Mercedes-Benz R-Class Service Bulletins
120 manufacturer communications on file.
- February 22, 2010•Document ID: 10034625Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:DIESEL
- Mfr Comm. #:
- LI03-20-P-048278
- Date Added:
- December 13, 2010
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES (XENTRY): ENGINE MAKES NOISE, TICKING/CRACKLING AT IDLE SPEEDS UP TO APPROX. 1500 RPM. RUN IN EFFECT OF 1ST CRANKSHAFT MAIN BEARING. MODELS 211, 219, 164, 251, 203, 204, 209, 221, 461 AND 463. NO MODEL YEARS LISTED. *PE
Associated Products (7)Associated Documents - February 5, 2010•Document ID: 10034626Service Bulletin/Repair InstructionsVISIBILITY:REAR WINDOW WIPER/WASHER
- Mfr Comm. #:
- LI82-30-P-045348
- Date Added:
- December 13, 2010
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES (XENTRY): REAR WINDOW WIPER FAILS TO FUNCTION OR STOPS INTERMITTENTLY. LOW VOLTAGE CUTOFF RELAY IN THE REAR FUSE AND RELAY BLOCK (REAR (SRB). ONLY PART NUMBER A164 540 02 72 CAUSES THIS CONDITION. CHECK PART NUMBER OF REAR SRB, IF THE PART NUMBER IS A164 540 02 72, FOLLOW PROCEDURE TO RESOLVE. MODELS 164.175/186 AND 251.165/175. NO MODEL YEARS LISTED. *PE
Associated Products (1)Associated Documents - December 16, 2009•Document ID: 10033070Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE; ELECTRICAL SYSTEM
- Mfr Comm. #:
- LI-58-40
- Date Added:
- June 30, 2010
- Manufacturer:
- MERCEDES BENZ
SummaryXENTRY (MERCEDES): ENGINE WARNING LAMP IS CURRENTLY ON OR WAS ON AND A DELAY FAULT OF THE CAMSHAFT ADJUST TO CURRENT OR STORED IN THE ENGINE CONTROL UNIT. MODELS 171, 203, 209, 211, 219, 221, 216, 230, 164, 251, AND 403. NO MODEL YEARS LISTED. *PE
Associated Products (16)2010 Mercedes-Benz CL-Class2010 Mercedes-Benz E-Class2010 Mercedes-Benz S-Class2009 Mercedes-Benz E-Class2009 Mercedes-Benz R-Class2008 Mercedes-Benz E-Class2008 Mercedes-Benz R-Class2007 Mercedes-Benz E-Class2007 Mercedes-Benz R-Class2006 Mercedes-Benz E-Class2006 Mercedes-Benz R-Class2005 Mercedes-Benz E-Class2005 Mercedes-Benz R-Class2004 Mercedes-Benz CLK-Class2004 Mercedes-Benz E-Class2003 Mercedes-Benz E-ClassAssociated Documents - October 5, 2009•Document ID: 10028025Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:TAIL LIGHTS
- Mfr Comm. #:
- TB-82-10-632
- Date Added:
- February 28, 2009
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: STOP/TAIL LIGHT NOT ILLUMINATING WITH DTCS 9102, 9103, 9106, 9107, 9126, 9127 OR 9136. (VEHICLES WITHOUT LED TAIL LAMPS) *PE UPDATED 5/13/09. *PE UPDATED 4/20/11. REPAIR DOES NOT APPLY TO LED TAIL LAMPS. *PE
Associated Products (4)Associated Documents - October 1, 2009•Document ID: 10036933Service Bulletin/Repair InstructionsEXTERIOR LIGHTING
- Mfr Comm. #:
- LI-82-10/598B
- Date Added:
- April 20, 2011
- Manufacturer:
- MERCEDES BENZ
SummaryXENTRY (MERCEDES BENZ): REPLACING EXTERIOR LIGHT BULBS. EXTERIOR LIGHTS. LI DID NOT MATCH DTB FROM WHICH IT WAS CREATED. (MAIN REMEDY FOR REPAIR WAS MISSING.) *PE
