Ram 3500 Service Bulletins (2016)
490 manufacturer communications on file.
- April 16, 2021•Document ID: 10221150Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- S1821000001
- Date Added:
- September 26, 2022
- Manufacturer:
- JEEP
SummaryGear Ratio DTC?s, Transmission Shift Concerns, Does Not Shift At Times, Shudders
Associated Products (251)2021 Alfa Romeo Stelvio2021 Chrysler 3002021 Chrysler Pacifica2021 Chrysler Voyager2021 Dodge Challenger2021 Dodge Charger2021 Dodge Durango2021 Fiat 500X2021 Jeep Cherokee2021 Jeep Compass2021 Jeep Gladiator2021 Jeep Grand Cherokee2021 Jeep Grand Wagoneer2021 Jeep Renegade2021 Jeep Wrangler2021 Ram 15002021 Ram 25002021 Ram 35002021 Ram 45002021 Ram 5500+ 231 moreAssociated Documents - April 7, 2021•Document ID: 10221097Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 9004009
- Date Added:
- September 26, 2022
- Manufacturer:
- JEEP
SummaryTransmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles. If the transmission bracket to the transmission case fasteners are removed during servicing, the fasteners (Part Number 06511385A$) are one-time usage. Vehicles built prior to 10/23/2015 requires Service Kit PN 68461214AA; includes Transmission Isolator PN 68264483AA, and Adaptation Bracket 68264479AA and Fastener Service Kit PN 68329056AA Vehicles built after on or after 10/23/2015 will require only the Fastener Service Kit PN 68329056AA. 2. All 3.6L/62TE equipped vehicles. If the vehicle you are repairing has a crack in the flex plate or failed pump bushing inspect and confirm that both (2) dowel pins are present in the engine block, which align the transmission center line to the crank shaft centerline and visually inspect the dowel alignment holes in the transmission case. If the holes are damaged or elongated the transmission should be replaced to prevent further damage to the transmission/flexplate or pump bushing due to the inability to properly align the engine to the transmission during the repair. 3. All 62TE equipped vehicles. If pump bushing is scored or damaged and the dowel pin alignment holes are ok, replace the pump assembly as opposed to complete transmission. 4. All 62TE equipped vehicles. If vehicle is jerking/slipping with MIL code(s) P0740 or P2764, check TCC Solenoid operation. If TCC Solenoid is ok, the codes are indicative of a torque converter failure. Replace the torque converter.
Associated Products (448)2022 Alfa Romeo Stelvio2022 Chrysler 3002022 Chrysler Pacifica2022 Chrysler Voyager2022 Dodge Challenger2022 Dodge Charger2022 Dodge Durango2022 Dodge Journey2022 Jeep Cherokee2022 Jeep Compass2022 Jeep Gladiator2022 Jeep Grand Cherokee2022 Jeep Grand Wagoneer2022 Jeep Renegade2022 Jeep Wagoneer2022 Jeep Wrangler2022 Ram 15002022 Ram 25002022 Ram 35002022 Ram 4500+ 428 moreAssociated Documents - March 31, 2021•Document ID: 10220922Service Bulletin/Repair InstructionsVISIBILITY
- Mfr Comm. #:
- S1723000001RevC
- Date Added:
- September 26, 2022
- Manufacturer:
- RAM
SummaryLeft Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger
Associated Products (34)2021 Chrysler Pacifica2021 Ram 15002021 Ram 25002021 Ram 35002020 Chrysler Pacifica2020 Ram 15002019 Chrysler Pacifica2019 Ram 15002019 Ram 25002019 Ram 35002019 Ram 45002019 Ram 55002018 Chrysler Pacifica2018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002018 Ram 55002017 Chrysler Pacifica2017 Ram 1500+ 14 moreAssociated Documents - March 31, 2021•Document ID: 10190669Service Bulletin/Repair InstructionsVISIBILITY
- Mfr Comm. #:
- S1723000001 Rev.
- Date Added:
- April 26, 2021
- Manufacturer:
- RAM
SummaryLeft Hand Drivers Side Mirror Takes Longer to Defrost Or Clear Than Right Side Passenger
Associated Products (30)2021 Chrysler Pacifica2021 Ram 15002021 Ram 25002021 Ram 35002021 Ram 45002020 Chrysler Pacifica2020 Ram 15002019 Chrysler Pacifica2019 Ram 15002019 Ram 25002019 Ram 35002019 Ram 45002018 Chrysler Pacifica2018 Ram 15002018 Ram 25002018 Ram 35002018 Ram 45002017 Chrysler Pacifica2017 Ram 15002017 Ram 2500+ 10 moreAssociated Documents - March 31, 2021•Document ID: 10190667Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- S1809000007 Rev.
- Date Added:
- April 26, 2021
- Manufacturer:
- DODGE
SummaryCustomer complaint may include engine oil leak/consumption.
Associated Products (199)2021 Alfa Romeo Stelvio2021 Chrysler 3002021 Chrysler Pacifica2021 Dodge Challenger2021 Dodge Charger2021 Dodge Durango2021 Fiat 500X2021 Jeep Cherokee2021 Jeep Compass2021 Jeep Gladiator2021 Jeep Grand Cherokee2021 Jeep Renegade2021 Jeep Wrangler2021 Ram 15002021 Ram 25002021 Ram 35002021 Ram 45002021 Ram 55002021 Ram Promaster City2020 Alfa Romeo Stelvio+ 179 moreAssociated Documents - February 24, 2021•Document ID: 10220620Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; BACK OVER PREVENTION; FUEL SYSTEM, GASOLINE; EXTERIOR LIGHTING; POWER TRAIN; FUEL SYSTEM, DIESEL; SERVICE BRAKES, HYDRAULIC
- Mfr Comm. #:
- 1802321
- Date Added:
- September 26, 2022
- Manufacturer:
- RAM
SummaryFlash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following DTCs.P20EE - SCR NOx Catalyst Efficiency Below Threshold - Bank 1. P1C54 - SCR NOx Catalyst Missing. P229F - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 2. P207F - Reductant Quality Performance. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P2201 - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 1. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. P0300 - Multiple Cylinder Misfire. P0301-00 - Cylinder 1 Misfire. P0302-00 - Cylinder 2 Misfire. P0303-00 - Cylinder 3 Misfire. P0304-00 - Cylinder 4 Misfire. P0305-00 - Cylinder 5 Misfire. P0306-00 - Cylinder 6 Misfire. P249E - Closed Loop SCR Reductant Injection Control At Limit - Flow Too High. P0401 - EGR System Performance. P0128 - Thermostat Rationality. P218F - Reductant No Flow Detected. U0001-00 - CAN C BUS. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P1451 - Diesel Particulate Filter System Performance. P229E - NOx Sensor Circuit - Bank 1 Sensor 2. P2281 - Air Leak Between MAF and Throttle Body. P0218 - Transmission High Temperature Operation Activated (68RFE Only). P0868 - Line Pressure Low, MIL Action (68RFE Only). U110E - Lost Ambient Temperature Message. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). The following Diagnostic Trouble Codes (DTCs) have been changed from a one trip fault to a two trip fault:P0421 - Catalyst 1 Efficiency Below Threshold Bank 1. P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low.
Associated Products (2)Associated Documents - February 24, 2021•Document ID: 10220496Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- 9004351
- Date Added:
- September 26, 2022
- Manufacturer:
- JEEP
SummaryPLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for this pressure plate: 65RFE use 04799116A$ 66RFE use 52119929A$
Associated Products (31)Associated Documents - February 24, 2021•Document ID: 10188824Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 18-023-21
- Date Added:
- March 15, 2021
- Manufacturer:
- RAM
SummaryFlash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. The customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find one or more of the following DTCs.P20EE - SCR NOx Catalyst Efficiency Below Threshold - Bank 1. P1C54 - SCR NOx Catalyst Missing. P229F - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 2. P207F - Reductant Quality Performance. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P2201 - Aftertreatment NOx Sensor Circuit Performance - Bank 1 Sensor 1. P202E - (Diesel Exhaust Fluid) Reductant Injector Performance. P0300 - Multiple Cylinder Misfire. P0301-00 - Cylinder 1 Misfire. P0302-00 - Cylinder 2 Misfire. P0303-00 - Cylinder 3 Misfire. P0304-00 - Cylinder 4 Misfire. P0305-00 - Cylinder 5 Misfire. P0306-00 - Cylinder 6 Misfire. P249E - Closed Loop SCR Reductant Injection Control At Limit - Flow Too High. P0401 - EGR System Performance. P0128 - Thermostat Rationality. P218F - Reductant No Flow Detected. U0001-00 - CAN C BUS. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P1451 - Diesel Particulate Filter System Performance. P229E - NOx Sensor Circuit - Bank 1 Sensor 2. P2281 - Air Leak Between MAF and Throttle Body. P0218 - Transmission High Temperature Operation Activated (68RFE Only). P0868 - Line Pressure Low, MIL Action (68RFE Only). U110E - Lost Ambient Temperature Message. P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). The following Diagnostic Trouble Codes (DTCs) have been changed from a one trip fault to a two trip fault:P0421 - Catalyst 1 Efficiency Below Threshold Bank 1. P2280 - Air Flow Restriction / Leak Between Air Cleaner And MAF. P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low.
Associated Products (2)Associated Documents - February 24, 2021•Document ID: 10188620Service Bulletin/Repair InstructionsEQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; SERVICE BRAKES
- Mfr Comm. #:
- 9004351
- Date Added:
- March 15, 2021
- Manufacturer:
- RAM
SummaryPLATE - CLUTCH PRESSURE For 68RFE trans use selective fit pressure plates between the overdrive and reverse clutch packs and hence use all three 52119929A$, 52119930A$, 04799116A$ maintain clearance For 65RFE & 66RFE no selectives for this pressure plate: 65RFE use 04799116A$ 66RFE use 52119929A$
Associated Products (31)Associated Documents - February 8, 2021•Document ID: 10220534Service Bulletin/Repair InstructionsEXTERIOR LIGHTING
- Mfr Comm. #:
- S1625000007RevA
- Date Added:
- September 26, 2022
- Manufacturer:
- RAM
SummaryMalfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Code (DTC) P207F ? Reductant Quality Performance Set.
Associated Products (19)Associated Documents - February 8, 2021•Document ID: 10188738Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); EXTERIOR LIGHTING; EQUIPMENT
- Mfr Comm. #:
- S1625000007 Rev.
- Date Added:
- March 15, 2021
- Manufacturer:
- RAM
SummaryMalfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Code (DTC) P207F ? Reductant Quality Performance Set.
Associated Products (15)Associated Documents - January 21, 2021•Document ID: 10215881Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- S2109000001
- Date Added:
- July 18, 2022
- Manufacturer:
- RAM
SummaryCustomer may complain of a MIL lamp on. Upon further investigation there could be a fault code in the PCM for P1524 ? Oil Pressure Out of Range ? Camshaft Advance/Retard Disabled.
Associated Products (26)2021 Dodge Durango2021 Jeep Grand Cherokee2021 Ram 15002021 Ram 25002021 Ram 35002021 Ram 45002020 Dodge Durango2020 Jeep Grand Cherokee2020 Ram 15002020 Ram 25002020 Ram 35002020 Ram 45002019 Dodge Durango2019 Jeep Grand Cherokee2019 Ram 15002019 Ram 25002019 Ram 35002019 Ram 45002018 Dodge Durango2018 Jeep Grand Cherokee+ 6 moreAssociated Documents - January 21, 2021•Document ID: 10187060Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- S2109000001
- Date Added:
- February 16, 2021
- Manufacturer:
- JEEP
SummaryCustomer may complain of a MIL lamp on. Upon further investigation there could be a fault code in the PCM for P1524 ? Oil Pressure Out of Range ? Camshaft Advance/Retard Disabled.
Associated Products (25)2021 Dodge Durango2021 Jeep Grand Cherokee2021 Ram 15002021 Ram 25002021 Ram 35002020 Dodge Durango2020 Jeep Grand Cherokee2020 Ram 15002020 Ram 25002020 Ram 35002020 Ram 45002019 Dodge Durango2019 Jeep Grand Cherokee2019 Ram 15002019 Ram 25002019 Ram 35002019 Ram 45002018 Dodge Durango2018 Jeep Grand Cherokee2018 Ram 1500+ 5 moreAssociated Documents - January 16, 2021•Document ID: 10215879Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR
- Mfr Comm. #:
- S1709000010 Rev.
- Date Added:
- July 18, 2022
- Manufacturer:
- JEEP
SummaryCustomer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary.
Associated Products (82)2021 Dodge Durango2021 Jeep Grand Cherokee2021 Ram 25002021 Ram 35002020 Dodge Durango2020 Jeep Grand Cherokee2020 Ram 15002020 Ram 25002020 Ram 35002019 Dodge Durango2019 Jeep Grand Cherokee2019 Ram 15002019 Ram 25002019 Ram 35002018 Dodge Durango2018 Jeep Grand Cherokee2018 Ram 15002018 Ram 25002018 Ram 35002017 Dodge Durango+ 62 moreAssociated Documents - January 16, 2021•Document ID: 10187058Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- S1709000010 Rev.
- Date Added:
- February 16, 2021
- Manufacturer:
- RAM
SummaryCustomer complaints may include abnormal engine noise, rough idle, lack of power, misfire. Upon investigation, it may be found that there is excessive camshaft lobe wear/lifter wear (roller failure) on one or more cam lobes and that camshaft/lifter replacement is necessary.
Associated Products (82)2021 Dodge Durango2021 Jeep Grand Cherokee2021 Ram 25002021 Ram 35002020 Dodge Durango2020 Jeep Grand Cherokee2020 Ram 15002020 Ram 25002020 Ram 35002019 Dodge Durango2019 Jeep Grand Cherokee2019 Ram 15002019 Ram 25002019 Ram 35002018 Dodge Durango2018 Jeep Grand Cherokee2018 Ram 15002018 Ram 25002018 Ram 35002017 Dodge Durango+ 62 moreAssociated Documents - November 5, 2020•Document ID: 10224022Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- S1908000102
- Date Added:
- October 17, 2022
- Manufacturer:
- CHRYSLER
Summary(Rev. A) Power Inverter Load Ratings
Associated Products (73)2019 Alfa Romeo Stelvio2019 Chrysler Pacifica2019 Dodge Durango2019 Dodge Journey2019 Jeep Cherokee2019 Jeep Compass2019 Jeep Grand Cherokee2019 Jeep Renegade2019 Jeep Wrangler2019 Ram 15002019 Ram 25002019 Ram 35002019 Ram 45002019 Ram 55002018 Alfa Romeo Stelvio2018 Chrysler Pacifica2018 Dodge Durango2018 Dodge Journey2018 Jeep Cherokee2018 Jeep Compass+ 53 moreAssociated Documents - November 5, 2020•Document ID: 10184699Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EQUIPMENT
- Mfr Comm. #:
- S1908000028 Rev.
- Date Added:
- December 28, 2020
- Manufacturer:
- RAM
Summary(Rev. A) Power Inverter Load Ratings
Associated Products (68)2019 Alfa Romeo Stelvio2019 Chrysler Pacifica2019 Dodge Durango2019 Dodge Journey2019 Jeep Cherokee2019 Jeep Compass2019 Jeep Grand Cherokee2019 Jeep Renegade2019 Jeep Wrangler2019 Ram 15002019 Ram 25002019 Ram 35002019 Ram 45002018 Alfa Romeo Stelvio2018 Chrysler Pacifica2018 Dodge Durango2018 Dodge Journey2018 Jeep Cherokee2018 Jeep Compass2018 Jeep Grand Cherokee+ 48 moreAssociated Documents - November 5, 2020•Document ID: 10184399Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:12V/24V/48V BATTERY
- Mfr Comm. #:
- S1908000028 Rev.
- Date Added:
- December 21, 2020
- Manufacturer:
- CHRYSLER
Summary(Rev. A) Power Inverter Load Ratings
Associated Products (68)2019 Alfa Romeo Stelvio2019 Chrysler Pacifica2019 Dodge Durango2019 Dodge Journey2019 Jeep Cherokee2019 Jeep Compass2019 Jeep Grand Cherokee2019 Jeep Renegade2019 Jeep Wrangler2019 Ram 15002019 Ram 25002019 Ram 35002019 Ram 45002018 Alfa Romeo Stelvio2018 Chrysler Pacifica2018 Dodge Durango2018 Dodge Journey2018 Jeep Cherokee2018 Jeep Compass2018 Jeep Grand Cherokee+ 48 moreAssociated Documents - October 10, 2020•Document ID: 10223967Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; ELECTRICAL SYSTEM; EXTERIOR LIGHTING
- Mfr Comm. #:
- 0809420
- Date Added:
- October 17, 2022
- Manufacturer:
- RAM
SummaryFlash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC) has been set::If the customer has any concerns with the transfer case or if the tech performs any repairs on the transfer case, the software must be updated.C140E - Transfer Case Motor Blocked. If DTC C140E is present, follow normal diagnostic procedures before updating the DTCM.In addition the customer may describe the following:The ?Service 4WD? message/fault is displayed in the Instrument Panel Cluster (IPC). Transfer case shift fork tabs broken during range shift. Noisy (clunking/ratcheting) transfer case range shifts. Failure to complete transfer case range shifts. The following software enhancement is available:This update will help reduce premature transfer case failure.
Associated Products (20)Associated Documents - October 10, 2020•Document ID: 10183078Service Bulletin/Repair InstructionsPOWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE); EQUIPMENT; ELECTRICAL SYSTEM
- Mfr Comm. #:
- 08-094-20
- Date Added:
- November 30, 2020
- Manufacturer:
- RAM
SummaryFlash: Drivetrain Control Module (DTCM) Update This bulletin involves reprogramming the DTCM with the latest available software. The customer may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find the following Diagnostic Trouble Code (DTC) has been set::If the customer has any concerns with the transfer case or if the tech performs any repairs on the transfer case, the software must be updated.C140E - Transfer Case Motor Blocked. If DTC C140E is present, follow normal diagnostic procedures before updating the DTCM.In addition the customer may describe the following:The ?Service 4WD? message/fault is displayed in the Instrument Panel Cluster (IPC). Transfer case shift fork tabs broken during range shift. Noisy (clunking/ratcheting) transfer case range shifts. Failure to complete transfer case range shifts. The following software enhancement is available:This update will help reduce premature transfer case failure.
Associated Products (20)Associated Documents