, 2023
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owned a 2003 Toyota Tacoma. The contact stated that while driving up the driveway at 5 MPH and turning into the garage, the accelerator pedal was depressed but went down to the floorboard and became stuck. The contact lost control of the vehicle, and the vehicle crashed into the fence gate and the corner of the neighbor's residence. The air bags did not deploy. There was no injury sustained. There was no police report filed. The vehicle was towed to a salvage yard, where it was totaled. The contact related the failure to NHTSA Campaign Number: 09V388000 (Vehicle Speed Control). The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 230,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11519611April 29, 2023
POWER TRAIN, ENGINE
The engine part “Coolant bypass joint” failed, started leaking coolant at 44k miles, because it was made of inferior plastic material, unlike the same part used in the same 3.5L V6 engines in the Lexus vehicles, which are made of aluminum. This is a widespread failure since 2016 model years, and Toyota refused change the design or manufacturing material of the part, or to repair it under warranty. The part number for this failed part is 16356-31051.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519552April 29, 2023
POWER TRAIN
Transmission pops out of 2nd gear everyday after setting on level ground. I have questioned Toyota about the fluid levels, which they say its a sealed unit and cant be checked. It takes about 20 feet before the transmission rengages. It only happens when the transmission temperature is cold, then does not happen again. This can leave me without any power. Toyota has checked the vehicle twice and cannot duplicate the issue. The issue started shortly after i bought the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519541April 29, 2023
AIR BAGS, SERVICE BRAKES
My vehicle was T-boned while driving through an intersection. After being hit, my vehicle continued moving forward, but the brakes would not engage or work. I pressed them several times and as firmly as possible, but the vehicle would not stop or slow down. As I approached a nearby curb, I pulled the emergency brake, which slowed down my vehicle slightly before colliding head-on with a fire hydrant and utility pole. The impact completely totaled the vehicle, yet the airbags did not deploy. Bottom line, in period of a few seconds, the brakes completely failed and the airbags did not deploy. The end result could have been devastating, but fortunately was not. The vehicle is set to be released to the insurance representative soon, but no analysis has been completed. A police report was filed. The vehicle is brand new (less than 2 months old) and no indications of fault or malfunction occurred prior to the incident.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11519489April 28, 2023
POWER TRAIN
While driving my Tacoma truck it has gone into "limp mode" (looses power and you can get but about 25mph) when I have pulled out into traffic 5 times over the last 3 years. I took it to a Toyota dealership on 4/28/2023 for evaluation but no codes where found to indicate a problem. When the truck goes into limp mode I pull over and cut the engine off. I immediately turn the engine back on and the truck operates normally. I know this is a protective system but if you are pulling out into traffic and the truck goes into limp mode for no good reason, it could result in an accident. In addition, the trucks computer system is not registering the event. I haven't noticed any warning lamps, messages prior to the failure. I did notice that the truck shuck prior to going into limp mode.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518998April 26, 2023
SUSPENSION
Lower ball joint detached, nearly caused major problems for me on the road
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518716April 24, 2023
FUEL/PROPULSION SYSTEM
I received a notice from Toyota Motor Corporation that certain 2011-2017 Model Year Tacoma Vehicles should be brought in for a Frame Corrosion Inspection. Subsequent to this inspection, the dealership could recommend either an application of Corrosion Resistant Compound OR an entire Frame replacement. My vehicle's Frame was severe enough to qualify for replacement, BUT, the dealership indicated that the Fuel Tank Band holding the fuel tank in place was sufficiently rusted that it should be replaced to the tune of $421.58 If this item is a safety issue, I'd think it would be subject to recall and replacement. Please advise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517602April 18, 2023
