Ram 1500 Complaints (2021)

669 consumer complaints on file.

#11744766June 17, 2026
TIRES:TREAD/BELT
On 12-4-2025 I purchased a set of kumho mavis mountaineers apt tires at the Thomson GA. location. They didn't balance the tires when they were installed. So I had to go back for them to be balanced. After 5 months my truck was still riding really rough and the tires had worn considerably more than they should have so I called Mavis about this problem and was instructed to go to the Evans GA location on 5-22-2026 for a tire inspection. This location said all for tires were dry-rotted and I haven't had these tires for 7 full months and have put 22,000 miles on them. One tire has worn to the point of being slick and this is the only vehicle my family has right now. This has been on going since the date of purchase and there is a good chance these tires will cause an accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743214June 10, 2026
ENGINE
I purchased a 2021 Ram 1500 North Edition (VIN: [XXX]) on XXX. As of last week, I noticed fluid leaking from under the engine compartment of the truck. I crawled under the truck and found that this five-year old truck has an oil pan that has rusted and rotted on the bottom and side leading to a leak of motor oil. I searched this online and found that this is a common issue amongst this model in this time frame and that it can cause a "catastrophic" loss of oil pressue while driving. I checked recalls and technical service bulletins and found no mention of this issue. Upon speaking with the service department of Hume's Chrysler, Jeep Dodge, and Ram of Waterford, PA, I was informed that they have seen this issue and that it is not covered by any warranty or recall because it's always caused by rust. This was only noticed because my wife's vehicle is in the shop and I parked in the garage causing me to notice it on the garage floor. My truck is normally parked in our gravel driveway and the oil leak went unnoticed. The truck was down approximately one-quart of oil when this was noticed. Had this not been noticed when it was, I fear that this issue could have caused an incident on the highway while the engine oil pressure was increased. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742815June 8, 2026
ENGINE
Both exhaust manifold cracked causing exhaust fumes to leak in to cab
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742065June 4, 2026
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
The contact owns a 2021 Ram 1500. The contact stated while driving at an undisclosed speed, there were abnormal sounds coming from the exhaust, the exhaust was leaking, and the contact discovered that there were cracks on the exhaust manifolds. No warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed that the exhaust manifolds and gasket needed to be replaced. The vehicle was repaired. The contact did research and was made aware of an unknown NHTSA Campaign Number however, the VIN was not included. The manufacturer was made aware of the failure and the manufacturer stated that NHTSA was responsible for adding each VIN to a recall. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741554June 2, 2026
FUEL/PROPULSION SYSTEM
My 2021 RAM 1500 ecodiesel was subject to an NHTSA recall (23V-263). The recall included a replacement High pressure fuel pump (HPFP) due to a mechanical defect in the Bosch CP4.2 high-pressure fuel pump (HPFP) that causes the pump to fail prematurely and destroy itself internally. The HPFP was replaced under the recall over two years ago, only for the new fuel pump to fail catastrophically and send parts through the fuel loop. The failure has been confirmed by a manufacturer dealership service center (Huntington Beach, CA). The failure lead to immediate engine shutoff while driving in traffic. The vehicle could not be moved out of a busy street under its own power. There were no warning signs prior to failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741285June 1, 2026
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
2021 Ram 1500, rear window leaked after it rained. (Common problem with these trucks, even a class action law suit because of this issue). Leak was bad enough to cause severe electrical damage, truck will not start. There is an extended warranty related to this issue BUT according to Ram my truck does not qualify…..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739617May 22, 2026
UNKNOWN OR OTHER
Vehicle serpentine belt is faulty and has required multiple replacements. The belt has cause multiple close calls with traffic accidents
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739206May 21, 2026
ELECTRICAL SYSTEM, ENGINE
Made several stops and on the last one when I went to start the vehicle it wouldn't start. Used jump pack and it started. Had a non-flashing check engine light and a service ESC light. Decided to drive across town to auto store and have them check battery and replace if bad, When I pulled into the auto store parking lot the truck died and wheels locked up. (Very sudden stop) All four gear selector lights (PRND) were lit. Thought to myself "I'm glad this didn't happen on the roadway." Turns out the battery was indeed bad, and a new battery got me running again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738547May 18, 2026
UNKNOWN OR OTHER, ELECTRICAL SYSTEM, ENGINE
[XXX] Fire occurred while driving [XXX] my Ram 2021 and it was like a mini blast with a lot of sparks as I saw in a rear-view mirror. Everything went out on the dashboard and the car stopped at the Top of Wolf Creek Pass [XXX] . I got out of the car and saw a small fire burning under the car. The fire under the car went out on its own. The very shape of the hole (perfectly round) in my muffler indicates an explosion that occurred simultaneously. Also, the fused edges of the round hole indicate a high temperature during this explosion and fire. I disagree that this fair damage [XXX] my Ram 2021 3.0 ecodiesel [XXX] is considered from Progressive insurance as simple "wear and tear." estimate only $1669,78. Garber Collision Pontiac repaired the Ram 2021 by 04.24.2026 and replaced the damaged wiring harness ($1161 self-pay) as required by Progressive. After this repair, the Ram 2021 was unable to move and was delivered to the Tucson Ram dealer on 05/04/2026. The dealer did not indicate the root cause of the damage in the estimate. The car was also returned to me by the dealer. When I asked the dealer on 05.12.2026 to indicate the root cause of the damage, the dealer replied that he was not aware of such a similar damage and indicated that the warranty on the car has expired and there are no open recalls. But The dealer's initial assessment from 05.13.2026 (estimates $9325.25) indicates the fire was caused by a failure of the Exhaust Gas Recirculation (EGR) cooler, which is a known issue (similar to recall VB1/19V-757) where the cooler cracks, leaks coolant, and causes a fire in the intake manifold. This is a component failure resulting in an explosion/fire, not typical wear. I need a diagnostic report that specifically mentions the EGR cooler failure as the source of the fire. I give my full consent for Ram Manufacturing to send an independent inspector to me for Ram 2021 3.0 Ecodisel INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11738443May 17, 2026
ELECTRICAL SYSTEM
I was driving at freeway speeds when the vehicle lost engine power and all the electronics in the vehicle stopped functioning. I was able to safely get the side of the road and stop the vehicle. Had vehicle towed to dealership. Tech inspected remote frequency hub (RFH) and observed corrosion on the circuit board. It looked as if water intrusion had occurred inside the vehicle, entered the RFH, causing corrosion and circuit failure. Believe intrusion occurred in the third brake light at the top of the cab. I am reporting this matter because a failure in the RFH caused the vehicle to stop functioning. I was lucky to be traveling on a straight, wide road and could safely get to a stop. I don't believe this would have been the case if I was on a curve or narrow road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737488May 13, 2026
ENGINE
The exhaust manifold on both sides of the motor have cracked and have broken bolts. The Ram dealer confirmed it and says it is a known issue that the manufacturer will not fix. With the crack and broken bolts, exhaust fumes are leaking out. It gets nauseating in the cab of the truck if the windows are up for too long. My independent mechanic is set to replace the manifolds with aftermarket ones due to literature saying the OEM will end up the same way. No dash lights have illuminated.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736338May 7, 2026
VEHICLE SPEED CONTROL, AIR BAGS
air bags, warning lamps on, it could be dangerous. don't know if it's been checked no accidents yet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734548April 29, 2026
FUEL SYSTEM, DIESEL
The contact owns a 2021 Ram 1500. The contact stated that the vehicle failed to start and was unable to be jump-started. The vehicle was towed to an independent mechanic to be diagnosed, and it was determined that fuel was not reaching the fuel housing. The contact was informed that the CP4 high-pressure fuel pump was previously replaced under an undisclosed recall in 2024. The vehicle was then towed to the dealer, who had previously completed the recall repair. The contact was informed that the secondary fuel pump located in the engine compartment needed to be replaced; however, the repair would be an out-of-pocket expense. The vehicle was not repaired due to the cost. The manufacturer was not contacted. The failure mileage was approximately 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733891April 26, 2026
ELECTRICAL SYSTEM, SERVICE BRAKES, POWER TRAIN
I was only allowed 3 components to choose from, but I want to make certain that Im including the these additional components that has been failing:Forward Collision Warning, Engine,Fuel/Propulsion System,Engine,Lane assistance/ Departure, and Lighting. There could be more to include but heres the dangerous issue I encounter everyday I utilize my vehicle,that has yet to be fixed nor addressed appropriately when I articulate EXACTLY what I feel,& see occur.My safety & everyone esle has been put at risk everyday which caused my 1st accident which I predicted was potentially likely since May 1,2025. It occurs exactly the same everytime just like the 1st terrifying experience: Id be stopped at a red light,intersection waiting for green light. With foot on brake between 5 to 10 seconds later I can feel the brake disenaging with my foot fully and physically on the brake simultaneously my vehicle screens will light up indicators erractically,(ghost touch,touch screen digitizer failure), while LUNGING FORWARD 5-7 ft on it OWNS,simultaneously screen blackout,& vehicle screen system reset followed by vehicle putting itself in emergency brake.This puts everyone around at RISKS AS MY VEHICLE OPERATES ON ITS OWN, which caused an accident at a red light where my truck plowed into the vehicle in front of me.Ive waited for an independent service contractor to evalute on 4 different occasions which they failed to appear or make contact on THEIR desired scheduled dates.The dealership has failed to reproduce due to unsatisfactory failed service repair attempts, discrepancies in verbal & documention.Absolute lack of concern for my safety or interest in issue, as at least 2 comeback services were met with breach of contract by dealer.The DEALERSHIP has been the only ones servicing my vehicle & according to their top tier diagnosis components successfully checked out in contrast to my many reoccurring service request for same issue.Prior to failure no warning lamps or messages appeared.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733482April 24, 2026
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
The vehicle experienced an overheating condition immediately after being picked up from dealership service on April 11, 2026. Within a short distance of driving, a warning appeared and the vehicle became unsafe to operate, requiring it to be pulled over and towed. The dealership later stated that coolant was low but also reported no leaks. This condition should have been identified and corrected while the vehicle was in their custody prior to release. The failure created a safety risk because the vehicle could not be operated safely on the roadway and required immediate removal from traffic. The issue occurred without prior warning before the failure following service.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732867April 21, 2026
STEERING, SUSPENSION
I own a 2021 Ram 1500, which I purchased on March 29, 2024, as a certified pre-owned truck, and the primary issue involves a serious failure of the front wheel assembly. On three separate occasions, the front wheels have detached from the truck while it was in motion—on June 14, 2024, February 26, 2026, and most recently on April 17, 2026, when the left front wheel came off. I was driving the vehicle all three times during the incidents. Although the dealership has stated that repairs were completed after each incident, the problem continues to occur, indicating that the defect has not been properly resolved. The vehicle is available for inspection upon request, along with all supporting documentation. This defect creates a severe safety hazard, as losing the front wheels while driving greatly increases the risk of a crash and poses a danger to both me and others on the road. I have reported the issue to the dealership multiple times, and they have evaluated the vehicle, confirming a recurring and unresolved problem, along with additional major mechanical concerns that have not been adequately addressed under warranty. Despite having warranty coverage, I have paid high out-of-pocket costs for repairs, yet the problem has not been fixed. Despite these efforts, no effective or lasting repair has been made. The vehicle has not yet been inspected by the manufacturer, law enforcement, or insurance representatives, but I am willing to make it available for further review. Given the repeated and dangerous nature of this failure, I no longer feel safe operating the vehicle and I am requesting immediate assistance and a proper resolution.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731381April 15, 2026
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
the reverse camera quit working, trailer reverse function inop, service electric throttle light is on. I have had the recall completed. the programing did not completely correct the issue. the vehicle s at the dealership now - has been there for a week now- no word on what the problem is.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731259April 14, 2026
ELECTRICAL SYSTEM, STEERING
July 2021 bought ram 1500 limited. $75k September 2021 3k miles took to dealer with REVERSE TRAILER STEERING UNAVAILABLE MESSAGES AND BACK UP CAMERA issues. Not fixed. Issues still happening. DEC 2021 ram 1500 recall y80 issued. RTSCM NEEDS updated. April 2022 dealer visit 11k miles recall y80 addressed and repaired. Issues continued. Several undocumented stop by dealer visits by request to look at while happening. Software updated each time. April 2023 purchasing dealer visit agin 26k miles. Up to this date vehicle was a lease. I bought the lease out with hopes to repair the issue. That dealer updated and also removed my dash to inspect the module. At this point as well 2 cases had been opened with ram themselves and I was wrote off as it will be fixed eventually. After that the issues never went away to this day but I was at a loss. A lemon law attorney told me that I didn’t have enough proof of the issue and i will share all my proof here with you guys. 2 month ago it froze the screen and accelerated on its own almost hitting a women and child pedestrian. I have had enough. I have worked hard for that money spent in the truck and cannot get the safety recall resolved. Now that the dash has been removed there are lights that shine in my eyes at night through the crease in the dash. All evidence cannot attach to this form because they are videos but I have over 65 showing proof and repair attempts
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730807April 13, 2026
SERVICE BRAKES, STEERING, UNKNOWN OR OTHER
While driving, a deer entered the roadway. I applied the brakes to avoid hitting the deer and lost traction due to icy road conditions. The vehicle spun out and struck a utility pole. I later became aware of an open recall involving the ABS and/or electronic stability control (ESC) system for this vehicle. There were no warning lights, messages, or alerts before or after the incident. The vehicle did not maintain stability as expected during braking on ice. I am unsure whether the ABS/ESC system functioned properly at the time of the incident. The crash resulted in vehicle damage and property damage. To my knowledge, the vehicle has not yet been inspected by the manufacturer. The vehicle is available for inspection upon request. After crash, airbags did not deploy no fluids leaked no warning lights ever came on dash before or after crash
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11730160April 9, 2026
ELECTRICAL SYSTEM
The contact owns a 2021 Ram 1500. The contact stated that while driving at an undisclosed speed, the check air bag warning light illuminated. The contact stated that the vehicle had a history of wiring failures and that the air bag wiring harness had been replaced three times; however, the failure persisted. The vehicle was taken to a dealer, where it was diagnosed with electrical wiring failure, and the wires were zip-tied in place. The vehicle was repaired, but the failure persisted. The manufacturer was not notified of the failure. The failure mileage was 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ram 1500