Associated Products (7)Associated Documents - September 17, 2009•Document ID: 10032727Service Bulletin/Repair InstructionsSUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM; SUSPENSION:FRONT:SPRINGS:AIR SUSPENSION:LINES AND FITTINGS
- Mfr Comm. #:
- TB-P-047927
- Date Added:
- May 6, 2010
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: FOLLOWING FAULT CODES ARE ENTERED IN THE CONTROL UNIT AND DISPLAYED-FC5320 DRAIN VALVE:OPEN CIRCUIT OR INSUFFICIENT VALVE CURRENT IN MODELS SERIES 211, 219; FC5260 DRAIN VALVE OPEN CIRCUIT OR INSUFFICIENT VALVE CURRENT IN MODEL 221; FC5250 DRAIN OPEN CIRCUIT OR INSUFFICIENT VALVE CURRENT IN MODEL SERIES 251, 164. DEFECTIVE CONNECTING CABLES TO DRAIN VALVE AT AIRMATIC COMPRESSOR. THIS RESULTS IN THE SETTING OF THE FAULT CODES. NO MODEL YEARS LISTED. *PE
Associated Products (14)2010 Mercedes-Benz E-Class2010 Mercedes-Benz S-Class2009 Mercedes-Benz E-Class2009 Mercedes-Benz R-Class2008 Mercedes-Benz E-Class2008 Mercedes-Benz R-Class2007 Mercedes-Benz E-Class2007 Mercedes-Benz R-Class2006 Mercedes-Benz E-Class2006 Mercedes-Benz R-Class2005 Mercedes-Benz E-Class2005 Mercedes-Benz R-Class2004 Mercedes-Benz E-Class2003 Mercedes-Benz E-ClassAssociated Documents - September 10, 2009•Document ID: 10032707Service Bulletin/Repair InstructionsFUEL SYSTEM, OTHER:DELIVERY
- Mfr Comm. #:
- SB-47-20-56
- Date Added:
- April 30, 2010
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: ENSURING UNOBSTRUCTED MOVEMENT FOR THE FUEL LEVEL SENSOR. WHEN INSTALLING THE LEFT OR RIGHT FUEL LEVEL SENSOR, IT IS ESSENTIAL FOR IT TO HAVE UNRESTRICTED, UNOBSTRUCTED MOVEMENT. *PE
Associated Products (5)Associated Documents - August 1, 2009•Document ID: 10032568Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- RB-2009060005
- Date Added:
- April 14, 2010
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES BENZ SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SOFTWARE CALIBRATION NUMBER (SCN) CODING; ENGINE CONTROL MODULE. THE VEHICLES FUEL TANK LEAK DIAGNOSIS SYSTEM MAY HAVE BEEN INADVERTENTLY DEACTIVATED DURING A VISIT TO THE WORKSHOP. THIS MAY CAUSE THE AFFECTED VEHICLES TO FAIL TO MEET THE STATUTORY REQUIREMENTS FOR INSPECTION AND OR MAINTENANCE (EMISSIONS INSPECTION). *PE
Associated Products (5)Associated Documents - June 15, 2009•Document ID: 10030929Service Bulletin/Repair InstructionsSERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:DRUM; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:SHOES/LININGS; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM:WHEEL CYLINDERS; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DRUM; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DIFFERENTIAL PROPORTIONAL VALVE; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR; SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
- Mfr Comm. #:
- TSB-42-10-109
- Date Added:
- December 23, 2009
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: CORROSION PROTECTION COATINGS FOR BRAKE COMPONENTS AND HARDWARE MAY BE DAMAGED AND OR STRIPPED AWAY IF HIGHLY CONCENTRATED ACID BASED CLEANERS ARE USED. ONCE THE CORROSION PROTECTION IS DAMAGED OR REMOVED THE BRAKE COMPONENTS AND OR HARDWARE CAN BEGIN TO CORRODE. INCLUDE ALL MODELS AND MODEL YEARS. *PE
Associated Products (5)Associated Documents - June 4, 2009•Document ID: 10033071Service Bulletin/Repair InstructionsVISIBILITY:WINDSHIELD WIPER/WASHER; VISIBILITY:REAR WINDOW WIPER/WASHER
- Mfr Comm. #:
- SB-82-30-366E
- Date Added:
- June 30, 2010
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES BENZ: ADJUSTING WIPER ARMS. IF YOU RECEIVE REPORTS ON CERTAIN VEHICLES OF WIPERS CHATTERING/NOISY, PROCEED AS FOLLOWS: INSPECT WIPER BLADES/INSERTS FOR WEAR AND REPLACE; THOROUGHLY CLEAN WINDSHIELD; VERIFY USE OF CORRECT WASHER FLUID; CHECK WASHER NOZZLE ADJUSTMENT; CHECK WIPER ARM ANGLE ADJUSTMENT; AND RECORD VALUES PER APPLICABLE MODEL; IF REQUIRED, ADJUST WIPER ARM ANGLE. MODELS 164/251. NO MODEL YEARS LISTED. *PE
Associated Products (5)Associated Documents - May 11, 2009•Document ID: 10028668Service Bulletin/Repair InstructionsSEATS:FRONT ASSEMBLY:HEAD RESTRAINT
- Mfr Comm. #:
- TB-91-16-177
- Date Added:
- May 14, 2009
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: ACTIVE HEAD RESTRAINTS ACTIVATE FOR NO REASON. THIS MAY BE CAUSED BY DAMAGE TO THE SEAT WIRING HARNESS CAUSING A SHORT CIRCUIT. MODELS 164 AND 251. MODEL YEARS UNKNOWN. *PE UPDATED 9/18/09. *PE
Associated Products (5)Associated Documents - May 1, 2009•Document ID: 10028625Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SB-2008110009
- Date Added:
- May 12, 2009
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: UPDATE REAR SAM SOFTWARE. THE OPENING AND CLOSING OF TAILGATE WITH KEY REMOTE, WHILE THE VEHICLE IS LOCKED, MAY CAUSE THE BATTERY TO DRAIN DUE TO INCORRECT REAR SAM REST CURRENT LOGIC. MODELS 164, 164.8, AND 251. MODEL YEAR 2008. *PE UPDATED 9/18/09. *PE
Associated Products (1)Associated Documents - March 1, 2009•Document ID: 10030665Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; UNKNOWN OR OTHER
- Mfr Comm. #:
- TSB-2009020004
- Date Added:
- November 9, 2009
- Manufacturer:
- MERCEDES-BENZ
SummaryMERCEDES: IT HAS BEEN DETERMINED THAT THE TELE AID MAY NOT FUNCTION PROPERLY AS A RESULT OF A HARDWARE FAULT IN THE TELE AID CONTROL MODULE. IF THIS CONDITION EXISTS AN INSTRUMENT CLUSTER MESSAGE OF NO SERVICE AND TELE AID INOPERABLE WILL BE SEEN. *PE
Associated Products (6)Associated Documents - December 4, 2008•Document ID: 10020460Service Bulletin/Repair InstructionsSTEERING:RACK AND PINION; STEERING:RACK AND PINION:RACK
- Mfr Comm. #:
- 462046
- Date Added:
- October 23, 2006
- Manufacturer:
- MERCEDES BENZ
SummaryPLAY IN THE RACK AND PINION STEERING SYSTEM. MODELS 203, 209, 210, 211, 215, 220, 230. MERCEDES BENZ. *KB UPDATED 5/13/09. *PE
Associated Products (18)2009 Mercedes-Benz CLS-Class2009 Mercedes-Benz E-Class2009 Mercedes-Benz R-Class2008 Mercedes-Benz CLS-Class2008 Mercedes-Benz E-Class2008 Mercedes-Benz R-Class2007 Mercedes-Benz CLS-Class2007 Mercedes-Benz E-Class2007 Mercedes-Benz R-Class2006 Mercedes-Benz CLS-Class2006 Mercedes-Benz E-Class2006 Mercedes-Benz R-Class2005 Mercedes-Benz C-Class2005 Mercedes-Benz E-Class2005 Mercedes-Benz R-Class2004 Mercedes-Benz CLK-Class2004 Mercedes-Benz E-Class2003 Mercedes-Benz E-ClassAssociated Documents - December 2, 2008•Document ID: 10028646Service Bulletin/Repair InstructionsSTEERING:GEAR BOX:SHAFT SECTOR; STEERING:GEAR BOX:SHAFT PITMAN
- Mfr Comm. #:
- TB-46-10-32
- Date Added:
- May 13, 2009
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: GROANING OR DULL, HEAVY CRACKING NOISES FROM STEERING SHAFT AREA. WHEN TURNING STEERING WHEEL OR MOVING OFF OR BRAKING. THIS MAY BE EMANATING FROM THE BEARING AND HOUSING OF UPPER STEERING SHAFT (FIREWALL PIVOT POINT) OR STEERING COUPLING (LOWER STEERING SHAFT). MODELS 164 AND 251. MODEL YEARS UNKNOWN. *PE
Associated Products (5)Associated Documents - December 2, 2008•Document ID: 10028645Service Bulletin/Repair InstructionsSTEERING: STEERING WHEEL/HANDLE BAR
- Mfr Comm. #:
- TB-46-10-39C
- Date Added:
- May 13, 2009
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: CHROME PLATING PEELING ON DECORATIVE CAPS ON THE STEERING WHEEL SPOKES, THIS IS DUE TO LESS THAN OPTIMAL ADHESION BETWEEN CHROME PLATING AND BASE MATERIAL. MODELS 164 AND 251. MODEL YEARS UNKNOWN. *PE
Associated Products (5)Associated Documents - November 1, 2008•Document ID: 10027967Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE
- Mfr Comm. #:
- SCB-2008100007
- Date Added:
- February 25, 2009
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: INSTALL EXHAUST BRACKET REINFORCEMENT AT TRANSMISSION. IN EXTREME DRIVING CONDITIONS THIS EXHAUST BRACKET MAY BREAK AT THE TRANSMISSION. *PE
Associated Products (1)Associated Documents - August 1, 2008•Document ID: 10028027Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:DIESEL
- Mfr Comm. #:
- SB-2008070004
- Date Added:
- February 28, 2009
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: CHECK COOLANT LINE ON DIESEL ENGINE, REPLACE, IF NECESSARY. THE COOLANT HOSE IN THE AREA OF THE FAN SHROUD MAY WORK LOOSE WHEN DRIVING ON ROUGH ROADS DUE TO INSUFFICIENT RETENTION OF THE BRACKET. *PE
Associated Products (2)Associated Documents - August 1, 2008•Document ID: 10028026Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
- Mfr Comm. #:
- SB-2008070002
- Date Added:
- February 28, 2009
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: REPLACE V BELT UPPER GUIDE PULLEY. THE V BELT UPPER GUIDE PULLEY OPTIMIZED FOR NOISE REDUCTION IS AVAILABLE. THE DEALER WILL REPLACE UPPER GUIDE PULLEY AT THE NEXT WORKSHOP VISIT. *PE
Associated Products (6)Associated Documents - August 1, 2008•Document ID: 10028024Service Bulletin/Repair InstructionsSUSPENSION:FRONT:SPRINGS:AIR SUSPENSION SYSTEM; SUSPENSION:REAR:SPRINGS:AIR SUSPENSION SYSTEM
- Mfr Comm. #:
- SB-2008080001
- Date Added:
- February 28, 2009
- Manufacturer:
- MERCEDES BENZ
SummaryMERCEDES: CHECK AIR SUSPENSION COMPRESSOR AND REPLACE IF NECESSARY. INSUFFICIENT AIR PRESSURE IN THE AIR SUSPENSION SYSTEM MAY RESULT FROM DAMAGE TO THE PRESSURE DISK IN THE AIR SUSPENSION COMPRESSOR. *PE
Associated Products (3)Associated Documents