VISIBILITY/WIPER
In March, 2022, we had ice that coated the car and the driveway of my residence that led to schools being closed. The next day conditions were better, and on my way home from work I noticed that the passenger side view mirror had developed a strange crack that at first made me think that a sticker had been placed on the mirror. When I examined it closer, I found it to be a crack in the mirror that I tend to think was the result of the icing from the previous day. My concern is that the crack will spread and make the mirror unusable. I discussed this with my service advisor at Wilde Toyota in Milwaukee on 4/11/22 and told him that I felt the crack was a manufacturers defect. The advisor told me that they would not cover the damage as a defect, but that he had taken photos and sent the information to Toyota for consideration. The paperwork provided to me did not confirm or state that anything had been sent to Toyota.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11517499April 17, 2023
SUSPENSION, STRUCTURE:FRAME AND MEMBERS
The contact owns a 2006 Toyota Tacoma. The contact stated that after the vehicle was taken to a local dealer for unrelated repairs, the mechanic determined that the rear subframe needed to be replaced. The contact was made aware of NHTSA Campaign Number: 14V604000 (Suspension); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The approximate failure mileage was 178,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516515April 11, 2023
POWER TRAIN
I was driving and all of the sudden I felt a vibration when I let off the gas...I checked under and saw that the drive shaft/yoke was separated a little, so I decided not to drive it anymore and to disassemble it and found out that the lock nut is missing and more likely it came off. I've noticed that no sign that the lock been staked to lock in position (picture attached)...this is a near miss and could possibly there are more like this on the road that could lead to a very serious accident if this comes off while running in high speed. I bought this car in 2005 brand new, and I know for sure that this never been work on...I am a mechanic myself so I does the Maintenace to all my cars...I just want to make the company aware to prevent any possible serious accident...I owe 5 Toyota cars and I know one of the best and safest vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516361April 10, 2023
STRUCTURE:BODY
I purchased this vehicle on 12/16/2019 with 20,990 miles on it. Now the vehicle has 33,000 miles on it and I was told by an independent service station that I have a large hole in the frame. I brought the truck on 4/07/2023 to a Toyota dealer and they said the recall for a new frame expired 12 years after the vehicle was purchased. I called Toyota and they told me the same thing. I had know idea that these trucks had frame rust issues when I bought it. I read that Canada received a 3 year extension to 15 years on Tacoma 2009 trucks with mileage under 36,000, I have only 33,000 miles. Please help!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516223April 10, 2023
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Auto Emergency Braking has gotten extremely dangerous and locking breaks when nothing is in front of me. Always while in cruise control mode. On long extended highways, the truck will randomly slam on the brakes and skid the back tires. It has happened 6 times now. This most recent one made us slide into the next lane and I had to turn the truck into a field (~20mph) after the truck brakes went off. To avoid on coming traffic. There was a car turning around half a mile ahead and was nowhere close. Additionally, a severe issue of premature rust and degradation is occurring on the truck. 13,000 miles and the bottom looks like it's been on the road for several years.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516201April 9, 2023
ENGINE, ELECTRICAL SYSTEM, UNKNOWN OR OTHER
TRAC OFF & ENGINE lights came on. Removed gas cap and put it back on. Removed cables to the battery and left them off. Replaced battery cables. Lights remain on. Went to dealership and they charged $100 to scan vehicle. They don't know what's wrong and said it'd be another $800 to check further. They said maybe a rodent had chewed through a cable??? Have seen several reports of this vehicle condition and the battery cable resetting took care of the problem a lot of the time. Not this time. Don't feel comfortable A. driving the truck with these lights on and B. Don't feel comfortable with handing over $800 for them to look into it. What to do?????????????
