Porsche Boxster Complaints

190 consumer complaints on file.

#10358136September 28, 2010
ENGINE AND ENGINE COOLING
1. I PURCHASED THIS CAR NEW. IT IS MY DAILY DRIVER. ONLY SERVICED MY PORSCHE MECHANICS. IT HAD 32,500 MILES AT TIME OF FAILURE. AFTER LEAVING A DOCTOR'S APPOINTMENT, I NOTICED AN UNUSUAL SOUND COMING FROM THE ENGINE COMPARTMENT. NOT VERY LOAD. I THOUGHT IT HAD CAUGHT A PIECE OF DEBRIS IN THE BELT SYSTEM. DROVE IT SLOWLY HOME, AND THE SOUND GOT PROGRESSIVELY LOUDER. THE NEXT MORNING THERE WAS A PUDDLE OF OIL UNDER THE CAR. I CALLED THE PORSCHE DEALER IN MOBILE, AL FOR A TOW TRUCK. 2. I WAS TOLD BY THE PORSCHE SERVICE MANAGER THAT THE CAR HAD EXPERIENCED THE INFAMOUS INTERMEDIATE SHAFT (IMS) FAILURE, AND THAT I WOULD NEED A NEW ENGINE. I WAS TOLD THERE IS LITTLE TO NO WARNING OF THIS FAILURE, AND THEY ARE ALMOST ALWAYS CATASTROPHIC. REQUIRING COMPLETE ENGINE REPLACEMENT. 3. PORSCHE NORTH AMERICA WAS CONTACTED WITH ALL PERTINENT INFORMATION. THEY RESPONDED WITH AN OFFER TO COVER HALF THE COST OF A FACTORY REBUILT ENGINE. I WOULD PAY THE OTHER HALF, PLUS ALL LABOR AND TOWING COSTS. THIS REPLACEMENT WILL COST ME OVER $11,000.00 !!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10354966September 11, 2010
ENGINE AND ENGINE COOLING:ENGINE
WE BOUGHT A 1998 PORSCHE BOXSTER IN AUG 2009. SERVICED AS REQUIRED. ON 9/7/10 OUT DRIVING, STOPPED AT A STOP SIGN AS WE PROCEEDED THROUGH THE STOP SIGN THE ENGINE DIED, WHITE SMOKE CAME POURING OUT THE BACK. HAD IT TOWED TO MECHANIC AND WAS INFORMED THAT THEN MOTOR HAD SEIZED DUE TO THE IMS (INTERMEDIATE SHAFT). CAR HAD APPROX 34K FOR MILEAGE. CONTACTED PORSCHE AMERICA AND WAS BASICALLY TOLD THERE WAS NOTHING THEY COULD DO. AFTER RESEARCHING ON THE WEB, THIS APPEARS TO BE A PRETTY COMMON PROBLEM WITH THE 97-99 BOXSTERS. THE COST TO REPLACE THE MOTOR WITH A USED MOTOR WAS APPROX 9K AND THEY WOULD BE USING THE SAME TYPE OF MOTOR WITH THE SAME DESIGN FLAW. THE CAR HAS BEEN TAKEN TO THE SALVAGE YARD AND WE ARE OUT QUITE A BIT OF MONEY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10344995July 23, 2010
ENGINE AND ENGINE COOLING:ENGINE
MY ENGINE FAILED DUE TO A PART CALLED THE INTERMEDIATE SHAFT. THE CAR IS A 2003 PORSCHE, BOXSTER S WITH 47,000. THIS PROBLEM IS WELL DOCUMENTED ON LINE AND APPEARS TO BE A MANUFACTURING PROBLEM. THE DEALERSHIP I WENT TO, KNEW RIGHT AWAY ABOUT THE FAILURE AS THEY SEE AT LEAST 1 PER MONTH. WHEN THIS PART FAILS, THE REMEDY IS A NEW (OR USED ENGINE). THERE IS NO WAY TO KNOW OF THIS FAILURE UNTIL IT HAPPENS. I REPLACED MY ENGINE AND IT COST $12,000. THIS WEBSITE PROVIDES A LOT OF INFORMATION ABOUT THIS PORSCHE PROBLEM AND IT SHOWS SOME OF THE RESEARCH CONDUCTED BY THEIR ENGINEER, HTTP://WWW.LNENGINEERING.COM/IMS.HTML. THEIR RESEARCH INDICATES THAT PORSCHE KNOWS OF THE PROBLEM AND THINKS IT HAS TO DO WITH PARTICULAR VIN NUMBER CARS (ONE OF WHICH IS MINE) AND FIXES IT WHEN IT HAPPENS DURING WARRANTY. I ASKED THEM TO HELP COVER THE COST AND THEY SAID NO, AS MY CAR WAS OUT OF WARRANTY. IT IS MY OPINION THAT A CAR (PORSCHE OR NOT) SHOULD NOT FAIL LIKE THIS ESPECIALLY WITH NO WARNING. AS AN FYI, IT APPEARS PORSCHE FINALLY REDESIGNED THIS PART IN 2006. I HOPE YOU CAN HELP ME CAPTURE SOME OF MY OUT OF POCKET EXPENSE AS WELL AS MAKE OTHER USERS AWARE WITH A POSSIBLE RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10339774June 23, 2010
POWER TRAIN:MANUAL TRANSMISSION
STARTING FROM A STOP LIGHT, I ENGAGED THE CLUTCH ON MY NEW 2010 PORSCHE CARRERA S. UPON REACHING APPROPRIATE SPEED, I LIFTED MY FOOT OFF THE CLUTCH PEDAL. THE ENGINE CONTINUED TO REV AS I APPLIED ACCELERATION, BUT THE CAR DID NOT MOVE FORWARD. I THEN NOTICED THE CLUTCH PEDAL DID NOT RETURN TO ITS FULLY DISENGAGED POSITION, RATHER IT STAYED HALF DEPRESSED. THIS RESULTED IN OVERREVING, LOSS OF SPEED IN TRAFFIC, AND BURNING AND SMOKE COMING FROM THE REAR OF THE CAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10320181March 16, 2010
ELECTRICAL SYSTEM, STRUCTURE
SEE ODI CASE NUMBER: 10318487, COMPUTER FAILURE DUE TO WATER LEAKAGE INTO CAB. THIS HAPPENED TO ME TWICE IN FALL, 2008. THE FIRST TIME, THE DEALER REPLACED THE COMPUTER (AT MY COST) AND ONE MONTH LATER, IT HAPPENED AGAIN. AGAIN, THE COMPUTER WAS REPLACED AND THE CARPETS NEEDED REMOVAL AND CLEANING DUE TO FUNGUS, ALL AT MY COST. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10319298March 12, 2010
ENGINE AND ENGINE COOLING
I HAVE A 2003 PORSCHE BOXSTER S WITH 32,000MI ON IT. ON THE 8TH OF MARCH, THE ENGINE FAILED WITH AN INTERMEDIATE SHAFT BEARING FAILURE REQUIRING THE REPLACEMENT OF THE ENGINE. PORSCHE CARS NORTH AMERICA ARE NOT HELPFUL. SUCH A CATASTROPHIC FAILURE OF THE ENGINE IN MY OPINION IS DANGEROUS AND SHOULD BE TAKEN MORE SERIOUSLY BY PCNA CONSIDERING THE NUMBER OF CASES THAT ARE OUT THERE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10318487March 10, 2010
ELECTRICAL SYSTEM, STRUCTURE:BODY, EQUIPMENT:ELECTRICAL
WE OWN A 2002 PORSCHE BOXSTER WITH APPROXIMATELY 66,000 MILES. WE PURCHASED THE VEHICLE, USED, IN LATE 2003. ON THREE SEPARATE OCCASIONS WE HAVE EXPERIENCED TOTAL LOSS OF USE OF THE VEHICLE DUE TO WATER LEAKING INTO THE INTERIOR COMPARTMENT AND FLOODING THE CONTROL UNIT, RENDERING THE CAR TOTALLY INOPERABLE. THE INCIDENTS HAVE TAKEN PLACE IN OCTOBER, 2004 AT 33,000 MILES, APRIL, 2008 AT 61,000 MILES, AND CURRENTLY IN FEBRUARY, 2010. THE REPAIR HAS INITIALED REPLACING THE CONTROL UNIT AND HAVING TO PULL OUT THE CARPET SO AS TO INHIBIT MOLD GROWTH. THE FIRST INCIDENT WAS REPAIRED UNDER THE VEHICLE'S WARRANTY, THE SECOND TIME WAS REPAIRED AT OUR EXPENSE OF APPROX. $1,600. THE ESTIMATE FOR THIS CURRENT REPAIR IS $1,500. WE BELIEVE THIS POSES A SEVERE SAFETY RISK BECAUSE THE FIRST INCIDENT TOOK PLACE WHILE THE CAR WAS IN USE. WE WERE DRIVING UP A HILL. SUDDENLY THE VEHICLE BECAME INOPERABLE AND WE HAD TO MANEUVER THE CAR USING THE HANDBRAKE, TO REVERSE DOWN THE HILL. THE CAR HAD TO BE TOWED TO THE DEALER. WE HAVE INVESTIGATED THE PROBLEM ON THE INTERNET AND FOUND THAT THIS IS A COMMON PROBLEM WITH CERTAIN PORSCHE'S VEHICLES. THERE IS A DEFECT IN THE VEHICLE AND/OR THE RESTRICTIVE FILTERS THAT CAUSE THEM TO BECOME CLOGGED WITH DEBRIS AND CAUSE THE WATER LEAKAGE. IN ADDITION TO THIS PROBLEM RECURRING DOMESTICALLY, WE NOTE THAT THE NHTSA, WAS INFORMED VIA FRCL-09F028-2453 DATED APRIL 5, 2009 OF A SIMILAR PROBLEM IN NON-U.S. MARKETS. WE WOULD APPRECIATE YOUR INVESTIGATING THIS DEFECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10308956February 12, 2010
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 1999 PORSCHE BOXSTER. THE CONTACT HAD MASSIVE ENGINE FAILURE WHILE DRIVING 20 MPH AND THE CRANK SHAFT BROKE. THE VEHICLE WAS TOWED TO A MECHANIC AND THE ENGINE WAS REPLACED. THE MANUFACTURER ADVISED THE CONTACT THAT THE WARRANTY WAS NOT VALID AND THAT THERE WERE NO RECALLS FOR THE FAILURE. ROUTINE MAINTENANCE WAS PERFORMED ON THE VEHICLE PRIOR TO THE FAILURE. THE FAILURE MILEAGE WAS 42,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10282277August 29, 2009
AIR BAGS
1998 PORSCHE BOXSTER AIRBAG LIGHT, RELATED TO SEAT BELT BUCKLE, KNOWN ISSUE WITH A FIX THAT HAS A PART NUMBER, BUT PORSCHE NEVER HAD A RECALL SO THE ONLY WAY THEY WILL REPLACE IT FOR FREE IS IF THE LIGHT CAME ON WITHIN THE WARRANTY TIME. COST OUT OF WARRANTY $500 TO $1500. THIS SHOULD NOT BE A WARRANTY ISSUE BUT A SAFETY ISSUE, IF THEY KNEW THAT THE PART WAS FAULTY THEY SHOULD HAVE RECALLED THE PART AND FIXED EVERY MODEL THAT CAME OUT WITH THE OLD DESIGN. THERE ARE MANY REVIEWS ALL OVER THE INTERNET BY 97' TO 99' BOXSTER OWNERS. 99' IS THIS YEAR THEY CAME OUT WITH THE FIX, BUT IF YOU KEPT YOUR PORSCHE CLEAN AND GARAGE KEPT IT WOULD BE WELL PAST THE WARRANTY BEFORE THE WIRES FAULTED AND THE LIGHT COME ON. ALTHOUGH THEY SAY IT IS NOT A SAFETY ISSUE AND THAT THE AIRBAG WILL STILL DEPLOY, BY HAVING THIS FAULT ACTIVE, YOU WILL NOT BE ABLE TO TELL IF A TRUE AIRBAG FAULT THAT WILL AFFECT THE AIRBAG OPERATION REALLY WENT OFF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10273686June 13, 2009
ENGINE AND ENGINE COOLING:ENGINE
ON SATURDAY, MAY 16TH THIS BOXSTER SUFFERED ENGINE FAILURE WHILE TRAVELING AT ~ 30 MPH. THE ENGINE FAILED WITH NO PRIOR WARNING. THE INITIAL INDICATION WAS A LOUD AND DISTRACTING FLAPPING NOISE THAT SOUNDED LIKE SOMETHING HAD BEEN PICKED UP ON THE CAR'S UNDERCARRIAGE. THIS WAS FOLLOWED WITHIN A MOMENT BY SHUTDOWN OF THE ENGINE AND LOSS OF POWER STEERING. WE FEEL FORTUNATE THAT THIS ENGINE FAILED AT RELATIVELY LOW SPEED IN LIGHT TRAFFIC, SO THAT NO ACCIDENT OR INJURIES OCCURRED. HAD THE FAILURE OCCURRED EARLIER IN THE DAY WHILE WE WERE DRIVING AT HIGHWAY SPEED ON CURVING ROADS, WE BELIEVE WE WOULD HAVE BEEN INVOLVED IN A SERIOUS ACCIDENT. PROPERTY DAMAGE WAS LIMITED TO LOSS OF THE ENGINE ITSELF - INSTALLATION OF A REMANUFACTURED ENGINE IS ESTIMATED AT $14,000 TO $15,000. WE PURCHASED THE VEHICLE THIS PAST JANUARY FOR $20,000 SO THAT THIS ENGINE FAILURE REPRESENTS A NEAR TOTAL, UNINSURED LOSS. THE ENGINE FAILURE HAS BEEN DIAGNOSED AS AN INTERMEDIATE ENGINE SHAFT (IMS) FAILURE BY A LOCAL MECHANIC SPECIALIZING IN PORSCHE MAINTENANCE AND REPAIR (THE CLOSEST PORSCHE DEALERSHIP IS OVER 100 MILES AWAY). OUR SUBSEQUENT INTERNET RESEARCH INDICATES THAT IMS FAILURE IS A COMMON PROBLEM FOR PORSCHE AUTOMOBILES WITH THE M96 ENGINE, WITH SOME ESTIMATES THAT GREATER THAN 25% OF THESE VEHICLES WILL SUFFER ENGINE FAILURE PRIOR TO REACHING 100,000 MILES. UNFORTUNATELY, THE TRUE STATISTICS ARE NOT AVAILABLE TO CONSUMERS. PORSCHE HAS NOT ADMITTED THAT THIS FAILURE MODE RESULTS FROM A BEARING DESIGN FLAW, HOWEVER THAT IS THE GENERALLY ACCEPTED ROOT CAUSE. PORSCHE CARS NORTH AMERICA DECLINES TO ASSIST WITH REPAIR. WE RECOMMEND THAT YOU OPEN AN INVESTIGATION INTO THE FAILURE RATE AND SAFETY ASPECTS OF THE PORSCHE M96 ENGINE. WE FURTHER SUGGEST THAT IT IS LIKELY THAT FATAL ACCIDENTS INVOLVING PORSCHES WITH THESE ENGINES HAVE BEEN IMPROPERLY ASSIGNED TO DRIVER ERROR. WE BELIEVE THAT PORSCHE SHOULD BE HELD RESPONSIBLE FOR IMS FAILURES OF M96 ENGINES THROUGH A SAFETY RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10267931May 7, 2009
ENGINE AND ENGINE COOLING, STEERING
TL*THE CONTACT OWNS A 2004 PORSCHE BOXSTER. WHEN ACCELERATING FROM A STOP LIGHT AT 2 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER AND THEY STATED THAT THE IMS (INTERMEDIATE SHAFT) FAILED, WHICH CAUSED THE ENGINE TO FAIL. IT WOULD COST $16,000-$20,000 TO REPLACE. THE MANUFACTURER STATED THAT THEY WERE NOT RESPONSIBLE FOR THE FAILURE BECAUSE THE VEHICLE EXCEEDED ITS WARRANTY. THE FAILURE AND CURRENT MILEAGES WERE 20468. UPDATED 05/27/09. *LJ THE INTERMEDIATE SHAFT BOLT BROKE WHICH CAUSED THE ENGINE TO FAIL. UPDATED 05/28/09.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10239526August 24, 2008
AIR BAGS
AIRBAG LIGHT COMES ON IN 1999 PORSCHE BOXSTER. THIS SEEMS TO BE A COMMON AND RECURRING PROBLEM WITH PORSCHE BOXSTERS. IT WAS TAKEN TO A REPAIR SHOP WHO DIAGNOSED THE PROBLEM AS A SEAT BUCKLE PROBLEM. THEY INDICATED THAT IT IS A COMMON PROBLEM. THE ISSUE IS THAT THERE SHOULD BE A RECALL ISSUED TO FIX THIS PROBLEM SINCE IT IS DANGEROUS TO HAVE THE AIRBAG WARNING LIGHT COME ON. PORSCHE SHOULD FIX THE PROBLEM IN ORDER CLEAR THIS PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10238710August 18, 2008
ELECTRICAL SYSTEM
TL*THE CONTACT OWNS A 2001 PORSCHE BOXSTER S. WHEN THE ENGINE WAS TURNED OFF, THE INSTRUMENT PANEL WARNING LIGHTS REMAINED ILLUMINATED. THERE WAS A MALFUNCTION WITH THE IGNITION MODULE. THE CONTACT ATTEMPTED TO REMOVE THE KEY FROM THE IGNITION, BUT WAS UNSUCCESSFUL. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 47,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10230885June 12, 2008
ELECTRICAL SYSTEM
THIS IS THE SECOND TIME, AFTER A RAIN STORM, OUR 2005 PORSHE BOXSTER WOULD NOT START. DEALER SAYS IT IS WATER IN THE ELECTRICAL HARNESS. IS THIS A DESIGN FLAW? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10230492June 10, 2008
ENGINE AND ENGINE COOLING:ENGINE
IT'S WELL DOCUMENTED THAT EARLY PRODUCTION PORSCHE BOXSTERS HAD A SIGNIFICANT NUMBER OF ENGINE FAILURES DUE TO CRACKED OR SLIPPED CYLINDER LINERS. THERE WAS NEVER A RECALL BUT PORSCHE DID REPLACE FAILED ENGINES UNDER WARRANTY. PORSCHE HAS NOT DIVULGED EXACTLY HOW MANY ENGINES THIS ACTUALLY OCCURRED IN OTHER THAN A BROAD RANGE OF 2.5 ENGINES IN LATE 1998-EARLY 1999. NOR HAVE THEY RELEASED ANY ENGINE NUMBERS THAT HAVE HAD SLEEVES INSTALLED. I PURCHASED MY CAR 2 WEEKS AGO FROM THE ORIGINAL OWNER WITH 69K MILES AND FULL MAIN DEALER SERVICE HISTORY. THE ENGINE HAS NOW FAILED DUE TO A SLIPPED CYLINDER LINER. THE ENGINE HAS NOT BEEN RACED OR OVER-REVVED. I'M LOOKING AT A POSSIBLE $8 - $13K REPAIR BILL FOR A REPLACEMENT/REBUILT ENGINE. FORTUNATELY THE ENGINE SEIZED WHILST IN A CAR PARK. HAD IT DONE SO WHILST DRIVING ON THE BUSY INTERSTATE, THE CONSEQUENCES COULD HAVE BEEN CATASTROPHIC. WITH THE INTRODUCTION OF THE BOXSTER, PORSCHE TEAMED UP WITH KOLBENSCHMIDT TO MANUFACTURE THEIR NEW WATER-COOLED ENGINE. THE CASES EXPERIENCED SEVERAL ISSUES STARTING WITH THEIR POROSITY. IN 1998 KOLBENSCHMIDT'S CASTING MACHINE WAS DAMAGED. THIS LEAD TO LINER FAILURES IN LATE 1998 TO EARLY 1999. THIS WOULD TRANSLATE INTO ONLY THE 1999 MODEL YEAR DUE TO PRODUCTION DATES. THE TIME REQUIRED TO REPAIR THE MACHINE COULD HAVE SLOWED BOXSTER PRODUCTION DOWN SEVERELY UNLESS A FIX WAS FOUND. THE SOLUTION WAS TO RELINE SOME NOT-QUITE-PERFECT BLOCKS THAT WERE ON HAND. MOST OF THESE BLOCKS HAD A CASTING DEFECT OR A POROSITY PROBLEM IN AT LEAST ONE CYLINDER. KOLBENSCHMIDT BEGAN THE PROCESS OF THE REPAIRS UNTIL THE CASTING MACHINE WAS FIXED. THIS PROCESS STARTED BY BORING OUT THE FAILED CYLINDER TO ALLOW FOR THE INSERTION OF THE LINER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10228539May 21, 2008
ENGINE AND ENGINE COOLING:ENGINE
I WAS DRIVING ON THE INNER LANE OF THE FREEWAY AT 65MPH. THE ENGINE SUDDENLY STALLED AND THE CHECK ENGINE LIGHT STARTED FLASHING. I MANAGED TO HAVE THE CAR SLIDING TOWARD THE SHOULDER AND GET OFF FREEWAY. THE CAR WASN'T ABLE TO RESTART AGAIN. A HIGHWAY PATROL CAME BY AND HELPED TO PUSH MY CAR TO WILDER SHOULDER FOR SAFETY. THE REAR BUMPER WAS DAMAGED IN THE PROCESS. THE CAR WAS TOWED TO THE DEALER FOR INSPECTION AND STILL IN THE SHOP NOW. THE MECHANIST SAID THE ENGINE NEED TO BE REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10224397April 14, 2008
POWER TRAIN:DRIVELINE, EQUIPMENT:MECHANICAL
REAR MAIN SEAL OIL LEAK PRONE TO THE PORSCHE BOXSTER. UNIT WAS FIXED 18 MONTHS AGO UNDER NORMAL FACTORY WARRANTY AND FAILED AGAIN. THE COST OF THE FIX WAS OVER $1,900.00. SHOULDN'T A FIX DONE BY THE DEALER LAST LONGER THEN 18 MONTHS AND 5,500 MILES? PORSCHE TOLD ME TO "DO WHAT I NEED TO DO" TO RECOVER FRONT HE LOSS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10202959September 13, 2007
AIR BAGS
I HAVE A 1998 POSCHE BOXSTER. THE CAR HAS A PROBLEM IN THAT THE AIRBAG LIGHT WILL COME ON AND THE OWNER WILL NOT KNOW IF THE AIRBAGS ARE WORKING PROPERLY OR NOT. PORSCHE HAS HAD OVER 7 FIXES ON THIS ISSUE AND NONE HAVE WORKED TO DATE. THEY HAVE NOT REPLACED MINE UNDER WARRANTY. I HAVE BEEN INFORMED BY MY LOCAL PORSCHE DEALER THIS IS AN ON GOING PROBLEM. PORSCHE NORTH AMERICA REFUSED TO FIX THIS PROBLEM BECAUSE THE CAR IS OUT OF WARRANTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10199061August 10, 2007
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
THIS CAR IS A SIX SPEED MANUAL TRANSMISSION. ON TWO OCCASIONS AFTER DEPRESSING THE CLUTCH PEDAL IT HAS REMAIN ON THE FLOOR. IN THIS CIRCUMSTANCE THE TRANSMISSION CANNOT BE SHIFTED AND I HAVE HAD TO PULL TO THE SIDE OF THE ROAD. I HAVE BEEN ABLE TO PHYSICALLY PULL OUT ON THE CLUTCH PEDAL TO RETURN IT TO IT'S PROPER OPERATING POSITION. I WAS SURPRISED TO FIND, THRU AN INTERNET SEARCH, THAT THIS IS AN ONGOING PROBLEM WITH A NUMBER OF PORSCHE AUTOMOBILES FOR AT LEAST THE PAST THREE MODEL YEARS. THIS PROBLEM RENDERS THE CAR UNDRIVEABLE AND CAN PUT THE OPERATOR AT RISK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10199069August 10, 2007
POWER TRAIN:CLUTCH ASSEMBLY
BRAND NEW CAR (1 WEEK OLD) WITH 400 TOTAL MILES. ATTEMPTED TO SWITCH FROM 1ST TO 2ND GEAR IN STOP AND GO TRAFFIC, CLUTCH PEDAL STUCK TO THE FLOOR WITH 2ND GEAR ENGAGED. WAS UNABLE TO OPERATE THE CLUTCH, ALTHOUGH IT REMAINED ENGAGED IN 2ND GEAR. AS TRAFFIC CAME TO A STOP, VEHICLE STALLED DUE TO INABILITY TO DISENGAGE THE CLUTCH. WAS NOT ABLE TO ENGAGE 1ST GEAR OR RESTART THE CAR. AFTER BLOCKING TRAFFIC FOR 5+ MINUTES, WAS ABLE TO FORCE GEAR LEVEL INTO 1ST GEAR AND RESTART THE IGNITION, MOVING FORWARD. WAS NOT ABLE TO DISENGAGE THE CLUTCH TO SWITCH GEARS. AFTER TOWING, DEALER EXAMINED CAR AND REPLACED CLUTCH MASTER CYLINDER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Porsche Boxster