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516219April 9, 2023
ENGINE
It has been well established among 2016 and up Toyota Tacoma owners and clubs that the Rear Coolant Bypass Joint leaks at different mileages, If the loss of coolant happens rapidly enough the engine could overheat and siez up and cause the pistions to weld to the cylinders along with causing extensive engine damage not to mention how the driver would handel the truck, Toyota dealerships and Manufacture also know of This Coolant Bypass joint leak and how common it is. Also the corrosive build up from the antifreeze will cause other parts and wires to not work, Attached is my part and the build up of antifreez before the leak,
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11516149April 9, 2023
SERVICE BRAKES
I was at a stop light and when the light turn green I started driving forward and the ABS/ Brake lights on instrument cluster came on with repeated blinking. I slowed off the gas to apply the brakes. Brake pedal went to the floor with no brakes or slowing down at all. Luckily no one was in front of me and I had to pull the emergency brake. It was the only brakes I had at all. Once vehicle was towed to the nearest Toyota Dealer I had them diagnose the problem. Right rear wheel had leaked out fluid due to the rear brake cylinder failing. Upon repair of all brake pads, rotors, brake shoes, brake drums, both rear brake cylinders the problem was still an issue. Costly amounts of money already being spent to find out another failure with the Brake Master Cylinder/ Module. That part alone is also very expensive. Research has shown that the 2018 and 2019 Toyota Tacoma’s did have history of faulty brakes in turn possibly causing an accident. For my case on the road I was lucky. I can’t understand a loyal customer of years with Toyota that the company refuses any sort of aid and assistance in the matter. Why did the recalls end? Especially if this affected not just the 2018 model but the 2019 model like my Tacoma as well. For such low miles and no abuse this vehicle has faced other failures not only with the brakes alone. Vehicle is still with the Dealer at this time. Requesting some assistance in the matter please. Thank you!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515941April 7, 2023
VEHICLE SPEED CONTROL
The contact owns a 2015 Toyota Tacoma. The contact stated while her husband was depressing the brake pedal, the vehicle accelerated independently. The contact stated no warning light was illuminated. The driver was able to regain control of the vehicle and continued driving to the residence but experienced the failure for second time. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the air filter, the intake box, the throttle body, and the fuel injectors to be replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was 85,599.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515510April 5, 2023
UNKNOWN OR OTHER
The frame is rusted out and now it wont pass inspection in PA.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515564April 5, 2023
TIRES, TIRES:TREAD/BELT
We purchased a set of these tires at the end of June and have only about 15,000mi on them now. The embossed tire wear indicators show more than the 80% tread life left. About two weeks or so ago, I noticed a blister on the tire. Looking at it, there were a few tread blocks separating from the carcass. Yes, separation like what caused issues with Firestone and Ford Explorers a while ago! Pictures attached. I tried reaching out directly to Nokian and received no reply. I then tried to contact the seller (Budget Center) and Amazon. Initially, Amazon was helpful and the seller told me to go check at a local store. Now, Amazon says there is nothing that they will do and I have to go through Nokian on my own. Note that I was not asking for a refund, only help contacting Nokian. We have purchased several sets of tires from Amazon and will never again if this is how they handle warrantable defects. Shameful! The consumer was able to get in contact with the manufacture and the new tire is now installed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515122April 3, 2023
ENGINE, FUEL/PROPULSION SYSTEM
When starting vehicle (2015 Tacoma TRD Sport) on a cold morning, received check engine light and trac light. Used code reader and received code P0418 Secondary Air Injection System Control A Circuit error. I reset the code and it came back immediately. I did some research and it is a known issue. I also contacted a local Toyota Dealer (Kool Toyota) and they stated there is no open recalls on my vehicle and that they have replaced this on some vehicles but mine is not included on the recall. In review this is a known issue with the Secondary Air Injection System failing with Tacomas yet Toyota fails to do anything about it. It is an expensive fix for a known issue. Toyota has recalled 2012s and have a service notice for a fix but it is expensive. The Service notice was created because of the issue however they fail to do anything about it besides a service notice.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11515096April 3, 2023
FUEL/PROPULSION SYSTEM
Front part of fuel tank dropped apparently due to corrosion. Electrical and fluid connections to fuel tank were disconnected when the tank dropped. Negligible fuel spill. Vehicle was towed from the scene. Driving on dirt road at the time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma